2022 Ford Maverick Hybrid

Purchased new 7-22-2022. On 8-10-2022 drove 14 mi, parked for 2 hours, tried to start truck, message on dash said “stop safely now “, with red triangle, check engine, battery warning lights. Tried repeatedly to start truck waiting 15 minutes each time, wouldn’t start. Used ford pass on phone to call for tow. When tow arrived 30 minutes later the truck started like normal. Drove around parking lot while tow truck waited seemed normal so I drove home. Had dealer check 12v battery on 8-12 and it was fine. Made appointment for diagnostic testing for 8-22. Other owners have received “stop safely now” message while driving on highway, engine lost power and coasted to stop on side of road - obviously a serious safety concern.

Had vehicle towed into shop because it was dead and jumping it couldn't sustain a charge. Dealer took a week to determine it was a DC converter problem and ordered part to replace. After replacement, it was determined it was a battery cable and has been backordered for 2 months. Parking brake error message was present randomly, otherwise no other warnings occurred.

I was driving on the highway at about 70 MPH when the truck gave me a "Powertrain Malfunction/Reduced Power" notification & the red battery light came on. The truck then had a "Pull Over Immediately" (Not 100% sure on the wording) notification on the dashboard and stopped accelerating. Once the notification popped up and the truck stopped accelerating, the air conditioning & power steering also stopped working. I was able to coast long enough to get over to the shoulder where I was able to call a tow truck. While waiting for the tow truck, the truck would not start, the hood latch would not open, and it was unable to shift gears so it could not be put in neutral to be towed.

I went to use the vehicle. All electrical components were not working. Unable to unlock car doors, shift the vehicle to neutral. Dash has no illumination at all. Occurred on July 5 and had used the car earlier in the morning without any issues. I had to have the vehicle towed to the dealer. Tow truck able to jumpstart vehicle to move onto the flatbed. Upon arrival at the dealer and subsequent inspection, found fuse had blown from the jumpstart of the truck. After the fuse was replaced, the dealer found a negative terminal connection from the harness had broken at the flat section. The harness is on national backorder. Repair is still waiting to occur.

With the initial instance (it has happened 3 separate times), I was traveling on the interstate on the way back from Tennessee to Georgia and stepped on the accelerator (basically punched it) to get around a big rig, all of a sudden I get a "tow truck" icon on my dash and the accelerator is unresponsive, so I think I was in electric mode only if that. Fortunately, I was close to an exit and was able to coast to a stop in a parking lot. I put it in park, whereby the shifter dial then locked into park, could not change it. My wife read a blog on the internet (the owners manual is useless) to wait a few minutes and everything should work, that turned out to be true, so we were able to be on our way, but scary as heck to be on the highway and your vehicle suddenly shuts down. My Ford Pass app showed a "High Voltage Battery warning" message and also the MIL (check engine light came on solid and stayed on for at least another day, but eventually went out. This happened 2 other times, the exact same scenario, but this time light to moderate acceleration. I believe my safety was put at risk because the vehicle was rendered useless while traveling at high speeds on the highway. My dealer had it for 2 weeks, and said they read some transmission codes but tell me Ford doesn't know what to do to fix the issue at this point.

I returned from a short trip, 3 days to a truck that was completely dead. I received a notice via my ford mypass app that remote features were being shut off to conserve battery life. Upon arriving I could not open the door using the factory keypad, nor open the doors through the app. Required a call to Ford and tow truck driver broke into car to retrieve key that was left in the glove box. Car required a jump. After starting this hybrid, no engine combustion required, I drove approximately 20 miles and parked the truck. That night I received the warning again and started the car, ran it for 15 minutes then drove the truck to the dealership. After 9 days, dealership indicates that they replaced 12 v battery, and car is ready for pickup. Before I picked up the truck, I have the same low batter warning on the app and remote features have been turned off. I don't believe that the issue has been resolved and it is being reported by a large number of other Maverick owners on the follwing post https://www.mavericktruckclub.com/forum/threads/tracking-dead-hybrid-mavericks-reported-dealer-solutions-fixes.16862/.

I shut off my Maverick to get out and get some water, when I got back in my truck, it had NO power. It was as if the battery was dead. I had it jump started and drove home. In the middle of a intersection, while turning, the truck shut off completely. NO power. When this happens, you have no emergency lights and can not put it in neutral to push it off of a road. If you are on a back road with no lights, you can't turn on the hazards nor push the vehicle off the road out of traffic. It was the wiring harness that went bad. My Maverick is at the dealer right now waiting for the part to come in. This is becoming a common issue for the Truck across the US. The dealer confirmed it was wiring harness. A cop jumped started the truck for me the second time. I had to have somebody follow me home as it kept dying in the middle of the road on the way home. I consider this a safety issue as you have no lights to keep from getting hit by another vehicle and no way to put it in neutral so you can get it out of the road. There were no warning lights or symptoms that it was going to fail, it just stopped working.