My truck repeatedly enters "Deep Sleep" mode. According to Ford, "Deep Sleep" mode activates when: (a) Vehicle inactivity for 14 consecutive days (b) The battery voltage drops below 9.5 volts; or (c) Extremely cold/hot weather conditions. My truck is never inactive for 14 days and has never been in extreme cold/hot weather cond…
Read full complaint
My truck repeatedly enters "Deep Sleep" mode. According to Ford, "Deep Sleep" mode activates when: (a) Vehicle inactivity for 14 consecutive days (b) The battery voltage drops below 9.5 volts; or (c) Extremely cold/hot weather conditions. My truck is never inactive for 14 days and has never been in extreme cold/hot weather conditions. Therefore I can only conclude severe voltage drops from the battery. The internet is full of complaints about this truck entering deep sleep mode and then failing to turn on again, even with a jump start. I'm concern for my safety that this vehicle will leave me stranded.
NHTSA ODI #11488140
Mileage unknown · Oct 4, 2022
Electrical System
VEHICLE HAS NO POWER ANYWHERE... AS IF THE BATTERY IS DISCONNECTED.. TECHNICAL SERVICE BULLETIN #22-2340
NHTSA ODI #11487814
Mileage unknown · Sep 26, 2022
Electrical SystemEngine
On my way home from a 200 mile trip, approx. 10 miles from home, engine lost power so I glided to the side of the road, as it slowly lurched to a stop on a rural highway. I wasn't able to get it off the highway as there was little to no shoulder so I backed it into a driveway, shut it off, looked under the hood, under body, tire…
Read full complaint
On my way home from a 200 mile trip, approx. 10 miles from home, engine lost power so I glided to the side of the road, as it slowly lurched to a stop on a rural highway. I wasn't able to get it off the highway as there was little to no shoulder so I backed it into a driveway, shut it off, looked under the hood, under body, tires, everything looked normal. Got back in, turned the key and hit the gas pedal hard and it wasn't lurching and said it was moving under all electric and that got me 3\4 ers of a mile down the road on all electric, then it died again and half the truck was sticking out onto the road. Attempts to put the truck in neutral to push off the road into a nearby residential driveway didn't work as every time i would get it in and try to leave the vehicle seat to push it would pop back into park. Dash Indicator display showed the battery symbol and engine lite and Fordpass alert showed up on my phone. Said it was going into deep sleep mode to preserve the high voltage battery power. Found out this morning 09/26/2022 there is a Ford TSB out to repair these battery cable, battery, electrical issues. The 12v battery cable to the engine fuse box connector has a bad weld connection.
NHTSA ODI #11486359
Mileage unknown · Sep 20, 2022
Electrical System
Vehicle wouldn't start, had to jump start it under the hood. 12V battery under rear seat showed sufficient voltage. Took vehicle to dealer and they reproduced and confirmed the conditions. Vehicle is still at the dealership awaiting repair. Suspect faulty soldered terminal in the battery wiring harness. Safety issue if similar f…
Read full complaint
Vehicle wouldn't start, had to jump start it under the hood. 12V battery under rear seat showed sufficient voltage. Took vehicle to dealer and they reproduced and confirmed the conditions. Vehicle is still at the dealership awaiting repair. Suspect faulty soldered terminal in the battery wiring harness. Safety issue if similar faulty soldered joints exist throughout the wiring harness or electrical system causing more catastrophic conditions, i.e. loss of power while driving.
NHTSA ODI #11485485
Mileage unknown · Sep 8, 2022
Electrical SystemEngine
Vehicle can not power on after shutting down. You must jumpstart the vehicle everytime. Dealer stated wiring harness is the issue
NHTSA ODI #11483576
Mileage unknown · Sep 8, 2022
Electrical System
When turning off the vehicle, all electrical is powered off, and will not turn back on. This includes all door locks and shifting abilities. The vehicle cannot be switched to neutral to be moved without battery power and a manual override.
NHTSA ODI #11483486
Mileage unknown · Sep 7, 2022
Electrical System
The vehicle lost all electrical power with no response from any of the vehicle systems (i.e., door locks, lights, ignition, etc.).
NHTSA ODI #11483412
Mileage unknown · Sep 7, 2022
Electrical System
Drove vehicle, stopped and turned off the vehicle. No lights, no power nothing at all. Jumped vehicle and drove the vehicle home with no issues. I tried to restart the vehicle and nothing at all again. 12 volt battery was tested and found to be in good condition so it was not the battery. I had the vehicle towed to the dealer.
NHTSA ODI #11483236
Mileage unknown · Sep 6, 2022
Electrical System
My car goes into deep sleep mode for no reason. The battery is fine, the harness is having issues.
NHTSA ODI #11483123
4,700 miles · Aug 31, 2022
Electrical SystemEngine And Engine CoolingStructure
The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 35 MPH, the check engine warning light illuminated. The contact stated that the vehicle decelerated as if the transmission was slipping. The contact pulled into his residence driveway when he noticed smoke coming from under the hood. The contac…
Read full complaint
The contact owns a 2022 Ford Maverick. The contact stated while driving approximately 35 MPH, the check engine warning light illuminated. The contact stated that the vehicle decelerated as if the transmission was slipping. The contact pulled into his residence driveway when he noticed smoke coming from under the hood. The contact opened the hood and a large amount of gray smoke coming from the engine compartment. The contact used a garden hose to put out the smoke. The contact stated that he never saw a flame; however, he smelled the odor of burnt plastic. The contact stated the vehicle then failed to start-up. The contact had the vehicle towed to a local dealer where it was diagnosed and determined that the 300 AMP fuse was burnt and needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The contact stated that he received a letter from the manufacturer for NHTSA Campaign Number: 22V484000 (Engine and Engine Cooling, Structure). The failure mileage was approximately 4,700.
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick Hybrid and 2020 Escape Hybrid vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will update the HPCM software, free of charge. Owner notification letters were mailed February 12, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S33. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 15, 2026. This is an expansion of Recalls 24V330 (24S33) and 25V133 (25S16).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ24014 · Loss Of Motive Power
Opened Nov 15, 2024 · Closed Oct 10, 2025
Status: closed (inferred from source dates) · Electrical SYSTEM:12V/24V/48V Battery
On January 31, 2024, The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24002) to investigate loss of motive power allegations in model year (MY) 2021 Ford Bronco Sport vehicles. Consumers reported a loss of engine power accompanied by complete electrical system failure either while driving or after stopping at a traffic light or stop sign. The vehicles generally could not be restarted, and the incidents were commonly diagnosed by dealerships to a failed 12-Volt (12V) battery. On April 12, 2024, Ford issued safety recall 24V-267 covering 456,565 MY 2021-2024 Ford Bronco Sport and MY 2022-2023 Ford Maverick vehicles. The recall addressed loss of motive power resulting from sudden degradation of the 12V battery during the drive cycle. The recall remedy consisted of software updates to the body control module and the powertrain control module. The updated software aimed to provide warning to consumers when the battery is failing and inhibit certain vehicle functions which can lead to loss of motive power incidents. Additionally, Ford removed the existing 12V Enhanced Flooded Battery (EFB) as both a service component for the subject vehicles and original equipment for newly built Bronco Sport vehicles (during MY 2024 production), replacing it with a more robust absorbed glass mat (AGM) battery. The same AGM battery had been incorporated into Ford Maverick production in late 2022. Following recall 24V-267, ODI received loss of motive power complaints in vehicles that had previously received Ford’s software-based remedy. Consumers reported that they did not receive warnings related to the 12V battery or the vehicle’s electrical system before the loss of power. On November 15, 2024, ODI opened Recall Query (RQ24014) to assess the effectiveness of the 24V-267 recall remedy. On January 19, 2025, Ford issued recall 25V-019 covering 272,817 MY 2021-2023 Bronco Sport and MY 2022-2023 Ford Maverick vehicles. The new recall addressed the same hazard as 24V-267 but required replacement of the existing 12V battery with an AGM battery as the remedy. Ford reported that following the opening of RQ24014, it evaluated several field-returned 12V batteries, and determined that EFBs produced by battery supplier Camel potentially contained internal manufacturing defects causing loss of motive power. Ford further concluded that the software updates provided in the 24V-267 recall remedy were unable to detect battery failures quickly enough to avoid loss of motive power. Vehicles previously within the scope of recall 24V-267, but outside of the scope of recall 25V-019, are equipped with EFBs produced by a different battery supplier (Clarios). When recall 25V-019 was issued, Ford had not identified any Clarios EFBs exhibiting the same failure mode as the Camel EFBs. In light of Ford’s recall action, ODI is closing this Recall Query. The agency will continue to monitor loss of motive power complaints in Bronco Sport vehicles equipped with Clarios EFBs and reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2022 Ford Maverick Hybrid Problems, Complaints & Recalls | Skip That Year
Illustration