2020 Ford Fusion

My vehicle was in service with my dealer for several months 3 separate occasions for powertrain issues which werent resolved and now the alignment in my steering wheel is really off. My spouse and I believe the PCM is messed up but have had no progress with our dealership and suspect them of committing consumer fraud and selling us a lemon. The vehicle in question is around 70,000 and started messing up at 60,000.

Began to hear loud rattling noise under hood. Brought to Ford dealer who determined the cause is a failed Flex Plate. Car is operable but was warned this could result in catastrophic failure of the transmission. Vehicle has approximately 62,000 miles, just 2,000 miles out of warranty. Ford Customer Satisfaction Program 22N12 address the issue with an extended warranty for certain model variants (Vehicles Equipped with a 2.0L EcoBoost Engine and 6F35 Transmission). My vehicle has suffered the same failure but has a 1.5L engine so has been excluded.

The steering cable is connected to the transmission hub, and the fitting that connects the two has a gasket that wears away and falls out. This is a recall with vehicles that are made from one of the two plants that assemble fusions, however my vehicle is not covered under the recall even though it is the very same issue as the recall from the other plant. it makes no sense, why is one assembly plant offering a recall for this issue while the other does not? For the same issue of the steering cable coming off the transmission, and not allowing the vehicle to go into gear. I have had to fix this car on the side of the highway before, it will not go into gear on the road. This is not safe at all. You cannot have vehicles just not going into gear while your driving down the highway, or road, street, etc.

The contact owns a 2020 Ford Fusion. The contact stated that while the vehicle was at the car wash, water entered through the closed sunroof. The vehicle was taken to an independent mechanic, who determined that the sunroof drain needed to be cleaned. The sunroof drain was cleaned, but the failure persisted. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 20V260000 (Visibility); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and instructed the contact to take the vehicle to the dealer to have the sunroof replaced. The failure mileage was approximately 80,000.

The contact's husband owns a 2020 Ford Fusion. The contact stated while driving at various speeds, there was an abnormal rumbling sound coming from the engine. There was no warning light illuminated. The vehicle was taken to a dealer where a diagnostic test was performed. The mechanic discovered a failure with the flex plate. The contact was initially informed that the vehicle was covered under warranty; however, the contact was later informed that the engine repair was not covered under warranty. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The vehicle remained with the dealer unrepaired. The failure mileage was approximately 70,000.

The alternator was producing too many volts, which would short circuit the battery and electrical components in the car. This would cause the car to lose power and not be able to accelerate. My car would randomly lose power on the highway, with no warning, resulting in my car suddenly slowing down. This was dangerous for the cars around me who are going 60+ and then my car quickly drops to 40 or less mph. In addition, to solve the issue I would have to pull off onto a shoulder to shut the car off and back on. This issue started around 3-4 yrs ago and has gotten worse as time passed. The problem was identified and resolved by Firestone when they ran a diagnostic. No check engine light was on in the car to alert me of any issues. I replaced both parts on the car.

The contact owns a 2020 Ford Fusion. The contact stated that the fuel door would randomly disconnect from the vehicle. While idling at a stop light, the vehicle shut off. The contact stated that while restarting the vehicle the vehicle jerked and hesitated while shifting gear before accelerating. The vehicle was taken to the dealer who was unable to determine the cause of the failure because there was no warning light illuminated. The fuel door had been replaced; however, the vehicle still experienced the failure with the START/STOP function. The contact stated that the failure became a persistent failure. The contact stated that approximately 6 to 8 months after the first failure, while driving approximately 35-45 MPH, the vehicle stalled. The contact used the App to restart the vehicle. The check engine warning light was illuminated. The vehicle was returned to the dealer however, the cause of the failure could not be determined. The dealer rebuilt the transmission, clutch, and axle; however, the failure persisted after the repairs. The vehicle was returned to the dealer who was unable to determine the cause of the failure. The vehicle had been taken to the dealer 22 times. The manufacturer was not made aware of the failure. The approximate failure mileage was 25,000.

The contact owns a 2020 Ford Fusion. The contact stated the vehicle was started and the check engine warning light illuminated. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that there was coolant intrusion into cylinder #2, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 68,000.