← New search

2020 Ford Fusion

Owner reports · Recalls · Investigations

Fewer warning signs than most model years

Owner complaints for the 2020 Ford Fusion are lower than the model-year median of 1,109.

About this comparison →

When problems were reported

Mileage at the reported incident

56 reports with mileage · 122 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

10 crash reports3 fire reports5 injury reports

Engine complaints

49 reports
Clear category filter
117,000 miles · Apr 30, 2024
EnginePower Train

The contact owns a 2020 Ford Fusion. The contact stated that while starting the vehicle, there was a rattling noise coming from the front end near the driver’s side close to the transmission. The vehicle would start moments after the failure had occurred. The rattling was more pronounced while the A/C system was running. The con…

Read full complaint

The contact owns a 2020 Ford Fusion. The contact stated that while starting the vehicle, there was a rattling noise coming from the front end near the driver’s side close to the transmission. The vehicle would start moments after the failure had occurred. The rattling was more pronounced while the A/C system was running. The contact stated that while depressing the accelerator pedal, the rattling sound was noticeable. Additionally, while driving at various speeds, the transmission felt as though it was slipping while changing gear. The contact stated that while inspecting the engine, underneath the hood was hotter than normal. The check engine warning light was illuminated. The vehicle had been taken to the dealer where it was diagnosed that the transmission flex plate had failed. The failure was linked to NHTSA Campaign Number: 10218899 (Power Train). The vehicle had not been repaired. The manufacturer was made aware of the failure, and it was confirmed that the VIN was not under recall. The contact was referred to the NHTSA Hotline to file a complaint. The failure mileage was 117,000.

NHTSA ODI #11586075

Mileage unknown · Apr 29, 2024
EnginePower Train

Cracked flexplate

NHTSA ODI #11585753

Mileage unknown · Apr 23, 2024
Engine

Intrusion into cylinder 2.

NHTSA ODI #11584802

Mileage unknown · Nov 13, 2023
Engine

Failure of the Flywheel. It’s broken in pieces according to the dealership at greenway Ford. Did some searching on line and other people have report the same issues. The problem is they installed crappy plates that crack between 60k-90k miles. As others have reported the Luckily for them It was at an intersection and could pull …

Read full complaint

Failure of the Flywheel. It’s broken in pieces according to the dealership at greenway Ford. Did some searching on line and other people have report the same issues. The problem is they installed crappy plates that crack between 60k-90k miles. As others have reported the Luckily for them It was at an intersection and could pull over to the side of the road but imagine if this happens to you while on the freeway!

NHTSA ODI #11554830

Mileage unknown · Sep 27, 2023
Electrical SystemEnginePower Train

At first the check engine light was on and the car would not start. The dash would display all the lights and at one point it turned off while driving luckily I was going 20-30mph. Took it to the dealership and they said an Intake Valve had to be replaced and it was covered by the warranty. Next the engine light was on and a MAP…

Read full complaint

At first the check engine light was on and the car would not start. The dash would display all the lights and at one point it turned off while driving luckily I was going 20-30mph. Took it to the dealership and they said an Intake Valve had to be replaced and it was covered by the warranty. Next the engine light was on and a MAP censor had to be replaced which wasn’t covered. Once again the engine light and service light came on and the code is saying the same censor needs to be replaced. Each time it has effected how the car drives and is dangerous especially on the interstate because it will not go over 20mph. When the car is in reverse it will shake and turn off displaying auto start stop issue and place the car in park. It will then turn off. It is hit or miss on when the check engine light and maintenance light will come on and each time the symptoms are the same. No one has provided a solution. This has been on going for almost a year.

NHTSA ODI #11546929

99,964 miles · Aug 18, 2023
Engine

The contact owns a 2020 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle was making an abnormally loud sound. The vehicle then failed to shift into drive or reverse. There were no warning lights illuminated. The vehicle was towed to the local dealer to be diagnosed. The contact was informed that…

Read full complaint

The contact owns a 2020 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle was making an abnormally loud sound. The vehicle then failed to shift into drive or reverse. There were no warning lights illuminated. The vehicle was towed to the local dealer to be diagnosed. The contact was informed that the cam shaft thrust plate was damaged and there was damage to the crank shaft. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 99,964.

NHTSA ODI #11539374

Mileage unknown · Mar 3, 2023
EnginePower Train

The car seems to lose power sometimes when you are going down the road. My engine light came on but it brings up a fuel cap code, and a emission control sensor. The extended warranty covered the emissions control purge valve. This started around 70,000 miles.

NHTSA ODI #11509984

Mileage unknown · Sep 20, 2022
EngineLane DepartureWheels

Constantly with this specific vehicle, especially with the lane assist. The vehicle continuously jerks either left or right even within the green parameters of the lane, especially when doing a slight turn on the highway. When it is raining the vehicle smart as go offline an cannot read the lane or the vehicle in front of it. …

Read full complaint

Constantly with this specific vehicle, especially with the lane assist. The vehicle continuously jerks either left or right even within the green parameters of the lane, especially when doing a slight turn on the highway. When it is raining the vehicle smart as go offline an cannot read the lane or the vehicle in front of it. When I first purchased the vehicle after driving for less than a year I had to take the vehicle in because the engine was warped. Constantly when I’m the vehicle the Apple car play system would either freeze or the screen would go black.

NHTSA ODI #11485409

Mileage unknown · Jun 21, 2022
Engine

There is Exhaust smell of rotten eggs that enter the cabin while driving and it happens almost every drive. I have brought the car to the dealer where they ran tests but found no problems. As soon as I got the car back it started producing the rotten egg smell again.

NHTSA ODI #11470174

Official recalls

3

25V685000 · Equipment:electrical:engine Block Heater

Oct 10, 2025

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Consequence & remedy

Consequence: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

25V442000 · Back Over Prevention:software

Jun 27, 2025

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Consequence & remedy

Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

23V440000 · Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)

Jun 23, 2023

Ford Motor Company (Ford) is recalling certain 2019-2020 Fusion PHEV vehicles. The battery energy control module (BECM) may become damaged due to excessive voltage and current flow.

Consequence & remedy

Consequence: A damaged BECM can result in a loss of drive power or fire, increasing the risk of a crash.

Remedy: Owners are advised not to charge their vehicles until the remedy is completed. Dealers will replace the battery and update the BECM software for free, or Ford will repurchase the vehicle. If your vehicle is currently operating normally, Ford has authorized dealers to replace the fuse block and a software update as an interim repair before the availability of remedy parts for the final repair. This repair will be free of charge (parts and labor). As an alternative remedy, Ford is offering a vehicle refund. Please see Ford's owner notification letter or contact Ford for full details. Owner notification letters were mailed May 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S33.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.