2020 Ford Fusion

My 2020 Ford Fusion has had multiple transmission failures and has now had a third transmission installed. The newest issue with with the engine design that Ford is aware of but is not covered by extended warranty. The engine block is cracked due overheating caused by coolant intrustion and flexplate problems. Each time these incidents were identified and examined by Ricart Ford in Columbus, OH. The car was also purchased by the same dealer in January of 2024. The check engine light along with the temperature light were triggured by the engine issue on [XXX] I immediately contacted Protective(My warranty company) and requested that the car be transported to Ricart. I also contacted the service deparment at Ricart and explained the issue. There was plenty of coolant in the resevoir but the coolant leaked into the cylinders and caused the car to overheat. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6

The contact owns a 2020 Ford Fusion. The contact stated that after starting the vehicle there was an abnormally loud knocking sound coming from the engine compartment. The vehicle was taken to the local dealer who diagnosed that the flex plate was cracked and needed to be replaced along with the torque converter, the transmission fluid pump, and seals. The vehicle was repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was no longer eligible for a Customer Satisfaction Campaign related to the failure. The failure mileage was 122,000.

Component or system that failed: Flex plate, engine electrical system, and alternator (possible related failures). The issue has been diagnosed by a licensed mechanic and is available for inspection upon request. Incident Description: On April 15, 2025, while driving my 2020 Ford Fusion SE 1.5L Turbo, the vehicle suddenly experienced a total power failure. The check engine light began flashing, and the battery light blinked rapidly. Within seconds, the engine shut down completely while I was mid-drive in traffic, leaving me stuck and unable to move for over 20 seconds. This was a terrifying and dangerous situation that nearly put my life at risk. I was eventually able to restart the vehicle, but it began shaking and rumbling violently — worse than ever before. This issue was never present before my car was involved in two separate collisions, where both other drivers were found 100% at fault. The vehicle was repaired at Fix Auto Santee (a USAA-assigned body shop), but they failed to inspect internal components. A licensed mechanic at J&L Auto Care later confirmed a broken flex plate and advised it was unsafe to drive. This problem has not been addressed or fixed by the responsible insurers (USAA and AAA) or the body shop. It has progressively worsened and now created a life-threatening situation. Warning lamps or symptoms before failure: A rattling and vibrating noise began immediately after I picked up the car from the body shop in March 2025. No lights were initially present. The electrical and engine lights only appeared on April 15 when the engine shut down mid-drive. Inspected by: •Independent service center (J&L Auto Care, diagnosed flex plate failure) •USAA and AAA were informed but refused to cover or further inspect the damage •Fix Auto Santee heard the issue but refused to inspect, citing body-only service Problem available for inspection: Yes — vehicle is currently undrivable and available for full inspection.

The contact owns a 2020 Ford Fusion. The contact stated that while driving approximately 35 MPH, the message "Engine Coolant Over-Temperature" was displayed, and the temperature gauge warning light illuminated. The contact pulled over to the side of the road and turned off the vehicle. The vehicle was restarted after 20 minutes. The vehicle was taken to the residence. The vehicle was towed to a dealer, where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 132,000.

I have had 2 transmissions within the last year, making this the third Transmission on my vehicle. I had to have another common issue with the car replaced, which is a purge valve. My ABS light goes off often causing difficulty to steer the car and warning lights are activated showing that the safety features are not available. Lastly, there is a crack in the engine block caused by coolant in the spark plug due to overheating. This engine issue is one with the engines that Ford is aware of but I do NOT see a recall. The engine is blown due to this design and the warranties do NOT cover it. Case number [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Ford Fusion. The contact stated that after starting the vehicle, while the vehicle was idling, there was an abnormal knocking sound coming from the engine. There was no warning light illuminated. The vehicle was taken to two independent mechanics, and unknown repairs were performed on the vehicle; however, the failure persisted. The contact took the vehicle to a dealer, where a diagnostic test was performed. The diagnostic test determined that the flex plate was cracked and needed to be replaced. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 117,000.

Began to hear loud rattling noise under hood. Brought to Ford dealer who determined the cause is a failed Flex Plate. Car is operable but was warned this could result in catastrophic failure of the transmission. Vehicle has approximately 62,000 miles, just 2,000 miles out of warranty. Ford Customer Satisfaction Program 22N12 address the issue with an extended warranty for certain model variants (Vehicles Equipped with a 2.0L EcoBoost Engine and 6F35 Transmission). My vehicle has suffered the same failure but has a 1.5L engine so has been excluded.

The contact's husband owns a 2020 Ford Fusion. The contact stated while driving at various speeds, there was an abnormal rumbling sound coming from the engine. There was no warning light illuminated. The vehicle was taken to a dealer where a diagnostic test was performed. The mechanic discovered a failure with the flex plate. The contact was initially informed that the vehicle was covered under warranty; however, the contact was later informed that the engine repair was not covered under warranty. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The vehicle remained with the dealer unrepaired. The failure mileage was approximately 70,000.