Engine. Review the 152 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

5 crash reports0 fire reports6 injury reports

Engine And Engine Cooling complaints

54 reports

Clear category filter

84,000 miles · Feb 23, 2023

Engine And Engine Cooling

Read full complaint

The contact owns a 2019 Ford Fusion. The contact stated while attempting to start the vehicle, the vehicle misfired and jerked. The contact took the vehicle to the dealer who diagnosed and determined that coolant was leaking into the cylinders causing the misfire. The dealer confirmed that the failure was related to service bulletin with NHTSA ID Number: 10214126 (Engine and Engine Cooling) however, the VIN was not included. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 84,000.

NHTSA ODI #11508731

35,454 miles · Jul 14, 2022

Engine And Engine Cooling

Read full complaint

The contact owns a 2019 Ford Fusion. The contact stated while driving 65 MPH, she heard abnormal bubbling sounds coming from the engine before the vehicle stalled. The contact was able to veer to the side of the roadway. The contact was able to restart the vehicle and drove to her residence. The vehicle was towed to the dealer where it was diagnosed that coolant had been leaking into the engine and had caused the engine to fail. The engine short block was replaced; however, the contact stated upon starting the vehicle three months later, she heard abnormal knocking sounds coming from the engine. The vehicle was taken to a local Pep Boys where the engine oil was replaced; however, the failure persisted. The vehicle was taken back to the dealer where it was diagnosed that the flywheel needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was approximately 35,454.

NHTSA ODI #11473876

Mileage unknown · Jun 23, 2022

EngineEngine And Engine Cooling

I bought this vehicle in 2019 and one of the engines cylinders was crack and now I need a new engine and I heard that this a very common problem with this vehicle

NHTSA ODI #11470643

Mileage unknown · Jun 23, 2021

EngineEngine And Engine Cooling

About a week or so ago I went out to crank my car and it sounded awful It was shuttering, sounded like it was going to shut off and the engine light came on, it's a 2019 Ford Fusion. I notice it does this every morning, well I took it to the dealer ship today, they said I have coolant leaking into the Engine.

NHTSA ODI #11422007

Official recalls

25V685000 · Equipment:electrical:engine Block Heater

Oct 10, 2025

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Consequence & remedy

Consequence: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

25V442000 · Back Over Prevention:software

Jun 27, 2025

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Consequence & remedy

Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

23V440000 · Electrical System:propulsion System:traction Battery:management System/energy Control Module (bms/becm)

Jun 23, 2023

Ford Motor Company (Ford) is recalling certain 2019-2020 Fusion PHEV vehicles. The battery energy control module (BECM) may become damaged due to excessive voltage and current flow.

Consequence & remedy

Consequence: A damaged BECM can result in a loss of drive power or fire, increasing the risk of a crash.

Remedy: Owners are advised not to charge their vehicles until the remedy is completed. Dealers will replace the battery and update the BECM software for free, or Ford will repurchase the vehicle. If your vehicle is currently operating normally, Ford has authorized dealers to replace the fuse block and a software update as an interim repair before the availability of remedy parts for the final repair. This repair will be free of charge (parts and labor). As an alternative remedy, Ford is offering a vehicle refund. Please see Ford's owner notification letter or contact Ford for full details. Owner notification letters were mailed May 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S33.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.