2019 Ford Fusion

The contact owns a 2019 Ford Fusion. The contact stated that the vehicle was taken to the dealer for a recommended maintenance inspection; however, the contact stated that upon the technician inspecting the vehicle, the contact was informed that the engine short block needed to be replaced due to coolant intrusion into the engine. The vehicle was not repaired. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the vehicle was out of warranty. The contact was informed to draft a letter for assistance. No further assistance was provided. The failure mileage was 119,000.

The contact owns a 2019 Ford Fusion. The contact stated while starting the vehicle the check engine warning light illuminated. The vehicle was taken to an independent mechanic who stated that coolant was leaking into cylinder #2 and that the spark plug needed to be replaced along with the coil. The spark plugs and ignition coils were replaced but the failure reoccurred. The vehicle was taken to the independent mechanic and the codes were reset but the failure reoccurred. The vehicle was taken back to the independent mechanic who stated that coolant was leaking into the cylinder causing the spark plug to misfire. The dealer was contacted and stated that there was a Customer Satisfaction Program issued but the VIN was not included. The vehicle was not repaired. The manufacturer was contacted, and a case was filed. The contact was referred to the NHTSA Hotline. The failure mileage was 89,000.

The contact owns a 2019 Ford Fusion. The contact stated while his daughter was driving approximately 40-45 MPH, the check engine warning light illuminated, and the vehicle went into LIMP mode. The contact stated that the vehicle failed to exceed 5 MPH. The contact's daughter pulled into a parking lot. The contact stated that he used an OBD reader to determine that cylinder #2 was misfiring. The vehicle was taken to the Chevrolet dealer where it was purchased, and was diagnosed with coolant intrusion into the engine, causing cylinder #2 to misfire. The contact was informed that the engine needed to be replaced. The vehicle was taken to a Ford dealer, where the diagnostic result was confirmed. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under Ford Campaign Number: 21N12. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 84,717.

The contact owns a 2019 Ford Fusion. The contact stated that the check engine warning light illuminated. The contact's friend used an ODB code reader and determined that there was a misfire in cylinder #3. The ignition coils were replaced; however, the failure persisted. The contact also discovered that the coolant level remained low. The vehicle was then taken to a dealer for a diagnostic test where it was determined that coolant had leaked into cylinder #3 and that the long block needed to be replaced. The manufacturer was notified of the failure. The vehicle was not repaired due to parts being on backorder. The failure mileage was approximately 76,000.

Last year my car started overheating for no apparent reason checked coolant reservoir and visibly seemed empty but when I removed the cap antifreeze rose fast. Added antifreeze and it stopped overheating. About 3 months ago Because it overheated I had to get the head gasket replaced, timing components replaced, heads repaired, and engine flushed(antifreeze had entered engine), not to mention labor all costing roughly $3,000. Only for it to happen again and now I’m out of $3,000 because the same thing is happen only this time my car is shaking and smoking from the tail pipe badly. In the mean time my fiancé has lost his job due to us not being able to drive the car. After doing god knows how much research to find out this is an ongoing problem with this particular make of car. Because of having to pay for countless repairs and no one seeming to know what’s going on with my car I am now behind on bills and still without a car that is only 4 years old. I haven’t done any long driving to other states beside neighbors states that are about 2-3 hours away but that shouldn’t matter because it’s a new car I shouldn’t have any problems driving it wherever. I purchased this car at a lil over 30k miles my problems started at about 61k miles which is odd since the manufacturer warranty had just expired about 1k miles before that. I believed in ford for the longest and now I am regretting ever buying one. My very first car purchase from a lot and it turns out to be the worst car I’ve ever purchased. I’m sure me typing all of this probably won’t get read or even looked into but this is an experience I wouldn’t dare want anyone else to go through so I’m sure to leave many reviews but I thought you should know. Also because of the over heating my car has cut off at times where my life could have been taken (at lights and intersections) have a good day!

May 16, 2023-check engine light activated reading code P0302 Cylinder 2 misfire May 27, 2023-warning light appeared reading engine overheating, and the car would not start. May 27, 2023-took it to the dealership and they advised me I had an internal engine coolant leak and that I needed to replace the short block and head gasket. I was quoted $7600! After doing some research I discovered it is an unaddressed recall from Ford and that NHTSA issued Bulletin# 21N12. Letters went out June 20, 2022 for a one-time no cost repair. The program ended five months later on November 30,2022. I never received the letter. I called Ford Customer service and they stated they cannot cover the repairs because I'm past the November 30, 2022 deadline.

The contact owns a 2019 Ford Fusion. The contact stated while attempting to start the vehicle, the vehicle hesitated to start. Additionally, the contact stated that the vehicle hesitated to respond while depressing the accelerator pedal. The check engine warning light was illuminated. The contact stated that the failure reoccurred while driving at various speeds and depressing the accelerator pedal. The dealer was contacted and informed the contact that they could not assist as the VIN was not included in a recall. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 92,770.