2017 Ford Fusion

I was driving the car and it started to overheat so I pulled over. I then drove the car to my home and it had a miss in the engine along with white smoke coming out of the exhaust. After getting home I checked the coolant and it was low so i filled it up and as the car sat there idling you could see the coolant disappear and the white smoke and rough idle. I could not see where the coolant leaked out on the ground. I also had to have the transmission replace at the dealership I bought it from due to transmission complete failure. Time to recall this make and model. 1. Engine, Transmission failure 2. Sitting along the highway in the middle of no where.. a woman, you can guess, not safe!! 3.Yes Transmission replaced by dealership and Engine confirmed by service center to have coolant in cylinders. 4. No warning lights at all for either. Only temp gage for overheating.

The check engine light began coming on. I took it to the mechanic to determine what may be going on, but he could not find anything. The check engine light continued to come on. Took it back in for deep-dive diagnostics. Service Charging System came on - randomly and intermittently - took it to two different mechanics. At this time problem was intermittent and not consistent. Three mechanics attempted to dive deep into the situation but could not find it. They ruled out the alternator and other issues they suspected. The coolant and Temperature lamps came on once. I immediately stopped driving and checked the coolant. Then, I had mechanics check the coolant and make sure all was good. I took it to another mechanic, and he said it was now throwing all kinds of codes. Took vehicle to local Ford dealership where I was told I needed a new motor and it was not covered by Ford. The cost would be over $13,000. Upon my own investigation, I found that this is a common and recurring problem with this motor. This vehicle has 94k miles on it. In 2022, we purchased it with 78k miles on it for my son to go to college in. Now, I am being told by Ford that the motor will cost more than the car actually did.

Engine light came on while driving on the highway with no other warnings or symptoms that could be noticed during standard operation. Vehicle was taken in to Ford for service the next day and it was discovered that coolant was leaking into cylinder #1 due to the design of the engine long block. Coolant intrusion into the cylinder was causing the cylinder to misfire, as well as engine overheating. If I had not taken the vehicle in for service immediately, overheating would have continued, leading to engine failure while actively driving. THIS IS A KNOWN ISSUE BY FORD AFFECTING SOME OF THEIR 2.0L ECO BOOST ENGINES. Ford issued a technical service bulletin (TSB 19-2346) for its technicians on how to diagnose and fix this defect in December 19th of 2019. Ford service told me the repair would not be covered in any extended coverage or powertrain coverage from the factory.

The contact owns a 2017 Ford Fusion. The contact stated that when the vehicle was started, the contact stated there was an abnormal amount of white smoke coming from the exhaust tips. The contact stated that the failure was persistent. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 45,000.

The contact's son owns a 2017 Ford Fusion. The contact stated that while her son was driving at 45 MPH, the check engine warning light was illuminated, and the temperature gauge increased to hot. Additionally, the contact stated that the vehicle lost motive power and failed to accelerate above 35 MPH. The vehicle was taken to a dealer where it was diagnosed and determined that the engine needed to be replaced due to a head gasket leak that caused coolant intrusion in the engine. The vehicle was repaired. The failure mileage was 94,000.

The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle was shaking and failed to accelerate above 40 MPH. An unknown warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion into cylinder #2, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact was advised to file a complaint with the NHTSA Hotline. The failure mileage was approximately 70,000. The VIN was unavailable.

The antifreeze leaks into the engine due to a KNOWN manufacturer design flaw, is available to inspection upon request and appointment made. Mine and others safety are at risk due to the fact that if the engine seizes up while driving, could lead to a sudden crash. Problem confirmed by a local mechanic. Not been inspected by anyone else other than a different independent mechanic. The first sign of a problem is a check engine light, followed by a sputter in the engine and lack of consistent speed control, first appeared in February, and lead to 2 sets of spark plugs being replaced

The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, it was difficult shifting gear. The contact stated that the vehicle was slow to respond. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, and the contact was informed that the vehicle was experiencing transmission failure. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 17V427000 (Power Train). The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 153,000.

The vehicle has started going through coolant and the exhaust has a sweet smell. It has the 1.5 litre ecoboost that has an active recall. I believe this is the issue. We still owe more than its worth and cannot afford to have a known recall issue cost us our transportation. It is only a matter of time before it destroys itself. I previously owned a 2014 fusion 2.0 that blew the motor due to the same issue. I had to put a new motor in that car. We picked the 1.5 engine since there were no reported issues at the time of purchase in 2022.

The contact owns a 2017 Ford Fusion. The contact stated that the vehicle shook abnormally while starting. The check engine warning light was illuminated. The contact stated that the engine had previously been replaced. The vehicle was taken to an independent mechanic, who diagnosed that there was coolant intrusion into cylinder #2 and determined that the engine needed to be replaced for the second time. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 64,000. The repairs were made in August of last year but the mechanic stated an additional $8,200 is need for more repairs.