NHTSA owner reports · September 18, 2026 snapshot.
Electronic Stability Control (esc) complaints
93 reportsClear category filter117,158 miles · Nov 12, 2019
Electronic Stability Control (esc)SteeringSuspension
TWO ISSUES: WHILE DRIVING ERROR MESSAGE MAINTENANCE POWER STEERING NOW CAME ON. AUTOMATIC STEERING WENT. TWICE AGAIN AFTER THE MECHANIC RESET IT. EXTREMELY DIFFICULT TO TURN. COULD BE EXTREMELY DANGEROUS. I TOOK THE CAR TO THE LOCAL DEALER, (WALKER FORD, CLEARWATER, FL) AND ALTHOUGH THERE IS A RECALL IT DOESN'T APPLY TO …
Read full complaint
TWO ISSUES: WHILE DRIVING ERROR MESSAGE MAINTENANCE POWER STEERING NOW CAME ON. AUTOMATIC STEERING WENT. TWICE AGAIN AFTER THE MECHANIC RESET IT. EXTREMELY DIFFICULT TO TURN. COULD BE EXTREMELY DANGEROUS. I TOOK THE CAR TO THE LOCAL DEALER, (WALKER FORD, CLEARWATER, FL) AND ALTHOUGH THERE IS A RECALL IT DOESN'T APPLY TO MY VEHICLE. VERY EXPENSIVE TO FIX, IN THE $2000 RANGE. THE OTHER PROBLEM WHICH IS THE FIRST REASON WE WENT TO THE MECHANIC. THE FRONT END HAS BEEN MAKING NOISES, CREAKING AND CRUNCHING WHEN MAKING TURNS OR COLD. THAT ISSUE NEEDS CONTROL ARM REPLACED WHICH IS CONNECTED TO THE SUBFRAME VERY COSTLY. I HAVE SEEN BOTH THESE ISSUED ADDRESSED IN NUMEROUS COMPLAINTS ONLINE. FRONT SUSPENSION CONTROL ARM PROBLEM OF THE 2012 FORD FUSION 2 FAILURE DATE: 03/02/2019 THIS BELOW IS WHAT HAPPENED IN DETAIL. THE LOW TIRE PRESSURE LIGHT CAME ON INSIDE THE DASH AS I WAS DRIVING SO I DROVE ABOUT TO GET AIR. AFTER I PUT AIR IN THE TIRE,STARTED THE CAR AND IMMEDIATELY GOT A WARNING THAT POWER STEERING NEEDED SERVICING. THEN GOT ANOTHER WARNING THAT ADVANCE TRACK NEEDED SERVICING. ALL HAPPENED AT THE SAME TIME AND THE POWER STEERING WAS COMPLETELY GONE OUT. CONTROLLING RACK NEEDS REPLACING. 2000 THE SERVICE DEPT SAID THE GEAR INSIDE THE POWER STEERING RACK HAS GONE BAD AND THE CONTROL ARMS IT SITS ON HAS WORN OUT THE GEAR THEREFORE NEEDING FRONT LOWER CONTROL ARMS COSTING $1500
NHTSA ODI #11279474
73,000 miles · Nov 4, 2019
Electrical SystemElectronic Stability Control (esc)Suspension
I PULLED IN MY DRIVEWAY, PARKED 2011 FORD FUSION AND THEN SHUT VEHICLE OFF. I RETURNED, STARTED VEHICLE, WENT TO START DRIVING MY VEHICLE OUT OF DRIVEWAY AND THE CAR STARTED BEEPING AND LISTED THAT THE POWER STEERING DID NOT WORK. I LOOKED IT UP ONLINE AND THERE WAS A RECALL FOR STEERING: ELECTRIC POWER ASSIST SYSTEM FAILURE (15…
Read full complaint
I PULLED IN MY DRIVEWAY, PARKED 2011 FORD FUSION AND THEN SHUT VEHICLE OFF. I RETURNED, STARTED VEHICLE, WENT TO START DRIVING MY VEHICLE OUT OF DRIVEWAY AND THE CAR STARTED BEEPING AND LISTED THAT THE POWER STEERING DID NOT WORK. I LOOKED IT UP ONLINE AND THERE WAS A RECALL FOR STEERING: ELECTRIC POWER ASSIST SYSTEM FAILURE (15V340000 OR 15S18). I TOOK TO DEALERSHIP AND WILL ATTACH QUOTE WHICH THEIR RECOMMENDATION IS EXACTLY WHAT FORD'S RECOMMENDATION WAS. HOWEVER MY CAR DOESN'T FALL INTO THE CORRECT DATE FOR THIS RECALL, I AM HAPPY THAT I WAS NOT DRIVING 75MPH DOWN INSTERSTATE 70 IN WHEELING, WV OR DRIVING UP TO WEST LIBERTY, WV WHERE I WORK. EITHER COULD HAVE RESULTED IN A HORRIBLE ACCIDENT FOR ME, MY KIDS AND POTENTIALLY OTHER VEHICLES INVOLVED. THE CAR HAS ONLY 73,000 MILES ON IT ROUGHLY AND IS IN EXCELLENT CONDITION.
NHTSA ODI #11278074
70,000 miles · Oct 24, 2019
Electronic Stability Control (esc)Service Brakes
IN AUGUST 2016, I CRANKED MY CAR (A 2011 FORD FUSION HYBRID) IN MY DRIVEWAY AND NOTICED THE SERVICE ADVANCETRAC, BRAKE FAILURE SYSTEM, AND ABS LIGHTS LIT UP ON THE DASH. I TRIED TO BACK OUT AND NOTCIED THE ELECTRIC BREAK WERE NOT WORKING AND THE BREAK PEDDLE WAS TO THE FLOOR AND DIFFICULT TO PRESS. THE CAR WAS TOWED TO A FORD D…
Read full complaint
IN AUGUST 2016, I CRANKED MY CAR (A 2011 FORD FUSION HYBRID) IN MY DRIVEWAY AND NOTICED THE SERVICE ADVANCETRAC, BRAKE FAILURE SYSTEM, AND ABS LIGHTS LIT UP ON THE DASH. I TRIED TO BACK OUT AND NOTCIED THE ELECTRIC BREAK WERE NOT WORKING AND THE BREAK PEDDLE WAS TO THE FLOOR AND DIFFICULT TO PRESS. THE CAR WAS TOWED TO A FORD DEALER. THEY KEPT THE CAR FOR A WEEK AND COULD NOT FIND A PROBELM. THE LIGHTS WENT OFF AND THE PROBELM WAS RESOLVED ON ITS OWN. IN AUGUST 2019, THIS PROBELM HAPPENED AGAIN. I CRANKED THE CAR IN A PARKING LOT AND NOTICED THE SAME WARNING LIGHTS FROM 3 YEARS AGO WERE ON. I WAS ABLE TO GET HOME, BUT THE BRAKES WERE NOT VERY RESPONSIVE AND WERE SIGNIFICIANTLY FURTHER DOWN THAN USUAL. I TOOK THE CAR TO A FORD DEALERSHIP AND THEY CLAIMED THEY "RESET THE SYSTEM" AND THE PROBLEM WAS RESOLVED. A FEW WEEKS LATER, THE ISSUE REOCCURED. THE DEALERSHIP SAID THEY DID NOT KNOW HOW TO RELSOVE THE PROBLEM. AFTER ABOUT 4 DAYS THE WARNING LIGHTS WENT OFF AND THE BRAKES RETURNED TO NORMAL. ON OCTOBER 20, 2019 THE WARNING LIGHTS CAME ON AGAIN AND THE ISSUE IS STILL OCCURING. THE CAR IS DRIVABLE, BUT IT DOES NOT FEEL SAFE. IT COULD NOT COME TO AN ABRUPT STOP IF NEEDED AND I LIVE ON A HIGHWAY WHERE PEOPLE OFTEN PULL OUT IN FRONT OF ME. IN 2009, FORD ISSUED A SOFTWARE UPDATE FOR THE BRAKE SYSTEM FOR FUSION HYBRIDS. IT SEEMS LATER HYBRID MODELS ALSO NEED A SOFTWARE UPDATE. I HAVE READ THAT REPLACING THE BRAKES OR ABS CONTROL MODULE DOES NOT RESLOVE THE PROBELM. IT IS AN ISSUE WITH THE COMPUTER SYSTEM.
NHTSA ODI #11270693
148,956 miles · Sep 19, 2019
Electronic Stability Control (esc)Steering
THE POWER STEERING FAILED TO OPERATE CORRECTLY AND THE DASH DISPLAYED A "POWER STEERING ASSIST FAULT" AND "SERVICE ADVANCETRAC SYSTEM" WARNING DURING STARTUP. THE ERROR REPEATED DURING SEVERAL STARTS AND FINALLY BECAME CONSTANT.
NHTSA ODI #11256576
85,000 miles · Sep 9, 2019
Electronic Stability Control (esc)Steering
PURCHASED MY CAR FROM FORD IN APRIL 2015, HAVE HAD 0 ISSUES WITH IT, UNTIL THURSDAY EVENING SEPT 5, 2019. ON THE WAY TO WORK, EVERYTHING WAS FINE. LEAVING WORK, EVERYTHING WAS FINE... UNTIL I GOT ON A 55MPH HIGHWAY, IN TRAFFIC, IN HEAVY RAIN (DUE TO HURRICANE DORIAN ENTERING OUR AREA). OUT OF NOWHERE, MY POWER STEERING WARNING A…
Read full complaint
PURCHASED MY CAR FROM FORD IN APRIL 2015, HAVE HAD 0 ISSUES WITH IT, UNTIL THURSDAY EVENING SEPT 5, 2019. ON THE WAY TO WORK, EVERYTHING WAS FINE. LEAVING WORK, EVERYTHING WAS FINE... UNTIL I GOT ON A 55MPH HIGHWAY, IN TRAFFIC, IN HEAVY RAIN (DUE TO HURRICANE DORIAN ENTERING OUR AREA). OUT OF NOWHERE, MY POWER STEERING WARNING AND ADVANCE TRAC LIGHTS CAME ON AND I LOST COMPLETE STEERING FUNCTION IN MY VEHICLE. I AM ALMOST 5 MONTHS PREGNANT AND ALMOST WRECKED IN 2 LANES FULL OF TRAFFIC OF OTHER PEOPLE HEADING HOME FROM WORK IN SUCH WEATHER! UPON RESEARCH, 400,000+ FORD FUSION 2011'S HAVE BEEN RECALLED OVER THIS SAME EXACT ISSUE - YET IT SEEMS THAT NO ONE'S VIN #S MATCH WITH THE RECALLED VEHICLES. YET AGAIN, OVER 2000+ RECENT COMPLAINTS ON NHTSA WEBSITE AS WELL! THIS IS RIDICULOUS - ALMOST 2 YEARS LEFT TO PAY ON MY LOAN AND MY VEHICLE DOESN'T MATCH THE VIN FOR THE RECALL - WHEN OBVIOUSLY, YES IT [XXX] WELL DOES! I HAD TO CALL FOR HELP BECAUSE I'M TOO PREGNANT TO FORCEFULLY MANHANDLE THE WHEEL THAT BARELY TURNS 2 INCHES TO EITHER SIDE, TO TRY AND STEER A VEHICLE WITH NO POWER STEERING! LUCKILY WE HAD FAMILY IN FROM OUT OF TOWN WHO EVACUATED FROM THE BEACH THAT COULD HELP US GET THE CAR HOME. WOULD FORD BE PAYING FOR MY ACCIDENT AND INJURIES TO POTENTIALLY 2 BECAUSE, AGAIN I'M PREGNANT - AND THEN ANYONE ELSE I COULD HAVE HIT ON MY EXIT! THIS IS RELATED TO AN OBVIOUS ONGOING ELECTRONIC FAILURE! THIS NEEDS TO BE ADDRESSED & FIXED NOW! INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #11254065
139,500 miles · Sep 6, 2019
Electronic Stability Control (esc)Steering
MY CAR WAS 100% FINE WHEN I DROVE TO WORK AND 3 HOURS LATER WHEN I WAS DRIVING FOR LUNCH THERE WAS A MESSAGE THAT THERE WAS A POWER STEERING ASSIST FAULT. THANKFULLY I WAS NOT IN A BUSY AREA BECAUSE I COULD BARELY CRANK MY WHEEL TO TURN. THERE IS A RECALL FOR 2011 FORD FUSIONS BUT MY VIN WAS NOT INCLUDED. YET WITH NO INDICATORS …
Read full complaint
MY CAR WAS 100% FINE WHEN I DROVE TO WORK AND 3 HOURS LATER WHEN I WAS DRIVING FOR LUNCH THERE WAS A MESSAGE THAT THERE WAS A POWER STEERING ASSIST FAULT. THANKFULLY I WAS NOT IN A BUSY AREA BECAUSE I COULD BARELY CRANK MY WHEEL TO TURN. THERE IS A RECALL FOR 2011 FORD FUSIONS BUT MY VIN WAS NOT INCLUDED. YET WITH NO INDICATORS MY POWER STEERING DOES NOT WORK.
NHTSA ODI #11253716
191,250 miles · Sep 1, 2019
Electronic Stability Control (esc)Power TrainVehicle Speed Control
WHILE TAKING A ONE LANE EXIT ON THE FREEWAY GOING AT 30 MILES PER HOUR A WRENCH LIGHT CAME ON AND MY CAR COMPLETELY LOSS POWER. THE CAR COASTED UNTIL IT CAME TO A COMPLETE STOP. THIS WAS VERY DANGEROUS! I COULD HAVE DIED. YOU GUYS REALLY NEED TO GET ALL OF THERE FORD FUSIONS OFF OF THE ROAD. I COULD NOT ACCELERATE OR BRAKE TO SL…
Read full complaint
WHILE TAKING A ONE LANE EXIT ON THE FREEWAY GOING AT 30 MILES PER HOUR A WRENCH LIGHT CAME ON AND MY CAR COMPLETELY LOSS POWER. THE CAR COASTED UNTIL IT CAME TO A COMPLETE STOP. THIS WAS VERY DANGEROUS! I COULD HAVE DIED. YOU GUYS REALLY NEED TO GET ALL OF THERE FORD FUSIONS OFF OF THE ROAD. I COULD NOT ACCELERATE OR BRAKE TO SLOW ON THE FREEWAY. I WAITED 5 MINUTES AND THE CAR TURNED ON WITH NO PROBLEM. MY MECHANIC COULD NOT REPLICATE THE PROBLEM SO HE SAID THERE WAS NO PROBLEM. WHILE LOOKING ONLINE THIS IS A THROTTLE BODY ISSUE. WHICH NEEDS TO BE RECALLED IMMEDIATELY. I CAN'T WORK IF I CAN'T GET THERE WITH A CAR THAT I'VE PURCHASED!!! I REFUSE TO DRIVE THIS CAR!
NHTSA ODI #11252656
240,000 miles · Aug 12, 2019
Electronic Stability Control (esc)Steering
DRIVING ON THE HIGHWAY WHEN THE POWER ASSIST STEERING FAILURE MESSAGE AND ADVANCE TRAC SERVICE MESSAGE CAME ON WITH AN ALARM. I PULLED OFF THE HIGHWAY AND DISCOVERED MANUAL ONLY STEERING AND IT WAS VERY VERY DIFFICULT TO TURN THE WHEEL TO PULL INTO A PARKING LOT AND ALMOST CRASHED. IF I HAD TO QUICKLY SWERVE TO AVOID ANYONE I W…
Read full complaint
DRIVING ON THE HIGHWAY WHEN THE POWER ASSIST STEERING FAILURE MESSAGE AND ADVANCE TRAC SERVICE MESSAGE CAME ON WITH AN ALARM. I PULLED OFF THE HIGHWAY AND DISCOVERED MANUAL ONLY STEERING AND IT WAS VERY VERY DIFFICULT TO TURN THE WHEEL TO PULL INTO A PARKING LOT AND ALMOST CRASHED. IF I HAD TO QUICKLY SWERVE TO AVOID ANYONE I WOULD HAVE CRASHED. I HAD THIS VEHICLE SERVICED WHEN I WAS NOTIFIED OF THE 15S18 RECALL AND FORD SERVICE ONLY REPROGRAMMED THE STEERING MODULE. THEY DID NOT REPLACE THE UNIT. I RETURNED THE VEHICLE BACK TO FORD SERVICE AFTER THIS INCIDENT AND THEY STATED THAT THE ELECTRONIC POWER ASSIST STEERING GEAR HAD FAILED.
NHTSA ODI #11243193
40,000 miles · Jul 29, 2019
Electronic Stability Control (esc)Service Brakes
WHILE DRIVING APPROXIMATELY 10 MPH ON A CITY STREET, THE CAR'S ABS SYSTEM RANDOMLY FAILED. THE BRAKES DID NOT WORK UNTIL DEPRESSED ALMOST COMPLETELY, AND NOT WELL. WHEN BROUGHT TO THE MECHANIC, COMPUTER CODE INDICATED INTERNAL ELECTRONIC FAILURE. RESEARCHING ONLINE, THIS SEEMS TO BE A KNOWN PROBLEM WITH FUSION HYBRIDS BUT HAS NO…
Read full complaint
WHILE DRIVING APPROXIMATELY 10 MPH ON A CITY STREET, THE CAR'S ABS SYSTEM RANDOMLY FAILED. THE BRAKES DID NOT WORK UNTIL DEPRESSED ALMOST COMPLETELY, AND NOT WELL. WHEN BROUGHT TO THE MECHANIC, COMPUTER CODE INDICATED INTERNAL ELECTRONIC FAILURE. RESEARCHING ONLINE, THIS SEEMS TO BE A KNOWN PROBLEM WITH FUSION HYBRIDS BUT HAS NOT BEEN ADDRESSED BY FORD IN A RECALL. THE PROBLEM SEEMS TO BE INTERMITTENT AND POSSIBLY RELATED TO A SOFTWARE GLITCH.
NHTSA ODI #11240308
136,000 miles · Jul 29, 2019
Electronic Stability Control (esc)SteeringWheels
I WAS ON THE INTERSTATE DRIVE WHEN THE VEHICLE'S POWER STEERING WHEEL LOST FULL FUNCTIONALITY. I WAS UNABLE TO STEER LEFT OR RIGHT WITHOUT THERE BEING A STRAIN. I WAS NEARLY 1 HOUR AWAY FROM THE NEAREST MECHANIC SHOP AND WAS FORCED TO MANUALLY OVERRIDE THE STEERING WHEEL'S CONTROL IN ORDER TO ARRIVE AT A MECHANIC SHOP NEAREST TO…
Read full complaint
I WAS ON THE INTERSTATE DRIVE WHEN THE VEHICLE'S POWER STEERING WHEEL LOST FULL FUNCTIONALITY. I WAS UNABLE TO STEER LEFT OR RIGHT WITHOUT THERE BEING A STRAIN. I WAS NEARLY 1 HOUR AWAY FROM THE NEAREST MECHANIC SHOP AND WAS FORCED TO MANUALLY OVERRIDE THE STEERING WHEEL'S CONTROL IN ORDER TO ARRIVE AT A MECHANIC SHOP NEAREST TO MY DESTINATION.
NHTSA ODI #11240242
Official recalls
7Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.
Feb 16, 2021
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Additional source detail variants (3)
Air Bags:frontal:passenger Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal:driver Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Jan 7, 2019
Ford Motor Company (Ford) is recalling certain 2014 Ford Mustang vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Ford is recalling certain 2011 Ford Ranger and Mercury Milan vehicles, 2011-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles and 2011-2014 Ford Mustang vehicles sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Ford is also recalling certain 2010 Ford Edge and Lincoln MKX vehicles, 2010-2011 Ford Ranger and Mercury Milan vehicles, 2010-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles, and 2010-2014 Ford Mustang vehicles sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 13, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall 19S01.
May 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
Nov 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2010-2011 Ford Fusion vehicles manufactured July 21, 2008, to March 4, 2011, and 2010-2011 Mercury Milan vehicles manufactured July 23, 2008, to December 10, 2010. The affected vehicles have fuel vapor canisters whose purge valves may not operate properly resulting in abnormal pressure changes in the fuel tank.
Consequence & remedy
Consequence: The pressure changes may cause the tank to crack and leak fuel. A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will update the vehicle powertrain control modules and inspect the vehicle for any diagnostic trouble codes (DTCs) for this issue and perform a leak test on the Canister Purge Valve (CPV). The fuel tank will be inspected for cracks. The CPV and fuel tank will be replaced as necessary. These repairs will be performed free of charge. The recall began on January 15, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S34.
Jun 2, 2015
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S18.
Dec 7, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2010-2011 FORD FUSION AND MERCURY MILAN VEHICLES EQUIPPED WITH 17 INCH STEEL WHEELS AND BUILT FROM APRIL 1, 2009, THROUGH APRIL 30, 2009, AND FROM DECEMBER 1, 2009, THROUGH NOVEMBER 13, 2010. THE WHEEL STUDS MAY FRACTURE, POTENTIALLY CAUSING A WHEEL TO SEPARATE.
Consequence & remedy
Consequence: WHILE DRIVING, MULTIPLE STUD FRACTURES COULD OCCUR AT THE WHEEL LOCATION, AND THE OPERATOR MAY EXPERIENCE VEHICLE VIBRATION AND/OR WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE REAR BRAKE DISC SURFACE FOR FLATNESS AND REPLACE THE DISCS AS NECESSARY. ADDITIONALLY, THE WHEEL LUG NUTS WILL BE REPLACED ON ALL FOUR WHEELS. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JANUARY 24, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA17004 · Power Steering Failure
Opened Nov 20, 2017 · Closed Feb 9, 2024
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System; Steering:rack And Pinion; Steering:rack And Pinion:rack
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (4)
Steering:electric Power Assist System
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:rack And Pinion
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:rack And Pinion:rack
On September 28, 2016, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE16-011) to investigate claims of power steering assist loss on model year (MY) 2010 Ford Fusion vehicles. During the PE, ODI received 718 unique claims related to the alleged problem with 598 reports indicating the power steering assist failed while driving at various speeds with no warning. Ford Motor Company (Ford) provided 1,851 unique reports and 1,720 warranty claims related to the alleged problem. It should be noted that as the result of investigation PE14-030, Ford conducted a safety recall (15V-340) ofMY 2011-2012 Ford Fusion and other vehicles using the same electric power assist steering unit to rectify incidents of loss of power steering assist. On November 20, 2017, PE16-011 was upgraded to this Engineering Analysis (EA17-004) to further assess the scope, frequency, and consequence of this failure. This was based on an analysis of the subject vehicle complaint data that had indicated an increased likelihood of failure as the vehicles age. At the time, the rate of occurrence of this failure was comparable to previous investigations involving loss of power steering assist including the previously mentioned PE14-030. During the EA, ODI’s analysis of the alleged defect in the subject vehicles identified the following: testing showed minor steering effort changes between “assist” and “no assist”, no root cause identified, a declining failure trend, the ramp-down or reduced assist provided when a DTC is set, a lower failure rate than the recalled Fusion vehicles, and the high age of the vehicles. A safety-related defect trend has not been identified. Accordingly, this Engineering Analysis is closed. See the attached Engineering Analysis Closing Report for details. The closing of this investigation does not constitute a finding by NHTSA that a safety defect does not exist, and ODI will take further actions if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE14030 · Electric Power Steering Failure
Opened Oct 2, 2014 · Closed Sep 10, 2015
Status: closed (inferred from source dates) · Steering:electric Power Assist System
The Office of Defects Investigation (ODI) opened a preliminary evaluation to investigate complaints of the loss of power steering while driving. The subject vehicles are equipped with a rack mounted Electric Power Assisted Steering (EPAS) unit.Some of the complaints alleged that the steering assist failed and resulted in increased steering efforts that contributed to a loss of control and in some cases a crash.The EPAS system was manufactured by TRW Automotive for Ford and was designated as Generation I.These units were first produced and put into vehicle production in July 2008 beginning with the model year (MY) 2010 Ford Fusion and Mercury Milan.The system is comprised of a mechanical steering rack-and-pinion gear with torque sensor, electric assist motor, motor position sensor and a power steering control module (PSCM). The PSCM is self-monitoring and designed to detect faults within the system and can store diagnostic trouble codes (DTCs) if a problem is detected.There are 29 potential DTCs the system can detect.Many of these allow the system to go into reduced-assist steering mode by using the default vehicle speed signal should the live speed signal be lost, if voltage to EPAS system falls below 10.7 or goes above 17 volts, the temperature at the PSCM goes above 105C (221F), or if high friction is detected.Some DTCs will cause the system to go into manual steering mode (no assist). On July 1, 2015, Ford filed a Defect Information Report (DIR) identifying a safety related defect in TRW GEN I EPAS systems installed in some of the subject vehicles (NHTSA Recall 15V-340, Ford No. 15S18).The DIR indicated that intermittent electrical connections caused by quality issues associated with conformal coat contamination and ribbon cable pin misalignment within the steering gear motor may lead to a loss of the motor position sensor signal, resulting in a sudden loss of power assist while driving.The recall covers approximately 393,623 vehicles built from September 2010 through February 2012:2011-12 Fusion built SEP 2010 - FEB 2012; 2011-12 Lincoln MKZ built SEP 2010 - FEB 2012; 2011 Milan built SEP 2010 - DEC 2010; 2011-13 Taurus built SEP 2010 - FEB 2012; 2011-13 Flex with 3.5L GTDI engine built SEP 2010 - FEB 2012; and 2011-13 MKS, MKT with 3.5L GTDI engine built SEP 2010 - FEB 2012.The repair consists of updating the PSCM software to prevent a loss of steering assist while driving. The revised software will provide audible and visual warnings to the driver. If one or more of the following DTCs are stored, C1B00-62, C200B-2F, C200B-61, C200B-62, C200C-2F, C200D-49, U0300-00, U2011-49, U2011-61, U3000-46, U3000-49, U3000-61, U3000-72, U3000-96, P07AE-09, the dealer will replace the EPAS system at no charge to the owner.ODI's analysis of failure data for this PE identified a total of 2,584 complaints to ODI and Ford and 9,967 Ford warranty claims related to the alleged defect.The recalled vehicles account for 1,634 of the complaints and 7,311 of the warranty claims.ODI's analysis identified 40 complaints alleging crashes that may be related to loss of steering assist while driving, 20 of which involved vehicles included in Ford's recall.The information available for the alleged crashes were not sufficient to assess specific causes of the incidents or to verify EPAS malfunctions in each case.Most of the crashes were low-speed impacts with curbs or roadside objects resulting in wheel or minor body damage.None of the injury claims indicated medical attention was required.In addition, statistical modeling of the failure data by NHTSA's National Center for Statistics and Analysis projected 10-year failur
PE13003 · Electronic Throttle Body Malfunction
Opened Feb 21, 2013 · Closed Feb 28, 2014
Status: closed (inferred from source dates) · Engine
On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles. During this investigation, Ford identified a condition in subject vehicles equipped with 2.5L and 3.0L engines that may result in a sudden reduction of engine power.According to Ford, the ETB internal motor contacts may develop a high resistance material buildup condition on the commutator, resulting in intermittent electrical connectivity and reduced engine power. When this condition occurs, the Malfunction Indicator Lamp (MIL) or Wrench light will illuminate and the vehicle may enter a limited limp home mode.Ford?s trade name for the feature is Failure Mode Effects Management (FMEM) mode.In this mode, engine power and vehicle speed are reduced, while full function of the power steering, power braking, lighting, and climate control systems are maintained.ODI?s complaint analysis indicate that the predominant failure mode involved reduced motive power associated with the limited limp home mode with engine speeds limited to approximately 900 RPM. Analysis of warranty claims provided by Ford identified 59,807 claims related to ETB replacements and approximately 50 percent of claims are associated with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed.Ford described several factors where the ETB motor may fail resulting in DTCs P2111 or P2112 but the failure is not an existing stuck open or closed ETB valve position.According to Ford, the ETB control strategy provides the driver with three FMEM modes that allow varying degrees of vehicle mobility depending on the severity of the fault detected.DTCs associated with stuck open or closed throttle valves are designated the highest failure severity resulting in engine speeds limited to high idle corresponding to the limited limp home mode.Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability.Other FMEM limp modes may result in reduced engine performance but will maintain vehicle speed above 20mph. During this investigation, Ford and its suppliers, Delphi and Igarashi, updated the powertrain control module (PCM) software to include a throttle body motor cleaning cycle during key-on and modified the ETB internal motor components design, surface finish and material composition to improve durability. Additionally, Ford developed a remedy procedure and issued a special Customer Satisfaction Program (CSP) 13N03 extending the ETB warranty coverage and instructing dealers to update the powertrain calibration to improve vehicle performance in the event that intermittent electrical connectivity of the throttle body motor contacts occurs. The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle, all vehicles are eligible for the program through January 31, 2015 regardless of mileage.Owners of the affected vehicles will be contacted by mail to take their vehicle to a Ford dealer who will reprogram the PCM to the latest calibration. The bulletin was sent to dealers on January 17, 2014 and the owner letter mailing began on January 27, 2014. See the investigative file for copies of Ford's bulletin and owner letter. This preliminary evaluation is closed. The closing of this investigation does not constitute a finding that
EA12009 · Floor Mat Interference With Accelerator
Opened Dec 12, 2012 · Closed Jun 12, 2014
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
Vehicle Speed Control
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated clockwise.Both the single- and double-clip (Figure 2) all-weather floor mats may interfere with the accelerator pedal return to idle when the mats are not secured by the retention clip(s).Testing showed that this can occur if the mats are moved forward from the clipped position approximately two inches into a position in which the rear edge of the mats will abut the retention clip(s) when installed singly and align with the clip(s) when stacked on another floor mat.The pedal interference incidents reviewed by the Office of Defects Investigation (ODI) include 1 crash and 9 incidents with allegations of brake friction materials smoking and/or requiring repair for heat related damage.The crash incident occurred after the parking brake was applied at speed, resulting in loss-of-control vehicle yaw event caused by lock-up of the rear tires.The spin-out resulted in a side impact collision with an oncoming vehicle in an opposing lane of traffic. For the 29 incidents with sufficient information available to make an assessment; 23 (79%) were controlled by the driver either shifting to neutral, turning the engine off, or both; 4 (14%) were ended by the driver either kicking the pedal free (2) or pulling the mat away from the pedal (2); and 2 (7%) were ended by the pedal freeing itself from the mat with no apparent driver action.None of the drivers who reacted to the incident by shifting to neutral or turning the engine off reported any difficulties with either action.The subject mats were sold by Ford and Lincoln dealers directly to customers as an optional accessory equipment item or, beginning in November 2007, the mats were also available as a factory installed accessory if ordered with a new vehicle.Ford estimates that approximately 82,579 affected driver's side all weather floor mats were sold worldwide; either over the counter through Ford dealerships or as original equipment.Owners that purchased the subject all-weather floor mats as a factory installed accessory with their new vehicle will be notified to return their all weather floor mats to their Ford or Lincoln Dealership in exchange for replacement mats.Owners of all other potentially affected vehicles will be notified that, if they have an affected Ford driver's side all weather floor mat, they should return their mats to the dealership in exchange for replacement mats.The VOQs associated with the closing of this investigation are: 10327597, 10332233, 10334211, 10335336, 10339330, 10348772 (and duplicate 10342572), 10372674, 10379562, 10415911, 10426255, 10434107, 10521053, 10554966.This investigation is hereby closed.
Illustration