IllustrationWHILE DRIVING HOME THROUGH THE VILLAGE AT UNDER 30MPH, SLOWING DOWN FROM 30MPH BECAUSE OF TRAFFIC STOP AHEAD, THE RIGHT FRONT SIDE OF VEHICLE CRASHED DOWN AND CONTROL WAS LOST CAUSING ME TO SIDESWIPE PARKED VEHICLE. THE PIECES OF THE FRONT END APPEAR TO HAVE FAILED AND WERE FALLING ALL OVER THE ROAD.
2014 Ford Focus
Owner reports · Recalls · Investigations
More warning signs than most Focus years
Owner complaints for the 2014 Ford Focus are substantially higher than the model-year median of 864.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Focus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
6600–25K
33425–50K
36450–75K
28375–100K
234100–150K
62150K+
1,937 reports with mileage · 664 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 1,576 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 442 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 298 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
68 crash reports9 fire reports38 injury reports
Steering complaints
221 reports2014 FORD FOCUS POWER STEERING ISSUE WHILE DRIVING THIS VEHICLE THE POWER STEERING FAILED WHILE MAKING A RIGHT TURN ON A BUSY ROADWAY IN A URBAN AREA. THE STEERING WHEEL LOCKED IN THE TURNING POSITION AND THE POWER STEERING ASSIST WARNING LIGHT CAME ON. I HAD TO PUT THE VEHICLE IN PARK AND TURN THE IGNITION OFF. I TURNED THE I…
Read full complaint
2014 FORD FOCUS POWER STEERING ISSUE WHILE DRIVING THIS VEHICLE THE POWER STEERING FAILED WHILE MAKING A RIGHT TURN ON A BUSY ROADWAY IN A URBAN AREA. THE STEERING WHEEL LOCKED IN THE TURNING POSITION AND THE POWER STEERING ASSIST WARNING LIGHT CAME ON. I HAD TO PUT THE VEHICLE IN PARK AND TURN THE IGNITION OFF. I TURNED THE IGNITION BACK ON AND PUT THE VEHICLE IN DRIVE AND THE VEHICLE'S POWER STEERING FAILED ONCE MORE AND THE STEERING WHEEL LOCKED A SECOND TIME. I ONCE AGAIN PUT THE VEHICLE IN PARK AND TURNED OFF THE IGNITION AND REMOVED THE KEY. I WAITED SEVERAL SECONDS AND STARTED THE IGNITION, PLACED THE VEHICLE IN DRIVE AND THE VEHICLE ONCE AGAIN FAILED. I HAD THE CAR TAKEN TO THE DEALERSHIP FOR SERVICING AND WAS TOLD THAT THIS IS A COMMON ISSUE THIS VEHICLE HAS AND IT WOULD TAKE SEVERAL WEEKS TO REPAIR DUE TO THE VOLUME OF REPAIRS THIS DEALERSHIP HAS AT THE MOMENT. I HAD THIS SAME VEHICLE REPAIRED SEVERAL MONTHS AGO FOR THE TRANSMISSION ISSUE THAT IS CURRENTLY UNDER RECALL. THE CAR PERFORMED FAIRLY WELL AFTER THE REPAIR. THE SAME HESITATION ISSUE BEGAN AGAIN A FEW WEEKS AGO AND NOW THIS ISSUE AROSE AS WELL. I ASKED THE DEALER IF THIS TOO WOULD BE COVERED UNDER THE RECALL / WARRANTY AND WAS TOLD THE TRANSMISSION WAS BUT THEY DID NOT KNOW IF THE POWER STEERING ISSUE WAS BUT WOULD GET ME AN ANSWER FROM FORD. I'VE READ ALL THE OTHER COMPLAINTS REGARDING THIS VEHICLES ISSUES AND MY EXPERIENCE IS THE EXACT SAME. THERE'S NO DOUBT IN MY MIND THAT FORD IS WELL AWARE OF THIS ISSUE JUDGING ON HOW MANY FORMAL COMPLAINTS HAVE BEEN ISSUED. I WILL BE LETTING GO OF THIS VEHICLE WHEN IT IS REPAIRED. I WILL NOT OPERATE THIS 2014 FORD FOCUS IN GOOD CONSCIENCE KNOWING FULL WELL THAT IT PRESENTS A SIGNIFICANT LIABILITY TO MY SAFETY AND THE SAFETY OF OTHERS.
MY DAUGHTER WAS DRIVING HER NEW/USED FORD FOCUS INTO TOWN AND THE EPAS--POWER STEERING ASSIST FAULT CODED AND SHE HAD NO POWER STEERING. SHE WAS GOING ROUGHLY 55 AND SHE COULD NOTICE IT BECOMING HARDER TO STEER. BY THE TIME SHE MADE IT SO A PARKING LOT FOR SAFETY IT WAS CLOSE TO NON-STEERABLE. IT BECAME HARD FOR HER TO STEER …
Read full complaint
MY DAUGHTER WAS DRIVING HER NEW/USED FORD FOCUS INTO TOWN AND THE EPAS--POWER STEERING ASSIST FAULT CODED AND SHE HAD NO POWER STEERING. SHE WAS GOING ROUGHLY 55 AND SHE COULD NOTICE IT BECOMING HARDER TO STEER. BY THE TIME SHE MADE IT SO A PARKING LOT FOR SAFETY IT WAS CLOSE TO NON-STEERABLE. IT BECAME HARD FOR HER TO STEER AND LUCKILY SHE DID NOT HAVE OR CAUSE AND ACCIDENT WITH THE SUDDEN CHANGE. SHE TRIED TO ASSESS WHAT WAS WRONG WHICH IS WHEN WE LEARNED THERE IS NO POWERSTEERING FLUID AS IT HAS AND ELETRIC STEERING ASSIST INSTEAD. IT DOESN'T WORK NOW AND SHORTLY AFTER THIS CODE FAULTED THE ENTIRE CAR SHUT DOWN. IT WON'T START AND IS USELESS--FORD REPLACED A PERFECTLY GOOD STEERING SYSTEM WITH CRAP. I HOPE NOBODY GETS HURT BE THIS DEFECTIVE SYSTEM.
TL* THE CONTACT OWNS A 2014 FORD FOCUS. THE CONTACT STATED WHILE THE VEHICLE WAS OPERATED AT NORMAL SPEEDS AND IT EXPERIENCED A LOSS OF POWER STEERING. THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE TOWED TO CHAPMAN FORD WHERE IT WAS DIAGNOSED THE STEERING COLUMN NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIE…
Read full complaint
TL* THE CONTACT OWNS A 2014 FORD FOCUS. THE CONTACT STATED WHILE THE VEHICLE WAS OPERATED AT NORMAL SPEEDS AND IT EXPERIENCED A LOSS OF POWER STEERING. THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE TOWED TO CHAPMAN FORD WHERE IT WAS DIAGNOSED THE STEERING COLUMN NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE HOWEVER, NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS APPROXIMATELY 31,000.
TL* THE CONTACT OWNS A 2014 FORD FOCUS. THE CONTACT STATED THAT THE STEERING WHEEL SHOOK WHILE DRIVING AT LOWER SPEEDS. THE CONTACT TOOK THE VEHICLE TO THE FOOTHILL FORD DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING CLUTCH FAILED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE CLUTCH WAS REPLACED TWICE UNDER WARRANTY; H…
Read full complaint
TL* THE CONTACT OWNS A 2014 FORD FOCUS. THE CONTACT STATED THAT THE STEERING WHEEL SHOOK WHILE DRIVING AT LOWER SPEEDS. THE CONTACT TOOK THE VEHICLE TO THE FOOTHILL FORD DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING CLUTCH FAILED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE CLUTCH WAS REPLACED TWICE UNDER WARRANTY; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE REPAIR WAS NO LONGER COVERED UNDER WARRANTY. THE CONTACT WAS REFERRED TO NHTSA TO FILE A COMPLAINT AND WAS ADVISED TO REFERENCE NHTSA CAMPAIGN NUMBER: 14V514000 (STEERING) AS THE CAUSE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 56,000. UPDATED 08/23/17*LJ *TR
UPON STARTUP NO POWER STEERING, MAKING STEERING EXTREMELY DIFFICULT. DASHBOARD MESSAGE STATING "ELECTRONIC STEERING ASSIST FAULT NEEDS SERVICE NOW" DIAGNOSIS CAME BACK STEERING GEAR IS BAD. CLASS ACTION HAS BEEN FILED FOR 2012-14 FORD FOCUS AS WELL AS 2010-2014 FORD FUSION SO IT IS A KNOWN ISSUE BUT STILL NO ASSISTANCE BY FORD.
BOUGHT A 2014 FORD FOCUS 1/17/16AND 6 MONTHS AFTER OWNING IT, THE VEHICLE SHUDDERED WHEN TAKING OFF AT A GREEN LIGHT, HAD LOST POWER AROUND CORNERS. GOT A RECALL NOTICE JUNE 2016 GOT A NEW CLUTCH AND TRANSMISSION POWER TRAIN. JANUARY 2017 PROBLEM PERSISTED BROUGHT IT BACK TO THE DEALER THEY SAID ITS OVER 60,000 WARRANTY AND HAV…
Read full complaint
BOUGHT A 2014 FORD FOCUS 1/17/16AND 6 MONTHS AFTER OWNING IT, THE VEHICLE SHUDDERED WHEN TAKING OFF AT A GREEN LIGHT, HAD LOST POWER AROUND CORNERS. GOT A RECALL NOTICE JUNE 2016 GOT A NEW CLUTCH AND TRANSMISSION POWER TRAIN. JANUARY 2017 PROBLEM PERSISTED BROUGHT IT BACK TO THE DEALER THEY SAID ITS OVER 60,000 WARRANTY AND HAVE TO PAY CASH FOR THE TRANSMISSION REPAIR . COULD NOT DRIVE THE CAR SAFELY IT WOULD NOT SHIFT. BROUGHT IT BACK WITHOUT RECALL NOTICE JUNE 20, 2017, AND THE DEALER SAID THEY WILL FILE A 360 ON REPAIR OF THE CLUTCH. WAITING FOR THE DEALER TO CALL NOW 6/21/17 . I NEED A RELIABLE CAR FOR WORK AND MY FAMILY AND CAN NOT DRIVE THIS CAR. SO SCARED DRIVING IT 3/4 CLOSE CALLS AND REAR ENDS. IT SITS AS I PAY FOR IT EVERY MONTH.
ELECTRIC FAILURE OF POWER STEERING. I WAS TOLD THAT THERE WAS A "SHORT" THAT CAUSED THE POWER STEERING MECHANISM TO FAIL. LESS THAN 3 YEARS AND 48K MILES. SUDDEN FAILURE WITH TOTAL LOSS OF POWER STEERING.
2014 FORD FOCUS. CONSUMER WRITES IN REGARDS TO AIRBAG SAFETY RECALL AND TRANSMISSION PROBLEMS. *LD UPDATED 05/1/2017*JS
AFTER BEING STALLED IN TRAFFIC FOR OVER AN HOUR I PULLED INTO A GAS STATION AND STARTED MY VEHICLE TO LEAVE. IMMEDIATELY I COULD FEEL SOMETHING WRONG WITH MY STEERING AND MY ALERT POPPED ON AND SAID PEER STEERING ASSIST WARNING. CALLED DEALERSHIP AND THEY SAID IT'S A COMMON FOR THE ELECTRIC COMPONENT TO FAIL AFTER IDLING. THEY …
Read full complaint
AFTER BEING STALLED IN TRAFFIC FOR OVER AN HOUR I PULLED INTO A GAS STATION AND STARTED MY VEHICLE TO LEAVE. IMMEDIATELY I COULD FEEL SOMETHING WRONG WITH MY STEERING AND MY ALERT POPPED ON AND SAID PEER STEERING ASSIST WARNING. CALLED DEALERSHIP AND THEY SAID IT'S A COMMON FOR THE ELECTRIC COMPONENT TO FAIL AFTER IDLING. THEY SAID THAT'S THIS HAS HAPPENED TO PEOPLE AS THEY ARE DRIVING. STEERING JUST FAILS. THEY SAID IT WAS A FUSE THAT OVERHEATS AFTER IDLING FOR SO LONG WITHOUT WARNING. IF THIS IS A COMPONENT THAT FAILS THAT AFFECTS STEERING IT NEEDS TO BE FIXED AND CHANGED.
Official recalls
1226V369000 · Fuel System, Gasoline:storage:evaporative Emissions:canister
Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2012-2018 Focus vehicles previously repaired incorrectly under recall number 18V735. The Canister Purge Valve (CPV) may malfunction, causing the engine to stall unexpectedly while driving.
Consequence & remedy
Consequence: An engine that stalls while driving increases the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed July 29, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S40. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6,2026.
26V011000 · Equipment:electrical:engine Block Heater
Jan 15, 2026
Ford Motor Company (Ford) is recalling certain 2013-2018 Focus, 2013-2019 Escape, and 2015-2016 MKC vehicles equipped with a 2.0L engine. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed March 6, 2026. Additional letters will be sent once the final remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S01. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 16, 2026.
20V331000 · Latches/locks/linkages:doors:latch
Jun 8, 2020
Ford Motor Company (Ford) is recalling certain 2011-2014 Fiesta, 2013-2014 Fusion, 2015 Mustang, 2013-2015 Escape and C-Max, 2012-2015 Focus, 2014-2016 Transit Connect, 2013-2014 Lincoln MKZ, and 2015 MKC vehicles. These vehicles were previously recalled and repaired under recalls 15V-246, 16V-643 or 17V-210, however the repair may not have been completed properly. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence & remedy
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Ford will notify owners, and dealers will inspect the latch date codes to confirm if the repair was done correctly, and replace the side door latches if necessary, free of charge. Owners will also have the option to inspect their own vehicle's door latches and enter the date codes into a website to determine if the latches are correct. Owner notification letters were mailed on July 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S30.
19V515000 · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:evaporative Emissions:canister
Jul 5, 2019
Ford Motor Company (Ford) is recalling certain 2012 and 2017 Focus vehicles equipped with 2.0L GDI gasoline engines and 2013-2014 Focus ST vehicles equipped with 2.0L GTDI engines, previously recalled under 18V-735. The affected vehicles did not have the Powertrain Control Module (PCM) updated as intended. Therefore, the Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in the fuel vapor management system.
Consequence & remedy
Consequence: The excessive vacuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began July 29, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S22.
Additional source detail variants (2)
Fuel System, Gasoline:storage:evaporative Emissions:canister
Ford Motor Company (Ford) is recalling certain 2012 and 2017 Focus vehicles equipped with 2.0L GDI gasoline engines and 2013-2014 Focus ST vehicles equipped with 2.0L GTDI engines, previously recalled under 18V-735. The affected vehicles did not have the Powertrain Control Module (PCM) updated as intended. Therefore, the Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in the fuel vapor management system.
Consequence: The excessive vacuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began July 29, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S22.
Fuel System, Gasoline:storage
Ford Motor Company (Ford) is recalling certain 2012 and 2017 Focus vehicles equipped with 2.0L GDI gasoline engines and 2013-2014 Focus ST vehicles equipped with 2.0L GTDI engines, previously recalled under 18V-735. The affected vehicles did not have the Powertrain Control Module (PCM) updated as intended. Therefore, the Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in the fuel vapor management system.
Consequence: The excessive vacuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began July 29, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S22.
18V735000 · Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:evaporative Emissions:canister
Oct 22, 2018
Ford Motor Company (Ford) is recalling certain 2012-2018 Ford Focus vehicles with a 2.0L GDI or 2.0L GTDI engine. The Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in fuel vapor management system.
Consequence & remedy
Consequence: The excessive vaccuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began August 19, 2019. Owners may contact Ford Customer service at 1-866-436-7332. Ford's number for this recall is 18S32. Note: Until the vehicle is serviced for this concern, owners are advised to keep the fuel tank at least halfway full.
Additional source detail variants (2)
Fuel System, Gasoline:storage:evaporative Emissions:canister
Ford Motor Company (Ford) is recalling certain 2012-2018 Ford Focus vehicles with a 2.0L GDI or 2.0L GTDI engine. The Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in fuel vapor management system.
Consequence: The excessive vaccuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began August 19, 2019. Owners may contact Ford Customer service at 1-866-436-7332. Ford's number for this recall is 18S32. Note: Until the vehicle is serviced for this concern, owners are advised to keep the fuel tank at least halfway full.
Fuel System, Gasoline:storage
Ford Motor Company (Ford) is recalling certain 2012-2018 Ford Focus vehicles with a 2.0L GDI or 2.0L GTDI engine. The Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in fuel vapor management system.
Consequence: The excessive vaccuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the Powertrain Control Module. Dealers will also check for fault codes and replace the CPV as needed. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. The recall began August 19, 2019. Owners may contact Ford Customer service at 1-866-436-7332. Ford's number for this recall is 18S32. Note: Until the vehicle is serviced for this concern, owners are advised to keep the fuel tank at least halfway full.
16V698000 · Latches/locks/linkages:hatchback/liftgate:lock; Structure:body:hatchback/liftgate
Sep 28, 2016
Ford Motor Company (Ford) is recalling certain model year 2013-2017 Ford Focus hatchback vehicles manufactured February 14, 2012, to August 26, 2016 and equipped with a manual transmission. The hatchback of the affected vehicles may be unlatched with a single press of the interior latch release button. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence & remedy
Consequence: With only a single press needed, the driver may accidently unlatch the hatchback, increasing the risk of injury to any unsecured passengers in the back.
Remedy: Ford will notify owners, and dealers will reprogram the Body Control Module with updated software, free of charge. The recall began February 10, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C13.
Additional source detail variants (2)
Latches/locks/linkages:hatchback/liftgate:lock
Ford Motor Company (Ford) is recalling certain model year 2013-2017 Ford Focus hatchback vehicles manufactured February 14, 2012, to August 26, 2016 and equipped with a manual transmission. The hatchback of the affected vehicles may be unlatched with a single press of the interior latch release button. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence: With only a single press needed, the driver may accidently unlatch the hatchback, increasing the risk of injury to any unsecured passengers in the back.
Remedy: Ford will notify owners, and dealers will reprogram the Body Control Module with updated software, free of charge. The recall began February 10, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C13.
Structure:body:hatchback/liftgate
Ford Motor Company (Ford) is recalling certain model year 2013-2017 Ford Focus hatchback vehicles manufactured February 14, 2012, to August 26, 2016 and equipped with a manual transmission. The hatchback of the affected vehicles may be unlatched with a single press of the interior latch release button. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence: With only a single press needed, the driver may accidently unlatch the hatchback, increasing the risk of injury to any unsecured passengers in the back.
Remedy: Ford will notify owners, and dealers will reprogram the Body Control Module with updated software, free of charge. The recall began February 10, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C13.
16V643000 · Latches/locks/linkages:doors:latch
Sep 6, 2016
Ford Motor Company (Ford) is recalling certain model year 2012-2015 Ford Focus, 2013-2015 Ford Escape and Ford C-MAX, 2015 Lincoln MKC and Ford Mustang, and 2014-2016 Ford Transit Connect vehicles. A component within the door latches may break, preventing the doors from latching and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence & remedy
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Ford will notify owners, and dealers will replace the door latches with an improved part, free of charge. The recall began on January 27, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S30.
15V813000 · Electrical System:wiring
Dec 2, 2015
Ford Motor Company (Ford) is recalling certain model year 2013 Escape vehicles manufactured January 11, 2012, to April 1, 2013, and 2013-2014 Focus ST vehicles manufactured May 03, 2012, to October 14, 2013. Insufficient compression in the engine wiring harness splices to the Manifold Absolute Pressure (MAP) sensor may provide incorrect signals to the powertrain control module (PCM).
Consequence & remedy
Consequence: The incorrect signals could cause the vehicle to hesitate or the engine to stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the current crimped splices with new splices, free of charge. The recall began on January 7, 2016. Owners may contact Ford customer service 1-866-436-7332. Ford's number for this recall is 14S17-S1.
15V005000 · Fuel System, Gasoline:delivery:fuel Pump
Jan 9, 2015
Ford Motor Company (Ford) notified the agency on January 8, 2015, that they are recalling certain model year 2014 Ford Escape vehicles manufactured April 15, 2014, to May 8, 2014, and 2015 Lincoln MKC vehicles manufactured April 21, 2014, to May 15, 2014. On April 30, 2015, Ford expanded the recall to cover an additional 45,505 vehicles, including certain model year 2014-2015 Ford Transit Connect vehicles manufactured November 11, 2013, to August 29, 2014, 2014-2015 Ford Fiesta vehicles manufactured April 10, 2014, to June 17, 2014 and 2014 Ford Edge vehicles manufactured April 30, 2014, to May 21, 2014. Improper nickel plating of components within the fuel pump may result in the fuel pump failing.
Consequence & remedy
Consequence: If the fuel pump fails, the vehicle may stall without warning, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel pump, free of charge. The recall began on February 27, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S30.
14V525000 · Fuel System, Gasoline:delivery
Sep 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 Ford Focus vehicles manufactured May 1, 2014, to May 24, 2014, 2014 Ford Escape vehicles manufactured on June 6, 2014, and 2015 Lincoln MKC vehicles manufactured June 4, 2014, to July 7, 2014. In the affected vehicles, the Fuel Delivery Module (FDM) may crack between the filter body and the filter cap, possibly resulting in low fuel pressure.
Consequence & remedy
Consequence: A reduction in fuel pressure may result in a vehicle stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the FDM, free of charge. The recall began in September 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S20.
14V514000 · Steering
Aug 22, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 Focus and C-Max vehicles manufactured August 8, 2014, to August 15, 2014. The affected vehicles may have steering gears that were incorrectly assembled.
Consequence & remedy
Consequence: The incorrectly manufactured steering gears may cause impaired steering, including the loss of steering control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the steering gears, free of charge. The recall began on November 11, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S18.
14V495000 · Electrical System:wiring
Aug 11, 2014
Ford Motor Company (Ford) is recalling certain model year 2013-2014 Escape vehicles manufactured October 5, 2011, to April 1, 2013, and equipped with 2.0 liter engines and Focus ST vehicles manufactured February 14, 2012, to October 14, 2013, and equipped with 2.0 liter engines. Insufficient compression in the engine wiring harness splices to the Manifold Absolute Pressure (MAP) sensor may provide incorrect signals to the powertrain control module (PCM).
Consequence & remedy
Consequence: The incorrect signals could cause the vehicle to hesitate or the engine to stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the current crimped splices with new splices, free of charge. The recall began in October 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S17.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ23006 · Loss Of Motive Power
Opened Sep 15, 2023 · Closed Dec 20, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:evaporative Emissions:canister
On September 15, 2023, the Office of Defect Investigation (ODI) opened this Recall Query (RQ) after receiving 98 consumer complaints alleging loss of motive power in model year (MY) 2012-2018 Ford Focus vehicles. The RQ focused on the effectiveness of the remedies of Recall 18V-735 and 19V-515. In October 2018, Ford issued Recall 18V-735, which updated Powertrain Control Module (PCM) software in MY 2012-2018 Ford Focus vehicles equipped with 2.0L GDI engines built prior to April 13, 2017, and those with 2.0L GTDI engines built prior to February 2, 2018. The recall addressed vehicles experiencing a malfunctioning Canister Purge Valve (CPV) that can stick open and PCM software that does not adequately detect a stuck-open CPV condition. A CPV that is stuck open can cause excessive vacuum in the fuel vapor management system, potentially deforming the fuel tank, collapsing on itself. This deformation of the fuel tank can cause a Malfunction Indicator Light (MIL) to illuminate, an inaccurate or erratic fuel gauge indication, drivability issues, and/or loss of motive power. In July 2019, Ford issued Recall 19V-515, which addressed certain MY 2012 and MY 2017 Ford Focus vehicles equipped with 2.0L GDI and MY 2013-2014 Ford Focus vehicles equipped with 2.0L GTDI engines whose PCM software had been reprogrammed as a part of recall 18V-735. The updated software calibrations for these subject vehicles were not properly installed by Ford at the time of production. Approximately one year after this RQ was opened, on September 25, 2024, Ford initiated a customer satisfaction program (24N07) for MY 2012-2018 Ford Focus vehicles equipped with the 2.0L GDI and GTDI engines to—as ODI learned during this investigation—address a different issue with the CPV from the primary focus of the safety recalls (18V-735 and 19V-515). Ford stated the CPV may not operate as intended in these vehicles. A failed CPV on its own merit, may cause drivability concerns such as engine hesitation, running rough, or stalling at low speed, which will be accompanied by an illuminated MIL. This program provides a one-time replacement of the CPV for vehicles with 15 years of service or less (with no mileage restriction). This coverage will automatically transfer to subsequent owners. It is to be noted that the customer satisfaction program being taken by Ford to address this RQ investigation results in a much different and significantly less severe problem than the safety action taken to remedy 18V-735 and 19V-515. ODI found no further issues with the combined scope and severity related to 18V-735 and 19V-515 therefore, ODI is closing this Recall Query. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ19005 · Door Latch Failures
Opened Dec 19, 2019 · Closed Feb 7, 2022
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:doors:latch; Structure:body; Structure:body:door
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Additional source detail variants (8)
Latches/locks/linkages:doors:latch
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Latches/locks/linkages:doors:latch
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Latches/locks/linkages
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Latches/locks/linkages
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Structure:body:door
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Structure:body:door
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Structure:body
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
Structure:body
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl spring tab typically results in a ?door will not close? condition, however in certain somewhat rare circumstances, may result in the door coming open while driving. In response to ODI?s investigation, Ford has announced three field actions, as discussed below.On March 23, 2020, Ford submitted Safety Recall 20V-177 (Ford 20S15), a regional recall campaign to address door latch failures in vehicles not previously recalled under Safety Recalls 15V-246, 16V-643 and 17V-210. The recall affects vehicles currently or ever registered in certain high ambient temperature states (see 20V-177 for affected states). As a remedy, Ford will replace all four door latches free of charge.On August 24, 2020, Ford issued a non-safety regional field action (Ford 20R01) to address door latch failures on the same model/MY vehicles not covered under 20V-177 (i.e., not currently/ever registered in affected states). According to Ford, spring tab failure rates for vehicles covered by this action are about half that of the 20V-177 vehicles. Under this action, dealers will replace all door latches, free of charge, if either; a) the vehicle exhibits a related latch concern, or b) if the vehicle owner expresses a concern about the latches in their vehicles. Details can be found under NHTSA TSB No. 10190990, a copy of which is available in this investigative file available at NHTSA.gov.On June 8, 2020, Ford submitted Safety Recall 20V-331 (Ford 20S30) addressing vehicles previously remedied under NHTSA Recalls 15V-246, 16V-643 and 17V-210, where the repair may not have been properly completed, specifically not all of the door latches were replaced, or replaced correctly. This recall involves an inspection of the latches, with the option for a consumer self-inspection; owners could view the date codes on their latches (and confirm child safety locks are present on the rear doors) and then submit the information to Ford?s mobile app or website. A dealership inspection option was also available. Any vehicle found to have unreplaced defective latches requires the replacement of all door latches as directed by Ford.Regarding the 4,494 reports cited above, 1,485 involve scope-related failures (with 13% alleging door opening), and the remaining 3,009 reports involving remedy concerns (with 18% alleging door opening - note ODI was unable to verify the allegations of door opening). The three ODI injuries were all relatively minor. Ford?s reported injury incidences include one (unconfirmed) report of an ejection, three minor injuries with the others involving undisclosed injuries. Ford?s crashes involved two (unconfirmed) crashes alleging the incident door contacted another vehicle and three involving doors striking other property.The recalled vehicles include MY 2011-2015 Ford Fiesta, 2013-2016 Ford Fusion and Lincoln MKZ, 2015 Ford Mustang and Lincoln MKC, 2013-2015 Ford Escape and Ford C-MAX, 2012-2015 Ford Focus and 2014-2016 Ford Transit Connect.Ford's actions address ODI's concerns at this time. ODI will take further action if warranted by new information. The reference (OD
PE16001 · Door Latch Failure
Opened Jan 16, 2016 · Closed Oct 29, 2016
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:doors:latch
In January, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation based on consumers' allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2012-2013 Ford Focus vehicles (subject vehicles).ODI has received 464 unique reports related to the alleged problem, with over 200 claiming that the door(s) opened inadvertently while the vehicle was in motion.One consumer alleged an injury that occurred while driving when a door inadvertently opened and then closed on a child's arm.Another alleged that a door that inadvertently opened struck a parked vehicle.In response to ODI's information request, Ford Motor Company (Ford) provided 500 unique reports related to the alleged problem on the subject vehicles.Ford reported no injury or accident claims.Ford also submitted 1,513 warranty claims related to door latch failures.Many customers indicated that the affected door could not be latched at all and some of them decided to restrain the door by other means in order to operate the vehicle.Some customers also reported door latch failures occurring on multiple doors and at different times.Additionally, Ford stated that MY 2014-2015 Ford Focus, 2013-2015 Ford Escape, 2013-2015 Ford C-Max, 2014-2016 Ford Transit Connect, 2015 Ford Mustang, and 2015 Lincoln MKC, all use the same door latch as the 2012-2013 Ford Focus.On September 6, 2016, Ford notified ODI that it would conduct a safety recall (16V-643) to remedy the door latches in the MY 2012-2015 Ford Focus and other Ford models mentioned above (total of approximately 2 million vehicles).According to Ford, a component within the door latch may break preventing the door from latching.Ford dealers will replace all four door latches in the recalled vehicles with a new more robust latch design that is currently in production.The recall action initiated by the manufacturer appears to address the safety risks.Accordingly, this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Additional source detail variants (2)
Latches/locks/linkages:doors:latch
In January, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation based on consumers' allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2012-2013 Ford Focus vehicles (subject vehicles).ODI has received 464 unique reports related to the alleged problem, with over 200 claiming that the door(s) opened inadvertently while the vehicle was in motion.One consumer alleged an injury that occurred while driving when a door inadvertently opened and then closed on a child's arm.Another alleged that a door that inadvertently opened struck a parked vehicle.In response to ODI's information request, Ford Motor Company (Ford) provided 500 unique reports related to the alleged problem on the subject vehicles.Ford reported no injury or accident claims.Ford also submitted 1,513 warranty claims related to door latch failures.Many customers indicated that the affected door could not be latched at all and some of them decided to restrain the door by other means in order to operate the vehicle.Some customers also reported door latch failures occurring on multiple doors and at different times.Additionally, Ford stated that MY 2014-2015 Ford Focus, 2013-2015 Ford Escape, 2013-2015 Ford C-Max, 2014-2016 Ford Transit Connect, 2015 Ford Mustang, and 2015 Lincoln MKC, all use the same door latch as the 2012-2013 Ford Focus.On September 6, 2016, Ford notified ODI that it would conduct a safety recall (16V-643) to remedy the door latches in the MY 2012-2015 Ford Focus and other Ford models mentioned above (total of approximately 2 million vehicles).According to Ford, a component within the door latch may break preventing the door from latching.Ford dealers will replace all four door latches in the recalled vehicles with a new more robust latch design that is currently in production.The recall action initiated by the manufacturer appears to address the safety risks.Accordingly, this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Latches/locks/linkages
In January, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation based on consumers' allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2012-2013 Ford Focus vehicles (subject vehicles).ODI has received 464 unique reports related to the alleged problem, with over 200 claiming that the door(s) opened inadvertently while the vehicle was in motion.One consumer alleged an injury that occurred while driving when a door inadvertently opened and then closed on a child's arm.Another alleged that a door that inadvertently opened struck a parked vehicle.In response to ODI's information request, Ford Motor Company (Ford) provided 500 unique reports related to the alleged problem on the subject vehicles.Ford reported no injury or accident claims.Ford also submitted 1,513 warranty claims related to door latch failures.Many customers indicated that the affected door could not be latched at all and some of them decided to restrain the door by other means in order to operate the vehicle.Some customers also reported door latch failures occurring on multiple doors and at different times.Additionally, Ford stated that MY 2014-2015 Ford Focus, 2013-2015 Ford Escape, 2013-2015 Ford C-Max, 2014-2016 Ford Transit Connect, 2015 Ford Mustang, and 2015 Lincoln MKC, all use the same door latch as the 2012-2013 Ford Focus.On September 6, 2016, Ford notified ODI that it would conduct a safety recall (16V-643) to remedy the door latches in the MY 2012-2015 Ford Focus and other Ford models mentioned above (total of approximately 2 million vehicles).According to Ford, a component within the door latch may break preventing the door from latching.Ford dealers will replace all four door latches in the recalled vehicles with a new more robust latch design that is currently in production.The recall action initiated by the manufacturer appears to address the safety risks.Accordingly, this investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.