Illustration2000 FORD FOCUS ZX3: THE TUMBLERS OF THE IGNITION ARE JAMMED. THE KEY HAS A ROUGH TIME GOING INTO THE MECHANISM AND OFTEN GETS STUCK ON THE WAY IN OR OUT. ONCE IN, THE IGNITION WILL NOT TURN AT ALL. THE CAR NOW HAS TO BE TOWED TO BE WORKED ON. *JB
2004 Ford Focus
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Ford Focus do not stand out strongly from the model-year median of 864.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Focus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
620–25K
7725–50K
5050–75K
5575–100K
33100–150K
16150K+
293 reports with mileage · 94 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 183 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
34 crash reports13 fire reports24 injury reports
What owners actually said
387 reportsCONTINUOUS PROBLEM WITH SMELL OF GAS IN VEHICLE. EXPERIENCE BAD ACCELERATION AND CAR BURNING EXCESSIVE AMOUNTS OF GAS. *BF THE VEHICLE WOULD ALSO COAST AND STOP IN THE MIDDLE OF THE STREET. THE EMISSION SYSTEM LIGHT HAD COME ON. THERE WAS AN INCIDENT WHEN THE CONSUMER VIEWED WHITE SMOKE COMING FROM OUT OF THE MUFFLER. THE…
Read full complaint
CONTINUOUS PROBLEM WITH SMELL OF GAS IN VEHICLE. EXPERIENCE BAD ACCELERATION AND CAR BURNING EXCESSIVE AMOUNTS OF GAS. *BF THE VEHICLE WOULD ALSO COAST AND STOP IN THE MIDDLE OF THE STREET. THE EMISSION SYSTEM LIGHT HAD COME ON. THERE WAS AN INCIDENT WHEN THE CONSUMER VIEWED WHITE SMOKE COMING FROM OUT OF THE MUFFLER. THE CONSUMER WAS INFORMED THAT THE FUEL PUMP WAS THE PROBLEM. *SC
CONSUMER PLACED THE KEY INSIDE OF THE IGNITION SWITCH AND IT FAILED TO TURN THE VEHICLE ON. CONSUMER HAD TO HIT THE IGNITION SWITCH HARD IN ORDER FOR THE KEY TO COME OUT. CONSUMER CONTACTED THE DEALER FOR INSPECTION AND APPOINTMENT.*AK
WHEN BRAKING THERE WOULD BE A SQUEAKING AND A RATTLING NOISE COMING FROM THE FRONT SUSPENSION. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
THE BRAKES HAVE BEEN REPLACED 6 TIMES SINCE I PURCHASED THE CAR. THEY GO OUT EVERY 3 TO 4,000 MILES. I HIT A TREE WITH THE SIDE OF MY CAR BECAUSE I HAD NO BRAKES AT ALL AT ON POINT WHILE I WAS DRIVING. THE CAR GIVES NO WARNING WITH THE BRAKES. I TALKED TO FORD ABOUT WHO WAS GOING TO BE LIABLE IF I WRECKED AND SOMEBODY GOT HU…
Read full complaint
THE BRAKES HAVE BEEN REPLACED 6 TIMES SINCE I PURCHASED THE CAR. THEY GO OUT EVERY 3 TO 4,000 MILES. I HIT A TREE WITH THE SIDE OF MY CAR BECAUSE I HAD NO BRAKES AT ALL AT ON POINT WHILE I WAS DRIVING. THE CAR GIVES NO WARNING WITH THE BRAKES. I TALKED TO FORD ABOUT WHO WAS GOING TO BE LIABLE IF I WRECKED AND SOMEBODY GOT HURT. THEY SAY IT MY PROBLEM. I'M NOT GETTING ANYWHERE WITH THE DEALERSHIP. THEY JUST TELL ME I DON'T KNOW HOW TO DRIVE. I FEEL MY CAR IS VERY UNSAFE ON THE ROAD. I ALSO HAVE A 4YEAR OLD THAT I WON'T DARE PUT IN THE CAR. JUST FOR THE FACT THAT THERE MAY NO BRAKES WHEN I STOP. O DO ADMIT IN THE FIRST 6,000 MILES I USED IT FOR BUSINESS. THEY STATED MY JOB WAS THE CAUSE OF IT. BUT I NO LONGER USE THIS CAR FOR MY BUSINESS. AND EVERYTIME I CALL THE FORD HOTLINE ABOUT MY CAR'S BRAKE PROBLEM. THEY JUST ALSO BLAME IT ON MY JOB. I TOLD THEM I NO LONGER DO THE JOB IN THIS CAR. THEY JUST ASSUME I DO. I DO USE MY CAR FOR ERRANDS AND JUST DRIVING AROUND. *AK
WHEN PARKING A 2004 FORD FOCUS, THEY ARE DESIGNED IN A MANNER IF YOU PARK TO CLOSE TO A CURB STOP THE OIL FILTER CAN BE HIT AND KNOCKED OFF THE CAR. ALL OF THE OIL DRAINED OUT AND WITHIN LESS THAN 4 MILES THE CAR WAS INOPERABLE. FORD MOTOR LOOKED AT THE VEHICLE STILL UNDER WARRANTY AND CLAIMED THE OWNER WOULD NEED TO COME UP WIT…
Read full complaint
WHEN PARKING A 2004 FORD FOCUS, THEY ARE DESIGNED IN A MANNER IF YOU PARK TO CLOSE TO A CURB STOP THE OIL FILTER CAN BE HIT AND KNOCKED OFF THE CAR. ALL OF THE OIL DRAINED OUT AND WITHIN LESS THAN 4 MILES THE CAR WAS INOPERABLE. FORD MOTOR LOOKED AT THE VEHICLE STILL UNDER WARRANTY AND CLAIMED THE OWNER WOULD NEED TO COME UP WITH $5300 TO FIX THE CAR. THEY CLAIMED THE CONSUMER WAS LIABLE AND IT WAS HER FAULT AND NOT A DESIGN DEFECT, CLAIMING THE MOTOR FROZE AFTER 2-4 MILES AND NO OIL LIGHT EVER COMING ON. *NM
WHILE DRIVING 45 MPH APPLIED THE BRAKE PEDAL AND THE BRAKES FAILED. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND DROVE IT TO THE DEALER FOR INSPECTION. HOWEVER, THE CAUSE HAD NOT BEEN DETERMINED. *AK
WHILE AS A SOLE DRIVER AND OCCUPANT OF A 2005 FORD FOCUS, I WAS STOPPED AT A RED LIGHT AND REAR-ENDED BY A FOUR DOOR 1995 DODGE INTREPID AT A SPEED OF APPROXIMATLEY 50 MILES PER HOUR. MY DRIVER'S SEAT COLLASPED IN THE COLLISION WHICH JERKED MY NECK AND BACK INTO THE REAR SEAT. AS A RESULT MY THORASIC SPINE, CERVICAL SIPNE WAS …
Read full complaint
WHILE AS A SOLE DRIVER AND OCCUPANT OF A 2005 FORD FOCUS, I WAS STOPPED AT A RED LIGHT AND REAR-ENDED BY A FOUR DOOR 1995 DODGE INTREPID AT A SPEED OF APPROXIMATLEY 50 MILES PER HOUR. MY DRIVER'S SEAT COLLASPED IN THE COLLISION WHICH JERKED MY NECK AND BACK INTO THE REAR SEAT. AS A RESULT MY THORASIC SPINE, CERVICAL SIPNE WAS SO INJREUD AS TO CAUSE MY NECK AND BACK INCLUDING MY BOTH ARMS TO SUFFER A DEGREE OF PARALYSIS, AND INJURY TO THE UPPER SPINAL CORD. *AK
CONSUMER APPLIED THE BRAKES AND PEDAL WENT TO THE FLOOR. THE AIR BAG LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. CONSUMER DROVE THE VEHICLE TO THE DEALER FOR INSPECTION, BUT MECHANIC COULD NOT DUPLICATE THE PROBLEM. *AK
MY HUSBAND JUST PURCHASED A 2004 FORD FOCUS WAGON AND THE BACK SEAT HAS NO HEADRESTS. THIS MAKES IT USELESS BECAUSE OF THE RISK OF HEAD/NECK INJURIES SHOULD A CRASH OCCUR. SUCH A SIMPLE THING WOULD HAVE MADE SUCH A DIFFERENCE!*AK
Official recalls
105V030000 · Latches/locks/linkages:doors:latch
Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.