IllustrationDT: THE CONTACT STATED THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED THE DEALERSHIP AND IT WAS DETERMINED THE FUEL PUMP FAILED. THE FUEL PUMP AND IAC VALVE WERE REPLACED. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURES. *AK
2002 Ford Focus
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Ford Focus do not stand out strongly from the model-year median of 864.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Focus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1480–25K
13425–50K
13950–75K
8375–100K
74100–150K
26150K+
604 reports with mileage · 335 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 277 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
82 crash reports20 fire reports60 injury reports
What owners actually said
939 reports45,000 MILE CAR HAS LEAKING CLUTCH MASTER CYLINDER. CLUTCH PEDAL IS WET AND SLIPPERY WITH BRAKE FLUID. I'VE HAD TO ADD BRAKE DUE TO THE LEAK. I'M AFRAID THAT MY BRAKES WILL GO OUT OR THAT MY FOOT WILL SLIP OFF OF THE CLUTCH PEDAL. I STILL HAVN'T HAD IT FIXED YET BECAUSE THE REPLACEMENT PART WILL LIKELY FAIL ALSO. IT'S A COM…
Read full complaint
45,000 MILE CAR HAS LEAKING CLUTCH MASTER CYLINDER. CLUTCH PEDAL IS WET AND SLIPPERY WITH BRAKE FLUID. I'VE HAD TO ADD BRAKE DUE TO THE LEAK. I'M AFRAID THAT MY BRAKES WILL GO OUT OR THAT MY FOOT WILL SLIP OFF OF THE CLUTCH PEDAL. I STILL HAVN'T HAD IT FIXED YET BECAUSE THE REPLACEMENT PART WILL LIKELY FAIL ALSO. IT'S A COMMON PROBLEM ACCORDING TO THE DEALER I TOOK IT TO FOR AN ESTIMATE. *NM
I PURCHASED MY 2002 FORD FOCUS IN JANUARY OF 2005. I LOVE MY CAR, HAVE FOUND OUT ABOUT OF THINGS THAT COULD GO WRONG LATER. RIGHT NOW I AM HAVING TROUBLE WITH MY FRONT WHEELS. I HAVE PUT SIX USED TIRES ON THE FRONT SINCE I PURCHASED THE FOCUS. IN NOVEMBER I HAD TWO BRAND NEW TIRES PUT ON PLUS IN MAY I HAVE HAD A WHEEL ALIGNMENT …
Read full complaint
I PURCHASED MY 2002 FORD FOCUS IN JANUARY OF 2005. I LOVE MY CAR, HAVE FOUND OUT ABOUT OF THINGS THAT COULD GO WRONG LATER. RIGHT NOW I AM HAVING TROUBLE WITH MY FRONT WHEELS. I HAVE PUT SIX USED TIRES ON THE FRONT SINCE I PURCHASED THE FOCUS. IN NOVEMBER I HAD TWO BRAND NEW TIRES PUT ON PLUS IN MAY I HAVE HAD A WHEEL ALIGNMENT DONE. THE CAR STILL SHAKES VERY BAD. FOUND OUT I NEED MY WHEEL HUB BEARING REPLACE, PLUS I FOUND OUT THERE MAY BE A RECALL ON THE REAR BEARING WHICH I HAVE NOT RECEIVED ANYTHING. I SHOULD NOT HAVE TO PAY FOR THESE THINGS TO BE DONE. *JB
IGNITION SWITCH LOCK-UP. NO PREVIOUS PROBLEMS. NOT COVERED BY WARRANTY. VEHICLE ONLY HAS 55,000 MILES. COST TO REPAIR APPROXIMATELY $300. *NM
THE CLUTCH MASTER CYLINDER LEAKS AT A PREMATURE MILEAGE. I ONLY NOTICED IT AT AROUND THE 42K MARK BUT IT HAS HAPPENED FOR AN UNKNOWN AMOUNT LONGER. THE LEAK GOES THROUGH THE CLUTCH PEDAL AND INTO THE INTERIOR OF THE DRIVERS SIDE CABIN. IT GETS ALL OVER THE CARPET AND CAN CAUSE FUTURE DAMAGE TO MY CARPET AND POSSIBLY FLOOR. T…
Read full complaint
THE CLUTCH MASTER CYLINDER LEAKS AT A PREMATURE MILEAGE. I ONLY NOTICED IT AT AROUND THE 42K MARK BUT IT HAS HAPPENED FOR AN UNKNOWN AMOUNT LONGER. THE LEAK GOES THROUGH THE CLUTCH PEDAL AND INTO THE INTERIOR OF THE DRIVERS SIDE CABIN. IT GETS ALL OVER THE CARPET AND CAN CAUSE FUTURE DAMAGE TO MY CARPET AND POSSIBLY FLOOR. THE FLUID IS VERY CORROSIVE AND SINCE ITS ON THE SAME SYSTEM AS THE BRAKES IT ALSO AFFECTS MY BRAKES. THIS IS A VERY SERIOUS PROBLEM AND I WAS NOT COVERED UNDER WARRANTY SINCE IT WAS OUT OF WARRANTY EVEN THOUGH THIS IS A VERY SERIOUS PROBLEM THAT SEEMS TO BE HAPPENING TO A LOT OF FORD FOCUS OWNERS OUT THERE. *NM
THE EVENTS LEADING UP TO THE FAILURE WERE DAILY USE. THE CLUTCH MASTER CYLINDER IS LOCATED INSIDE THE VEHICLE. IT IS A VERY COMMON FAILURE FOR IT TO BEGIN LEAKING, DRIPPING ON THE CARPET AND EVENTUALLY CAUSING THE RUBBER PAD ON THE CLUTCH PEDAL TO FALL OFF. THIS IN ITSELF IS DANGEROUS, BUT THE HYDRAULIC CLUTCH UTILIZES THE SA…
Read full complaint
THE EVENTS LEADING UP TO THE FAILURE WERE DAILY USE. THE CLUTCH MASTER CYLINDER IS LOCATED INSIDE THE VEHICLE. IT IS A VERY COMMON FAILURE FOR IT TO BEGIN LEAKING, DRIPPING ON THE CARPET AND EVENTUALLY CAUSING THE RUBBER PAD ON THE CLUTCH PEDAL TO FALL OFF. THIS IN ITSELF IS DANGEROUS, BUT THE HYDRAULIC CLUTCH UTILIZES THE SAME FLUID RESERVOIR AS THE BRAKE SYSTEM, SO THE BRAKES COULD BE AFFECTED BY A LEAKING CLUTCH. ON MY VEHICLE, I REPLACED THE CLUTCH MASTER CYLINDER MYSELF. WHEN I WAS UNDER THE CAR, I NOTICED A DRIP FROM THE DRAIN HOLE IN THE BELL HOUSING- THE SLAVE CYLINDER IS LEAKING, TOO. THESE ARE NOT "CONSUMABLE" PARTS OF A CAR. THE SIMULTANEOUS FAILURE OF BOTH INDICATES THAT EITHER THEY ARE WOEFULLY UNDER-ENGINEERED, OR THE SEALS THEY USED ARE NOT COMPATIBLE WITH BRAKE FLUID. BECAUSE OF THE CORROSIVE NATURE OF BRAKE FLUID, HAVING IT DRIP INTO THE CARPET AND PADDING OF THE INTERIOR OF MY CAR IS A BIT OF A CONCERN. ALL IN ALL, THIS IS A MAJOR SHORTCOMING THAT COMPROMISES THE SAFETY OF THE VEHICLE. *NM
DT: CONTACT STATED THERE WAS A NAIL IN THE FRONT PASSENGER'S TIRE. UPON REPLACEMENT OF THE TIRE THE DEALER FOUND THAT THE FRONT PASSENGER COIL SPRING BROKE. THE DEALER REPLACED THE FRONT PASSENGER COIL SPRING. *AK
AFTER STOPPING AT A STOP LIGHT I WAS SHIFTING THROUGH THE GEARS ON MY MANUAL TRANSMISSION AND WHEN I WENT TO SHIFT IN TO 2ND GEAR, I MISSED 2ND AND ACCIDENTALLY WENT INTO 4TH BUT REALIZED IT BEFORE LETTING OFF THE CLUTCH, IT THEN GOT STUCK AND WOULD NOT MOVE FROM THAT GEAR. I COULD NOT GET ANYWHERE TO GET IT FIXED SO I WAS F…
Read full complaint
AFTER STOPPING AT A STOP LIGHT I WAS SHIFTING THROUGH THE GEARS ON MY MANUAL TRANSMISSION AND WHEN I WENT TO SHIFT IN TO 2ND GEAR, I MISSED 2ND AND ACCIDENTALLY WENT INTO 4TH BUT REALIZED IT BEFORE LETTING OFF THE CLUTCH, IT THEN GOT STUCK AND WOULD NOT MOVE FROM THAT GEAR. I COULD NOT GET ANYWHERE TO GET IT FIXED SO I WAS FORCED TO SIT ON THE SIDE OF A MAJOR ROAD IN 20 DEGREE WEATHER FOR MORE THAN 45 MINUTES. *JB
AT AROUND 35,000 MILES MY FATHER NOTICED A GRINDING NOISE ON THE FRONT OF HIS FOCUS. THINKING THAT IT WAS THE SCREECH OF A WARNING INDICATOR HE PARKED THE VEHICLE UNTIL HE COULD HAVE ME LOOK AT IT. BOTH FRONT ROTORS WERE SEVERELY GROUND DOWN WITH THE LEFT INSIDE PAD BEING TOTALLY DOWN FLUSH WITH THE METAL. THIS SHOULDN'T BE NO…
Read full complaint
AT AROUND 35,000 MILES MY FATHER NOTICED A GRINDING NOISE ON THE FRONT OF HIS FOCUS. THINKING THAT IT WAS THE SCREECH OF A WARNING INDICATOR HE PARKED THE VEHICLE UNTIL HE COULD HAVE ME LOOK AT IT. BOTH FRONT ROTORS WERE SEVERELY GROUND DOWN WITH THE LEFT INSIDE PAD BEING TOTALLY DOWN FLUSH WITH THE METAL. THIS SHOULDN'T BE NORMAL WEAR. BACK BRAKES SHOWED SIGNS OF NORMAL IF NOT LESS THAN NORMAL WEAR. THIS SHOULD NOT BE NORMAL WEAR AND TEAR ON A VEHICLE WITH THIS FEW MILES ON IT. I HAD TO REPLACE BOTH ROTORS PREMATURELY. WE WILL KEEP THE OLD PARTS FOR THIRTY DAYS IN CASE THEY ARE NEEDED. *JB
DT: THE CONTACT STATED THE IGNITION LOCKED, AND THE KEY/STEERING WHEEL WOULD NOT TURN. THE VEHICLE WAS TOWED TO THE DEALERSHIP, AND THEY FOUND THE IGNITION CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, AND THERE HAVE BEEN NO PROBLEMS SINCE THEN. *AK
Official recalls
105V030000 · Latches/locks/linkages:doors:latch
Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available