IllustrationPASSENGER SIDE COIL SPRING IS FRACTURED. *JB
2002 Ford Focus
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Ford Focus do not stand out strongly from the model-year median of 864.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Focus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1480–25K
13425–50K
13950–75K
8375–100K
74100–150K
26150K+
604 reports with mileage · 335 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 277 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
82 crash reports20 fire reports60 injury reports
What owners actually said
939 reportsHAVE HAD AN IGNITION FREEZING UP PROBLEM AND RESEARCHED IT ONLINE AND NOTICED THIS HAS BEEN AN ON GOING PROBLEM WITH FORD. I HAVE A 2002 FORD FOCUS. FIRST TIME I HAVE HAD A CAR IGNITION FREEZE UP. *JB
AT VEHICLE START UP, MY WIFE HEARD A LOUD POP, FOLLOWED BY ENGINE SPUTTERING, AND SMELL OF GAS FUMES. MY WIFE TOOK THE KIDS OUT OF THE CAR AND RAN AWAY FOR FEAR OF FIRE. THE FOLLOWING DAY, WE HAD IT TOWED TO THE DEALERSHIP. THE DEALERSHIP TOLD ME A SPARK PLUG BLEW OUT OF THE ENGINE AND STRIPED THE ENGINE BLOCK. I CALLED FORD MOT…
Read full complaint
AT VEHICLE START UP, MY WIFE HEARD A LOUD POP, FOLLOWED BY ENGINE SPUTTERING, AND SMELL OF GAS FUMES. MY WIFE TOOK THE KIDS OUT OF THE CAR AND RAN AWAY FOR FEAR OF FIRE. THE FOLLOWING DAY, WE HAD IT TOWED TO THE DEALERSHIP. THE DEALERSHIP TOLD ME A SPARK PLUG BLEW OUT OF THE ENGINE AND STRIPED THE ENGINE BLOCK. I CALLED FORD MOTOR CORP. THEY SAID THEY COULD NOT HELP ME WITH THE REPAIRS, SINCE MY VEHICLES WARRANTY JUST EXSPIRED. THE CAR ONLY HAS 35,000 MILE ON IT, AND HAS HAD OTHER MAJOR ELECTRICAL PROBLEMS AT 25,000 MILES. NOW I AM PAYING FOR A CAR THAT DOESN'T EVEN RUN, I GUESS I SHOULD HAVE KNOWN BETTER THAN TO BUY A FORD. FORD HAS LOST A CUSTOMER FOREVER. *NM
CAR SPUTTERED, STALLED, AND DIED IN TRAFFIC ON TWO DIFFERENT OCCASIONS (ONE MONTH APART), REQUIRING TOWING. I WOULD DESCRIBE THE SYMPTOM AS "FUEL STARVATION", LIKE A BAD FUEL PUMP OR FILTER. BOTH TIMES, IT OCCURRED WITH A WARM ENGINE, 1/4 TANK OF GAS, AND ACCELERATING NORMALLY FROM A STOP. MECHANIC SUBSEQUENTLY DETECTED NO PR…
Read full complaint
CAR SPUTTERED, STALLED, AND DIED IN TRAFFIC ON TWO DIFFERENT OCCASIONS (ONE MONTH APART), REQUIRING TOWING. I WOULD DESCRIBE THE SYMPTOM AS "FUEL STARVATION", LIKE A BAD FUEL PUMP OR FILTER. BOTH TIMES, IT OCCURRED WITH A WARM ENGINE, 1/4 TANK OF GAS, AND ACCELERATING NORMALLY FROM A STOP. MECHANIC SUBSEQUENTLY DETECTED NO PROBLEMS, EXCEPT BLOWN FUEL PUMP FUSE. *NM
THE IGNITION SWITCH OF THE FORD FOCUS YEARS 2000-2002 FOR SURE MAY BE OTHER YEARS BECOME JAMMED WHICH COULD LEAD TO CRASHES. I AM WORRIED EVERY TIME I DRIVE MY CAR. THIS ITEM NEEDS TO BE RECALLED BY FORD MOTOR COMPANY. *JB
FAILING CLUTCH MASTER CYLINDER. THIS IS NOT A PART THAT HAS A RECOMMENDED REPLACEMENT TERM. THIS PART HAS FAILED PRIOR TO THE TUNE UP MILEAGE. IT FAILED LESS THAN 2K MILES OUT OF WARRANTY. *JB
DT*: THE CONTACT STATED WHILE SLOWING DOWN AT TEN MPH AND PUTTING THE VEHICLE IN NEUTRAL THE RPM'S DROP TO 500. THIS CAUSES THE VEHICLE TO STALL OR SPUTTER INTERMITTENTLY. THE DEALER CAN NOT DUPLICATE THE PROBLEM AND NO REPAIRS HAVE BEEN MADE.
DT*: THE CONTACT STATED WHILE DRIVING 60 MPH THE VEHICLE LOST POWER. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. UPON INSPECTION, THE DEALERSHIP DETERMINED THE FUEL DELIVERY MODULE NEEDED TO BE REPLACED, HOWEVER NO REPAIRS WERE MADE. THERE IS A NHTSA RECALL, # 03V482000, REGARDING THE FUEL SYSTEM GASOLINE. THE VE…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 60 MPH THE VEHICLE LOST POWER. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. UPON INSPECTION, THE DEALERSHIP DETERMINED THE FUEL DELIVERY MODULE NEEDED TO BE REPLACED, HOWEVER NO REPAIRS WERE MADE. THERE IS A NHTSA RECALL, # 03V482000, REGARDING THE FUEL SYSTEM GASOLINE. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.
THREE INSTANCES. VEHICLE ELECTRICAL SYSTEM (DASH, GAUGES, LAMPS, ETC) SUDDENLY GO DEAD. ENGINE THEN SURGES AND STALLS. POWER STEERING AND POWER BRAKES FAIL. VEHICLE FAILS TO RESTART. 1ST INSTANCE (12/2004): DEALER HAD FAILED TO PROPERLY RECONNECT ELECTRICAL CONNECTORS AFTER RECALL SERVICE. ACCIDENT OCCURRED, MINOR INJURIES. 2ND…
Read full complaint
THREE INSTANCES. VEHICLE ELECTRICAL SYSTEM (DASH, GAUGES, LAMPS, ETC) SUDDENLY GO DEAD. ENGINE THEN SURGES AND STALLS. POWER STEERING AND POWER BRAKES FAIL. VEHICLE FAILS TO RESTART. 1ST INSTANCE (12/2004): DEALER HAD FAILED TO PROPERLY RECONNECT ELECTRICAL CONNECTORS AFTER RECALL SERVICE. ACCIDENT OCCURRED, MINOR INJURIES. 2ND INSTANCE (1/22/2006): DEALER FOUND NO PROBLEM. VEHICLE RESTARTED. 3. 3RD INSTANCE (2/3/2006): DEALER FOUND FAULTY ALTERNATOR/ALTERNATOR WIRING. *NM
IGNITION DOES NOT TURN ON 2002 FORD FOCUS. I CANNOT TURN THE KEY. I HAVE LOOKED AROUND ON THE INTERNET AND THERE WERE A LOT OF PEOPLE WHO HAD THIS SAME PROBLEM. I FIXED IT BY TAPPING THE KEY WITH A HAMMER AS I TURNED THE KEY. THE DEALERSHIP WANTED ME TO PAY THEM $400 TO FIX THIS PROBLEM, BUT I THOUGHT FORD SHOULD JUST FI…
Read full complaint
IGNITION DOES NOT TURN ON 2002 FORD FOCUS. I CANNOT TURN THE KEY. I HAVE LOOKED AROUND ON THE INTERNET AND THERE WERE A LOT OF PEOPLE WHO HAD THIS SAME PROBLEM. I FIXED IT BY TAPPING THE KEY WITH A HAMMER AS I TURNED THE KEY. THE DEALERSHIP WANTED ME TO PAY THEM $400 TO FIX THIS PROBLEM, BUT I THOUGHT FORD SHOULD JUST FIX IT BEFORE THEY MAKE THEIR WORTHLESS CARS.*AK
Official recalls
105V030000 · Latches/locks/linkages:doors:latch
Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available