NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
277 reportsClear category filter41,000 miles · May 13, 2005
Electrical SystemEngine And Engine Cooling
WHILE DRIVING AT 30 MPH, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO THE DEALERSHIP. THE BATTERY CABLE MELTED AND THE ALTERNATOR WAS BAD AND NEEDED REPLACEMENT. A WEEK PRIOR, THE CHECK ENGINE LIGHT CAME ON AND SMOKE HAD COME FROM THE ENGINE COMPARTMENT. THE FOURTH GEAR WENT OUT BECAUSE IT'S WIRE CONNECTION MELTED…
Read full complaint
WHILE DRIVING AT 30 MPH, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO THE DEALERSHIP. THE BATTERY CABLE MELTED AND THE ALTERNATOR WAS BAD AND NEEDED REPLACEMENT. A WEEK PRIOR, THE CHECK ENGINE LIGHT CAME ON AND SMOKE HAD COME FROM THE ENGINE COMPARTMENT. THE FOURTH GEAR WENT OUT BECAUSE IT'S WIRE CONNECTION MELTED. THE CONSUMER FELT THE FAILURES WERE DUE TO THE ENGINE MISPLACED CABLE PROBLEM AS STATED IN RECALL 02V288000. *AK *SC *JB
NHTSA ODI #10118956
Mileage unknown · May 12, 2005
Electrical SystemFire
VEHICLE WAS PARKED AT STATE EMPLOYEE'S RESIDENCE FOR ABOUT 10 HOURS WHEN IT SUDDENLY CAUGHT FIRE. FIRE DEPT. RESPONDED AND EXTINGUISHED FIRE. VEHICLE IS A TOTAL LOSE.
NHTSA ODI #10120753
43,000 miles · Apr 19, 2005
Electrical System
MY IGNITION LOCKED UP AND I WAS STRANDED IN A PARKING LOT AFTER PURCHASING A 2002 FORD, FOCUS LESS THAN A MONTH AGO. I HAD TO HITCH A RIDE HOME BECAUSE I DIDN'T HAVE THE MONEY FOR A TOW. THE NEXT DAY, I HAD MY VEHICLE TOWED TO A FORD DEALER FOR REPAIRS. EVIDENTLY THIS WAS A MAJOR PROBLEM, PEOPLE GETTING STRANDED DUE TO A FAU…
Read full complaint
MY IGNITION LOCKED UP AND I WAS STRANDED IN A PARKING LOT AFTER PURCHASING A 2002 FORD, FOCUS LESS THAN A MONTH AGO. I HAD TO HITCH A RIDE HOME BECAUSE I DIDN'T HAVE THE MONEY FOR A TOW. THE NEXT DAY, I HAD MY VEHICLE TOWED TO A FORD DEALER FOR REPAIRS. EVIDENTLY THIS WAS A MAJOR PROBLEM, PEOPLE GETTING STRANDED DUE TO A FAULTY IGNITION SWITCH. WHAT IS IT GOING TO TAKE TO GET THIS PROBLEM FIXED. WHO IS MAKING THE FORTUNE ON ALL THESE PART REPLACEMENTS???? IS IT FORD???? WHO MAKES THESE FAULTY IGNITIONS???? THEY ARE PROBABLY STILL MAKING A FORTUNE AND STILL MAKING THESE BAD PARTS. THIS COULD RESULT IN A VERY DANGEROUS SITUATION. PLEASE GET THIS PROBLEM FIXED!*AK
NHTSA ODI #10118140
43,000 miles · Apr 19, 2005
Electrical System
MY IGNITION LOCKED UP AND I WAS STRANDED IN A PARKING LOT AFTER PURCHASING A 2002 FORD, FOCUS LESS THAN A MONTH AGO. I HAD TO HITCH A RIDE HOME BECAUSE I DIDN'T HAVE THE MONEY FOR A TOW. THE NEXT DAY, I HAD MY VEHICLE TOWED TO A FORD DEALER FOR REPAIRS. EVIDENTLY THIS IS A MAJOR PROBLEM, PEOPLE GETTING STRANDED DUE TO A FAULT…
Read full complaint
MY IGNITION LOCKED UP AND I WAS STRANDED IN A PARKING LOT AFTER PURCHASING A 2002 FORD, FOCUS LESS THAN A MONTH AGO. I HAD TO HITCH A RIDE HOME BECAUSE I DIDN'T HAVE THE MONEY FOR A TOW. THE NEXT DAY, I HAD MY VEHICLE TOWED TO A FORD DEALER FOR REPAIRS. EVIDENTLY THIS IS A MAJOR PROBLEM, PEOPLE GETTING STRANDED DUE TO A FAULTY IQNITION SWITCH. WHAT IS IT GOING TO TAKE TO GET THIS PROBLEM FIXED. WHO IS MAKING THE FORTUNE ON ALL THESE PART REPLACEMENTS???? IS IT FORD???? WHO MAKES THESE FAULTY IGNITIONS???? THEY ARE PROBABLY STILL MAKING A FORTUNE AND STILL MAKING TTHESE BAD PARTS. THIS COULD RESULT IN A VERY DANGEROUS SITUATION. PLEASE GET THIS PROBLEM FIXED! *AK
NHTSA ODI #10118139
66,000 miles · Apr 14, 2005
Electrical System
I HAVE BEEN HAVING PROBLEMS WITH MY 2002 FORD FOCUS IGNITION. EVERY TIME I PUT MY KEY IN THE IGNITION IT WILL GO IN, BUT THE KEY WILL NOT TURN. I NEED TO SEE WHAT I NEED TO DO TO KEEP THIS FROM HAPPENING AGAIN. I HAVE NOT REPLACED ANYTHING YET BECAUSE I WAS HOPING THEY WOULD CONSIDER A RECALL ON THIS PART. SO FAR I HAVE JUST…
Read full complaint
I HAVE BEEN HAVING PROBLEMS WITH MY 2002 FORD FOCUS IGNITION. EVERY TIME I PUT MY KEY IN THE IGNITION IT WILL GO IN, BUT THE KEY WILL NOT TURN. I NEED TO SEE WHAT I NEED TO DO TO KEEP THIS FROM HAPPENING AGAIN. I HAVE NOT REPLACED ANYTHING YET BECAUSE I WAS HOPING THEY WOULD CONSIDER A RECALL ON THIS PART. SO FAR I HAVE JUST BEEN FORCING MY KEY TO TURN AND ON APRIL 13, 2005 IT HAPPENED SO I WENT AND GOT SOME KEYS MADE AND IT STILL WOULD NOT WORK. THE NEXT DAY ABOUT 45 MINUTES OF WORK IT FINALLY TURNED AND GOT STARTED UP. FOR RIGHT NOW I AM LEAVING A KEY IN THE IGNITION TO KEEP UP FROM GETTING STUCK AGAIN.*AK
NHTSA ODI #10116918
52,000 miles · Apr 12, 2005
Electrical System
CONSUMER COMPLAINED ABOUT AN IGNITION. PROBLEM. OWNER HAD PARKED VEHICLE AND WENT INSIDE OF A BUILDING FOR AN HOUR. UPON RETURNING, OWNER PUT THE KEY IN THE IGNITION AND THE KEY WOULD NOT TURN. OWNER HAD THE VEHICLE TOWED TO DEALER WHERE IT WAS BEING SERVICED. *AK
NHTSA ODI #10117795
Mileage unknown · Apr 6, 2005
Electrical System
WHILE INSERTING THE KEY INTO THE IGNITION IT LOCKED. DRIVER WAS UNABLE TO TURN THE KEY. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE IGNITION CYLINDER NEEDED TO BE REPLACED. *AK
NHTSA ODI #10117567
2,000 miles · Mar 11, 2005
Electrical SystemExterior LightingFuel System, Other
MY CAR STALLED WHEN DRIVING ANYWHER FROM 20 - 70MPH. THE GAUGES GO HAYWIRE THE LIGHT CUT OFF AND ON , THE CLOCK RESETS, THE SPEEDOMETER GOES CRAZY, AND I HAVE A YOUNG DAUGHTER THAT RIDES IN THIS CAR. THIS STARTED IN OCTOBER AND IS STILL GOING ON TO DATE. MY CAR IS STILL UNDER WARRANTY. *AK
NHTSA ODI #10113959
46,000 miles · Mar 9, 2005
Electrical System
I HAVE A 2002 FORD FOCUS 4-DOOR SEDAN. I HAVE APPROXIMATELY 45000 MILES ON THE VEHICLE. WHEN DRIVING THE VEHICLE, IT STALLS PARTICULARLY WHEN THE ELECTRIC PARTS ARE TURNED ON. YOU CAN JUMP THE CAR AND GET IT TO START, BUT THE SAME THING KEEPS HAPPENING. *AK ALSO, WHEN YOU TURN ON THE RADIO, IT MAKES A BUZZING NOISE AS IF THER…
Read full complaint
I HAVE A 2002 FORD FOCUS 4-DOOR SEDAN. I HAVE APPROXIMATELY 45000 MILES ON THE VEHICLE. WHEN DRIVING THE VEHICLE, IT STALLS PARTICULARLY WHEN THE ELECTRIC PARTS ARE TURNED ON. YOU CAN JUMP THE CAR AND GET IT TO START, BUT THE SAME THING KEEPS HAPPENING. *AK ALSO, WHEN YOU TURN ON THE RADIO, IT MAKES A BUZZING NOISE AS IF THERE IS INTERFERENCE FROM THE MOTOR. THE PROBLEM APPEARS TO BE GETTING WORSE. ALSO, THERE SEEMS TO BE SOME SORT OF A NOISE COMING FROM THE BACK OF THE VEHICLE WHEN STOPPING. IT IS NOT THE SOUND OF WORN-OUT BREAKS BUT AS IF THERE IS AN AXLE PROBLEM. I HAVE HAD MY REAR RIGHT TIRE REPLACED TWICE.
NHTSA ODI #10112782
40,000 miles · Mar 1, 2005
Electrical System
THE KEY WON'T TURN IN THE IGNITION. UNABLE TO MOVE VEHICLE. HAD TO HAVE IT TOWED TO FORD DEALERSHIP. CROW- MODDIE BURLINGTON KS. NOT FIXED YET.*JB
NHTSA ODI #10112382
Official recalls
1Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
Illustration