NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,761 reports81,700 miles · Feb 26, 2007
Electrical System
IT HAD BECOME HARDER AND HARDER OVER THE COURSE OF A COUPLE OF MONTHS TO TURN THE KEY IN MY IGNITION. THEN ONE NIGHT AFTER WORK, I PUT THE KEY IN THE IGNITION AND IT WOULD NOT TURN AT ALL. I CONTACTED AAA, AND THEY SENT OUT A LOCKSMITH THE NEXT DAY. THE LOCKSMITH HAD TO COMPLETELY REPLACE THE IGNITION BECAUSE, ACCORDING TO HI…
Read full complaint
IT HAD BECOME HARDER AND HARDER OVER THE COURSE OF A COUPLE OF MONTHS TO TURN THE KEY IN MY IGNITION. THEN ONE NIGHT AFTER WORK, I PUT THE KEY IN THE IGNITION AND IT WOULD NOT TURN AT ALL. I CONTACTED AAA, AND THEY SENT OUT A LOCKSMITH THE NEXT DAY. THE LOCKSMITH HAD TO COMPLETELY REPLACE THE IGNITION BECAUSE, ACCORDING TO HIM, CERTAIN PIECES WERE BROKEN. *JB
NHTSA ODI #10183560
42,000 miles · Feb 21, 2007
Engine And Engine CoolingVisibility
TL* - THE CONTACT OWNS A 2001 FORD FOCUS ZX3. THE CONTACT PURCHASED THE VEHICLE ,AND TWO WEEKS LATER THE HEAT STOPPED WORKING. THE CONTACT STATED THAT SHE TOOK THE VEHICLE TO THE DEALER FOR REPAIRS, AND THEY DID AN INCOMPLETE REPAIR JOB. THE DEALER GOT THE HEAT TO WORK BUT IT ONLY WORKED WHEN THE CONTACT TURNED THE HEAT O…
Read full complaint
TL* - THE CONTACT OWNS A 2001 FORD FOCUS ZX3. THE CONTACT PURCHASED THE VEHICLE ,AND TWO WEEKS LATER THE HEAT STOPPED WORKING. THE CONTACT STATED THAT SHE TOOK THE VEHICLE TO THE DEALER FOR REPAIRS, AND THEY DID AN INCOMPLETE REPAIR JOB. THE DEALER GOT THE HEAT TO WORK BUT IT ONLY WORKED WHEN THE CONTACT TURNED THE HEAT ON HIGH. THE CONTACT STATED THAT ON A REALLY BAD SNOW DAY SHE SMELLED RUBBER BURNING AND TURNED THE HEAT OFF AND OPENED THE WINDOW. SHE HAD TO SHUT THE WINDOW AND TURN THE HEAT BACK ON, AND WHEN SHE DID FUMES BEGAN TO GATHER IN THE VEHICLE, AND THE ENTIRE VEHICL WAS FILLED WITH SMOKE. THE CONTACT CONTINUED TO DRIVE HOME WHEN THE CAR SHUT DOWN ENTIRELY. FORD AND TOYOTA GAVE HER THE RUN AROUND CONCERNING REPLACING THE VEHICLE AND A TRADE IN. THE CONTACT WAS INSTRUCTED TO CONTINUE USING THE VEHICLE WHILE A TRADE IN WAS BEING NEGOTIATED. WHEN THE CONTACT WENT TO SIGN NEGOTIATION PAPERS SHE WAS DECLINED. *AK THE CONSUMER STATED AFTER PICKING UP THE VEHICLE, ALL THE LIGHTS ILLUMINATED, THE CONSUMER WAS TOLD IT WAS FIXED. THE SALESMAN TEST DROVE THE VEHICLE AND IT CUT OFF IN THE MIDDLE OF THE STEET. UPDATED 03/30/07. *JB
NHTSA ODI #10183149
43,000 miles · Feb 17, 2007
Electrical System
IGNITION LOCK CYLINDER FAILED, PREVENTING CAR FROM STARTING. KEY WOULD GO INTO IGNITION BUT WOULD NOT TURN. I WAS STRANDED IN PARKING GARAGE UNTIL A TOW TRUCK THAT COULD REACH IT WAS LOCATED. IGNITION CYLINDER REBUILT, NEW KEYS CREATED, TOTAL COST $550. DEALER KEPT OLD PARTS. THIS IS THE SECOND FAILURE OF THE SAME PART. IT…
Read full complaint
IGNITION LOCK CYLINDER FAILED, PREVENTING CAR FROM STARTING. KEY WOULD GO INTO IGNITION BUT WOULD NOT TURN. I WAS STRANDED IN PARKING GARAGE UNTIL A TOW TRUCK THAT COULD REACH IT WAS LOCATED. IGNITION CYLINDER REBUILT, NEW KEYS CREATED, TOTAL COST $550. DEALER KEPT OLD PARTS. THIS IS THE SECOND FAILURE OF THE SAME PART. IT WAS FIRST REPLACED IN OCTOBER 2003. *JB
NHTSA ODI #10182847
47,312 miles · Feb 16, 2007
Fuel System, Gasoline
DRIVING ON HIGHWAY, 45 MPH...5:30 AM MST...NO INDICATION OF ANY PROBLEM. VEHICLE DRIVING SMOOTHLY, NO SPUTTERS AND NO INDICATOR LIGHTS. DROVE MY SON TO HIS WORKPLACE APPROXIMATELY 20 MILES AND ON THE WAY HOME, VEHICLE SIMPLY STALLED, JERKED AND AS I STEPPED ON THE GAS....NOTHING. CARS SWERVED AROUND ME AS I STRUGGLED TO PULL …
Read full complaint
DRIVING ON HIGHWAY, 45 MPH...5:30 AM MST...NO INDICATION OF ANY PROBLEM. VEHICLE DRIVING SMOOTHLY, NO SPUTTERS AND NO INDICATOR LIGHTS. DROVE MY SON TO HIS WORKPLACE APPROXIMATELY 20 MILES AND ON THE WAY HOME, VEHICLE SIMPLY STALLED, JERKED AND AS I STEPPED ON THE GAS....NOTHING. CARS SWERVED AROUND ME AS I STRUGGLED TO PULL OFF TO THE RIGHT. I WAS NEARLY HIT BY THREE DIFFERENT VEHICLES. IT WAS VERY DARK AND I WAS ALONE IN THE CAR. I MANAGED TO WALK TO A GAS STATION/STORE AND CALLED MY DAUGHTER. HER HUSBAND HELPED ME TOW THE VEHICLE TO KEARNS AUTO CENTER NEAR WHERE THE CAR HAD STALLED. THE FUEL PUMP HAD TO BE REPLACED. MANAGER ADVISED THAT THE FUEL PUMP SHIELD WAS A 2002 ADDITION, EVEN THOUGH VEHICLE WAS SOLD AND MANUALS DISTRIBUTED WAS FOR A 2001 FORD FOCUS. THE SHIELD HAD ALLOWED GAS TO LEAK UNTIL IT TOTALLY DESTROYED THE FUEL PUMP ITSELF. THERE WAS NO DISCLOSURE, VEHICLE WAS BOUGHT BRAND NEW WITH 8 MILES SHOWING. MANUAL AND CARE SCHEDULE WAS FOR THAT OF A 2001. VEHICLE MILEAGE AT THE TIME OF INCIDENT WAS 47,312 MILES...FORD CUSTOMER SERVICE, AND TWO DEALERS IN THE SALT LAKE CITY AREA WERE NOTIFIED OF THE SITUATION, NONE HAVE RESPONDED. *NM
NHTSA ODI #10182742
102,000 miles · Feb 13, 2007
Electrical System
TL* - THE CONTACT CALLED REGARDING THE 2001 FORD FOCUS. THE CONTACT STATED THE VEHICLE WOULD NOT START. THE CONTACT HAD THE BATTERY REPLACED, AND TWO DAYS LATER THE VEHICLE WOULD NOT START. HE LIFTED THE HOOD, AND SAW SMOKE COMING FROM THE BATTERY CABLE. THE CABLES MELTED. THE VEHICLE WAS TOWED TO A REPAIR SHOP. THE BATT…
Read full complaint
TL* - THE CONTACT CALLED REGARDING THE 2001 FORD FOCUS. THE CONTACT STATED THE VEHICLE WOULD NOT START. THE CONTACT HAD THE BATTERY REPLACED, AND TWO DAYS LATER THE VEHICLE WOULD NOT START. HE LIFTED THE HOOD, AND SAW SMOKE COMING FROM THE BATTERY CABLE. THE CABLES MELTED. THE VEHICLE WAS TOWED TO A REPAIR SHOP. THE BATTERY CABLE AND THE HARNESS WERE REPLACED. THE FAILURE MILEAGE 102,000. THE CONTACT WAS TOLD THERE WAS A RECALL FOR THE BATTERY CABLE. THE CONTACT CALLED THE MANUFACTURER, AND WAS TOLD THE VEHICLE WAS NOT A PART OF THE RECALL. *AK
NHTSA ODI #10182446
Mileage unknown · Feb 11, 2007
Electrical SystemVisibility
I OWN A 2001 FORD FOCUS SE AUTOMATIC: MY IGNITION LOCK AND THE STEERING WHEEL ARE JAMMED. IT IS A VERY RECENT DEVELOPMENT AND I AM FINDING OUT THAT I MAY HAVE TO PAY HUNDREDS OF DOLLARS TO FIX IT, WHICH I AM VERY UNHAPPY ABOUT SINCE IT WOULD HAVE BEEN PREVENTED BY A RECALL OF THE VEHICLE. I STILL HAVE NO IDEA HOW I AM GOING TO …
Read full complaint
I OWN A 2001 FORD FOCUS SE AUTOMATIC: MY IGNITION LOCK AND THE STEERING WHEEL ARE JAMMED. IT IS A VERY RECENT DEVELOPMENT AND I AM FINDING OUT THAT I MAY HAVE TO PAY HUNDREDS OF DOLLARS TO FIX IT, WHICH I AM VERY UNHAPPY ABOUT SINCE IT WOULD HAVE BEEN PREVENTED BY A RECALL OF THE VEHICLE. I STILL HAVE NO IDEA HOW I AM GOING TO FIX IT AND I MIGHT HAVE TO END UP TOWING THE CAR WHICH WILL COST EVEN MORE AND I DON'T HAVE ENOUGH MONEY TO DO THAT, BUT IF I LEAVE IT ON MY STREET THEN I WILL GET A PARKING TICKET. SHAME ON YOU FORD FOR NOT ISSUING A RECALL, WHAT AM I SUPPOSED TO DO? ANOTHER PROBLEM WITH MY FOCUS IS THAT THE REAR PASSENGER SIDE WINDOW BROKE IN 2005. THE MOTOR GOT JAMMED AND BROKE OR SOMETHING, BUT NOW MY WINDOW WON'T ROLL UP AND MY CAR IS GETTING RAINED INSIDE OF, AGAIN THANKS FORD FOR NOT ISSUING A RECALL ON THAT PROBLEM, WHICH IS A PROBLEM THAT EVERY FORD FOCUS OWNER THAT I KNOW HAS. I WILL NEVER BUY A FORD AGAIN, AND I WILL TELL EVERYONE THAT FORD'S SUCK!!!!! *NM
NHTSA ODI #10182284
65,000 miles · Feb 8, 2007
Visibility
REAR WINDOW DOES NOT OPERATE AUTOMATICALLY EITHER FROM THE DRIVER'S MECHANISMS NOR THE ONE BY THE WINDOW. THIS IS THE SECOND WINDOW, THIS HAS HAPPENED TO. THE FIRST WINDOW, ALSO REAR ON THE DRIVER'S SIDE BROKE COUPLE OF YEARS AGO AND WE HAD TO HAVE IT FIXED AT THE TIME. SINCE THIS IS THE SECOND WINDOW, AND NOW THE DRIVER'S WINDO…
Read full complaint
REAR WINDOW DOES NOT OPERATE AUTOMATICALLY EITHER FROM THE DRIVER'S MECHANISMS NOR THE ONE BY THE WINDOW. THIS IS THE SECOND WINDOW, THIS HAS HAPPENED TO. THE FIRST WINDOW, ALSO REAR ON THE DRIVER'S SIDE BROKE COUPLE OF YEARS AGO AND WE HAD TO HAVE IT FIXED AT THE TIME. SINCE THIS IS THE SECOND WINDOW, AND NOW THE DRIVER'S WINDOW IS STARTING TO SOUND LIKE IT'S GOING TO BREAK, I FEAR THIS SHOULD BE CONSIDERED A DEFECT, AND THE MANUFACTURER IS NOT USING PROPER MATERIAL TO ENSURE THE VEHICLE WORKS PROPERLY. BEING UNABLE TO OPEN AND/OR CLOSE THE WINDOW PRESENTS A HAZARD, THUS THIS MATTER SHOULD BE TAKEN SERIOUSLY BY THE MANUFACTURER AND FIXED AT THEIR AND NOT OUR EXPENSE, ESPECIALLY SINCE IT IS AN ONGOING PROBLEM. *JB
NHTSA ODI #10182033
136,000 miles · Feb 7, 2007
Engine And Engine Cooling
AT SEEMINGLY RANDOM TIME MY 2001 FORD FOCUS ZX3 STALLS. SO FAR THE STALL HAS ONLY HAPPENED WHEN AT A STOP, BUT SPUTTERING AND LOSS OF POWER RANDOMLY AT HIGHWAY SPEEDS HAS ME WORRIED ABOUT AN EMINENT STALL. I HAVE HAD THE FUEL FILTER CHANGED AS WELL AS THE EGR VALVE AND EGR PRESSURE FLOW SENSOR AND NOTHING HAS SOLVED THIS PROBL…
Read full complaint
AT SEEMINGLY RANDOM TIME MY 2001 FORD FOCUS ZX3 STALLS. SO FAR THE STALL HAS ONLY HAPPENED WHEN AT A STOP, BUT SPUTTERING AND LOSS OF POWER RANDOMLY AT HIGHWAY SPEEDS HAS ME WORRIED ABOUT AN EMINENT STALL. I HAVE HAD THE FUEL FILTER CHANGED AS WELL AS THE EGR VALVE AND EGR PRESSURE FLOW SENSOR AND NOTHING HAS SOLVED THIS PROBLEM. *MN
NHTSA ODI #10181915
87,000 miles · Feb 2, 2007
Electrical System
I WAS OUT SHOPPING AT NIGHT IN A DARK PARKING LOT AND WHEN I WENT TO MY CAR THE KEY WOULD NOT TURN I WAS LEFT STRANDED FOR HOURS UNTIL A TOW COULD COME GET MY CAR THE KEY WOULD NOT TURN IT WAS LOCKED. *NM
NHTSA ODI #10181399
21,000 miles · Jan 18, 2007
Structure
WATER LEAKS INTO PASSENGER FLOOR WHEN IT RAINS I HAVE HAD TO DEALER TWICE STILL NOT FIXED NOW WARRANTY HAS RUN OUT. *JB
NHTSA ODI #10179035
Official recalls
7Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
Illustration