NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
38 reportsClear category filterMileage unknown · Jun 11, 2002
Engine And Engine CoolingFuel System, GasolineTires
HAVE HAD NUMEROUS PROBLEMS WITH THE CAR HESITATING AND STALLING. HAVE TAKEN THE CAR IN A TOTAL OF 7 TIMES. 5 OF WHICH WERE RELATED TO HESITATION. 3 OF THE THOSE 5 TIMES THEY FOUND PROBLEMS WITH THE CAR. 2 TIMES FOR AN EGR EMISSIONS SENSOR AND 1 FOR A FUEL PUMP (THEY THINK). THE OTHER TWO TIMES THEY COULNDT FIND ANYTHING WRON…
Read full complaint
HAVE HAD NUMEROUS PROBLEMS WITH THE CAR HESITATING AND STALLING. HAVE TAKEN THE CAR IN A TOTAL OF 7 TIMES. 5 OF WHICH WERE RELATED TO HESITATION. 3 OF THE THOSE 5 TIMES THEY FOUND PROBLEMS WITH THE CAR. 2 TIMES FOR AN EGR EMISSIONS SENSOR AND 1 FOR A FUEL PUMP (THEY THINK). THE OTHER TWO TIMES THEY COULNDT FIND ANYTHING WRONG AT THE TIME. I HAVE CALLED FORD DIRECTLY AND THEY CAN DO NOTHING ABOUT THE CAR, BECAUSE THEY SAY IT IS REPAIRABLE. I HAVE HAD THE CAR BACK NOW FOR A LITTLE OVER A WEEK SINCE THEY HAVE REPLACED THE FUEL PUMP. SEEMS TO HAVE A LITTLE HESITATION STILL, BUT HAS NOT STALLED. WE HAVE HAD THE LEFT REAR TIRE REPLACE ONCE FOR CUPPING OF THE TIRE. FORD DEALERSHIP WASNT SURE WHAT CAUSED IT, BUT THEY SAY I COULD HAVE RUN OVER SOMETHING HARD. THE NEW TIRE STARTING CUPPING LIKE THE ONE THEY REPLACED, THEN THAT IS WHEN THE RECALL FOR THE REAR WHEEL BEARINGS WAS ISSUED. NO PROBLEMS SINCE THEN WITH THE TIRES.
NHTSA ODI #762931
Mileage unknown · Jun 9, 2002
Engine And Engine CoolingUnknown Or Other
THE PROBLEM IS THAT THE CAR ALWAYS SHAKES WHEN ITS IN PARK OR AT A STOP LIGHT AND IT STALLED 2 TIME. HAVE TAKEN IT TO DEALER NUMEROUS TIMES AND STILL CANT FIND THE PROBLEM.
NHTSA ODI #762854
Mileage unknown · May 28, 2002
Engine And Engine CoolingFuel System, GasolineUnknown Or Other
MY VEHICLE HAS JUST BEEN TURNED INTO OUR DEALERSHIP THIS MORNING, FOR THE SAME REPEATED PROBLEM OF ENGINE CHECK LIGHT COMING ON WHILE DRIVING VEHICLE. THIS IS OUR 5TH VISIT, AND WE ARE ON OUR 4TH EGR VALVE. SAME COMPLAINT, THE CAR DRIVES SLUGGISHLY, SHUTTERS AND ABOUT 2 MONTHS AGO SHUT OFF WHILE DRIVING. THIS HAPPENED WHIL…
Read full complaint
MY VEHICLE HAS JUST BEEN TURNED INTO OUR DEALERSHIP THIS MORNING, FOR THE SAME REPEATED PROBLEM OF ENGINE CHECK LIGHT COMING ON WHILE DRIVING VEHICLE. THIS IS OUR 5TH VISIT, AND WE ARE ON OUR 4TH EGR VALVE. SAME COMPLAINT, THE CAR DRIVES SLUGGISHLY, SHUTTERS AND ABOUT 2 MONTHS AGO SHUT OFF WHILE DRIVING. THIS HAPPENED WHILE MY 14 YEAR OLD DAUGHTER WERE DRIVING THE VEHICLE TRAVELING THROUGH A MAJOR INTERSECTION AT NIGHT. WE WERE IN THE PROCESS OF A LEFT HAND TURN, AT THIS PARTICULAR INTERSECTION, 2 LANES OF TRAFFIC ARE TURNING LEFT AT THE SAME TIME. WE WERE ON THE INSIDE LANE, MAKING OUR TURN AND THE FOCUS SHUT OFF. WE WERE NEARLY REAR ENDED, AND BARELY AVOIDED A LARGE INTERSECTION ACCIDENT WITH TRAFFIC BEHIND US QUICKLY BRAKING AND SWERVING INTO THE OTHER LANE. IT WAS TERRIFYING! WE HAVE HAD THE FUEL PUMP REPLACED, AND EACH TIME OF OUR COMPLAINT, THE DEALER CANNOT DIAGNOSIS THE DIRECT PROBLEM. I HAVE READ NUMEROUS ARTICLES REGARDING OTHER FORD FOCUS VEHICLES HAVING SIMILAR PROBLEMS. JUST RECENTLY HAVE READ ABOUT THE PAINT CHIPPING OFF FROM THE INSIDE OF THE GAS TANK, CAUSING A BLOCKAGE, SO THAT FUEL CANNOT FLOW THROUGH INTO THE PUMP. THERE IS A DEFINITE PROBLEM. HOW MANY OTHER FOCUS OWNERS ARE EXPERIENCING THESE SAME REPEATED DIFFICULTIES? I PURCHASED THIS VEHICLE FOR A GOOD RELIABLE CAR FOR MY 16 YEAR DAUGHTER TO EVENTUALLY HAVE, AND CONSIDERING THE EXPERIENCES I HAVE HAD WITH SHUTTERING, SHUT OFFS..DO NOT WANT TO PUT HER BEHIND THE WHEEL OF THIS CAR FOR SAFETY REASONS. OUR PAPERWORK FROM THE DEALERSHIP SEEMS TO ACCUMULATING, WITH NO DIRECT ANSWERS.*AK
NHTSA ODI #762346
Mileage unknown · Apr 29, 2002
Engine And Engine CoolingUnknown Or Other
WHILE DRIVING MY 2001 FOCUS WAGON ON INTERSTATE OFF RAMPS IT STARTS TO STALL AND HESITATE. THE RPMS DROP OUT WITH ABSOLUTLY NO POWER. THIS HAS HAPPENED NUMEROUS TIMES AND IS REALLY SCARY. THE LAST TIME IT HAPPENED WAS YESTERDAY WHILE IWAS MERGING FROM A RAMP AND MY CAR DIED OUT INFRONT OF A SEMI TRYING TO GET ONTO THE RAMP.I PUL…
Read full complaint
WHILE DRIVING MY 2001 FOCUS WAGON ON INTERSTATE OFF RAMPS IT STARTS TO STALL AND HESITATE. THE RPMS DROP OUT WITH ABSOLUTLY NO POWER. THIS HAS HAPPENED NUMEROUS TIMES AND IS REALLY SCARY. THE LAST TIME IT HAPPENED WAS YESTERDAY WHILE IWAS MERGING FROM A RAMP AND MY CAR DIED OUT INFRONT OF A SEMI TRYING TO GET ONTO THE RAMP.I PULLED OVER AS FAR AS I COULD TO GET OUT OF HIS WAY HE LOCKED UP HIS BRAKES. I TAKE THIS SAME RAMP ALL THE TIME SINCE ITS ONMY WAY HOME FROM WORK. THIS PROBLEM STARTS IF I LET THE GAS GET BELOW A 1/2 TANK. I BEEN TO THE DEALER AND THEY CAN'T FIND ANYTHING WRONG. I AM BRINGING IT BACK TOMORROW AGAIN TO HAVE THEY FIND THE PROBLEM. I AM AT MY WITS END WITH THIS. I TOLD MY FAMILY ABOUT THE PROBLEM AND SAID IF I GET KILLED IN AN ACCIDENT ON A RAMP IT BECAUSE OF THE PROBLEM OF IT DYING. AND TO GO AFTER FORD FOR THIS. MY FAMILY HAS BEEN IN THE CAR WHEN THIS HAPPENS SO THEY KNOW WHAT I AM TALKING ABOUT. I WENT OVER YOUR OTHER COMPLAINTS ABOUT THIS VEHISCLE/ IT IS UNREAL THE AMOUNT OF PROBLEMS THAT I HAVE IN COMMON WITH THEM, IT WORRYS ME. I WAS GOING TO GIVE THIS CAR TO MY DAUGHTER TO DRIVE SHE 16 BUT NOT NOW. I WANT HER TO COME HOME IN ONE PIECE. I HAVE HAD A WATER NOISE IN THE DASH THEY CANT FIND, STICKING GAS PEDAL NOW FIX FOR NOE AFTER 2 TIMES IN THE SHOP. THE OIL SMELL IN THE CAR. LEAKING OIL I SEE IN IN THE DRIVEWAY BUT CAN'T SEEM TO FIND WHERE ITS COMMING FROM. I WISH I KNEW MORE ABOUT THE LEMON LAW A COUPLE OF MONTHS AGO. IT DOESN'T APPLY TO ME NOW BECAUSE OF MY MILEAGE. I DRIVE ABOUT 100 MILES A DAY. IF YOU HAVE ANY QUESTION PLEASE CONTACT ME. THANK YOU. *AK
NHTSA ODI #761347
Mileage unknown · Feb 14, 2002
Electrical SystemEngine And Engine CoolingParking Brake
PURCHASED CAR IN DECEMBER 2000 WITHIN DAYS BRAKES SQUEALING AND GRINDING..CALLED DEALER SAID TO LET WEAR IN..PROBLEM PERSISTED..ENGINE LIGHT CAME ON ..TOOK CAR TO NEAREST D DEALERSHIP..IN JANUARY 2001..BRAKES SHOES BACK AND PADS ON FRONT REPLACED. OXYGEN SENSOR, AND PARKING BRAKE REPLACED ..BRAKES STILL HAD PROBLEM ENGINE LIGHT …
Read full complaint
PURCHASED CAR IN DECEMBER 2000 WITHIN DAYS BRAKES SQUEALING AND GRINDING..CALLED DEALER SAID TO LET WEAR IN..PROBLEM PERSISTED..ENGINE LIGHT CAME ON ..TOOK CAR TO NEAREST D DEALERSHIP..IN JANUARY 2001..BRAKES SHOES BACK AND PADS ON FRONT REPLACED. OXYGEN SENSOR, AND PARKING BRAKE REPLACED ..BRAKES STILL HAD PROBLEM ENGINE LIGHT STILL ON..TOOK TO DEALERSHIP WHERE PURCHASED..KEPT 12 DAYS..BRAKES ADJUSTED AND COMPUTOR AND IGNITION WERE REPLACED..LIGHT OFF..BRAKES STILL TROUBLE..TOOK BACK NUMEROUS TIMES..FOR CHECK-UPS..AT 16,000 TOLD BRAKES NEED TO BE REPLACED IN FRONT AND TIRES WHERE ALL WORN AWAY ON INSIDE OF TIRE..BALD!! ..MANUFACTOR AND DEALER WOULD NOT PAY FOR..REPLACED ALL FOUR TIRES, ALIGNMENT, AND NEW BRAKES PUT ON FRONT BRAKES..CAR STILL NOT RIGHT WITH BRAKES..SHAKING VIOLENTLY OF CAR WHILE BRAKING AT ANY SPEED. OR GOING DOWNHILL .TOOK BACK TO DEALERSHIP ROTORS WERE NO GOOD AS WELL AS FRONT BRAKES. THEY REPLACED..INNER TIRES ALREADY WEARING OUT...BRAKES STILL GIVING NOISE AND GRINDING..TOOK BACK WITHIN MONTH..THEY SAID FINE..TOOK BACK AGAIN WHEN OIL CHANGED..BRAKES WHERE SAID TO BE FINE..BRAKES NOISY AND GRINDING AS USUAL..3 WEEKS LATER BRAKES FAILED..HAD CAR TOWED TO DEALERSHIP....THEY STATE NEEDS NEW BRAKES ON FRONT AND BACKSHOES CRACKED AND NEED NEW ROTORS...THEY KEEP SAYING ITS THE WAY WE DRIVE CAR...NO WAY..NEVER HAD THIS MUCH PROBLEM WITH ANY BRAKES IN ANY CAR WE HAVE OWNED...CAR IS VERY UNSAFE AND MADE WITH INFERIOR PRODUCTS.. (TIRESIZE: 15)
NHTSA ODI #758210
Mileage unknown · Feb 6, 2002
Electrical SystemPower TrainUnknown Or Other
AVANCE TRAC CONTROL DOESN'T ENGAGE AND/OR MULFUNCTIONS-DISABLING IT TOTAL. MANY ELECT PROBLEMS. TWICE IT HAS SHUT DOWN ON INTERSTATE I40 AT RATE OF SPEED OF 50 AND 60 AND ONCE AT MAYBE 5 MPH IN THE DRIVEWAY. WHEN IT SHUTS DOWN THERE IS NO WARNING. OTHER PROBLEMS W/THIS CAR HAVE BEEN RADIO HAD TO BE REPLACED, FUEL PUMP MODULE,…
Read full complaint
AVANCE TRAC CONTROL DOESN'T ENGAGE AND/OR MULFUNCTIONS-DISABLING IT TOTAL. MANY ELECT PROBLEMS. TWICE IT HAS SHUT DOWN ON INTERSTATE I40 AT RATE OF SPEED OF 50 AND 60 AND ONCE AT MAYBE 5 MPH IN THE DRIVEWAY. WHEN IT SHUTS DOWN THERE IS NO WARNING. OTHER PROBLEMS W/THIS CAR HAVE BEEN RADIO HAD TO BE REPLACED, FUEL PUMP MODULE, KEY GETS STUCK AND KEY WILLN'T TURN. *AK
NHTSA ODI #757888
Mileage unknown · Jul 17, 2001
Unknown Or Other
ELECTRICAL DOOR OPENER WILL NOT OPERATE WHILE VEHICLE IS STILL RUNNING. DEALER WAS NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION. *AK
NHTSA ODI #893059
Mileage unknown · Oct 8, 2000
Unknown Or Other
DASH LIGHTS FLASHED ON AND OFF SEVERAL TIMES THEN QUIT
NHTSA ODI #733707
Official recalls
7Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
Illustration