IllustrationGEAR SHIFT LOCKED WITHOUT WARNING. AS A RESULT, VEHICLE BECAME INOPERATIVE. *AK
2001 Ford Focus
Owner reports · Recalls · Investigations
More warning signs than most Focus years
Owner complaints for the 2001 Ford Focus are substantially higher than the model-year median of 864.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Focus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1350–25K
25825–50K
20050–75K
14775–100K
157100–150K
56150K+
953 reports with mileage · 808 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 496 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 277 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 243 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
172 crash reports47 fire reports110 injury reports
Power Train complaints
90 reportsTHE TRANSMISSION ON MY 2001 FORD FOCUS FAILED AFTER MY OWNING IT FOR LESS THAN 2 1/2 YEARS AND IT'S AROUND 58,000 MILES. I BOUGHT IT NEW. THE DEALERSHIP IS SURPRISED AND SAID THEY'VE NEVER SEEN THIS BEFORE; IT'S ONLY PARTIALLY BEING COVERED BY WARRANTY. *AK
WHILE DRIVING AT AN UNDETERMINED SPEED VEHICLE STALLED. CONSUMER TOOK VEHICLE TO DEALER, AND MECHANIC DETERMINED THAT ENGINE AND TRANSMISSION FAILED. *AK
CONSUMER RECEIVED A LETTER CONCERNING FUEL PUMP FILTERS. *PH ON SEVERAL OCCASIONS THE TRANSMISSION FAILED LEAVING THE CONSUMER STRANDED. THE DEALERSHIP REPLACED THE PART BUT THE TRANSMISSION FAILED AGAIN. *TT *JB
I PURCHASED A 2001 FORD FOCUS SE 4-DOOR SEDAN IN NOVEMBER 2002. THE CAR WAS A MANUFACTURER BUY-BACK FROM THE ORIGINAL OWNER AND HAD A SMALL WARRANTY LEFT. AT THE END OF NOVEMBER 2002, I BROUGHT THE CAR BACK TO THE DEALERSHIP TO HAVE THE SPARK PLUGS, SPARK PLUG WIRES AND A FAULTY BELT REPLACED. AT THE END OF DECEMBER 2002, …
Read full complaint
I PURCHASED A 2001 FORD FOCUS SE 4-DOOR SEDAN IN NOVEMBER 2002. THE CAR WAS A MANUFACTURER BUY-BACK FROM THE ORIGINAL OWNER AND HAD A SMALL WARRANTY LEFT. AT THE END OF NOVEMBER 2002, I BROUGHT THE CAR BACK TO THE DEALERSHIP TO HAVE THE SPARK PLUGS, SPARK PLUG WIRES AND A FAULTY BELT REPLACED. AT THE END OF DECEMBER 2002, THE CAR WAS MAKING A STRANGE NOISE AND THE ENGINE LIGHT WAS ON, SO I RETURNED THE CAR TO THE DEALERSHIP. A DAY OR SO BEFORE MY APPOINTMENT WITH THE DEALERSHIP, I RECEIVED A RECALL NOTICE FROM FORD REGARDING THE PINCH BOLT. UNFORTUNATELY, I RECEIVED THAT RECALL NOTICE TOO LATE THE FAULTY PINCH BOLT HAD ALREADY FAILED AND CAUSED SO MUCH DAMAGE TO THE RACK AND PINION THAT IT HAD TO BE REPLACED. I HAVE SINCE REPLACED THE FRONT BRAKES. I ALSO EXPERIENCED A FAULTY VALVE IN THE HEATING SYSTEM THAT WAS ALLOWING WATER TO FLOW INTO THE CAR'S CABIN AND SOAK THE CARPETING. GETTING TO THE TRANSMISSION PROBLEM, ABOUT A WEEK AGO, THE CAR REFUSED TO ACCELERATE GOING UP A HILL AND INSTEAD THE ENGINE REVVED. NO MATTER WHAT I TRIED, I COULD NOT GET THE CAR TO ACCELERATE PAST 30 MPH. SINCE THE CAR IS NOW LONG PAST ITS SMALL MANUFACTURERS WARRANTY, I HAD AN INDEPENDENT MECHANIC LOOK AT THE CAR. HE RECOMMENDED THAT I FLUSH THE TRANSMISSION AND SEE IF THAT WOULD HELP THE PROBLEM. I SPENT $100 ON A TRANSMISSION FLUSH. THAT DIDN'T WORK AND THE PROBLEM CONTINUES. I CALLED FORD MOTOR COMPANY TO COMPLAIN ABOUT THE CAR AND TO ASK FOR A BUYBACK, BUT MY REQUEST WAS REFUSED. I THEN TOOK MY CAR TO WISCASSET FORD. THEY DIAGNOSED THE PROBLEM(S) WITH THE CAR (AT NO CHARGE). I NEED A NEW TRANSMISSION. THEY GAVE ME TWO OPTIONS FOR PAYMENT. 1) PAY FOR THE NEW TRANSMISSION OUT-OF-POCKET, ESTIMATED COST AT $2500 - $3000; 2) BUY AN EXTENDED WARRANTY ON THE DRIVE TRAIN FOR $500. I AM PLANNING ON PURCHASING THE EXTENDED DRIVE TRAIN WARRANTY WHICH WILL ALLOW WISCASSET FORD TO REPLACE MY TRANSMISSION AND WILL ALSO GIVE ME AN EXTRA 15K MILES FOR THE DRIVE TRAIN.
I HAVE HAD NUMEROUS PROBLEMS WITH MY FOCUS. ABOUT 3MO AFTER I BOUGHT IT, THE TRANSMISSION BEGAN TO FEEL LIKE IT WAS SLIPPING, AND MAKING A NOISE. I TOOK IT TO THE PURCHASING DEALERSHIP, AND A MECHANIC TOLD ME IT WAS THE TORQUE CONVERTER. THEY DIDN'T HAVE A LOANER CAR FOR ME, SO I MADE AN AN APPOINTMENT FOR THE FOLLOWING WEEK. TH…
Read full complaint
I HAVE HAD NUMEROUS PROBLEMS WITH MY FOCUS. ABOUT 3MO AFTER I BOUGHT IT, THE TRANSMISSION BEGAN TO FEEL LIKE IT WAS SLIPPING, AND MAKING A NOISE. I TOOK IT TO THE PURCHASING DEALERSHIP, AND A MECHANIC TOLD ME IT WAS THE TORQUE CONVERTER. THEY DIDN'T HAVE A LOANER CAR FOR ME, SO I MADE AN AN APPOINTMENT FOR THE FOLLOWING WEEK. THE NEXT DAY ON MY WAY HOME FROM WORK, THE CAR SHUT DOWN. I CALLED A TOW TRUCK, THEY TOOK IT TO THE CLOSEST DEALERSHIP. WHEN I CALLED THE DEALERSHIP THE NEXT DAY, THEY SAID THE FUEL PUMP WENT OUT. THEY TOLD ME THAT THE STUTTER I WAS FEELING IN MY CAR WAS PROBABLY THAT. A FEW DAYS LATER, THE SAME PROBLEM. TOOK IT BACK TO THE SELLING DEALERSHIP, AND THE SHOP SUPERVISOR WENT OUT WITH ME. HE SAID I WAS DRIVING THE CAR OUT OF CONTEXT. WHAT HE MEANT BY THAT, HE WOULDN'T ELABORATE, BUT SAID THERE IS NOTHING WRONG WITH MY CAR. I HAVE BEEN DRIVING IT SINCE, AND THE COMPUTER WILL FADE IN AND OUT, BUT I WON'T LOSE ENGINE POWER. MY CAR HAS TO HAVE NEW BRAKE PADS EVERY COUPLE OF MONTHS, NEW TIRES, AND OTHER MAINTENANCE THINGS. AT LESS THAN 40000 MILES, IT NEEDED NEW SPARK PLUGS, AND WIRES, WHICH I HAPPILY BOUGHT. THE DEALERSHIP WANTED $300, BECAUSE THE PLUGS WERE IN THE BACK OF THE MOTOR. I WENT TO MY CAR, POPPED THE HOOD, FOUR SPARK PLUGS LINED THE TOP OF THE HEAD COVER. THERE WAS NO FURTHER EXPLANATION OF THE ATTEMPTED OVER CHARGE. MY CAR HAS SEVERAL OTHER PROBLEMS. THE POSITIVE CABLE ON THE BATTERY, HAS MELTED BACK, THERE IS A LOUD ROAR IN THE CAB OF THE CAR, AND THREE OF THE FOUR LUG NUTS ON THE RIGHT REAR TIRE HAS SNAPPED OFF. THE EXPLANATION FOR THE LUG NUTS, WAS THAT THE TIRE WAS LOOSE, NOT FASTENED PROPERLY. BUT THIS PROBLEM OCCURRED 3-4 MO AFTER I BOUGHT IT. THE TIRES HAD NOT BEEN TAKEN OFF. I AM TO THE POINT WHERE I HATE FORD FOR SELLING ME THIS CAR. I WILL EVER BUY FORD AGAIN, BUT I LOVE THE CONCEPT OF THE CAR
THE REASON SOME OF THESE ARE NOT DATED IS BECAUSE THE PROBLEMS KEEP ON PERSISTING THEY SAY THEY CAN NOT FIND OUT WHAT THE PROBLEM IS. MY CAR DIES ON ME AND THE CAN NOT FIND THE CAUSE. IT MAKES A WINDING SOUND WHEN I TAKE OFF AND STILL THEY CAN NOT FIND THE CAUSE. MY GEARS ALWAYS WIND AND AS SOON AS I GET IT OUT OF THE SHOP ABOUT…
Read full complaint
THE REASON SOME OF THESE ARE NOT DATED IS BECAUSE THE PROBLEMS KEEP ON PERSISTING THEY SAY THEY CAN NOT FIND OUT WHAT THE PROBLEM IS. MY CAR DIES ON ME AND THE CAN NOT FIND THE CAUSE. IT MAKES A WINDING SOUND WHEN I TAKE OFF AND STILL THEY CAN NOT FIND THE CAUSE. MY GEARS ALWAYS WIND AND AS SOON AS I GET IT OUT OF THE SHOP ABOUT ONE TO TWO WEEKS LATER IT IS DOING IT AGAIN, WHEN I AM DRIVING IT JERKS LIKE IT WANTS TO DIE OR GO OUT OF GEAR(KEEP IN MIND I HAVE HAD THESE PROBLEMS A COUPLE OF MONTHS AFTER I BOUGHT IT). I HAVE HAD TO REPLACE THE TIRES TWO TIMES I AM ON MY THIRD SET OF TIRES AND THEY ARE MESSED UP NOW. I AM NOT A BAD DRIVER I KNOW IT IS NOT ME I HAVE A CHILD THAT IS CONSTANTLY WITH ME I DO NOT DRIVE CRAZY TO MAKE ALL OF THESE PROBLEMS HAPPEN. I HAVE HAD THE BRAKE REPLACED ONCE ALREADY AND NOW THEY ARE SQEEKING AGAIN. MY CAR CIGARETTE LIGHTER KEEPS ON BURNING OUT. I JUST GET SO FRUSTRATED THAT I AM SPENDING ALL OF THIS MONEY FOR THEM TO WORK ON MY CAR WITH THE WARRANTY AND THEN TELL ME THEY DON'T KNOW WHAT THE PROBLEM IS AND NOW THE WARRANTY IS OUT I HAVE TO PAY FOR THIS PEICE OF JUNK. I HAVE HAD 2 OTHER CARS AND THEY NEVER GAVE ME ANY PROBLEMS AND KNOW I AM STUCK UNHAPPY EVERYDAY WITH THIS CAR I CAN NOT STAND TO DRIVE, I FEEL UNSAFE IN IT EVERYDAY.
ENGINE LIGHT ON. JERKY GEAR ENGAGING. CHOPPY ACCELERATION. 8/02 REPLACED ALTERNATOR 8/02 REPLACED V BELT 10/02 BLINKERS OUT & ELECTRIC WINDOWS BROKE 10/02 BATTERY LIGHT ON "CORROSION ON WIRES" 1/03 WOULDN'T START, BATTERY LIGHT ON, "WIRE FELL OFF ALTERNATOR" AIRBAG LIGHT ON THEN OFF
WHEN TRANSMISSION SHIFTS INTO 3RD GEAR IT FREEWHEELS AND OR WILL NOT PULL
REAR WHEEL BEARINGS ARE WEARING OUT ON VEHICLE.*MR THE AUTOMATIC TRANSMISSION DOES NOT SHIFT PROPERLY, THE CONSUMER DISCOVERED THE WRONG TRANSMISSION FLUID WAS IN THE VEHICLE. THE FRONT WINDSHIELD CRACKED DUE TO EXCESSIVE HEAT. THE REAR SEAT LATCH, THE SEAT FABRIC AND THE KEY IGNITION FAILED.*TS THE WINDSHIELD WIPERS WORE OUT,…
Read full complaint
REAR WHEEL BEARINGS ARE WEARING OUT ON VEHICLE.*MR THE AUTOMATIC TRANSMISSION DOES NOT SHIFT PROPERLY, THE CONSUMER DISCOVERED THE WRONG TRANSMISSION FLUID WAS IN THE VEHICLE. THE FRONT WINDSHIELD CRACKED DUE TO EXCESSIVE HEAT. THE REAR SEAT LATCH, THE SEAT FABRIC AND THE KEY IGNITION FAILED.*TS THE WINDSHIELD WIPERS WORE OUT, WHICH WERE ONLY USED ABOUT SEVEN TIMES AND THE REAR BRAKES HAD TO BE REPLACED. *JB
Official recalls
705V030000 · Latches/locks/linkages:doors:latch
Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
03V482000 · Fuel System, Gasoline
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
02V288000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
02V289000 · Steering:linkages
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
01V258000 · Visibility:windshield Wiper/washer:motor
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
01V108000 · Seats:front Assembly:recliner
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
00V418000 · Seats:front Assembly:recliner
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.