NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
277 reportsClear category filterMileage unknown · Aug 22, 2007
Engine And Engine CoolingEquipmentFuel System, Gasoline
BOUGHT NEW IN '01 FORD FOCUS. NOTICED RIGHT OFF BRAKES WOULD MAKE A GRINDING NOISE AND SQUEAK. TIRES WERE WORN REAL BAD ON INSIDE ON ONE FRONT SIZE SINCE WE BOUGHT IT. REPEATED ALIGNMENTS WITH NO IMPROVEMENT. STILL EXPERIENCE THIS PROBLEM. STARTED EXPERIENCING PROBLEMS WITH IT MISSING DURING ACCELERATION. CHECK ENGINE LIGHT CAME…
Read full complaint
BOUGHT NEW IN '01 FORD FOCUS. NOTICED RIGHT OFF BRAKES WOULD MAKE A GRINDING NOISE AND SQUEAK. TIRES WERE WORN REAL BAD ON INSIDE ON ONE FRONT SIZE SINCE WE BOUGHT IT. REPEATED ALIGNMENTS WITH NO IMPROVEMENT. STILL EXPERIENCE THIS PROBLEM. STARTED EXPERIENCING PROBLEMS WITH IT MISSING DURING ACCELERATION. CHECK ENGINE LIGHT CAME ON IN FEBRUARY 2005 AND TOOK IT TO THE DEALERSHIP. THEY REPLACED SENSORS THAT HAD RECALL,WAS RECALL CODE P0401. ENGINE LIGHT STAYED ON. THEY SAID THAT WE WERE USING GAS THAT WAS DIRTY AND WAITING TOO LATE TO PUT GAS INTO THE CAR AND THAT WAS WHY IT WAS STALLING. WE PAID $272.98 FOR THEM TO REPLACE THIS WHOLE SECTION THAT HAD TO DO WITH THE FUEL BEING FILTERED. CAR LOSES POWER AND STUTTERS GOING AROUND CURVES WITH EVEN OVER A HALF A TANK OF GAS. STALLING TO THE POINT WE MUST PULL OVER INTO THE EMERGENCY LANE AFRAID OF ACCIDENT! I OWN CAR I BOUGHT BRAND NEW AND IT JERKS AND SPUTTERS LIKE SOME PIECE OF CRAP FROM JD BYRIDER! EVERYTIME WE START THE CAR YOU SMELL OIL BURNING FOR15 MINUTES AFTERWARDS. HAD IT CHECKED NO LEAKS OR ANYTHING COULD BE FOUND. APRIL OF 2005 NOTICED WHEN THE CAR IDLED AT A TRAFFIC LIGHT THE THERMOSTAT WOULD SHOW SHOOT UP SHOWING IT WAS RUNNING HOT! TOOK IT IN TO THE DEALERSHIP AND THEY FOUND ANTI-FREEZE LEAKING. WAS TOLD THE THERMOSTAT HOUSING AND THERMOSTAT HAD TO BE REPLACED. RETESTED IT AND WAS TOLD PROBLEM SOLVED. OUR BILL WAS $375.00. THIS WAS FIRST BRAND NEW CAR AND WAS TAKEN WELL CARE OF, IT ONLY HAS AROUND 78,000 MILES ON THE ODOMETER. I WAS TOLD THERE WAS A SILENT RECALL ON THESE FOR THE ENGINE PROBLEMS AND THEY WERE BEING FIXED FOR NO COST TO THE OWNER. WE WERE NOT NOTIFIED OF A RECALL AND PAID FOR ALL OF THIS OUT OF POCKET .CAR IS PAID OFF NOW AND CANNOT ENJOY HAVING A PAID OFF CAR WITH LOW MILEAGE BECAUSE WE ARE SCARED TO DRIVE IT AND BOUGHT A NEW CAR THAT WAS SAFE TO DRIVE AROUND WITH OUR KIDS! TIME GOES ON AND IT IS GETTING WORSE. SOMETIMES NOT WANTING TO START AT ALL! ENGINE STILL STALLS DESPITE ALL THESE REPAIRS. *TR
NHTSA ODI #10200528
158,000 miles · Aug 6, 2007
Fuel System, GasolineFuel System, Other
INITIALLY THE PROBLEM SEEMED TO BE HESITATION IN THE TRANSMISSION AT HIGH SPEED ON THE HIGHWAY. HOWEVER, IT GRADUALLY WORSENED AND RESULTED IN SURGING AND LOSS OF POWER. THE THROTTLE BECAUSE TOTALLY UNRESPONSIVE AND I HAD TO COAST TO A STOP ON THE SIDE OF A BUSY HIGHWAY. THE CAR IS IN THE SHOP PRESENTLY. GIVEN THE AMOUNT OF D…
Read full complaint
INITIALLY THE PROBLEM SEEMED TO BE HESITATION IN THE TRANSMISSION AT HIGH SPEED ON THE HIGHWAY. HOWEVER, IT GRADUALLY WORSENED AND RESULTED IN SURGING AND LOSS OF POWER. THE THROTTLE BECAUSE TOTALLY UNRESPONSIVE AND I HAD TO COAST TO A STOP ON THE SIDE OF A BUSY HIGHWAY. THE CAR IS IN THE SHOP PRESENTLY. GIVEN THE AMOUNT OF DATA OUT THERE TO SHOW THIS IS A COMMON DEFECT FOR THE 2001 FOCUS, I EXPECT FORD TO COVER THE REPAIR. *TR
NHTSA ODI #10198596
546 miles · Aug 3, 2007
Fuel System, Gasoline
JULY 11, 07 I HAD TO TRAVEL FOR WORK AND THREE HOURS OUT THE CAR STOPPED IN THE ROAD AND AT THAT TIME THE CAR CONTINUED TO ROLL SO I MERGED TO THE SIDE TO GET OF THE ROAD, THE ENGINE LIGHT CAME ON AND DIDN'T START TILL 30MIN LATER. I HAD TO TURN BACK AROUND AND HEAD HOME AND THE CAR CONTINUED TO STOP AND START OVER 20 TIMES TIL…
Read full complaint
JULY 11, 07 I HAD TO TRAVEL FOR WORK AND THREE HOURS OUT THE CAR STOPPED IN THE ROAD AND AT THAT TIME THE CAR CONTINUED TO ROLL SO I MERGED TO THE SIDE TO GET OF THE ROAD, THE ENGINE LIGHT CAME ON AND DIDN'T START TILL 30MIN LATER. I HAD TO TURN BACK AROUND AND HEAD HOME AND THE CAR CONTINUED TO STOP AND START OVER 20 TIMES TILL I MADE IT HOME. AT TIMES IT WOULD NOT PICK UP SPEED OR IT WOULD DECREASE. 07-26-07 I TOOK IT TO A FORD DEALERSHIP SERVICE CENTER AND THEY BROUGHT UP THAT THE PROBLEM WAS IN THE FUEL PUMP, FUEL FILTER AND PC VALVE AND OTHER ITEMS THAT DID NOT PERTAIN TO THE PROBLEM BUT NEEDED FUTURE ATTENTION. THE LADY WHO HELPED ME TOLD ME I NEED AN UPDATED VERSION OF THE FUEL PUMP AND WAS CHARGED $590.43 FOR EVERYTHING INCLUDING FEES. AUGUST 1ST, 2007 A FRIEND HAD TOLD ME THAT A DEALERSHIP IN HIS AREA WAS REPLACING ALL FUEL PUMPS FOR FORD FOCUS 2001 THAT FAILED WITHIN AN EXTENDED WARRANTY OF 7 YEARS UNDER 100,000 MILES AND THAT THE COMPANY WAS NOT TELLING ANYONE UNTIL THE PART FAILED AND THEY BROUGHT IT IN FOR SERVICE. I LOOKED UP THE CLAIM ON THE INTERNET AND FOUND THAT IT WAS TRUE. I GOT INFORMATION FROM THE DEALERSHIP AND COMPANY THAT MY PARTICULAR VEHICLE NUMBER , WAS NOT INCLUDED IN THE REPLACEMENT PROGRAM. I STILL HAVE NO ANSWER AS TO WHY MY VEHICLE WAS NOT SELECTED WHEN MY CAR CLEARLY SHOWED SYMPTOMS OF THE DEFECTED FUEL PUMP. THE ANSWER I RECEIVE WAS THAT IT COULD BE A VARIABLE OF REASONS INCLUDING WHERE IT WAS MADE AND WHERE THE PART WAS MADE. I WAS ALSO TOLD THAT MY CAR HAS A 3YR WARRANTY AND THERE IS NOTHING THAT THEY COULD ASSIST ME WITH. THE MORE I TRIED TO GET ANSWERS ABOUT THE PROGRAM AND THE CARS INVOLVED, WHO I CAN SPEAK TO OR WHAT CAN I DO TO SOLVE THIS ISSUE THE MORE THE REPRESENTATIVES GOT AGGRAVATED AND RUDE. SINCE FORD WOULD NOT PROVIDE ME WITH DETAILS OR HELP WITH MY FUEL PUMP DEFECT I WANTED TO SEEK HELP THROUGH THE NHTSA TO DO AN INVESTIGATION OF MY VEHICLE IN ORDER TO PUSH A RECALL FOR MY MODEL. *TR
NHTSA ODI #10198414
84,000 miles · Jul 24, 2007
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING 58 MPH THE FUEL PUMP FAILED ON TWO OCCASIONS. THE DEALER STATED THAT THE FUEL DELIVERY MODULE FAILED. THE CURRENT AND FAILURE MILEAGES WERE 84,000.
NHTSA ODI #10197336
90,000 miles · Jun 4, 2007
Fuel System, GasolineCrash
TL*THE CONTACT OWNS A 2001 FORD FOCUS SE. THE CONTACT STATED THAT THE VEHICLE WOULD HESITATE AND LOOSE POWER WHILE DRIVING. THE FAILURE OCCURRED WITHOUT WARNING. THE DEALER REPLACED THE FUEL FILTER, BUT THE FAILURE PERSISTS. THE CONTACT STATED THAT THE FAILURE HAS BEEN ONGOING AND RESULTED IN A VEHICLE CRASH. THE MANUFACTUR…
Read full complaint
TL*THE CONTACT OWNS A 2001 FORD FOCUS SE. THE CONTACT STATED THAT THE VEHICLE WOULD HESITATE AND LOOSE POWER WHILE DRIVING. THE FAILURE OCCURRED WITHOUT WARNING. THE DEALER REPLACED THE FUEL FILTER, BUT THE FAILURE PERSISTS. THE CONTACT STATED THAT THE FAILURE HAS BEEN ONGOING AND RESULTED IN A VEHICLE CRASH. THE MANUFACTURER STATED THAT HER VEHICLE WAS NOT INCLUDED AS PART OF ANY RECALLS. A VALID VIN, THE ENGINE SIZE, AND POWERTRAIN WERE UNKNOWN. THE CURRENT MILEAGE IS 110,000 AND FAILURE MILEAGE WAS 90,000.
NHTSA ODI #10192415
71,000 miles · May 16, 2007
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING 65 MPH, THE VEHICLE BEGAN TO HESITATE AND EVENTUALLY SHUT OFF. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO THE DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE CONTACT RESTARTED THE VEHICLE AND DROVE AWAY, ONLY TO ENCOUNTER THE SAME FAILURE. A DIFFERENT DEALER REPLAC…
Read full complaint
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING 65 MPH, THE VEHICLE BEGAN TO HESITATE AND EVENTUALLY SHUT OFF. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO THE DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE CONTACT RESTARTED THE VEHICLE AND DROVE AWAY, ONLY TO ENCOUNTER THE SAME FAILURE. A DIFFERENT DEALER REPLACED THE FUEL PUMP ASSEMBLY. THIS IS THE SECOND TIME THE FUEL PUMP ASSEMBLY HAD BEEN REPLACED. THE FIRST TIME WAS IN 2004 AT 40,000 MILES. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 72,000 AND FAILURE MILEAGE WAS 71,000. UPDATED 06/26/07 *TR
NHTSA ODI #10190896
53,800 miles · May 14, 2007
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE CURRENT AND FAILURE MILEAGE WERE 53800. WHILE DRIVING AT 35 MPH UNDER NORMAL DRIVING CONDITIONS, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO ROLL THE VEHICLE INTO A PARKING LOT. AFTER ABOUT FIVE MINUTES THE CONTACT WAS ABLE TO START THE VEHICLE AGAIN. THE VEHICLE WA…
Read full complaint
TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE CURRENT AND FAILURE MILEAGE WERE 53800. WHILE DRIVING AT 35 MPH UNDER NORMAL DRIVING CONDITIONS, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO ROLL THE VEHICLE INTO A PARKING LOT. AFTER ABOUT FIVE MINUTES THE CONTACT WAS ABLE TO START THE VEHICLE AGAIN. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE FUEL PUMP FAILED. SAME PROBLEM AS NHTSA RECALL # 03V482000.
NHTSA ODI #10190681
39,800 miles · Apr 20, 2007
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING 70 MPH THE ENGINE HESITATED, SPUTTERED, AND COMPLETELY SHUT OFF. THE ENGINE WARNING LIGHT ILLUMINATED IMMEDIATELY AFTERWARDS. THE CONTACT STATED THAT THE ENGINE WAS WARM AND THERE WAS APPROXIMATELY 1/4 OF A TANK OF GAS IN THE VEHICLE. HE HAD TO WAIT APPROXIMATELY 5 MINUTE…
Read full complaint
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING 70 MPH THE ENGINE HESITATED, SPUTTERED, AND COMPLETELY SHUT OFF. THE ENGINE WARNING LIGHT ILLUMINATED IMMEDIATELY AFTERWARDS. THE CONTACT STATED THAT THE ENGINE WAS WARM AND THERE WAS APPROXIMATELY 1/4 OF A TANK OF GAS IN THE VEHICLE. HE HAD TO WAIT APPROXIMATELY 5 MINUTES BEFORE HE WAS ABLE TO RESTART THE VEHICLE. A DEFECT INVESTIGATION RECALL CAMPAIGN # 03V482000 INCLUDED SIMILAR SYMPTOMS. THE DEALER STATED THAT THE FAILURE WAS THE FUEL PUMP. THE FUEL PUMP WAS REPLACED, AND NO OTHER FAILURES HAVE OCCURRED. THE CURRENT MILEAGE IS 40,500 AND FAILURE MILEAGE WAS 39,800.AK
NHTSA ODI #10188425
Mileage unknown · Apr 17, 2007
Fuel System, Gasoline
2001 FORD FOCUS CUSTOMER STATES THAT THE FUEL PUMP AND FUEL FILTER ARE BAD AN NEEDS TO BE RECALLED**CC AFTER THE REPAIRS WERE MADE IN LATE SUMMER OF 2004, THE CONSUMER EXPERIENCED THE SAME PROBLEMS IN MARCH 2007 THE PUMP WAS REPLACED AGAIN. THE MANUFACTURER REFERRED TO THE PROBLEM AS A SAFETY AND CUSTOMER SATISFACTION ISSUE NO…
Read full complaint
2001 FORD FOCUS CUSTOMER STATES THAT THE FUEL PUMP AND FUEL FILTER ARE BAD AN NEEDS TO BE RECALLED**CC AFTER THE REPAIRS WERE MADE IN LATE SUMMER OF 2004, THE CONSUMER EXPERIENCED THE SAME PROBLEMS IN MARCH 2007 THE PUMP WAS REPLACED AGAIN. THE MANUFACTURER REFERRED TO THE PROBLEM AS A SAFETY AND CUSTOMER SATISFACTION ISSUE NOT A RECALL.*JB UPDATED 06/26/07. *JB
NHTSA ODI #10188990
140,000 miles · Apr 10, 2007
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
TL* - THE CONTACT OWNS A 2001 FORD FOCUS WITH A CURRENT AND FAILURE MILEAGE OF 140,000. THE CONTACT STATED THAT SHE WAS DRIVING 55 MPH ON A HOT DAY AND THE VEHICLE WOULD SPUTTER AND LOSE ACCELERATION , THEN LOST POWER. THE CONTACT STATED THAT THE ENGINE WOULD STALL, BUT THE CAR WOULD STILL BE DRIVING UNTIL THE CONTACT APPLIED T…
Read full complaint
TL* - THE CONTACT OWNS A 2001 FORD FOCUS WITH A CURRENT AND FAILURE MILEAGE OF 140,000. THE CONTACT STATED THAT SHE WAS DRIVING 55 MPH ON A HOT DAY AND THE VEHICLE WOULD SPUTTER AND LOSE ACCELERATION , THEN LOST POWER. THE CONTACT STATED THAT THE ENGINE WOULD STALL, BUT THE CAR WOULD STILL BE DRIVING UNTIL THE CONTACT APPLIED THE BRAKES. THE CONTACT HAD THE MECHANIC CHANGED THE SPARK PLUGS, WIRES, AND FUEL FILTER, BUT THE PROBLEM PERSISTED. THE CONTACT CALLED THE MANUFACTURER, AND THEY TOLD HIM TO TAKE IT TO THE FORD DEALER TO GET IT DIAGNOSED. THE MECHANIC STATED THAT IT WAS A FAILURE IN THE FUEL DISTRIBUTION SYSTEM, BUT THE PARTS WERE ON NATIONWIDE BACK ORDER. *AK
NHTSA ODI #10187509
Official recalls
7Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
Illustration