IllustrationA/C FAN SWITCH BURNED ALONG WITH THE CONNECTING WIRE BLOCK, PUTTING SMOKE INTO THE VEHICLE, IF THE VEHICLE HADN'T BEEN TURNED OFF AFTER SEEING SMOKE COULD HAVE RESULTED IN FIRE. *TR
2001 Ford Focus
Owner reports · Recalls · Investigations
More warning signs than most Focus years
Owner complaints for the 2001 Ford Focus are substantially higher than the model-year median of 864.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Focus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1350–25K
25825–50K
20050–75K
14775–100K
157100–150K
56150K+
953 reports with mileage · 808 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 496 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 277 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 243 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
172 crash reports47 fire reports110 injury reports
Equipment complaints
34 reportsBOUGHT NEW IN '01 FORD FOCUS. NOTICED RIGHT OFF BRAKES WOULD MAKE A GRINDING NOISE AND SQUEAK. TIRES WERE WORN REAL BAD ON INSIDE ON ONE FRONT SIZE SINCE WE BOUGHT IT. REPEATED ALIGNMENTS WITH NO IMPROVEMENT. STILL EXPERIENCE THIS PROBLEM. STARTED EXPERIENCING PROBLEMS WITH IT MISSING DURING ACCELERATION. CHECK ENGINE LIGHT CAME…
Read full complaint
BOUGHT NEW IN '01 FORD FOCUS. NOTICED RIGHT OFF BRAKES WOULD MAKE A GRINDING NOISE AND SQUEAK. TIRES WERE WORN REAL BAD ON INSIDE ON ONE FRONT SIZE SINCE WE BOUGHT IT. REPEATED ALIGNMENTS WITH NO IMPROVEMENT. STILL EXPERIENCE THIS PROBLEM. STARTED EXPERIENCING PROBLEMS WITH IT MISSING DURING ACCELERATION. CHECK ENGINE LIGHT CAME ON IN FEBRUARY 2005 AND TOOK IT TO THE DEALERSHIP. THEY REPLACED SENSORS THAT HAD RECALL,WAS RECALL CODE P0401. ENGINE LIGHT STAYED ON. THEY SAID THAT WE WERE USING GAS THAT WAS DIRTY AND WAITING TOO LATE TO PUT GAS INTO THE CAR AND THAT WAS WHY IT WAS STALLING. WE PAID $272.98 FOR THEM TO REPLACE THIS WHOLE SECTION THAT HAD TO DO WITH THE FUEL BEING FILTERED. CAR LOSES POWER AND STUTTERS GOING AROUND CURVES WITH EVEN OVER A HALF A TANK OF GAS. STALLING TO THE POINT WE MUST PULL OVER INTO THE EMERGENCY LANE AFRAID OF ACCIDENT! I OWN CAR I BOUGHT BRAND NEW AND IT JERKS AND SPUTTERS LIKE SOME PIECE OF CRAP FROM JD BYRIDER! EVERYTIME WE START THE CAR YOU SMELL OIL BURNING FOR15 MINUTES AFTERWARDS. HAD IT CHECKED NO LEAKS OR ANYTHING COULD BE FOUND. APRIL OF 2005 NOTICED WHEN THE CAR IDLED AT A TRAFFIC LIGHT THE THERMOSTAT WOULD SHOW SHOOT UP SHOWING IT WAS RUNNING HOT! TOOK IT IN TO THE DEALERSHIP AND THEY FOUND ANTI-FREEZE LEAKING. WAS TOLD THE THERMOSTAT HOUSING AND THERMOSTAT HAD TO BE REPLACED. RETESTED IT AND WAS TOLD PROBLEM SOLVED. OUR BILL WAS $375.00. THIS WAS FIRST BRAND NEW CAR AND WAS TAKEN WELL CARE OF, IT ONLY HAS AROUND 78,000 MILES ON THE ODOMETER. I WAS TOLD THERE WAS A SILENT RECALL ON THESE FOR THE ENGINE PROBLEMS AND THEY WERE BEING FIXED FOR NO COST TO THE OWNER. WE WERE NOT NOTIFIED OF A RECALL AND PAID FOR ALL OF THIS OUT OF POCKET .CAR IS PAID OFF NOW AND CANNOT ENJOY HAVING A PAID OFF CAR WITH LOW MILEAGE BECAUSE WE ARE SCARED TO DRIVE IT AND BOUGHT A NEW CAR THAT WAS SAFE TO DRIVE AROUND WITH OUR KIDS! TIME GOES ON AND IT IS GETTING WORSE. SOMETIMES NOT WANTING TO START AT ALL! ENGINE STILL STALLS DESPITE ALL THESE REPAIRS. *TR
RADIO/CD/CLOCK UNIT APPEARS TO SHORT OUT AT VARIOUS UNPREDICTABLE TIMES. THE CD OR RADIO WILL ACT AS IF THE UNIT IS TURNED OFF; HOWEVER THE CLOCK DISPLAY ALSO DISAPPEARS FROM THE PANEL. AFTER 10 MINUTES OR LONGER THE CLOCK DISPLAY WILL RETURN TO THE SCREEN - WITH THE CORRECT TIME AND THE RADIO/CD PORTION CAN BE TURNED BACK ON AS…
Read full complaint
RADIO/CD/CLOCK UNIT APPEARS TO SHORT OUT AT VARIOUS UNPREDICTABLE TIMES. THE CD OR RADIO WILL ACT AS IF THE UNIT IS TURNED OFF; HOWEVER THE CLOCK DISPLAY ALSO DISAPPEARS FROM THE PANEL. AFTER 10 MINUTES OR LONGER THE CLOCK DISPLAY WILL RETURN TO THE SCREEN - WITH THE CORRECT TIME AND THE RADIO/CD PORTION CAN BE TURNED BACK ON AS IF WAS TURNED OFF. DURING THESE "SHUTDOWNS" I CAN NOT DO ANYTHING TO MAKE THE UNIT WORK. THIS INCLUDES USING THE ON OFF BUTTONS AND ANY AND ALL OF THE OTHER CONTROL OPTION/BUTTONS. THIS HAS HAPPENED THREE TIMES THAT I AM AWARE OF SINCE I HAVE BEEN DRIVING THIS 01 FOCUS 4 DOOR MODEL. STARTING IN APRIL OF THIS YEAR 2006. *JB
I WAS DRIVING MY 2001 FORD FOCUS IN THE LEFT LANE OF A 2 LANE HIGHWAY AT ABOUT 40 MPH WHEN I TURNED THE AC ON AND THE CAR JUST STOPPED. I TOOK IT TO A GARAGE AND THEY TOLD ME I NEEDED A NEW COMPRESSOR WHICH WOULD COST 1000 DOLLARS..I FOUND A GARAGE THAT WOULD DO IT FOR LESS USING A USED ONE...MY PROBLEM WAS THIS WOULD HAPPEN EVE…
Read full complaint
I WAS DRIVING MY 2001 FORD FOCUS IN THE LEFT LANE OF A 2 LANE HIGHWAY AT ABOUT 40 MPH WHEN I TURNED THE AC ON AND THE CAR JUST STOPPED. I TOOK IT TO A GARAGE AND THEY TOLD ME I NEEDED A NEW COMPRESSOR WHICH WOULD COST 1000 DOLLARS..I FOUND A GARAGE THAT WOULD DO IT FOR LESS USING A USED ONE...MY PROBLEM WAS THIS WOULD HAPPEN EVERY TIME I TURNED THE AIR OR THE DEFROSTER ON. I WAS AFRAID I WOULD CAUSE AN ACCIDENT..AND AM STILL AFRAID TODAY WHEN I DRIVE IT FAR..WONDERING IF IT WILL STALL OUT AT HIGH SPEED AGAIN AND CAUSE ME TO HAVE AN ACCIDENT. I ALSO HAVE HAD PROBLEMS WITH THE KEY JAMMING AND NOT TURNING AND MY NEWEST PROBLEM IS I STOPPED FOR GAS AND WHEN I TRIED TO START IT ALL I GOT WAS A CLICKING SOUND.. *NM
2001 FORD FOCUS AIR CONDITIONING WAS REPAIRED DUE TO LEAK, CONSUMER WOULD LIKE TO BE REIMBURSED FOR PARTS. *KB ***NAR*** THE EVAPORATOR AND HEATER CORE WAS LEAKING. *JB
2001 FORD FOCUS WORE THROUGH AN AIR CONDITIONING HOSE. *TS ***NO ANSWER REQUIRED*** THE CONSUMER STATED THE AIR CONDITIONING HOSE WAS DESIGNED POORLY. IT HANGS DOWN BETWEEN THE FRONT TIRES AND IF THE TIRES COME UP AGAINST A CURB, IT SMASHES THE HOSE INTO THE ALTERNATOR PULLEY. NOT ONLY THAT, IF THE HOSE BREAKS, IT LEAKS OI…
Read full complaint
2001 FORD FOCUS WORE THROUGH AN AIR CONDITIONING HOSE. *TS ***NO ANSWER REQUIRED*** THE CONSUMER STATED THE AIR CONDITIONING HOSE WAS DESIGNED POORLY. IT HANGS DOWN BETWEEN THE FRONT TIRES AND IF THE TIRES COME UP AGAINST A CURB, IT SMASHES THE HOSE INTO THE ALTERNATOR PULLEY. NOT ONLY THAT, IF THE HOSE BREAKS, IT LEAKS OIL AND THEN A BELT HAS TO BE REPLACED. *JB
POORLY DESIGNED IGNITION CYLINDERS. THIS CAUSES THE TUMBLERS TO FAIL RESULTING IN A LOCK-UP OF THE IGNITION. THE OWNER CANNOT TURN THE KEY TO START THE CAR AND AS A RESULT, HAS TO BE TOWED. I WAS TOLD THAT THE IGNITION CYLINDERS IN THE 2000 AND 2001 FOCUS WERE THE EUROPEAN DESIGN. I HAVE HAD TO REPLACE MY CYLINDER TWICE.…
Read full complaint
POORLY DESIGNED IGNITION CYLINDERS. THIS CAUSES THE TUMBLERS TO FAIL RESULTING IN A LOCK-UP OF THE IGNITION. THE OWNER CANNOT TURN THE KEY TO START THE CAR AND AS A RESULT, HAS TO BE TOWED. I WAS TOLD THAT THE IGNITION CYLINDERS IN THE 2000 AND 2001 FOCUS WERE THE EUROPEAN DESIGN. I HAVE HAD TO REPLACE MY CYLINDER TWICE. ONCE IT WAS COVERED UNDER WARRANTY, THE SECOND TIME IT WAS NOT AND I HAD TO PAY $200. THERE ARE OTHER FOCUS OWNERS WHO HAVE THIS PROBLEM. SEE THE WEBSITES BELOW. HTTP://WWW.AUTOWHIZ.COM/MESSAGEBOARDS/MESSAGE.PHP?ID=1784 HTTP://CONSUMERAFFAIRS.COM/AUTOMOTIVE/FORD_FOCUS_IGNITION.HTML HTTP://TOWNHALL-TALK.EDMUNDS.COM/DIRECT/VIEW/.EEA6DD2/286 AMONG MANY OTHERS I WAS TOLD THAT THEY PUT AN ENGINEER IN THE POSITION TO SPECIFICALLY RE-DESIGN THE IGNITION CYLINDER. SO WHILE FORD CONTINUALLY CLAIMS TO NOT KNOW ABOUT THE PROBLEM, IT IS APPARENT THAT THEY DID. WHILE THERE WERE NO DEATHS NOR INJURIES, IT IS NOT UP TO THE PEOPLE TO PAY FOR FORD'S POOR QUALITY. *NM
MY STEERING COLUMN LOCKS UP AND WILL NOT ALLOW ME TO TURN THE CAR ON. I DROVE MY CAR TO WORK NO PROBLEM WHEN I CAME OUT I COULD NOT GET THE KEY TO TURN IN THE IGNITION. THE STEERING WHEEL IS LOCKED AND WILL NOT MOVE THEREBY NOT ALLOWING ME TO TRUN THE CAR ON
I HAVE REPLACED MY ROTORS AND BRAKES 3 TIMES ALREADY AND NOW THEY ARE STARTING TO MAKE THAT SOUND AGAIN WHERE IT STARTS TO DRAG. I JUST REPLACED MY BRAKES IN MAY OF 2004 AND I HAVE ONLY DRIVEN IT 8,000 MILES. I STILL HAVE 4,000 MILES LEFT ON THE WARRANTY. I TOOK IT IN TO BILL PIERRE FORD AND THEY TOLD ME IT WAS NORMAL TO HAVE TH…
Read full complaint
I HAVE REPLACED MY ROTORS AND BRAKES 3 TIMES ALREADY AND NOW THEY ARE STARTING TO MAKE THAT SOUND AGAIN WHERE IT STARTS TO DRAG. I JUST REPLACED MY BRAKES IN MAY OF 2004 AND I HAVE ONLY DRIVEN IT 8,000 MILES. I STILL HAVE 4,000 MILES LEFT ON THE WARRANTY. I TOOK IT IN TO BILL PIERRE FORD AND THEY TOLD ME IT WAS NORMAL TO HAVE THIS NIOSE AND THAT THERE IS PLENTY OF BRAKE LEFT. I AM THINKING THAT THEY ARE WANTING ME TO DRIVE IT UNTIL THE WARRANTY IS UP SO I WILL HAVE TO REPLACE THE ROTORS AND BRAKE PADS AND PAY OUT OF MY POCKET INSTEAD OF JUST REPLACEING THEM NOW! I AM VERY IRRITATED NOW CAUSE I CAN NOT GET ANY HELP AND IT IS GOING TO COST ME ANOTHER $600.00 DOLLARS!! I HAVE ALREADY REPLACED THEM 3 TIMES OUT OF MY POCKET . WHAT THE HELL IS GOING ON WITH FORD HOW CAN THEY GET AWAY WITH THIS!*AK
2001 FORD FOCUS IGNITION LOCKS. UNABLE TO START VEHICLE. *AK
Official recalls
705V030000 · Latches/locks/linkages:doors:latch
Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
03V482000 · Fuel System, Gasoline
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
02V288000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
02V289000 · Steering:linkages
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
01V258000 · Visibility:windshield Wiper/washer:motor
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
01V108000 · Seats:front Assembly:recliner
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
00V418000 · Seats:front Assembly:recliner
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.