NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
243 reportsClear category filterMileage unknown · May 20, 2013
Electrical SystemEngine And Engine Cooling
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE FLOOR MAT BECAME WET. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE CONDENSER BOX TO THE AIR CONDITIONING UNIT WAS CRACKED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WA…
Read full complaint
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE FLOOR MAT BECAME WET. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE CONDENSER BOX TO THE AIR CONDITIONING UNIT WAS CRACKED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS UNKNOWN. *TR
NHTSA ODI #10512897
157,000 miles · Aug 23, 2012
Engine And Engine CoolingFuel System, Gasoline
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT WAS TRAVELING 30 MPH WHEN THE VEHICLE STALLED. THE VEHICLE WAS RESTARTED SHORTLY THEREAFTER. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT THE VIN FAILED TO QUALIFY UNDER NHTSA CAMPAIGN ID NUMBER:03V482000 ( FUEL SYSTEM, GASOLINE). …
Read full complaint
TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT WAS TRAVELING 30 MPH WHEN THE VEHICLE STALLED. THE VEHICLE WAS RESTARTED SHORTLY THEREAFTER. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT THE VIN FAILED TO QUALIFY UNDER NHTSA CAMPAIGN ID NUMBER:03V482000 ( FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 157,000...UPDATED 01/30/13 *BF THE CONSUMER STATED THE DEALERSHIP FOUND PCV HOSE AT THE BACK OF THE ENGINE COLLAPSED (REPAIRED), PERFORMED FUEL INDUCTION SYTEM FLUSH, AAA REPLACED ENTIRE COOLING SYSTEM. THE VEHICLE HAS BEEN REPAIRED AS A WHOLE. UPDATED 2/5/2013 *JS
NHTSA ODI #10471993
108,000 miles · Jul 28, 2012
Engine And Engine CoolingFuel/propulsion SystemFire
ON 7/27/2012, THE CAR CAUGHT ON FIRE WHILE BEING DRIVEN. THE SMOKE STARTED COMING INTO THE INTERIOR THROUGH THE VENTS. WHEN ATTEMPTING TO PULL OVER,THERE WAS NO BRAKE (MY GUESS IS THAT THE BRAKE LINE HAD MELTED.). MY HUSBAND USED THE E BRAKE AND PARK TO STOP AND SOMEONE YELLED...GET OUT OF THE CAR.MY HUSBAND AND SON JUMPED OUT A…
Read full complaint
ON 7/27/2012, THE CAR CAUGHT ON FIRE WHILE BEING DRIVEN. THE SMOKE STARTED COMING INTO THE INTERIOR THROUGH THE VENTS. WHEN ATTEMPTING TO PULL OVER,THERE WAS NO BRAKE (MY GUESS IS THAT THE BRAKE LINE HAD MELTED.). MY HUSBAND USED THE E BRAKE AND PARK TO STOP AND SOMEONE YELLED...GET OUT OF THE CAR.MY HUSBAND AND SON JUMPED OUT AND THE CAR BECAME ENGULFED. THERE IS NOTHING LEFT. HE TOLD ME THAT JUST BEFORE THAT IT STARTED HESITATING SOME,LIKE IT WAS GOING TO CUT OFF, BUT DIDN'T. FOR A MORE DETAILED STATEMENT PLEASE CONTACT HIM. I AM SO THANKFUL THAT THEY GOT OUT... THANK YOU, *TR
NHTSA ODI #10468063
140,000 miles · Nov 14, 2011
Engine And Engine Cooling
ENGINE SUDDENLY HAD NO OIL IN IT. IN TURN, THE ENGINE IS NOW BLOWN. *TR
NHTSA ODI #10435475
104,000 miles · Oct 30, 2011
Engine And Engine CoolingFuel System, GasolineVisibility
MY MAIN COMPLAINTS ARE THE POWER WINDOWS, AIR CONDITIONING, FUEL SYSTEM ISSUE 3 OF THE 4 POWER WINDOW MECHANISM IN MY CAR HAVE BROKEN AND TWO ARE WEDGED UP, WHICH WASN'T A HUGE SAFETY CONCERN TO ME BECAUSE I RARELY HAVE PEOPLE IN THE REAR SEATS. NOW, I HAVE TO DECIDE IF I SHOULD FIX MY DRIVER WINDOW OR WEDGE IT. IT IS A SAFET…
Read full complaint
MY MAIN COMPLAINTS ARE THE POWER WINDOWS, AIR CONDITIONING, FUEL SYSTEM ISSUE 3 OF THE 4 POWER WINDOW MECHANISM IN MY CAR HAVE BROKEN AND TWO ARE WEDGED UP, WHICH WASN'T A HUGE SAFETY CONCERN TO ME BECAUSE I RARELY HAVE PEOPLE IN THE REAR SEATS. NOW, I HAVE TO DECIDE IF I SHOULD FIX MY DRIVER WINDOW OR WEDGE IT. IT IS A SAFETY CONCERN FOR ME BECAUSE IF I GET INTO AN ACCIDENT AND CANNOT OPEN MY WINDOW THEN I MIGHT MAKE IT OUT ALIVE. MY A/C IS BROKEN AS WELL SO IN THE SUMMER MONTHS, I NEED TO CHOOSE TO EITHER FIX MY A/C OR FIX MY POWER WINDOW SO THAT I CAN HAVE VENTILATION. ALSO, I HAVE BEEN TRYING TO GET AN ISSUE FIXED WITH THE FUEL SYSTEM AS IT SOMETIMES LURCHES IN THE MIDDLE OF DRIVING. IT HASN'T STALLED ON ME YET IN THE MIDDLE OF AN INTERSECTION LIKE IT HAS FOR SOME PEOPLE, BUT I AM WORRIED IT WILL HAPPEN SOON. I AM HOPEFUL FORD WILL FIX MY WINDOW ISSUES AS THIS IS A DIRECT CAUSE OF CHEAP PARTS. *TR
NHTSA ODI #10433585
130,000 miles · Oct 29, 2011
Engine And Engine CoolingSteeringSuspension
I'VE HAD NUMEROUS PROBLEMS WITH MY FORD FOCUS AND DESPITE REGULAR MAINTENANCE I'VE BEEN STRANDED ON THE SIDE OF A HIGHWAY COUNTLESS TIMES.THUS FAR I'VE REPLACED THE ENGINE TWICE. TWICE I'VE HAD TO REPLACE THE ALTERNATOR. MY THROTTLE DOES NOT RETURN TO IDLE AND HAS UNEXPECTED MOMENTS OF ACCELERATION AND I'VE HAD TO REPLACE THE EN…
Read full complaint
I'VE HAD NUMEROUS PROBLEMS WITH MY FORD FOCUS AND DESPITE REGULAR MAINTENANCE I'VE BEEN STRANDED ON THE SIDE OF A HIGHWAY COUNTLESS TIMES.THUS FAR I'VE REPLACED THE ENGINE TWICE. TWICE I'VE HAD TO REPLACE THE ALTERNATOR. MY THROTTLE DOES NOT RETURN TO IDLE AND HAS UNEXPECTED MOMENTS OF ACCELERATION AND I'VE HAD TO REPLACE THE ENGINE THROTTLE SENSOR. BOTH OF MY FRONT COIL SPRINGS HAVE BROKEN AND WERE VERY CLOSE TO PUNCTURING MY TIRES. AFTER TAKING MY VEHICLE TO NUMEROUS MECHANICS NONE OF THEM HAVE BEEN ABLE TO DIAGNOSE WHY MY CAR SHAKES SO BADLY. I HAVE VERY POOR VISIBILITY AT NIGHT WITH THE EXTERIOR LIGHTING WHICH IS SIGNIFICANTLY LESS COMPARED TO OTHER VEHICLES. MY FAN HAS HAD TO BE REPLACED SINCE IT WAS MALFUNCTIONING AND MY CAR WAS HAVING PROBLEMS OVERHEATING AS WELL. DURING THE COURSE OF ALL OF THESE CAR MALFUNCTIONS, I'VE BEEN IN DANGEROUS SITUATIONS ON THE SIDE OF THE HIGHWAY AND IN RISKY NEIGHBORHOODS AT NIGHT. THIS CAR HAS PROVEN TO BE VERY UNRELIABLE AND UNSAFE. *TR
NHTSA ODI #10433536
140,000 miles · Sep 15, 2011
Electrical SystemEngine And Engine Cooling
THIS VEHICLE HAS SUDDENLY DIED DOZENS OF TIMES SINCE APRIL OF 2011. IT DIES WHEN APPLYING THE BRAKES ON THE INTERSTATE, IT DIES WHEN BRAKING IN A PARKING AREA. THERE IS NO SPECIFIC SPEED WHEN THIS OCCURS. THE VEHICLE STARTS BACK UP AFTER TWO OR THREE TIMES WHILE GIVING IT GAS. IT HAPPENS WHEN THE GAS TANK IS FULL OR LOW AND OUR …
Read full complaint
THIS VEHICLE HAS SUDDENLY DIED DOZENS OF TIMES SINCE APRIL OF 2011. IT DIES WHEN APPLYING THE BRAKES ON THE INTERSTATE, IT DIES WHEN BRAKING IN A PARKING AREA. THERE IS NO SPECIFIC SPEED WHEN THIS OCCURS. THE VEHICLE STARTS BACK UP AFTER TWO OR THREE TIMES WHILE GIVING IT GAS. IT HAPPENS WHEN THE GAS TANK IS FULL OR LOW AND OUR VERY REPUTABLE MECHANIC CAN FIND NO CAUSE. THIS IS EXTREMELY DANGEROUS, ESPECIALLY IN HIGH TRAFFIC AREAS AND I HAVE SEEN WHERE NUMEROUS COMPLAINTS HAVE BEEN FILED ONLINE AND I HOPE REPORTING THIS WILL SHOW A PATTERN WITH THESE VEHICLES. *KB
NHTSA ODI #10425648
62,000 miles · Mar 14, 2011
Engine And Engine Cooling
AFTER PURCHASING CAR WITH 62K MILES ON IT, I DISCOVERED A COOLANT LEAK THE NEXT DAY. THIS LEAK HAS GOTTEN WORSE OVER THE LAST WEEK. A SEARCH OF DIFFERENT INTERNET SITES FOUND AT LEAST 15 REPORTS OF THE THERMOSTAT HOUSING COMING LOOSE/BREAKING LOOSE FROM ITS POSITION AGAINST THE ENGINE BLOCK. THIS IS WHERE THE LEAK IS COMING FROM…
Read full complaint
AFTER PURCHASING CAR WITH 62K MILES ON IT, I DISCOVERED A COOLANT LEAK THE NEXT DAY. THIS LEAK HAS GOTTEN WORSE OVER THE LAST WEEK. A SEARCH OF DIFFERENT INTERNET SITES FOUND AT LEAST 15 REPORTS OF THE THERMOSTAT HOUSING COMING LOOSE/BREAKING LOOSE FROM ITS POSITION AGAINST THE ENGINE BLOCK. THIS IS WHERE THE LEAK IS COMING FROM ON MY CAR, AND THE DESCRIPTION IN AT LEAST ONE OTHER CASE APPEARS TO BE IDENTICAL TO MY OWN LEAK. THE DESCRIPTIONS FOUND ONLINE RANGE FROM NEARLY IMMEDIATELY AFTER PURCHASE TO APPROXIMATELY 1 YEAR AFTER PURCHASE. THIS LEAK IS SEVERE ENOUGH TO GENERATE A 2FT WIDE BY 4FT LONG PUDDLE OF COOLANT IN APPROXIMATELY 12HOURS. CONTINUOUS LEAK EVEN AFTER CAR HAS SAT FOR GREATER THAN 12 HOURS RULES OUT A FAILURE ONLY WHILE UNDER PRESSURE. *TR
NHTSA ODI #10390107
70,000 miles · May 5, 2010
Engine And Engine Cooling
I HAVE HAD A FORD FOCUS 2001 FOR TWO YEARS AND IN THOSE YEARS I HAVE HAD TO REPLACE THE ENGINE AND ENGINE MOUNTS. I HAVE FOUND OUT THAT THIS I COMMON PLACE IN ALMOST ALL FORD FOCUS'S. I FEAR THAT THIS CAR MIGHT LEAVE ME ANYWHERE, NOW ONE WEEK AGO THE IGNITION CYLINDER HAS BROKEN. THIS IS NOT WEAR AND TEAR. I DEMAND THAT THESE CA…
Read full complaint
I HAVE HAD A FORD FOCUS 2001 FOR TWO YEARS AND IN THOSE YEARS I HAVE HAD TO REPLACE THE ENGINE AND ENGINE MOUNTS. I HAVE FOUND OUT THAT THIS I COMMON PLACE IN ALMOST ALL FORD FOCUS'S. I FEAR THAT THIS CAR MIGHT LEAVE ME ANYWHERE, NOW ONE WEEK AGO THE IGNITION CYLINDER HAS BROKEN. THIS IS NOT WEAR AND TEAR. I DEMAND THAT THESE CARS OF 1998 THREW 2003 BE LABELED AS LEMONS AND HAVE FORD ISSUE A RECALL OR REIMBURSEMENTS ON THEM. *TR
NHTSA ODI #10328931
129,000 miles · Apr 28, 2010
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING AT APPROXIMATELY 15 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT PULLED OVER AND WHEN HE RESTARTED IT, THE VEHICLE FUNCTIONED PROPERLY. THE DEALER, WHEN CONTACTED, STATED THAT THEY WERE UNAWARE OF SUCH A PROBLEM. THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY. THE MANUFACTURE…
Read full complaint
TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING AT APPROXIMATELY 15 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT PULLED OVER AND WHEN HE RESTARTED IT, THE VEHICLE FUNCTIONED PROPERLY. THE DEALER, WHEN CONTACTED, STATED THAT THEY WERE UNAWARE OF SUCH A PROBLEM. THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS RELATED TO THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 129,000. THE CURRENT MILEAGE WAS 130,275.
NHTSA ODI #10327854
Official recalls
7Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Mar 28, 2001
PM CERTAIN SEDANS AND WAGONS, THE SEAT BACK RECLINER HANDLE SPRING COULD HAVE BEEN DAMAGED DURING AN IN-PROCESS TEST AND THE OCCUPANT MAY NOTICE A CHUCKING, OR PERCEIVED LOOSENESS OF THE FRONT SEAT BACK, OR THE SEAT BACK COULD UNEXPECTEDLY RECLINE.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE SEAT BACK RECLINER HANDLE SPRING FOR THE DRIVER AND FRONT PASSENGER SEATS. OWNER NOTIFICATION BEGAN APRIL 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
Illustration