IllustrationWHEN AIR CONDITIONER IS RUNNING CAN NOT PUT CAR IN PARK OR THE CAR STALLS...THIS STARTING HAPPENING AFTER A HOSE OF SOME TYPE WAS REPLACED AT THE BACK OF THE ENGINE. *TR
2000 Ford Focus
Owner reports · Recalls · Investigations
More warning signs than most Focus years
Owner complaints for the 2000 Ford Focus are substantially higher than the model-year median of 864.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Focus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1300–25K
41325–50K
44950–75K
28875–100K
238100–150K
52150K+
1,570 reports with mileage · 2,116 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 1,343 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 474 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 406 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
248 crash reports118 fire reports129 injury reports
What owners actually said
3,686 reportsAFTER TWO DAYS OF RAIN MY PASSENGER SIDE OF MY 2000 FORD FOCUS FILLED UP WITH WATER. THEN WHEN I WENT TO TURN ON THE AIR CONDITIONING WATER CAME POURING OUT OF THE FLOOR VENTS. I ALWAYS HESITATE TO TAKE IT INTO A DEALERSHIP SO I USED THE INTERNET TO SEARCH FOR SIMILAR COMPLAINTS. AFTER LOOKING AROUND I FOUND AROUND 25 COMPLAI…
Read full complaint
AFTER TWO DAYS OF RAIN MY PASSENGER SIDE OF MY 2000 FORD FOCUS FILLED UP WITH WATER. THEN WHEN I WENT TO TURN ON THE AIR CONDITIONING WATER CAME POURING OUT OF THE FLOOR VENTS. I ALWAYS HESITATE TO TAKE IT INTO A DEALERSHIP SO I USED THE INTERNET TO SEARCH FOR SIMILAR COMPLAINTS. AFTER LOOKING AROUND I FOUND AROUND 25 COMPLAINTS JUST ON ONE WEBSITE HTTP://WWW.CARSURVEY.ORG/VIEWMORECOMMENTS_REVIEW_8122_2.HTML . ON THIS SITE MANY PEOPLE REFERRED TO THE POLLEN FILTER WHERE THERE WAS NOT A TIGHT SEAL OR SOME TYPE OF DEFECTIVE PART THAT WOULD CAUSE WATER TO ENTER INTO THE VENT SYSTEM OF THE CAR THEN FILL THE PASSENGER SIDE OF THE INTERIOR. THIS SOUNDS LIKE A HUGE PROBLEM AND I WOULD APPRECIATE IT IF YOU WOULD LOOK INTO IT. *TR
2000 FORD FOCUS; BOTH FRONT COIL SPRINGS BROKEN OR COILS OVERLAPPING. *TR
TL*THE CONTACT OWNS A 2000 FORD FOCUS. WHILE DRIVING BETWEEN 35-45 MPH, THE REAR WHEELS BEGAN TO WOBBLE. THE MECHANIC STATED THAT THE REAR WHEEL BEARINGS NEEDED TO BE REPLACED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 00V303000 (WHEELS, LUGS, NUTS/BOLTS); HOWEVER, THE FAILURE HAS RECURRED. THE CONTA…
Read full complaint
TL*THE CONTACT OWNS A 2000 FORD FOCUS. WHILE DRIVING BETWEEN 35-45 MPH, THE REAR WHEELS BEGAN TO WOBBLE. THE MECHANIC STATED THAT THE REAR WHEEL BEARINGS NEEDED TO BE REPLACED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 00V303000 (WHEELS, LUGS, NUTS/BOLTS); HOWEVER, THE FAILURE HAS RECURRED. THE CONTACT INQUIRED ABOUT NHTSA SAFETY IMPROVEMENT CAMPAIGN NUMBER 01I017000 (WHEELS, LUGS, NUTS/BOLTS) AND WAS INFORMED THAT THE CAMPAIGN WAS OVER. THE FAILURE MILEAGE WAS 170,000.
2000 FOR FOCUS IGNITION LOCK. I AM ABOUT TO REPLACE MY IGNITION LOCK FOR THE 3RD TIME. EACH TIME, I HAVE GONE TO MY CAR IN THE EVENING ONLY TO FIND THE KEY WON'T GO INTO THE LOCK, IT WON'T TURN, ETC. I HAVE NOW BEEN STRANDED APPROXIMATELY 9 TIMES IN SOMETIMES ROUGH AREAS. THIS IS A WELL KNOWN AND DOCUMENTED SAFETY ISSUE. *TR
EVERY TIME I WOULD TAKE MY CAR TO THE DEALER FOR REPAIRS . THEY WOULD TELL ME THERE WERE NONE. IN JUNE I TOOK MY FOCUS TO THE DEALER FOR A LOUD NOISE COMING FROM THE LEFT REAR WHEEL. THEY TOLD ME THERE WERE NO BALL BEARINGS ON THE LEFT SIDE AND THE RIGHT SIDE NEEDED TO BE DONE ALSO, THEY ONLY HAD ONE IN STOCK THAT DAY. *TR
FIRST THE BACK PASSENGER DOOR LOCK WENT OUT, AND THEN THE DRIVERS DOOR LOCK WENT OUT. YOU CAN NOT OPEN WITH A KEY, NOR THE AUTOMATIC LOCKS. I TOOK THE HANDLE OFF TO TRY TO MANUALLY UNLOCK THE DOOR, AND YOU CAN'T. ALSO THE AIR AND FAN JUST WENT OUT. IT WAS WORKING GREAT, AND THEN ALL OF A SUDDEN IT JUST STOPPED WORKING! *TR
I AM EXPERIENCING WHAT THOUSANDS OF OTHERS HAVE EXPERIENCED WITH THE 2000 FORD FOCUS. FOR THE PAST YEAR, WE HAVE INTERMITTENTLY HAD THE IGNITION SWITCH LOCK UP, UNABLE TO TURN THE KEY AND START THE CAR. I HAVE BEEN STRANDED MANY TIMES. MY MECHANIC TOLD ME THIS IS A OVERWHELMINGLY COMMON PROBLEM WITH THE 2000 FOCUS AND SUGGEST…
Read full complaint
I AM EXPERIENCING WHAT THOUSANDS OF OTHERS HAVE EXPERIENCED WITH THE 2000 FORD FOCUS. FOR THE PAST YEAR, WE HAVE INTERMITTENTLY HAD THE IGNITION SWITCH LOCK UP, UNABLE TO TURN THE KEY AND START THE CAR. I HAVE BEEN STRANDED MANY TIMES. MY MECHANIC TOLD ME THIS IS A OVERWHELMINGLY COMMON PROBLEM WITH THE 2000 FOCUS AND SUGGESTED TAPPING AND BANGING ON THE IGNITION SWITCH TO GET IT TO TURN. THIS WORKED FOR ABOUT A YEAR, HOWEVER, AS I AM FINDING OUT BY READING THESE COMPLAINTS, IT FINALLY HAS FROZEN AND WILL NOT TURN. FORD WANTS TO CHARGE PEOPLE FOUR HUNDRED FIFTY DOLLARS TO REPLACE THIS DEFECTIVE SWITCH, ONLY TO REPLACE IT WITH ANOTHER DEFECTIVE SWITCH,WHICH WILL ULTIMATELY NEED REPLACING , YET ANOTHER $450.. MY HUSBAND PURCHASED AN IGNITION SWITCH FROM AN AUTO PARTS STORE, ONLY TO HAVE TO TAKE IT TO FORD ANYWAY TO INSTALL BECAUSE THEY GET YOU BY CHARGING $150. TO "REPROGRAM THE PATS SYSTEM ON THE KEY. AT WHAT POINT AND HOW MANY VEHICLES HAVE TO BE REPORTED TO BE DEFECTIVE , HOW MANY OWNERS HAVE TO BE CHARGED THOUSANDS OF DOLLARS TO REPLACE DEFECTIVE PARTS WITH DEFECTIVE PARTS AND FORD ALLOWED TO KEEP CHARGING AND RECHARGING US TO FIX THE SAME PROBLEM RATHER THAN BEING ACCOUNTABLE FOR THE PROBLEM AND RECALLING THE PART?? WHY AREN'T CONSUMER'S PROTECTED AGAINST THIS? *TR
FORD WILL NOT HONOR RECALL ON WHEEL BEARING. STATEMENT SAID EVEN IF THE CAR HAS BEEN SERVICE BEFORE IT WILL FIX. NOT TRUE I SPENT A HOUR ON THE PHONE WITH THEM . FORD WILL NOT HONOR AGGREEMENT BECAUSE IT DID IT AGAIN. SEARCH RESULTS REPORT DATE : JUNE 20, 2008 AT 11:33 AM NHTSA CAMPAIGN ID NUMBER : 01I017000 …
Read full complaint
FORD WILL NOT HONOR RECALL ON WHEEL BEARING. STATEMENT SAID EVEN IF THE CAR HAS BEEN SERVICE BEFORE IT WILL FIX. NOT TRUE I SPENT A HOUR ON THE PHONE WITH THEM . FORD WILL NOT HONOR AGGREEMENT BECAUSE IT DID IT AGAIN. SEARCH RESULTS REPORT DATE : JUNE 20, 2008 AT 11:33 AM NHTSA CAMPAIGN ID NUMBER : 01I017000 MAKE / MODELS : MODEL/BUILD YEARS: FORD / FOCUS 2000-2001 MANUFACTURER : FORD MOTOR COMPANY MFR'S REPORT DATE : NOV 29, 2001 NHTSA CAMPAIGN ID NUMBER : 01I017000 N/A NHTSA ACTION NUMBER: N/A COMPONENT: WHEELS:LUGS/NUTS/BOLTS POTENTIAL NUMBER OF UNITS AFFECTED : 238653 SUMMARY: THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2000-2001 FORD FOCUS PASSENGER VEHICLES, ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF , OHIOM, . IN HIGH CORROSION AREAS, WHERE SALT IS USED ON ROADWAYS IN THE WINTER, THE REAR WHEEL BEARING SEAL RACE CAN EXPERIENCE SURFACE CORROSION. IF THIS CONDITION OCCURS, THE WHEEL BEARING SEALS COULD BECOME DAMAGED AND ALLOW CONTAMINATION TO ENTER THE WHEEL BEARINGS. CONSEQUENCE: THE WHEEL BEARINGS COULD PREMATURELY WEAR AND CAUSE A NOTICEABLE NOISE. IF NOT REPAIRED, THIS CONDITION COULD PROGRESS TO THE POINT WHERE THE WHEEL BEGINS TO WOBBLE. REMEDY: DEALERS WILL REPLACE THE REAR WHEEL BEARINGS AT NO COST TO THE CONSUMER. ADDITIONAL BEARING SEALS WILL ALSO BE INSTALLED TO ENSURE A SMOOTH RIDE. THIS PROGRAM WILL BE IN EFFECT UNTIL DECEMBER 31, 2002, REGARDLESS OF MILEAGE. EVEN IF THE VEHICLE HAS ALREADY BEEN SERVICED UNDER RECALL CAMPAIGN 00S31, FORD HAS TAKEN ADDITIONAL STEPS TO KEEP THE WHEEL BEARINGS IN TOP SHAPE. OWNERS FORD HAS DECIDED TO CONDUCT A SERVICE CAMPAIGN TO REPLACE THE REAR WHEEL BEARINGS. OWNERS CAN CONTACT FORD AT 1-866-436-7332, CONCERNING THIS PROGRAM. *TR
CAR WAS TURNED ON TO RETURN HOME FROM WORK. HEARS A LOUD NOISE FROM FRONT OF CAR WHEN PUT IN DRIVE. CAR AFTER THAT WAS RUBBING ON RIGHT FRONT TIRE SO DIDN'T DRIVE HOME. LEFT IN WORK PARKING LOT. HAD TOWED TO METCALF'S AUTO CLINIC IN DYER, IN. RIGHT FRONT COIL SPRING HAD BROKEN. ASKED WHY WOULD THAT HAPPEN WHEN MILES ARE LOW…
Read full complaint
CAR WAS TURNED ON TO RETURN HOME FROM WORK. HEARS A LOUD NOISE FROM FRONT OF CAR WHEN PUT IN DRIVE. CAR AFTER THAT WAS RUBBING ON RIGHT FRONT TIRE SO DIDN'T DRIVE HOME. LEFT IN WORK PARKING LOT. HAD TOWED TO METCALF'S AUTO CLINIC IN DYER, IN. RIGHT FRONT COIL SPRING HAD BROKEN. ASKED WHY WOULD THAT HAPPEN WHEN MILES ARE LOW 49K FOR 2000 FORD FOCUS SE AND GARAGE KEPT. ATTENDANT SAID FORD IS AWARE OF PROBLEM SO I CALLED FORD DEALERSHIP IN MERRIVILLE IN. WAS TOLD NOTICES WENT OUT TO INFORM OWNERS OF PROBLEM IN NOV OF 2004 AND THAT AN EXTENDED WARRANTY WAS GIVEN TO FIX IF PROBLEM OCCURRED. ONLY I NEVER RECEIVED SUCH NOTICE. SO NOW I AM ASKING FOR FORD TO PAY FOR REPAIR AND THEY REFUSED IT SAYING IT WASN'T FIXED AT A FORD DEALERSHIP. I WAS ALSO TOLD THAT YOU WERE NOTIFIED WHEN A NOTICE WAS SENT TO ME.. BUT WHEN I CALLED I WAS TOLD ONLY FORD HAS THAT INFORMATION. SO IS A CATCH TWENTY TWO. WARRANTY OFFERED BY FORD IS SUPPOSE TO BE FOR 10 YEARS AND 150,000 MILES. SO I FALL UNDER WARRANTY BUT CANNOT PROVE I DIDN'T RECEIVE NOTICE AND IS THEIR EXCUSE FOR NOT WANTING TO RE-IMBURSE ME FOR REPAIR. *TR
Official recalls
1105V030000 · Latches/locks/linkages:doors:latch
Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
03V482000 · Fuel System, Gasoline
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
02V288000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
02V289000 · Steering:linkages
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
01V258000 · Visibility:windshield Wiper/washer:motor
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
00V418000 · Seats:front Assembly:recliner
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
00V411000 · Electrical System:wiring
Dec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
Consequence & remedy
Consequence: THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
00V302000 · Vehicle Speed Control:cables
Oct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
00V303000 · Wheels:lugs/nuts/bolts/studs
Oct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
00V218000 · Structure:frame And Members
Aug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
Remedy: DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
99V346000 · Vehicle Speed Control
Dec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA04023 · Rear Door Latch Failure
Opened Aug 18, 2004 · Closed Feb 4, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
THIS INVESTIGATION WAS OPENED ON APRIL 8, 2004 AS PE04-033 AND UPGRADED ON AUGUST 18, 2004 TO EA04-023.THE COMPLAINANTS ALLEGED THAT THE REAR DOOR LATCHES FAILED TO KEEP THE DOORS IN A CLOSED POSITION, RESULTING IN REAR DOORS COMING OPEN WHILE THE VEHICLES WERE BEING DRIVEN.SOME COMPLAINANTS REPORTED THAT AT TIMESA REAR DOOR, OR DOORS, COULD BE DIFFICULT TO CLOSE.OTHERS REPORTED THAT CORROSION OF THE DOOR LATCH MECHANISM CAUSED BINDING OF THE LATCH.FORD HAS IDENTIFIED A CONDITION OF CORROSION IN THE PAWL PIVOT AREA OF THE DOOR LATCH ASSEMBLY THAT PREVENTS PROPER ENGAGEMENT OF THE DOOR LATCH CATCH TO THE LATCH STRIKER ON THE VEHICLE BODY.BY LETTER OF FEBRUARY 1, 2005, FORD MOTOR COMPANY NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL ON MODEL YEAR 2000 THROUGH 2002 FOUR AND FIVE-DOOR FOCUS VEHICLES REGISTERED IN, OR ORIGINALLY SOLD IN, CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. DEALERS WILL INSPECT REAR DOOR LATCHES AND REPLACE BINDING LATCHES AS REQUIRED.DEALERS WILL ALSO LUBRICATE ALL REAR DOOR LATCHES TO PREVENT FUTURE CORROSION AND BINDING.A LOWER ROCKER SEAL WILL ALSO BE ADDED TO THE REAR DOORS. SEE SAFETY RECALL 05V030 FOR DETAILS.
PE04033 · Rear Door Latch Failure
Opened Apr 8, 2004 · Closed Aug 20, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
THIS INVESTIGATION WAS OPENED ON APRIL 8, 2004, BASED ON 17 REPORTS THAT ONE OR BOTH REAR DOOR LATCHES DID NOT FUNCTION PROPERLY.THE COMPLAINANTS ALLEGED THAT THE DOORS WERE DIFFICULT TO CLOSEAND THAT THE DOOR LATCHES WOULD NOT REMAIN LATCHED WHILE THE VEHICLES WERE BEING DRIVEN, RESULTING IN A DOOR COMING OPEN.SEVERAL OF THE COMPLAINANTS REPORTED THAT CORROSION OF THE DOOR LATCH MECHANISM CAUSED BINDING OF THE LATCH.FORD'S RESPONSE TO THE PRELIMINARY EVALUATION INFORMATION REQUEST PROVIDED 19 CONSUMER REPORTS AND 28 WARRANTY CLAIMS ATTRIBUTED TO THE DOOR LATCH WHERE THE DOORS CAME OPEN WHILE THE VEHICLES WERE BEING DRIVEN.THREE (3) OF THE 17 OPENING ODI REPORTS WERE DUPLICATED IN FORD'S RESPONSE.THIS INVESTIGATION HAS BEEN UPGRADED TO ENGINEERING ANALYSIS EA04-023 FOR FURTHER STUDY.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02032 · Engine Compartment Fires
Opened Mar 12, 2002 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
PE02016 · Rear Wheel Bearing
Opened Feb 8, 2002 · Closed Nov 8, 2002
Status: closed (inferred from source dates) · Wheels
There is no summary currently available