NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
170 reportsClear category filter68,000 miles · Nov 28, 2005
Vehicle Speed Control
I WAS DRIVING ON A HIGHWAY AND TURNED ON CRUISE CONTROL GOING UP A HILL. WHEN THE CAR CLEARED THE HILL, IT CONTINUED TO ACCELERATE PAST THE SET POINT (PROBABLY 65 MPH). AT 70-75 MPH I BECAME ALARMED AND HIT THE OFF BUTTON TO DISENGAGE CRUISE CONTROL, BUT THE CAR CONTINUED TO ACCELERATE. I THEN HIT THE BRAKES LIGHTLY, THINKING TH…
Read full complaint
I WAS DRIVING ON A HIGHWAY AND TURNED ON CRUISE CONTROL GOING UP A HILL. WHEN THE CAR CLEARED THE HILL, IT CONTINUED TO ACCELERATE PAST THE SET POINT (PROBABLY 65 MPH). AT 70-75 MPH I BECAME ALARMED AND HIT THE OFF BUTTON TO DISENGAGE CRUISE CONTROL, BUT THE CAR CONTINUED TO ACCELERATE. I THEN HIT THE BRAKES LIGHTLY, THINKING THIS WOULD DISENGAGE CRUISE, BUT IT DID NOT AND THE CAR CONTINUED TO ACCELERATE TO ABOUT 80 - 85 MPH, AT WHICH POINT I TURNED OFF THE ENGINE AND COASTED TO A STOP ON THE SHOULDER. I THEN RE-STARTED THE CAR 2-3 TIMES, AND EACH TIME, THE ENGINE IMMEDIATELY WENT TO VERY HIGH RPM, SO I SHUT IT DOWN QUICKLY. I HAD THE CAR TOWED TO A DEALERSHIP WHERE I LIVE, AND THE NEXT DAY THE SERVICE MANAGER HAD THE SAME EXPERIENCE: CAR REVVED VERY HIGH AND HE SHUT IT DOWN QUICKLY. THE SECOND TIME HE TRIED IT, THE BATTERY WAS DEAD. WHEN I SPOKE TO THE SERVICE MANAGER THIS MORNING, HE TOLD ME THAT THE CRUISE CONTROL ACTUATOR HAD BECOME "TURNED AROUND" AND THAT THIS HAD KINKED THE CRUISE CONTROL CABLE, PREVENTING IT FROM RETURNING THROTTLE CONTROL TO THE GAS PEDAL. THERE HAVE BEEN TWO RECALLS ON 2000 FORD FOCUS VEHICLES RELATED TO THE CRUISE CONTROL SYSTEM (NHTSA CAMPAIGN ID NUMBERS 99V346000 AND 00V302000), BUT APPARENTLY NEITHER APPLIES TO MY PARTICULAR VIN, WHICH IS [XXX]. THIS OBVIOUSLY COULD HAVE TURNED OUT VERY DIFFERENTLY HAD I BEEN DRIVING IN HEAVY TRAFFIC OR HAD I NOT THOUGHT TO SIMPLY SHUT THE ENGINE OFF, AND I VIEW IT AS A VERY SIGNIFICANT SAFETY HAZARD FOR THIS VEHICLE. I HOPE THAT YOU WILL INITIATE AN INVESTIGATION, AS THIS FAILURE COULD EASILY HAVE FATAL CONSEQUENCES. *JB UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10143790
Mileage unknown · Oct 18, 2005
Vehicle Speed Control
THE VEHICLE HAS A RECALL FOR THE SPEED CONTROL CABLE AND SERVO UNIT (99V346000). THE DEALER AND FORD MOTOR CO. SERVICE STATE THAT THE RECALL DOESN'T APPLY TO MY VEHICLE EVEN THOUGH I HAVE THE PROBLEM DESCRIBED IN THE RECALL WHICH IS A FAULTY SERVO UNIT. *JB
NHTSA ODI #10140129
12,685 miles · Sep 27, 2005
Electrical SystemPower TrainService Brakes, Air
PURCHASED 2000 FORD FOCUS, VIN [XXX] FROM CROFT FORD ON DEC. 19, 2001; MILEAGE WAS 12,163 (CAR WAS STILL UNDER WARRANTY); HAVE BEEN UNABLE TO WALK SINCE MARCH OF 2002 (MILEAGE ON CAR IS NOW JUST OVER 13,000; LAST 200 PLUS MILES HAS BEEN PUT ON BY FORD DEALERSHIPS ATTEMPTING TO FIX CAR). HAVE HAD THIS CAR IN TO SEVERAL FORD DEAL…
Read full complaint
PURCHASED 2000 FORD FOCUS, VIN [XXX] FROM CROFT FORD ON DEC. 19, 2001; MILEAGE WAS 12,163 (CAR WAS STILL UNDER WARRANTY); HAVE BEEN UNABLE TO WALK SINCE MARCH OF 2002 (MILEAGE ON CAR IS NOW JUST OVER 13,000; LAST 200 PLUS MILES HAS BEEN PUT ON BY FORD DEALERSHIPS ATTEMPTING TO FIX CAR). HAVE HAD THIS CAR IN TO SEVERAL FORD DEALERSHIPS; NONE OF WHICH CAN SOLVE PROBLEM OF ENGINE SURGES; DASH LIGHTS SWEEPING; TRANSMISSION BOLTING; ETC., ETC., ETC. THIS CAR IS NOT SAFE TO DRIVE; I HAVE NOTIFIED FORD MOTOR COMPANY; THE DEALERSHIPS, ETC., AND FEEL THAT IT SHOULD BE COVERED UNDER "MANUFACTURER WARRANTY" .. INSTEAD LATEST WAS THAT FORD DEALERSHIP WANTED $500 TO REPLACE ALTERNATOR AND COULD NOT GUARANTY THAT WOULD FIX PROBLEM; I ALREADY PAID $105; PLUS $110 AND THE SAME PROBLEMS ARE HAPPENING. THE CAR HAS BEEN AT THE FORD DEALERSHIP IN WOODBRIDGE, VA, FOR OVER 2 WEEKS, WHICH LEAVES MY FAMILY WITHOUT A CAR TO TRANSPORT ME. THIS IS NOT RIGHT. I TOLD TODD CROFT OF CROFT FORD THAT I NEEDED A GOOD, DEPENDABLE, SAFE CAR BECAUSE THIS WOULD BE THE LAST CAR I EVER PURCHASED. HE KNEW THAT I DID NOT DRIVE MUCH AT ALL AND I FEEL THAT HE SOLD THE CAR (WITH AN EXISTING PROBLEM) TO ME THINKING THAT I WOULD NEVER KNOW. MY DAUGHTER WAS THE ONE WHO REALIZED THIS CAR HAD A SERIOUS DEFECT AND TOOK IT TO CROFT FORD TO BE FIXED SEVERAL MONTHS AGO; TO DATE, IT STILL IS NOT FIXED; IS A DANGER TO DRIVE, NOT ONLY TO THE PERSON/OCCUPANTS OF THE CAR, BUT TO ANY VEHICLES NEAR WHEN THE POWER SURGES OCCUR AND THE TRANSMISSION BOLTS. *JB UPDATED 07/18/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10137913
Mileage unknown · Sep 14, 2005
Fuel System, GasolineVehicle Speed Control
DT: THE CONSUMER COMPLAINED ABOUT A VEHICLE SPEED CONTROL PROBLEM. THIS PROBLEM HAS BEEN OCCURRING SINCE THE CONSUMER PURCHASED THE VEHICLE ON MARCH 1, 2000. THE CONSUMER TOOK VEHICLE TO DEALER, AND THEY TOLD HER THERE WAS NO PROBLEM. THERE IS NHTSA RECALL 99V346000 ON THIS ISSUE FOR THE 2000 FORD .FOCUS ZX3. THE CO…
Read full complaint
DT: THE CONSUMER COMPLAINED ABOUT A VEHICLE SPEED CONTROL PROBLEM. THIS PROBLEM HAS BEEN OCCURRING SINCE THE CONSUMER PURCHASED THE VEHICLE ON MARCH 1, 2000. THE CONSUMER TOOK VEHICLE TO DEALER, AND THEY TOLD HER THERE WAS NO PROBLEM. THERE IS NHTSA RECALL 99V346000 ON THIS ISSUE FOR THE 2000 FORD .FOCUS ZX3. THE CONSUMER OWNS A ZTS 2000 FORD FOCUS, WHICH IS NOT INCLUDED IN THE RECALL. ALSO, THERE IS A FUEL SYSTEM PROBLEM. VEHICLE EXPERIENCES HESITATION, LOSS OF POWER, SURGING, AND DYEING THIS PROBLEM FIRST STARTED ON JUNE 1, 2004. WHEN THE CONSUMER TOOK VEHICLE TO A DEALERSHIP FOR REPAIRS THEY TOLD HER THEY THOUGHT IT WAS THE FILTER IN THE FUEL TANK. THERE IS NHTSA RECALL CAMPAIGN 03V482000. THE DEALERSHIP TOLD HER THAT THIS VEHICLE IS NOT INCLUDED IN THE RECALL BECAUSE IT IS A ZTS. *AK
NHTSA ODI #10136507
37 miles · Jul 14, 2005
Exterior LightingLatches/locks/linkagesVehicle Speed ControlCrashInjury
DT: THE TURN SIGNAL DO NOT CANCEL AFTER A TURN. THE SPRING BROKE THREE TIMES. THE TRUNK DOES NOT LATCH PROPERLY. DEALERSHIP HAS TAKEN CARE OF BOTH ISSUES, BUT THE PROBLEM RECURRED. IN COLD WEATHER THE IDLE SPEED WAS TOO HIGH. WHEN PUT INTO REVERSE IT BACKED OUT LIKE A ROCKET. THIS CAUSED AN ACCIDENT ON APRIL 9, 200…
Read full complaint
DT: THE TURN SIGNAL DO NOT CANCEL AFTER A TURN. THE SPRING BROKE THREE TIMES. THE TRUNK DOES NOT LATCH PROPERLY. DEALERSHIP HAS TAKEN CARE OF BOTH ISSUES, BUT THE PROBLEM RECURRED. IN COLD WEATHER THE IDLE SPEED WAS TOO HIGH. WHEN PUT INTO REVERSE IT BACKED OUT LIKE A ROCKET. THIS CAUSED AN ACCIDENT ON APRIL 9, 2000. THE CONSUMER WAS BACKING OUT WITH THE BACK DOOR OPEN. IT HAPPENED SO FAST HE DID NOT HAVE A CHANCE TO PUT ON THE BRAKES. THE CAR DOOR HIT THE GARAGE POST. THERE WAS NO POLICE REPORT. CONSUMER STATED HE HAD MENTAL INJURIES AND LOST HIS JOB. VEHICLE WAS STILL IDLING HIGH IN COLD WEATHER.*AK
NHTSA ODI #10128802
54,550 miles · Jul 8, 2005
Vehicle Speed Control
ON INTERSTATE 95 WITH CRUISE SET AT 70M.P.H. MY CAR EXCELERATED TO 95 M.P.H. I COULD NOT DISENGAGE THE CRUISE AND THE BRAKES DID NOT FUNCTION. I WAS ABLE TO SLOW THE CAR TO 60 M.P.H. BY PRESSING THE BRAKES AS HARD AS POSSIBLE THEN I TURNED THE KEY OFF WHICH STOPPED THE EXCELERATION BUT ALSO IMPAIRED THE STEERING. I WAS ABLE …
Read full complaint
ON INTERSTATE 95 WITH CRUISE SET AT 70M.P.H. MY CAR EXCELERATED TO 95 M.P.H. I COULD NOT DISENGAGE THE CRUISE AND THE BRAKES DID NOT FUNCTION. I WAS ABLE TO SLOW THE CAR TO 60 M.P.H. BY PRESSING THE BRAKES AS HARD AS POSSIBLE THEN I TURNED THE KEY OFF WHICH STOPPED THE EXCELERATION BUT ALSO IMPAIRED THE STEERING. I WAS ABLE TO GET THE CAR TO THE EMERGENCY LANE AND MY SON PUSHED US OFF THE SHOULDER OF THE ROAD.
NHTSA ODI #10128159
21,000 miles · Jul 5, 2005
Vehicle Speed Control
DT: CONSUMER STATED THE CRUISE CONTROL WENT INTO FULL THROTTLE POSITION AND COULD NOT BE DEACTIVATED BY PRESSING THE BRAKE PEDAL. THE ONLY WAY TO SHUT IT OFF WAS TO TURN THE KEY OFF. THE CONSUMER HAD TO HAVE THE CRUISE CONTROL DISABLED. HE HAS NOT CONTACTED A SERVICE DEALER. *AK
NHTSA ODI #10127517
65,000 miles · Jun 20, 2005
Vehicle Speed ControlCrash
THE CONSUMER FOUND THAT RECENTLY A PROBLEM WITH HIS VEHICLE WHEN ACCELERATING IT DOESN'T SLOW DOWN ONCE THE CONSUMERS FOOT WAS OFF OF THE GAS. THE VEHICLE WAS IN AN ACCIDENT AND THE CONSUMER BELIEVED THAT THE ACCELERATION PROBLEM CONTRIBUTED TO THE ACCIDENT. WHEN THE VEHICLE WAS TAKEN TO THE DEALER HE WAS TOLD THERE WAS A RECA…
Read full complaint
THE CONSUMER FOUND THAT RECENTLY A PROBLEM WITH HIS VEHICLE WHEN ACCELERATING IT DOESN'T SLOW DOWN ONCE THE CONSUMERS FOOT WAS OFF OF THE GAS. THE VEHICLE WAS IN AN ACCIDENT AND THE CONSUMER BELIEVED THAT THE ACCELERATION PROBLEM CONTRIBUTED TO THE ACCIDENT. WHEN THE VEHICLE WAS TAKEN TO THE DEALER HE WAS TOLD THERE WAS A RECALL ON THROTTLE CABLE. THEN HE WAS TOLD THAT THE VEHICLE WAS NOT RECALLED DUE TO THE VIN. THE CONSUMER STATED THAT THERE HAVE BEEN COMPLAINTS OF THIS PARTICULAR VEHICLE. *AK RECALL CAMPAIGN #00V302000. *SC *JB
NHTSA ODI #10119808
74,365 miles · Apr 4, 2005
Vehicle Speed Control
AFTER RELEASING ACCELERATOR THE ENGINE RPMS REMAIN AT THE ORIGINAL LEVEL AS IF IT WAS PRESSED IN NETRUAL OR THE CLUTCH IS ENGAGGED. ACCELERATOR IS NOT STICKING. THEN RPM'S ARE NORMAL FOR A TIME WHILE DRIVING. IT SEEMS TO HAPPEN ABOVE 3000 RPMS. *AK
NHTSA ODI #10116363
Mileage unknown · Feb 15, 2005
Vehicle Speed Control
VEHICLE LURCHED FORWARD, AND OWNER HAD TO TAKE OUT THE KEY FROM IGNITION IN ORDER TO STOP THE VEHICLE. MANUFACTURER WILL BE CONTACTED BY CONSUMER.*AK
NHTSA ODI #10111503
Official recalls
11Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Dec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
Consequence & remedy
Consequence: THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Oct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Oct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Aug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
Remedy: DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Dec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA04023 · Rear Door Latch Failure
Opened Aug 18, 2004 · Closed Feb 4, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
THIS INVESTIGATION WAS OPENED ON APRIL 8, 2004 AS PE04-033 AND UPGRADED ON AUGUST 18, 2004 TO EA04-023.THE COMPLAINANTS ALLEGED THAT THE REAR DOOR LATCHES FAILED TO KEEP THE DOORS IN A CLOSED POSITION, RESULTING IN REAR DOORS COMING OPEN WHILE THE VEHICLES WERE BEING DRIVEN.SOME COMPLAINANTS REPORTED THAT AT TIMESA REAR DOOR, OR DOORS, COULD BE DIFFICULT TO CLOSE.OTHERS REPORTED THAT CORROSION OF THE DOOR LATCH MECHANISM CAUSED BINDING OF THE LATCH.FORD HAS IDENTIFIED A CONDITION OF CORROSION IN THE PAWL PIVOT AREA OF THE DOOR LATCH ASSEMBLY THAT PREVENTS PROPER ENGAGEMENT OF THE DOOR LATCH CATCH TO THE LATCH STRIKER ON THE VEHICLE BODY.BY LETTER OF FEBRUARY 1, 2005, FORD MOTOR COMPANY NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL ON MODEL YEAR 2000 THROUGH 2002 FOUR AND FIVE-DOOR FOCUS VEHICLES REGISTERED IN, OR ORIGINALLY SOLD IN, CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. DEALERS WILL INSPECT REAR DOOR LATCHES AND REPLACE BINDING LATCHES AS REQUIRED.DEALERS WILL ALSO LUBRICATE ALL REAR DOOR LATCHES TO PREVENT FUTURE CORROSION AND BINDING.A LOWER ROCKER SEAL WILL ALSO BE ADDED TO THE REAR DOORS. SEE SAFETY RECALL 05V030 FOR DETAILS.
PE04033 · Rear Door Latch Failure
Opened Apr 8, 2004 · Closed Aug 20, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
THIS INVESTIGATION WAS OPENED ON APRIL 8, 2004, BASED ON 17 REPORTS THAT ONE OR BOTH REAR DOOR LATCHES DID NOT FUNCTION PROPERLY.THE COMPLAINANTS ALLEGED THAT THE DOORS WERE DIFFICULT TO CLOSEAND THAT THE DOOR LATCHES WOULD NOT REMAIN LATCHED WHILE THE VEHICLES WERE BEING DRIVEN, RESULTING IN A DOOR COMING OPEN.SEVERAL OF THE COMPLAINANTS REPORTED THAT CORROSION OF THE DOOR LATCH MECHANISM CAUSED BINDING OF THE LATCH.FORD'S RESPONSE TO THE PRELIMINARY EVALUATION INFORMATION REQUEST PROVIDED 19 CONSUMER REPORTS AND 28 WARRANTY CLAIMS ATTRIBUTED TO THE DOOR LATCH WHERE THE DOORS CAME OPEN WHILE THE VEHICLES WERE BEING DRIVEN.THREE (3) OF THE 17 OPENING ODI REPORTS WERE DUPLICATED IN FORD'S RESPONSE.THIS INVESTIGATION HAS BEEN UPGRADED TO ENGINEERING ANALYSIS EA04-023 FOR FURTHER STUDY.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02032 · Engine Compartment Fires
Opened Mar 12, 2002 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
PE02016 · Rear Wheel Bearing
Opened Feb 8, 2002 · Closed Nov 8, 2002
Status: closed (inferred from source dates) · Wheels
There is no summary currently available
Illustration