NHTSA owner reports · September 18, 2026 snapshot.
Tires complaints
88 reportsClear category filter44,313 miles · Jun 14, 2004
TiresCrash
MY SON WAS ALMOST KILLED ALONG WITH DRIVERS ON THE FREEWAY BELOW THE OVERPASS HE WAS ON WHEN A 2 WEEK OLD TIRE BLEW AND HE INSTANTLY LOST CONTROL OF THE VEHICLE. IN VIEWING THIS TIRE, I FOUND IT TO LOOK AS IF IT HAS DRY ROT ALL AROUND IT. LITTLE TINY HOLES UNDERNEATH THE TREADS ALL AROUND AS IF EATEN AWAY BY TERMITES OR SOMETH…
Read full complaint
MY SON WAS ALMOST KILLED ALONG WITH DRIVERS ON THE FREEWAY BELOW THE OVERPASS HE WAS ON WHEN A 2 WEEK OLD TIRE BLEW AND HE INSTANTLY LOST CONTROL OF THE VEHICLE. IN VIEWING THIS TIRE, I FOUND IT TO LOOK AS IF IT HAS DRY ROT ALL AROUND IT. LITTLE TINY HOLES UNDERNEATH THE TREADS ALL AROUND AS IF EATEN AWAY BY TERMITES OR SOMETHING. FOR A NEW TIRE IT IS OLDER LOOKING THAN THE OTHER 6 MONTH OLD TIRES. I KNOW NO ONE WHO WOULD LAB TEST THE MATERIAL, BUT IN MY GUT SOMETHING IS VERY WRONG WITH IT. IT BLEW FROM UNDERNEATH A THICK NEW TREAD THAT HAS NO PUNCTURES ON TOP. IT IS A FIRESTONE/FIREHAWK P205/50R16, DOT# W2W11TB0804. MY CAR IS A TOTAL LOSS, BUT MY SON MADE IT THROUGH OK THANK GOD. I TOOK IT TO THE DEALER MGR I PURCHASED IT FROM AND HE OUTRIGHT DISAGREED AND STARTED TO TAKE THE TIRE FROM ME SAYING HE WOULD HAVE THIER LAB TEST IT, BUT I HAVE LITTLE TRUST FOR THIER LAB. I NEED HELP IN REVIEWING THIS. I HAVE NO CAR AND I FEEL IT IS BECAUSE OF AN ACCIDENT CAUSED BY A DEFECTIVE TIRE. INSURANCE DOES NOT PAY COMPRABLE TO THE VEHICLE YOU HAD. I HAD ONLY ONE LAST PAYMENT TO GO. MY SON AND MANY OTHER PEOPLE COULD HAVE BEEN KILLED. BUYING TIRES IS LIKE A GAME OF RUSSIAN ROULETTE WITH LIFE AND DEATH. IT SEEMS WE ALL JUST ACCEPT THAT FACT.*AK
NHTSA ODI #10075355
56,000 miles · Apr 1, 2004
Electrical SystemTires
IT WAS DIFFICULT FOR THE CONSUMER TO TURN KEY IN THE IGNITION SWITCH. ON NUMEROUS OCCASIONS CONSUMER WAS UNABLE TO START THE VEHICLE. THE DEALERSHIP WAS NOTIFIED, BUT WAS UNABLE TO RESOLVE THE PROBLEM. *AK PROBLEMS WITH VEHICLE TIRES/ TIRES HAVE CUTS IN TREAD.*MR
NHTSA ODI #10059173
2,500 miles · Jan 28, 2004
Service Brakes, HydraulicTiresVisibility
I BOUGHT MY FOCUS IN 2000. SINCE THEN I HAVE SUFFERED 2 BLOWOUTS THAT NEITHER FORD OR FIRESTONE WOULD FIX. I'VE HAD BRAKE PADS REPLACED ONCE AND NOW HAVE TO HAVE BRAKEPADS AND ROTOR REPLACED. SOMETIMES THE KEY WON'T TURN THE IGNITION. AND OF COURSE THIS MORNING (ONE OF THE COLDEST DAYS WE'VE HAD) SOMETHING HAS GONE WRONG WIT…
Read full complaint
I BOUGHT MY FOCUS IN 2000. SINCE THEN I HAVE SUFFERED 2 BLOWOUTS THAT NEITHER FORD OR FIRESTONE WOULD FIX. I'VE HAD BRAKE PADS REPLACED ONCE AND NOW HAVE TO HAVE BRAKEPADS AND ROTOR REPLACED. SOMETIMES THE KEY WON'T TURN THE IGNITION. AND OF COURSE THIS MORNING (ONE OF THE COLDEST DAYS WE'VE HAD) SOMETHING HAS GONE WRONG WITH THE HEATER. *AK
NHTSA ODI #10055070
107,829 miles · Jan 15, 2004
Engine And Engine CoolingFuel System, GasolineService Brakes, Hydraulic
I PURCHASED MY 2000 FORD FOCUS SE FROM MERLIN MOTORS IN SASKATOON. PRODUCTION DATE - MAY 2/2000, STOCK NO. PP24941, R.O. NO. 155631. I BELIEVE THIS CAR WAS PREVIOUSLY OWNED BY SOMEONE IN BRITISH COLUMBIA. HERE IS A CHRONOLOGICAL BREAKDOWN OF REPAIRS. APRIL 17/01 - TOOK CAR IN BECAUSE DRIVER MIRROR VIBRATED BADLY WHEN DRIVING…
Read full complaint
I PURCHASED MY 2000 FORD FOCUS SE FROM MERLIN MOTORS IN SASKATOON. PRODUCTION DATE - MAY 2/2000, STOCK NO. PP24941, R.O. NO. 155631. I BELIEVE THIS CAR WAS PREVIOUSLY OWNED BY SOMEONE IN BRITISH COLUMBIA. HERE IS A CHRONOLOGICAL BREAKDOWN OF REPAIRS. APRIL 17/01 - TOOK CAR IN BECAUSE DRIVER MIRROR VIBRATED BADLY WHEN DRIVING - SO BADLY THAT I COULD NOT LOOK INTO IT, IT WAS SHAKING THAT MUCH. ALSO, THE TRUNK WOULD NOT OPEN FROM THE RELEASE INSIDE THE CAR. PARTS WERE ORDERED AT THIS TIME. VEHICLE KILOMETERS- 32854. JUNE 19/01 - THEY CHECKED FOR DRIVER MIRROR VIBRATING WHEN DRIVING AND REPLACED DRIVER SIDE EXTERIOR MIRROR. THE ALSO CHECKED FOR TRUNK NOT OPENING FROM THE RELEASE INSIDE THE CAR, THEY REPLACED THE TRUNK STOP AND ADJUSTED. VEHICLE KILOMETERS- 35222 JUNE 20/01 - THEY CHECKED FOR POWER STEERING LEAK AND REPLACED STEERING RACK AND SET TOE. VEHICLE KILOMETERS- 37782?? (THIS IS OBVIOUSLY AN ERROR - I KNOW I DID NOT DRIVE 2, 560 KM IN ONE DAY!) I ALSO DID NOT COMPLAIN ABOUT THE POWER STEERING AND DON'T RECALL WHY MY CAR WAS IN THERE AT THE TIME. SEPT 21/01 - THEY REPAIRED RATTLE IN RIGHT FRONT GOING OVER BUMPS, TIGHTENED ALL ASSEMBLE BOLTS IN FRONT END, REMOVED RIGHT CALIPER AND ROTOR, LUBED ALL BUSHING, ADJUSTED FRONT SPLASH SHIELDS, FOUND TIE ROD BOLT LOOSE AND TIGHTENED. THEY ALSO FIXED MOLDING ON WINDOW BELT, WHICH WAS LOOSE AND CHECKED INSIDE REAR VIEW MIRROR AND FOUND IT FLAWED - PART ON ORDER. VEHICLE KILOMETERS- 43170. NOV 3/01 - WE WERE DRIVING IN SASKATOON WHEN ENGINE STARTED TO BOIL. WE KNEW THIS BECAUSE OF STEAM COMING FROM THE HOOD, ALL GAUGES IN THE CAR READ NORMAL! WE TOOK CAR TO MERLIN - THEY COULD FIND NOTHING WRONG WITH THE CAR AFTER THEIR CHECKS, AND TOLD US TO BRING IT BACK IF IT HAPPENED AGAIN! WORK ORDER FOR THIS DATE STATES: CUSTOMER SAW STEAM COMING FROM UNDER HOOD, ANTIFREEZE POOLED ON ENGINE, GAUGE READ NORMAL, STEAM COMING FROM OVERFLOW TANK - FILL WITH A/FREEZE, PRESSURE TEST FOR LEAKS, NO LEAKS FOUND.
NHTSA ODI #10071379
13,600 miles · Jan 15, 2004
Power TrainService Brakes, HydraulicSuspension
PURCHASED FORD FOCUS SE IN MAY OF 2002 WITH 13,260 MILES. WE DID NOT BUY THE EXTENDED WARRANTY BECAUSE WE COULD NOT AFFORD. SOON AFTER BRINGING THE CAR HOME, WE NOTICED THE TIRE WAS VERY WOBBLY, AND THE BRAKES WERE SQUEAKING--TOOK IT TO THE FORD DEALER AND THEY TOLD US THESE CARS ARE NOTORIOUS FOR BRAKE NOISE, AS FOR THE TIRE …
Read full complaint
PURCHASED FORD FOCUS SE IN MAY OF 2002 WITH 13,260 MILES. WE DID NOT BUY THE EXTENDED WARRANTY BECAUSE WE COULD NOT AFFORD. SOON AFTER BRINGING THE CAR HOME, WE NOTICED THE TIRE WAS VERY WOBBLY, AND THE BRAKES WERE SQUEAKING--TOOK IT TO THE FORD DEALER AND THEY TOLD US THESE CARS ARE NOTORIOUS FOR BRAKE NOISE, AS FOR THE TIRE NOTHING IS WRONG-THE SERVICE DEPT. TEST DROVE AND DIDN'T NOTICE A THING. HAVE TAKEN IT IN SEVERAL OTHER TIMES AFTER THAT FOR WOBBLY TIRE-STILL SAME ANSWER NOTHING IS WRONG. HAVE TAKEN THE CAR IN FOR SEVERAL RECALLS. KEY WAS STUCK IN IGNITION AND HAD TO BE TOWED TO DEALERSHIP-BUT THE NEXT TIME MY TEENAGED DAUGHTER DROVE THE CAR THE STEERING WHEEL WAS STUCK WHEN SHE WAS TURNING AT AN INTERSECTION-HAD IT TOWED AGAIN, THERE WAS A PIECE OF MATERIAL (FROM THEM FIXING THE IGNITION PROBLEM) THAT WAS STUCK IN THE STEERING COLUMN. OUR LATEST EPISODE WITH THIS CAR IS OUR TRIP FROM WA-VIRGINIA. THE CAR WAS FINE ON THE WAY THERE, EXCEPT FOR THE WOBBLE IN THE TIRE IN WHICH WE HAD THE TIRES ROTATED YET AGAIN. BUT ON OUR WAY BACK WE STARTED EXPERIENCING SPUTTERING AND SURGING OF THE CAR, WE WOULD PULL OFF THE SIDE OF THE ROAD EVERY 20 MILES (THINKING IT WAS FROM THE HOT WEATHER), WE WOULD GET ANOTHER 20 MILES IN AND SAME THING UNTIL FINALLY WE DROVE THROUGH CHICAGO, IL AND IT WAS WORSE, SO WE PULLED OFF THE HIGHWAY AND ON TO AN ON RAMP--WALKED ACROSS THE HIGHWAY TO USE A BUSINESS'S TELEPHONE TO CALL FOR A TOW TRUCK. THEY FOUND US A TOW TRUCK BUT UNFORTUNATELY IT WASN'T A KING CAB, SO OUR INSURANCE CO., CALLED US A CAB. THE TOW TRUCK TOOK US TO THE NEAREST FORD DEALER--THE CAR HOWEVER SEEMED TO RUNNING FINE, SO WE DECIDED TO DRIVE SOME MORE. WE GOT ABOUT 15 MILES DOWN THE ROAD AND SPUTTERING AGAIN, SO WE CALLED FOR ANOTHER TOW--AND IN THE MEANTIME WE CALLED FIRESTONE, WE DROVE IT THERE, THE SERVICEMAN DROVE THE CAR AND FELT WHAT IT WAS DOING AND SAID HE DIDN'T NEED TO HOOK IT UP TO ENGINE DIAGNOSTIC THAT IT WAS THE TRANSMISSION.
NHTSA ODI #10070828
Mileage unknown · Jan 15, 2004
Service Brakes, HydraulicSteeringSuspension
I DRIVE 25000 MILES A YEAR TO AND FROM WORK APPROXIMTLY 115 MILES A DAY AND 70% OF THAT IS ON OPEN INTERSTATE HIWAY. STOP AND GO IS LESS THAN 20 MILES A DAY. TIRES COMPLETELY WORE OUT AT 41000 MILES. TIRES STARTED HUMMING AT 10 TO 15000 MILES. I CONSTLY COMPLAINED ABOUT FRONT END AND TIRE NOISE. I PUT A SET OF GOODYEAR AQUATRED …
Read full complaint
I DRIVE 25000 MILES A YEAR TO AND FROM WORK APPROXIMTLY 115 MILES A DAY AND 70% OF THAT IS ON OPEN INTERSTATE HIWAY. STOP AND GO IS LESS THAN 20 MILES A DAY. TIRES COMPLETELY WORE OUT AT 41000 MILES. TIRES STARTED HUMMING AT 10 TO 15000 MILES. I CONSTLY COMPLAINED ABOUT FRONT END AND TIRE NOISE. I PUT A SET OF GOODYEAR AQUATRED TIRES ON AT 41476 MILES. THEY ALSO STARTED HUMMING, SO THE FRONT END WAS LINED UP. THIS DID NOT STOP THE TIRES FROM HUMMING. NOW CAR HAS 80000 MILES, TIRES ARE SCARMING GO DOWN THE ROAD FAST OR SLOW. FRONTEND SUSPENSION HAS BEEN MAKING CLANKING OR THUD TYPE NOISE. JUST RECENTLY TURING LEFT GETING OFF INTERSTATE IT FELLES LIKE THE RIGHT FRONT IS CHANGING GEOMITRY. CAR TURNS LEFT VILENTLY - MUST CORECT STERING. THIS WILL HAPPENS WITHOUT NOTICE. THIS CAR IS EXTMLY DANGERAS. WHEN DRIVEN ON ICE AND SNOW, IT WILL BRAKE LOSE WHEN GOING STARIGHT FOR NO REASON AND START TO SPIN OUT. BRAKES WORE OUT AT 45000 MILES. $400 TO FIX FRONT BRAKES ONLY. I HAVE NEVER HAD TO PUT BRAKES AND TIRES ON A CAR AT LESS THAN 50000 MILES. MORE LIKE 65 TO 75000 MILES.
NHTSA ODI #10070133
35,000 miles · Jan 15, 2004
EquipmentFuel System, GasolinePower Train
CAR IS ONLY 2YRS,8MO. HAVE CURRENTLY EXPENDED OVER $4000.00 ON REPAIRS. PROBLEM WITH SEALS ALLOWING FUMES IN CAR FROM OTHER VEHICLES RUNNING BESIDE MINE. THE NOISE AND WIND SHEAR LEVEL IS VERY UNSATISFACTORY. SQUEAL NOISE AND THUMPING FEELING FROM PRESSING ON BRAKE PEDAL. HESITATION ON ACCELERATING INTO TRAFFIC FLOW. POOR QUALIT…
Read full complaint
CAR IS ONLY 2YRS,8MO. HAVE CURRENTLY EXPENDED OVER $4000.00 ON REPAIRS. PROBLEM WITH SEALS ALLOWING FUMES IN CAR FROM OTHER VEHICLES RUNNING BESIDE MINE. THE NOISE AND WIND SHEAR LEVEL IS VERY UNSATISFACTORY. SQUEAL NOISE AND THUMPING FEELING FROM PRESSING ON BRAKE PEDAL. HESITATION ON ACCELERATING INTO TRAFFIC FLOW. POOR QUALITY ON PARTS AND WORKMANSHIP FROM MANUFACTURER
NHTSA ODI #10070124
Mileage unknown · Jan 15, 2004
Electrical SystemEngine And Engine CoolingEquipmentCrash
BAD BRAKES, LEAKING TRANSMISSION X 2 REPAIRS, NUMEROUS ELECTRICAL PROBS, ONE "ACCIDENT", DAMAGE REPAIRED AT FORD EXPENSE, BAD TIRE, NOISE FROM FRONT RT SIDE, "SURGE" PROB, CAR SEEMED TO "STICK" IN A GEAR. I DON'T HAVE MY FILE WITH ME BUT I KNOW THERE IS MORE.
NHTSA ODI #10069965
Mileage unknown · Jan 15, 2004
Electrical SystemPower TrainSeat Belts
MY COMPLAINT IS ALL THE PROBLEMS WE HAVE HAD WITH THE FOCUS. WE HAVE HAD NUMEROUS RECALLS AND WORK DONE FROM THE DRIVERS SEAT COLLAPSING, WIRING HARNESS REPLACED, BEARINGS IN FRONT, AND REAR, BRAKE ASSEMBLY, SWAY BAR, AND HAVE HAD TO REPLACE 3 SETS OF TIRES, AND LINE UP 3 TIMES BECAUSE THEY WILL NOT MAKE GOOD AND THE CAR EATS TI…
Read full complaint
MY COMPLAINT IS ALL THE PROBLEMS WE HAVE HAD WITH THE FOCUS. WE HAVE HAD NUMEROUS RECALLS AND WORK DONE FROM THE DRIVERS SEAT COLLAPSING, WIRING HARNESS REPLACED, BEARINGS IN FRONT, AND REAR, BRAKE ASSEMBLY, SWAY BAR, AND HAVE HAD TO REPLACE 3 SETS OF TIRES, AND LINE UP 3 TIMES BECAUSE THEY WILL NOT MAKE GOOD AND THE CAR EATS TIRES. NOW WE HAVE 52,000 MILES ON THE CAR, AND A PIN HAS COME LOOSE AND GONE THROUGH THE TRANSMISSION, AND CASE. ALTOUGH THE DEALER HAS BEEN VERY GOOD, WE BOUGHT A NEW CAR SO WE WOULD NOT HAVE THIS HASSLE, AND THAT IS ALL WE HAVE HAD.
NHTSA ODI #10069676
65,000 miles · Jan 15, 2004
Service Brakes, HydraulicSuspensionTires
THE BRAKE SYSTEM IS HORRIBLE. THEY MAKE NOISES ALL THE TIME. I HAVE REPLACED THE CYLINDERS AND THE SHOES AND IT STILL DOES NOT SOUND RIGHT. THE SUSPENSION IS BAD AND NEEDS REPLACING, BUT I CAN NOT AFFORD IT. I AM A TEACHER. CRUISE CONTROL HAS GONE BAD, BECAUSE OF A FAULTY WIRE.
NHTSA ODI #10069367
Official recalls
11Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Dec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
Consequence & remedy
Consequence: THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Oct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Oct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Aug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
Remedy: DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Dec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA04023 · Rear Door Latch Failure
Opened Aug 18, 2004 · Closed Feb 4, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
THIS INVESTIGATION WAS OPENED ON APRIL 8, 2004 AS PE04-033 AND UPGRADED ON AUGUST 18, 2004 TO EA04-023.THE COMPLAINANTS ALLEGED THAT THE REAR DOOR LATCHES FAILED TO KEEP THE DOORS IN A CLOSED POSITION, RESULTING IN REAR DOORS COMING OPEN WHILE THE VEHICLES WERE BEING DRIVEN.SOME COMPLAINANTS REPORTED THAT AT TIMESA REAR DOOR, OR DOORS, COULD BE DIFFICULT TO CLOSE.OTHERS REPORTED THAT CORROSION OF THE DOOR LATCH MECHANISM CAUSED BINDING OF THE LATCH.FORD HAS IDENTIFIED A CONDITION OF CORROSION IN THE PAWL PIVOT AREA OF THE DOOR LATCH ASSEMBLY THAT PREVENTS PROPER ENGAGEMENT OF THE DOOR LATCH CATCH TO THE LATCH STRIKER ON THE VEHICLE BODY.BY LETTER OF FEBRUARY 1, 2005, FORD MOTOR COMPANY NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL ON MODEL YEAR 2000 THROUGH 2002 FOUR AND FIVE-DOOR FOCUS VEHICLES REGISTERED IN, OR ORIGINALLY SOLD IN, CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. DEALERS WILL INSPECT REAR DOOR LATCHES AND REPLACE BINDING LATCHES AS REQUIRED.DEALERS WILL ALSO LUBRICATE ALL REAR DOOR LATCHES TO PREVENT FUTURE CORROSION AND BINDING.A LOWER ROCKER SEAL WILL ALSO BE ADDED TO THE REAR DOORS. SEE SAFETY RECALL 05V030 FOR DETAILS.
PE04033 · Rear Door Latch Failure
Opened Apr 8, 2004 · Closed Aug 20, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
THIS INVESTIGATION WAS OPENED ON APRIL 8, 2004, BASED ON 17 REPORTS THAT ONE OR BOTH REAR DOOR LATCHES DID NOT FUNCTION PROPERLY.THE COMPLAINANTS ALLEGED THAT THE DOORS WERE DIFFICULT TO CLOSEAND THAT THE DOOR LATCHES WOULD NOT REMAIN LATCHED WHILE THE VEHICLES WERE BEING DRIVEN, RESULTING IN A DOOR COMING OPEN.SEVERAL OF THE COMPLAINANTS REPORTED THAT CORROSION OF THE DOOR LATCH MECHANISM CAUSED BINDING OF THE LATCH.FORD'S RESPONSE TO THE PRELIMINARY EVALUATION INFORMATION REQUEST PROVIDED 19 CONSUMER REPORTS AND 28 WARRANTY CLAIMS ATTRIBUTED TO THE DOOR LATCH WHERE THE DOORS CAME OPEN WHILE THE VEHICLES WERE BEING DRIVEN.THREE (3) OF THE 17 OPENING ODI REPORTS WERE DUPLICATED IN FORD'S RESPONSE.THIS INVESTIGATION HAS BEEN UPGRADED TO ENGINEERING ANALYSIS EA04-023 FOR FURTHER STUDY.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02032 · Engine Compartment Fires
Opened Mar 12, 2002 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
PE02016 · Rear Wheel Bearing
Opened Feb 8, 2002 · Closed Nov 8, 2002
Status: closed (inferred from source dates) · Wheels
There is no summary currently available
Illustration