NHTSA owner reports · September 18, 2026 snapshot.
Equipment complaints
112 reportsClear category filter43,000 miles · Nov 17, 2003
Electrical SystemEngine And Engine CoolingEquipment
HI, I OWN A 2000 FORD FOCUS AND IT HAS BEEN NOTHING BUT TROUBLE. I PURCHASED THE CAR BRAND NEW IN 2000 AND HAVE HAD IT IN THE SHOP SO MANY TIMES. I HAVE HAD MY REAR PASSENGER SIDE WINDOW MECHANISM REPLACED BY FORD, THEN PERSONALLY REPLACED THE DRIVER FRONT WINDOW MECHANISM AND THE DRIVER BACK MECHANISM DUE TO CABLE BREAKS. I …
Read full complaint
HI, I OWN A 2000 FORD FOCUS AND IT HAS BEEN NOTHING BUT TROUBLE. I PURCHASED THE CAR BRAND NEW IN 2000 AND HAVE HAD IT IN THE SHOP SO MANY TIMES. I HAVE HAD MY REAR PASSENGER SIDE WINDOW MECHANISM REPLACED BY FORD, THEN PERSONALLY REPLACED THE DRIVER FRONT WINDOW MECHANISM AND THE DRIVER BACK MECHANISM DUE TO CABLE BREAKS. I HAVE HAD IT IN WITH THE RADIO 3 TIMES AND IT STILL DOES NOT WORK CORRECTLY. I HAVE HAD TO HAVE THE BRAKES REPLACED, THE IGNITION BLOCK REPLACED, THE STRUTS AND SHOCKS. THE TRUNK RELEASE HAS NEVER WORKED. NOW IT KEEPS BREAKING DOWN ON ME IF I DRIVE FOR MORE THAN 1 HOUR NON STOP. THIS WEEKEND I WENT TO SAN ANTONIO FROM CORPUS, IT DIED ON THE HIGHWAY 3 TIMES GOING TO SA AND COMING HOME 4 TIMES & HOW SAFE IS THAT! FORD SAID THEY CANNOT DO ANYTHING FOR ME UNLESS IT IS MESSING UP WHEN I BRING IT IN WHILE IT IS ACTING UP, HOWEVER IT ALWAYS HAPPENS WHEN I AM AWAY FROM TOWN. THEY TOLD ME THAT IF THEY HOOK IT UP TO THE MACHINE IT WILL NOT TELL THEM ANYTHING. ALSO, ON SEVERAL OCCASIONS MY ACCELERATOR HAS STUCK AND I CANNOT BRAKE, I HAVE TO PUT THE CAR IN NEUTRAL AND PRESS ON THE BRAKE HARD WHILE THE RPM'S ARE STILL REVVING AND PULL THE EMERGENCY BRAKE, THE FIRST TIME THIS HAPPENED I WAS PULLING INTO A PARKING SPOT AND WENT OVER THE YELLOW DIVIDER. IS THERE ANYTHING I CAN DO? *LA
NHTSA ODI #10047047
Mileage unknown · Nov 11, 2003
EquipmentSuspension
2000 FORD FOCUS - RECALLED IN 2001 FOR REAR WHEEL BEARING PROBLEM - SUPPOSEDLY THE DEALERSHIP - VILLAGE FORD DEARBORN, MI - INSPECTED AND PROCEEDED WITH THE PROPER SERVICE - NOW WITH BAD REAR WHEEL BEARING PROBLEM - MY TIRE WAS READY TO FALL OFF PER THE MECHANIC - WHEN THE MECHANIC CONTACTED FORD CUSTOMER SERVICE FOR PART - HE W…
Read full complaint
2000 FORD FOCUS - RECALLED IN 2001 FOR REAR WHEEL BEARING PROBLEM - SUPPOSEDLY THE DEALERSHIP - VILLAGE FORD DEARBORN, MI - INSPECTED AND PROCEEDED WITH THE PROPER SERVICE - NOW WITH BAD REAR WHEEL BEARING PROBLEM - MY TIRE WAS READY TO FALL OFF PER THE MECHANIC - WHEN THE MECHANIC CONTACTED FORD CUSTOMER SERVICE FOR PART - HE WAS TOLD THAT WAS A RECALL ITEM AND I SHOULD BRING TO A FORD DEALERSHIP FOR REPAIR. ON 11-11-03 I BROUGHT MY VEHICLE TO AVIS FORD SOUTHFIELD MI FOR THIS REPAIR - I WAS TOLD BY THE DEALERSHIP THAT NO RECALL EXIST ON THE REAR WHEEL BEARING AND FURTHERMORE IF ONE DID EXIST THE WARRANTY ON THE REPLACEMENT WOULD BE VOID. THE MECHANIC THAT EVALUATED MY CAR ON 11-8-03 STATED THIS NEEDED TO BE ADDRESSED ASAP - HE TIGHTENED THE WHEEL- WHICH IS WHY I SCHEDULED A REPAIR ON 11-11-03. I WILL NEED TO RETURN MY VEHICLE TO THE FORMER MECHANIC FOR SERVICE BUT WILL BE UNABLE TO DO SO UNTIL 11-15-03. PLEASE ADVISE THE PROCESS FOR FILING COMPLAINT AGAINST FORD MOTOR COMPANY - SO I CAN RECOVER MY EXPENSES. THE MECHANIC WILL GIVE ME THE DEFECTIVE PART. I DO NOT THINK THAT VILLAGE FORD EVER CHANGED THE PART OR DID THE REPAIRS UNDER THE EARLIER RECALL. VIN [XXX]. *AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10045947
Mileage unknown · Oct 21, 2003
EquipmentLatches/locks/linkages
I HAVE HAD THIS FOCUS FOR ABOUT 2 YEARS. WHEN I PURCHASED IT, I WAS NOT TOLD OF ANY OF THE POSSIBLE MECHANICAL PROBLEMS THAT MAY BE ASSOCIATED WITH THE MODEL. SINCE THEN, I HAVE HAD 4 RECALLS REPAIRED. RECENTLY, THE DOOR HANDLE ON THE DRIVER'S SIDE DOOR WAS GETTING STUCK. NOW, THE FACTORY INSTALLED SECURITY SYSTEM WILL NOT WORK…
Read full complaint
I HAVE HAD THIS FOCUS FOR ABOUT 2 YEARS. WHEN I PURCHASED IT, I WAS NOT TOLD OF ANY OF THE POSSIBLE MECHANICAL PROBLEMS THAT MAY BE ASSOCIATED WITH THE MODEL. SINCE THEN, I HAVE HAD 4 RECALLS REPAIRED. RECENTLY, THE DOOR HANDLE ON THE DRIVER'S SIDE DOOR WAS GETTING STUCK. NOW, THE FACTORY INSTALLED SECURITY SYSTEM WILL NOT WORK. I CANNOT LOCK THE DRIVER'S SIDE DOOR AT ALL AND I MUST LOCK THE OTHER 3 DOORS MANUALLY. MY KEY CHAIN DOOR LOCKER DOES NOT WORK AT ALL. THE INSIDE BUTTON FOR UNLOCKING THE TRUNK WILL NOT WORK EITHER. THE FRONT CONSOLE IS TOO BIG FOR THE CAR AND COFFEE CUPS WILL NOT FIT INTO IT. I ALSO SEEM TO HAVE TROUBLE SEEING BEHIND ME WHEN TRYING TO LOOK TO THE LEFT FROM THE DRIVER'S SIDE DUE TO THE PLACEMENT OF THE HEADREST. *LA
NHTSA ODI #10043329
70,000 miles · Aug 24, 2003
EquipmentSuspension
THE REAR PASSENGER WHEEL BEARING FAILED CAUSING SMOKE AND ALMOST A FIRE. I HAD THE RECALL DONE AT TRI COUNTY FORD IN MAULDRAUGH KY, AND THIS IS THE SECOND TIME IT HAD HAPPENED. I WENT TO LES PINKHAM LINCOLN MERCURY AND BOUGHT NEW WHEEL BEARINGS AND HAD MY PERSONAL MECHANIC REPLACE THE BEARING. HE STATED THAT THE BRAKE DRUM AND…
Read full complaint
THE REAR PASSENGER WHEEL BEARING FAILED CAUSING SMOKE AND ALMOST A FIRE. I HAD THE RECALL DONE AT TRI COUNTY FORD IN MAULDRAUGH KY, AND THIS IS THE SECOND TIME IT HAD HAPPENED. I WENT TO LES PINKHAM LINCOLN MERCURY AND BOUGHT NEW WHEEL BEARINGS AND HAD MY PERSONAL MECHANIC REPLACE THE BEARING. HE STATED THAT THE BRAKE DRUM AND WHEEL ARE POSSIBLE WARPED AND MIGHT NEED REPLACEING. I ALSO WANT A REFUND ON THE BEARINGS AND LABOR COST FOR THE MECHANIC TO REPLACEMENT OF BEARINGS.*AK
NHTSA ODI #10033408
Mileage unknown · Aug 24, 2003
EquipmentService Brakes, Hydraulic
I OWN A 2000 FORD FOCUS. CURRENTLY I AM EXPERIENCING SEVERAL PROBLEMS. THE FIRST IS THE AIR CONDITIONING A/C. THE A/C WORKS ON THE #4 SETTING BUT DOESN'T WORK ON #1, #2, OR #3. NO AIR COMES FROM THE AIR VENTS WHEN THE FAN IS SET TO 1, 2, OR 3 WHETHER THE A/C IS ON OR NOT. THE SECOND PROBLEM IS THE BRAKES. I HAVE LESS THAN…
Read full complaint
I OWN A 2000 FORD FOCUS. CURRENTLY I AM EXPERIENCING SEVERAL PROBLEMS. THE FIRST IS THE AIR CONDITIONING A/C. THE A/C WORKS ON THE #4 SETTING BUT DOESN'T WORK ON #1, #2, OR #3. NO AIR COMES FROM THE AIR VENTS WHEN THE FAN IS SET TO 1, 2, OR 3 WHETHER THE A/C IS ON OR NOT. THE SECOND PROBLEM IS THE BRAKES. I HAVE LESS THAN 46,000 MILES ON THE CAR, AND THE BRAKES FEEL LIKE THEY ARE GOING OUT. I'VE NEVER HAD TO REPLACE THE BRAKES ON A CAR BEFORE 70,000 MILES. THE THIRD PROBLEM IS COMPRISED OF THE GAUGES. WHEN I START MY CAR, ALL THE GAUGES GO IMMEDIATELY TO THE RIGHT. AFTER A FEW MOMENTS THEY RETURN TO THEIR PROPER POSITION, BUT I'M NOT SURE WHAT IS GOING ON. I FEEL THAT IF I PUT THE CAR IN GEAR DURING THIS PERIOD, THAT I WILL LOSE CONTROL OF THE VEHICLE AND IT MAY SURGE FORWARD. THE FOURTH PROBLEM IS THAT I HAVE ALREADY HAD TO REPLACE ALL OF THE TIRES ON THIS VEHICLE. THE FIFTH PROBLEM IS THE TRANSMISSION/ENGINE. MANY TIMES, ESPECIALLY IN THE IDLE POSITION (AT A STOP SIGN, ETC.), I FEEL THAT THE ENGINE IS GOING TO STALL. IT ALMOST FEELS LIKE THE ENGINE IS NOT RUNNING ON ALL CYLINDERS. THE SIXTH PROBLEM, AND PROBABLY NOT THE LAST, IS THAT I'VE ALREADY HAD TO DEAL WITH ALL OF THE RECALLS ON THIS VEHICLE, AND YET THIS CAR IS STILL UNSAFE AND FORD HAS DONE NOTHING TO CORRECT THIS EXCEPT OFFER A 5 YEAR/100,000 MILE WARRANTY TO NEW FORD FOCUS BUYERS.*AK
NHTSA ODI #10033382
Mileage unknown · Aug 15, 2003
Electrical SystemEquipmentService Brakes, AirCrash
CONSUMER WAS ON 7TH SET OF TIRES AT 60,000, AN ALIGNMENT WITH EACH SET. RADIO HAD BEEN REPLACED TWICE/ BRAKES HAD BEEN COMPLETELY REPLACED TWICE/ WHEEL BEARINGS HAD BEEN REPLACED,AND IGNITION WAS REPLACED ONCE AFTER VEHICLE HAD BEEN TOWED. LOW AND BEHOLD, CONSUMER'S FOCUS WAS SITTING IN DRIVEWAY NEEDED TO BE TOWED FOR THE S…
Read full complaint
CONSUMER WAS ON 7TH SET OF TIRES AT 60,000, AN ALIGNMENT WITH EACH SET. RADIO HAD BEEN REPLACED TWICE/ BRAKES HAD BEEN COMPLETELY REPLACED TWICE/ WHEEL BEARINGS HAD BEEN REPLACED,AND IGNITION WAS REPLACED ONCE AFTER VEHICLE HAD BEEN TOWED. LOW AND BEHOLD, CONSUMER'S FOCUS WAS SITTING IN DRIVEWAY NEEDED TO BE TOWED FOR THE SAME PROBLEM AGAIN. CAR WAS GETTING HORRIBLE GAS MILEAGE, SOMETIMES HAD BRAKE FAILURE WHICH CAUSED 2 ACCIDENTS. ALSO, LUGS:NUTS HAD BEEN REPLACED. THE CAR WOULD SOMETIMES STALL FOR NO APPARENT REASON, AND WAS IN NEED OF AN ALTERNATOR.*AK
NHTSA ODI #10032911
82,190 miles · Jul 31, 2003
Electrical SystemEngine And Engine CoolingEquipment
CONSTANT SQUEAKING NOISE WHEN THE BRAKES ARE APPLIED. I'VE ALREADY REPLACED THE ROTORS, BRAKES, BRAKE PADS, AND DRUMS ON SEVERAL OCCASIONS SINCE BUYING THIS FOCUS ABOUT 3 YEARS AGO. ALSO MY STEERING WHEEL LOCKED ON ME ONE DAY IN APRIL OF 2002 THE KEY WOULD NOT FIT INTO THE IGNITION TO START THE CAR I HAVE NO IDEA WHY THIS WOUL…
Read full complaint
CONSTANT SQUEAKING NOISE WHEN THE BRAKES ARE APPLIED. I'VE ALREADY REPLACED THE ROTORS, BRAKES, BRAKE PADS, AND DRUMS ON SEVERAL OCCASIONS SINCE BUYING THIS FOCUS ABOUT 3 YEARS AGO. ALSO MY STEERING WHEEL LOCKED ON ME ONE DAY IN APRIL OF 2002 THE KEY WOULD NOT FIT INTO THE IGNITION TO START THE CAR I HAVE NO IDEA WHY THIS WOULD HAPPEN FROM ONE DAY TO ANOTHER. I HAD MY VEHICLE TOWED TO THE FORD DEALERSHIP AND THEY DIDN'T KNOW WHAT THE PROBLEM WAS CAUSED BY. THEY SAID THAT THEY NEEDED TO UPDATE THE LOCK CYLINDER. LUCKILY I PURCHASED THE API EXTENDED WARRANTY THAT COVER THE CAR FOR 100,000 MILES. SO THE COST OF THE WORK DONE FOR THIS WAS $427.20. ALL BUT $50.00 OF WHICH WAS MY DEDUCTIBLE WAS COVER BY THIS WARRANTY. THE PROBLEMS DIDN'T STOP HERE. I ALSO HAVE HAD TO GET THE CD SYSTEMS THAT CAME INSTALLED IN THE CAR REPLACED. THE WAS A CONSTANT CLICKING NOISE WITH THE CD PLAYER AND 90% OF THE TIME THE CD'S WOULDN'T EVEN PLAY. I CALLED THE DEALERSHIP AND THEY SAID THAT THEY COULD REPLACE IT FOR ME BUT THAT IT WOULDN'T BE COVERER BY THE WARRANTY SO I WOULD HAVE TO PAY FOR IT OUT OF MY POCKET. I ENDED UP HAVING A NEW SYSTEM INSTALLED BUT NOT FROM THE FORD DEALERSHIP, I TOOK IT TO CIRCUIT CITY. RECENTLY THIS MONTH JULY 2003, MY CAR HAS BEEN STALING AND SHUTTING OFF AT STOP SIGNALS AND STOP LIGHT ALSO JUST SHUT COMPLETELY OFF ON THE FREEWAY THANK GOD NO ACCIDENT OCCURRED. I CALLED THE DEALERSHIP TO REPORT THIS PROBLEM ALSO MY CHECK ENGINE LIGHT WOULD COME ON AND OFF SEVERAL TIMES AND THEY SAID TO BRING IT IN AND THEY WOULD CHECK THE ENGINE LIGHT BUT THAT I WOULD HAVE TO PAY $165. 00 JUST FOR THEM TO CHECK THE LIGHT AND IT WOULD BE MORE $$$ TO REPAIR WHAT EVER PROBLEM IT WAS. I WAS FED UP BY THEN. *PH
NHTSA ODI #10030509
Mileage unknown · Jul 14, 2003
Engine And Engine CoolingEquipment
CONSUMER STATES WHEN AIR CONDITIONING IS ON AND VEHICLE IS IDLING T MOTOR STARTS MISSING. CAUSE IS UNKNOWN. *AK
NHTSA ODI #10027246
16,000 miles · May 16, 2003
EquipmentTires
THERE IS A VIBRATION FELT IN STEERING WHEEL WHEN DRIVING AT FREEWAY SPEEDS. I HAVE HAD THE CAR ALIGNED 2 TIMES, REPLACED THE TIRES 3-TIMES, REPLACED THE BRAKES 3-TIMES AND HAD THE TIRES ROTATED AND RE-BALANCED 6 TIMES, IN TWO YEARS. I HAVE HAD ALL OF THE RECALLS COMPLETED. THE VIBRATION STILL EXISTS AND THE DEALER CANNOT FIX …
Read full complaint
THERE IS A VIBRATION FELT IN STEERING WHEEL WHEN DRIVING AT FREEWAY SPEEDS. I HAVE HAD THE CAR ALIGNED 2 TIMES, REPLACED THE TIRES 3-TIMES, REPLACED THE BRAKES 3-TIMES AND HAD THE TIRES ROTATED AND RE-BALANCED 6 TIMES, IN TWO YEARS. I HAVE HAD ALL OF THE RECALLS COMPLETED. THE VIBRATION STILL EXISTS AND THE DEALER CANNOT FIX IT. THE DEALER JUST KEEPS TELLING ME TO GET THE TIRES RE-BALANCED, OR GET NEW TIRES AGAIN. *NLM
NHTSA ODI #10018793
Mileage unknown · Apr 13, 2003
Electrical SystemEquipmentLatches/locks/linkages
AFTER ABOUT 10 DAYS OF BUYING MY 2000 FORD FOCUS THE PROBLEM. STARTED AND ONE YEAR LATER THE PROBLEMS ARE STILL COMING LIKE CLOCK WORK. FIRST MY BREAKS WERE SQUEALING I CALLED THE DEALER, HE SAID NOT TO WORRY ABOUT IT UNTIL I HAD TIME TO COME IN. 1 TO 2 MONTHS LATER, AFTER SEVERAL CALLS ASKING IF IT WAS STILL OKAY TO DRIVE, I TO…
Read full complaint
AFTER ABOUT 10 DAYS OF BUYING MY 2000 FORD FOCUS THE PROBLEM. STARTED AND ONE YEAR LATER THE PROBLEMS ARE STILL COMING LIKE CLOCK WORK. FIRST MY BREAKS WERE SQUEALING I CALLED THE DEALER, HE SAID NOT TO WORRY ABOUT IT UNTIL I HAD TIME TO COME IN. 1 TO 2 MONTHS LATER, AFTER SEVERAL CALLS ASKING IF IT WAS STILL OKAY TO DRIVE, I TOOK MY CAR IN AND THE ROUTERS AND BREAKS WERE BAD, THEY SD I SHOULD HAVE BROUGHT MY CAR IN SOONER. WELL PER THERE REQUEST I TOOK MY TIME. I HAD TO PAY THE GET THIS TAKEN CARE OF. IT DIDN'T STOP THERE, MY TIRES KEPT GETTING FLATS SO I HAS TO ONCE AGAIN REPLACE AT MY OWN EXPENSES. NOW THE REAL PROBLEMS START, MY CRUISE CONTROL WAS JUST OUT OF CONTROL, MY CAR WOULD ACCELERATE EVERY TIME I WOULD PUT IN ON CRUISE. THE WINDSHIELD WIPERS WOULD NOT WORK AND MY RADIO KEPT TURNING OFF BY ITSELF. I HAD ONCE AGAIN AT MY OWN EXPENSES REPLACE MY WINDSHIELD WIPERS CALLING THE MAINTENANCE. DEPT. AT MERIDIAN FORD. THEY FIXED THE PROBLEM. WITH THE CRUISE CONTROL AND IT WAS WORKING FINE FOR ABOUT 2 MONTHS IT IS NOW HAPPENING AGAIN! NOW I HAVE PROBLEMS WITH THE KEY GETTING STUCK AND WILL NOT TURN, THE TRUNK WILL NOT SHUT, AND MY CAR WILL SHUT OFF WHEN THE CAR IS IN IDLE. IT TURNS OFF IF IN PARK OR DRIVE AFTER ABOUT ONE MIN. IDLE. THIS IS VERY FRUSTRATING. AND HAS CAUSED SO MANY FINANCIAL AND STRESS PROBLEMS. I DON'T FEEL SAFE IN THIS CAR AND I FEEL CHEATED! I WAS SOLD A LEMON! A LIST OF WHAT WAS WRONG WITH MY NEW CAR..BAD BREAKS, BAD ROUTERS, BAD WINDSHIELD WIPERS, BAD CRUISE CONTROL, BAD TRUNK, BAD TIRES, THE KEY GETS STUCK AND WILL NOT TURN, AND NOW IT TURNS OFF WHILE IN IDLE. ALL THESE THINGS ARE STILL WRONG WITH IT AND ITS COSTING ME MONEY, STRESS,TIME AND IT IS COSTING ME TO BE LATE ON MY CAR PAYMENTS AND OTHER BILLS BECAUSE I HAVE TO PAY FOR ALL THIS CRAP TO BE FIXED! WHY IS THIS HAPPENING! DO I NEED TO GET A LAWYER OR DO YOU NEED TO REPLACE OR FIX MY CAR AT YOUR EXPENSIVE. I HAVE LOST SO MUCH AND FEEL HELPLESS. I HOPE THIS DOES NOT FALL ON DEAF EARS. *NLM
NHTSA ODI #10014326
Official recalls
11Feb 1, 2005
CERTAIN PASSENGER VEHICLES WITH FOUR OR FIVE DOORS AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, A BUILD-UP OF CORROSION AT THE PAWL PIVOT AREA OF THE REAR DOOR LATCH CAN CAUSE A BINDING CONDITION OF THE PAWL THAT MAY AFFECT PROPER ENGAGEMENT OF THE PAWL INTO THE CATCH. THE OCCUPANT MAY EXPERIENCE DIFFICULTY OPENING OR CLOSING A REAR DOOR, AND EVENTUALLY THE REAR DOOR MAY NOT LATCH PROPERLY.
Consequence & remedy
Consequence: IF NOT LATCHED PROPERLY, THE DOOR MAY OPEN WHILE THE VEHICLE IS IN MOTION. IF AN OCCUPANT FELL OUT OF THE VEHICLE, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL HAVE A LOWER ROCKER SEAL ADDED TO THE DOOR AND HAVE THE REAR DOOR LATCHES EVALUATED FREE OF CHARGE. A LATCH THAT PASSES THE EVALUATION WILL BE LUBRICATED TO PREVENT FUTURE CORROSION. A LATCH THAT DOES NOT PASS THE EVALUATION WILL BE REPLACED. IN ADDITION, A STICKER WILL BE AFFIXED TO THE REAR DOORS ADVISING THE OWNERS TO USE THE RECOMMENDED LUBRICANT. THE RECALL BEGAN ON MARCH 9, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 19, 2003
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
Consequence & remedy
Consequence: THIS MAY CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED TO CAUSE THE ENGINE TO STALL, WHICH COULD RESULT IN A CRASH.
Remedy: THIS ACTION IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN AND IS NOT BEING CONDUCTED UNDER THE SAFETY ACT. ALL OWNERS WILL BE NOTIFIED OF THE PROBLEM, AND DEALERS WILL REPLACE THE FDM WITH A NEW DESIGN AT NO CHARGE IF THE OWNER REPORTS THAT THE VEHICLE EXHIBITS ANY OF THE IDENTIFIED SYMPTOMS. THE FREE REPLACEMENT WILL BE AVAILABLE FOR A PERIOD OF 10 YEARS FOLLOWING THE ORIGINAL PURCHASE OF THE VEHICLE, WITH NO MILEAGE LIMIT. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ZETEC ENGINES, LOOSE OR BROKEN ATTACHMENTS AND MISROUTED BATTERY CABLES COULD LEAD TO CABLE INSULATION DAMAGE.
Consequence & remedy
Consequence: THIS, IN TURN, COULD CAUSE THE BATTERY CABLES TO SHORT RESULTING IN HEAT DAMAGE TO THE CABLES. BESIDES HEAT DAMAGE, THE "CHECK ENGINE" LIGHT MAY ILLUMINATE, THE VEHICLE MAY FAIL TO START, OR SMOKE, MELTING, OR FIRE COULD ALSO OCCUR.
Remedy: DEALERS WILL INSPECT THE BATTERY CABLES FOR THE CONDITION OF THE CABLE INSULATION AND PROPER TIGHTENING OF THE TERMINAL ENDS. AS NECESSARY, CABLES WILL BE REROUTED, RETAINING CLIPS INSTALLED, AND DAMAGED BATTERY CABLES REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 6, 2002
CERTAIN PASSENGER VEHICLES HAVE LOOSE PINCH BOLTS THAT SECURE THE LOWER CONTROL ARM TO THE STEERING KNUCKLE HAVE BEEN REPORTED.
Consequence & remedy
Consequence: LOOSE PINCH BOLTS COULD EXHIBIT NOISE, VIBRATION AND, IN EXTREME CASES IF LEFT UNCORRECTED, SEPARATION OF THE JOINT OR FRACTURE OF THE BALL JOINT STUD, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING KNUCKLE PINCH BOLT FOR TIGHTNESS AND CORRECT AS NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 10, 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Dec 14, 2000
VEHICLE DESCRIPTION: STATION WAGONS AND 3-DOOR VEHICLES. THE SUBJECT VEHICLES HAVE A FOLDING 60/40 SECOND SEAT THAT BECOMES A LOAD FLOOR IN THE FOLDED POSITION. WHEN THE 60% PORTION OF THE SEAT IS FOLDED DOWN AND A LOAD IS APPLIED TO THE FRONT EDGE OF THE LOAD FLOOR, THE OUTBOARD HINGE PIVOT COULD DISENGAGE FROM THE HINGE.
Consequence & remedy
Consequence: IF THE SEAT IS THEN RETURNED TO THE UPRIGHT POSITION WITHOUT RE-ENGAGING THE HINGE PIVOT, THE SEAT AND SEAT BELTS MAY NOT PROVIDE THE INTENDED LEVEL OF PERFORMANCE IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSTALL A REVISED SEAT BACK HINGE PIVOT.
Dec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DECKLID WIRE HARNESS CAN FATIGUE AND DEVELOP BROKEN WIRES IN THE BEND AREA OF THE WIRE HARNESS.
Consequence & remedy
Consequence: THIS COULD RESULT IN EITHER A LOSS OF INDIVIDUAL LAMP FUNCTIONS, OR IN THE CASE OF A SHORT OF THE BROKEN WIRES THAT CAUSES A FUSE TO OPEN, IN THE LOSS OF STOP LAMP OR TAIL LAMP FUNCTION. LOSS OF STOP LAMP OR TAIL LAMP FUNCTION COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DECKLID WIRE HARNESS.
Oct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL AND AUTOMATIC TRANSMISSION. A SPEED CONTROL CABLE COULD HAVE A CORE WIRE THAT IS LONG ENOUGH TO CATCH ON THE SLEEVE AT THE THROTTLE BODY END OF THE CABLE DURING WIDE-OPEN THROTTLE ACCELERATION.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN REDUCED VEHICLE CONTROL AND, POTENTIALLY, A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND, IF NECESSARY, REPLACE THE SPEED CONTROL CABLE. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Oct 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR WHEEL HUB RETAINING NUTS CAN LOOSEN AND ALLOW THE LEFT REAR WHEEL AND BRAKE DRUM ASSEMBLY TO SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: THIS CONDITION COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE REAR WHEEL BEARINGS AND INSTALL A REAR WHEEL RETENTION CAP TO PREVENT LEFT REAR WHEEL SEPARATION. OWNER NOTIFICATION BEGAN OCTOBER 12, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Aug 11, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE RESULTANT HIC(D) VALUE AT ONE TARGET LOCATION AP1, LOCATED ON THE TRIM PANEL AT THE JUNCTURE OF THE A-PILLAR AND ROOF SIDE RAIL, MAY BE GREATER THAN DESIGN INTENT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, AN OCCUPANT CONTACTING THAT LOCATION MAY NOT BE PROVIDED THE INTERIOR IMPACT PROTECTION INTENDED.
Remedy: DEALERS WILL REMOVE THE LEFT AND RIGHT SIDE B-PILLAR AND A-PILLAR TRIM PANELS, REVISE THE HEADLINER EDGE NEAR THE TOPS OF THE A-PILLARS TO ACCEPT THE NEW A-PILLAR TRIM PANELS WITH THEIR ENERGY ABSORBING TUBES, AND INSTALL THE NEW A-PILLAR AND THE OLD B-PILLAR TRIM PANELS.
Dec 3, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH SPEED CONTROL. THE SPEED CONTROL CABLE END FITTING CAN ALLOW WATER TO ENTER THE SPEED CONTROL SERVO ASSEMBLY. IF THIS OCCURS, CORROSION IN THE SERVO ASSEMBLY COULD DEVELOP AND CAUSE INTERMITTENT SPEED CONTROL OPERATION OR PREVENT THE THROTTLE FROM RETURNING TO IDLE.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SPEED CONTROL CABLE (WITH A NEW CABLE THAT INCORPORATES A GLASS-FILLED END CAP) AND INSPECT THE ASSEMBLY FOR INTERNAL CORROSION. SERVOS WITH EVIDENCE OF CORROSION WILL ALSO BE REPLACED. OWNERS ARE ADVISED NOT TO USE THE SPEED CONTROL UNTIL THE VEHICLES ARE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
EA04023 · Rear Door Latch Failure
Opened Aug 18, 2004 · Closed Feb 4, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
THIS INVESTIGATION WAS OPENED ON APRIL 8, 2004 AS PE04-033 AND UPGRADED ON AUGUST 18, 2004 TO EA04-023.THE COMPLAINANTS ALLEGED THAT THE REAR DOOR LATCHES FAILED TO KEEP THE DOORS IN A CLOSED POSITION, RESULTING IN REAR DOORS COMING OPEN WHILE THE VEHICLES WERE BEING DRIVEN.SOME COMPLAINANTS REPORTED THAT AT TIMESA REAR DOOR, OR DOORS, COULD BE DIFFICULT TO CLOSE.OTHERS REPORTED THAT CORROSION OF THE DOOR LATCH MECHANISM CAUSED BINDING OF THE LATCH.FORD HAS IDENTIFIED A CONDITION OF CORROSION IN THE PAWL PIVOT AREA OF THE DOOR LATCH ASSEMBLY THAT PREVENTS PROPER ENGAGEMENT OF THE DOOR LATCH CATCH TO THE LATCH STRIKER ON THE VEHICLE BODY.BY LETTER OF FEBRUARY 1, 2005, FORD MOTOR COMPANY NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL ON MODEL YEAR 2000 THROUGH 2002 FOUR AND FIVE-DOOR FOCUS VEHICLES REGISTERED IN, OR ORIGINALLY SOLD IN, CONNECTICUT, DELAWARE, THE DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN. DEALERS WILL INSPECT REAR DOOR LATCHES AND REPLACE BINDING LATCHES AS REQUIRED.DEALERS WILL ALSO LUBRICATE ALL REAR DOOR LATCHES TO PREVENT FUTURE CORROSION AND BINDING.A LOWER ROCKER SEAL WILL ALSO BE ADDED TO THE REAR DOORS. SEE SAFETY RECALL 05V030 FOR DETAILS.
PE04033 · Rear Door Latch Failure
Opened Apr 8, 2004 · Closed Aug 20, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
THIS INVESTIGATION WAS OPENED ON APRIL 8, 2004, BASED ON 17 REPORTS THAT ONE OR BOTH REAR DOOR LATCHES DID NOT FUNCTION PROPERLY.THE COMPLAINANTS ALLEGED THAT THE DOORS WERE DIFFICULT TO CLOSEAND THAT THE DOOR LATCHES WOULD NOT REMAIN LATCHED WHILE THE VEHICLES WERE BEING DRIVEN, RESULTING IN A DOOR COMING OPEN.SEVERAL OF THE COMPLAINANTS REPORTED THAT CORROSION OF THE DOOR LATCH MECHANISM CAUSED BINDING OF THE LATCH.FORD'S RESPONSE TO THE PRELIMINARY EVALUATION INFORMATION REQUEST PROVIDED 19 CONSUMER REPORTS AND 28 WARRANTY CLAIMS ATTRIBUTED TO THE DOOR LATCH WHERE THE DOORS CAME OPEN WHILE THE VEHICLES WERE BEING DRIVEN.THREE (3) OF THE 17 OPENING ODI REPORTS WERE DUPLICATED IN FORD'S RESPONSE.THIS INVESTIGATION HAS BEEN UPGRADED TO ENGINEERING ANALYSIS EA04-023 FOR FURTHER STUDY.
EA02022 · Engine Stalling
Opened Sep 9, 2002 · Closed Jan 16, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other:delivery:fuel Pump; Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Fuel System, Other:delivery:fuel Pump
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
Vehicle Speed Control:linkages
CLOGGING OF THE FUEL DELIVERY MODULE (FDM) FILTERS IN THE SUBJECT VEHICLES CAN LEAD TO STALLING AND OTHER RELATED SYMPTOMS.THESE SYMPTOMS BECOME INCREASINGLY OBVIOUS TO THE DRIVER AS THE CLOGGING GRADUALLY INCREASES OVER EXTENDED PERIODS OF DRIVING.STALLING IN THESE VEHICLES IS MOST LIKELY TO OCCUR WHEN ACCELERATING THROUGH A RIGHT HAND TURN SUCH AS MERGING INTO FREEWAY TRAFFIC WHEN THE FUEL LEVEL IN THE FUEL TANK IS LESS THAN 1/4 FULL.MORE THAN 90% OF THE STALLING COMPLAINTS PERTAIN TO THE ORIGINAL DESIGN FDM INSTALLED IN MY 2000 AND 2001 (PARTIAL YEAR) FOCUS VEHICLES. FORD HAS DECIDED TO CONDUCT A CAMPAIGN (03V-482) TO ADDRESS STALLINGIN THESE VEHICLES.THE SMALLER NUMBER AND RATE OF COMPLAINTS ASSOCIATED WITH THE INTERIM AND CURRENT FDM DESIGNS INDICATE IMPROVEMENT BUT ALSO REFLECT A SHORTER TIME IN SERVICE FOR THESE DESIGNS. ACCORDINGLY, ODI WILL MONITOR THE STALLING PERFORMANCE OF MY 2001 - 2002 FOCUS VEHICLES EQUIPPED WITH INTERIM AND CURRENT DESIGN FDMS.
EA02023 · Front Susp Collapse/wheel Separation
Opened Sep 9, 2002 · Closed Feb 19, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Additional source detail variants (4)
Suspension:front:control Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Arm
SEE ATTACHED REPORT.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
Suspension:front
SEE ATTACHED REPORT.
EA02017 · Burn Injuries Due To Air Bag Deployment
Opened Aug 16, 2002 · Closed Aug 15, 2003
Status: closed (inferred from source dates) · Air Bags
ALL OF THE CONSUMER COMPLAINTS ALLEGE AN INCIDENT IN WHICH DEPLOYMENT OF THE DRIVER FRONTAL AIR BAG CAUSED SOME TYPE OF BURN INJURY.MOST OF THESE INJURIES ARE DUE TO CONTACT AND/OR ABRASION WITH THE AIR BAG AND ARE OF RELATIVELY MINOR TO MODERATE SEVERITY.IT IS POSSIBLE THAT SOME DRIVERS MAY HAVE SUSTAINED BURN INJURIES TO THE SKIN AS A RESULT OF HOT GASES EXHAUSTING FROM THE VENTS OF THE AIR BAGS IN THE SUBJECT VEHICLES, BUT THE NUMBER OF SUCH INCIDENTS APPEARS TO BE LOW.FURTHER DETAILS OF THE INVESTIGATION ARE CONTAINED IN SUBSEQUENT PAGES OF THIS REPORT.BASED ON THE ABOVE, FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02014 · Engine Compartment Fires
Opened Jul 31, 2002 · Closed Nov 13, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE02044 · Front Suspension Lower Control Arm
Opened May 1, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE02040 · Engine Stalling
Opened Apr 4, 2002 · Closed Sep 9, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE PRIMARY CONCERN OF THIS PE IS LOSS OF ENGINE POWER.STALLING MAY OCCUR AT LOW SPEED OR HIGH SPEED.AT THE TIME OF OCCURRENCE THE AVERAGE VEHICLE MILEAGE IS 30,000 MILES.BECAUSE THESE VEHICLES STALL AND/OR HESITATE UNPREDICTABLY, AN INCREASED RISK IS INHERENT TO THESE VEHICLES.IF A DRIVER EXPECTING THIS VEHICLE TO PERFORM AS DESIGNED, IS TRYING TO CROSS AN INTERSECTION OR MERGE INTO TRAFFIC WHEN THE VEHICLE STALLS IT PLACES ALL MOTORISTS WITHIN THE AREA AT RISK.A DISABLED VEHICLE IS VULNERABLE TO COLLISIONS NOT ONLY WITHIN THE ROADWAY, BUT ALSO ALONG SIDE THE ROAD AS IT WAITS FOR ASSISTANCE.
PE02032 · Engine Compartment Fires
Opened Mar 12, 2002 · Closed Jul 31, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE02026 · Inappropriate Air Bag Deployment
Opened Feb 28, 2002 · Closed Sep 18, 2002
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE02020 · Air Bag Burn Injuries/vehicle Fires
Opened Feb 11, 2002 · Closed Aug 16, 2002
Status: closed (inferred from source dates) · Air Bags
INFORMATION DISCLOSED DURING THIS PE SHOWS ALLEGATIONS OF BURN INJURIES RESULTING FROM ABRASION AND/OR TERMAL CAUSES.ALLEGATIONS OF CHEMICAL BURNS ALSO EXIST.SEVERAL INCIDENTS ALLEGE VEHICLES FIRES RESULTING FROM DEPLOYMENT OF THE AIR BAGS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO FACILITATE A THOROUGH REVIEW OF THE COMPLEX ISSUES IN THIS MATTER.
PE02016 · Rear Wheel Bearing
Opened Feb 8, 2002 · Closed Nov 8, 2002
Status: closed (inferred from source dates) · Wheels
There is no summary currently available
Illustration