TL* THE CONTACT OWNS A 2009 FORD F-650 SD. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT THE BRAKES FAILED TO RESPOND. THE CONTACT HAD TO MAKE A SHARP LEFT TURN TO AVOID CRASHING INTO A VEHICLE. THE EMERGENCY BRAKE WAS ACTIVATED AND SHIFTED THE GEAR SHIFTER INTO SLOW RANGE TO BE…
Read full complaint
TL* THE CONTACT OWNS A 2009 FORD F-650 SD. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT THE BRAKES FAILED TO RESPOND. THE CONTACT HAD TO MAKE A SHARP LEFT TURN TO AVOID CRASHING INTO A VEHICLE. THE EMERGENCY BRAKE WAS ACTIVATED AND SHIFTED THE GEAR SHIFTER INTO SLOW RANGE TO BE ABLE TO CONTINUE DRIVING THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT A CONTROL UNIT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 17,000. UPDATED 05/19/17*LJ *CN
FORD IS RECALLING CERTAIN MODEL YEAR 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH CATERPILLAR C7 ENGINE. THE #5 AND #6 FUEL LINES MAY CRACK AT THE FASTENING POINT TO THE COMMON FUEL RAIL AND CAUSE A FUEL LEAK.
Consequence & remedy
Consequence: A FUEL LEAK, IN THE PRESENCE OF AN IGNITION SOURCE, CAN RESULT IN A VEHICLE FIRE.
Remedy: FORD IS WORKING WITH CATERPILLAR TO NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY AUTHORIZED CATERPILLAR DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 8, 2010. OWNERS MAY CONTACT CATERPILLAR TOLL-FREE AT 1-800-447-4986 OR FORD AT 1-866-436-7332.
FORD IS RECALLING MODEL YEARS 2009 F-650 AND F-750 TRUCKS. THE CHASSIS WIRE HARNESS MAY HAVE BEEN ASSEMBLED WITHOUT A CONNECTOR SEAL IF THIS SEAL IS MISSING, THE CONNECTOR TERMINALS MAY CORRODE AFFECTING THE PROPER ILLUMINATION OF THE VEHICLE'S REAR BRAKE LAMPS, TAIL LAMPS, TURN SIGNAL LAMPS OR TRAILER LAMPS (IF EQUIPPED.) ALSO, THE FUNCTION OF THE ANTI-LOCK BRAKE SYSTEM MAY BE AFFECTED.
Consequence & remedy
Consequence: INOPERATIVE LAMPS MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE CONNECTOR AND REPAIR THE MAIN AND REAR CHASSIS WIRE HARNESS IF NECESSARY. A MISSING SEAL WILL BE REPLACED AND ELECTRICAL GREASE APPLIED TO PREVENT FUTURE CORROSION. THE SAFETY RECALL BEGAN ON DECEMBER 16, 2009. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR THROUGH THE INTERNET AT WWW.FORDOWNER.COM.
FORD IS RECALLING 2,811 MY 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH C7 OR C9 CATERPILLAR DIESEL ENGINES. THE FUEL PUMP OUTLET CHECK PLUG MAY BE CRACKED WHICH COULD CAUSE FUEL TO SPRAY AND LEAK.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: FORD IS WORKING WITH CATERPILLAR (PLEASE SEE 08E042). CATERPILLAR WILL REPLACE THE FUEL PUMP PLUG FREE OF CHARGE. OWNERS MAY CONTACT CATERPILLAR AT 1-800-447-4986, OR FORD AT 1-800-343-5338 (FLEET OWNERS) OR 1-866-906-9811 (MOTOR HOME OWNERS).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2009 Ford F-650 Sd Problems, Complaints & Recalls | Skip That Year
Illustration