Brought the truck in to ford and they told me that paint lining from the tank may of gone into the fuel lines and system so they suggested that we replace the tank and they also replaced 2 injectors and the wiring harness for the injectors and reset the check engine light drove fine till the check engine light come on then its i…
Read full complaint
Brought the truck in to ford and they told me that paint lining from the tank may of gone into the fuel lines and system so they suggested that we replace the tank and they also replaced 2 injectors and the wiring harness for the injectors and reset the check engine light drove fine till the check engine light come on then its in limp mode and only drives at 40 miles per hour it is unsafe to drive on the highway and I do like this truck
NHTSA ODI #11491913
31,871 miles · Jan 19, 2015
EngineFuel/propulsion SystemPower Train
THE TRUCK HAS NOT RUN PROPERLY SINCE IT WAS PURCHASED, AND THE MOTOR WAS REPLACED BACK IN 2013 WITH MILEAGE OF 31,00 DUE TO OIL BEING SPLATTERED ALL OVER AND NO POWER. WE HAD SPEND OVER 10,000.00 TO FIX THE DEFECTIVE ISSUES. NOW ALMOST 2 YEARS TO THE DAY THE ENGINE HAS AGAIN FAILED. FORD OFFERS NO HELP OR EXPLANATIONS AS TO WHY …
Read full complaint
THE TRUCK HAS NOT RUN PROPERLY SINCE IT WAS PURCHASED, AND THE MOTOR WAS REPLACED BACK IN 2013 WITH MILEAGE OF 31,00 DUE TO OIL BEING SPLATTERED ALL OVER AND NO POWER. WE HAD SPEND OVER 10,000.00 TO FIX THE DEFECTIVE ISSUES. NOW ALMOST 2 YEARS TO THE DAY THE ENGINE HAS AGAIN FAILED. FORD OFFERS NO HELP OR EXPLANATIONS AS TO WHY THIS CONTINUES TO HAPPEN.. *TR
NHTSA ODI #10676458
20,000 miles · Feb 20, 2013
Fuel/propulsion System
TL* THE CONTACT OWNS A 2008 FORD F-550. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP WAS CLOGGED DUE TO THE FUEL TANK DELAMINATING. AS A RESULT, BOTH THE FUEL PUMP AND THE FUEL TANK NEEDED TO BE RE…
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD F-550. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP WAS CLOGGED DUE TO THE FUEL TANK DELAMINATING. AS A RESULT, BOTH THE FUEL PUMP AND THE FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED TO PAY THE REPAIR COSTS FOR THE FUEL PUMP AND A PERCENTAGE OF THE FUEL TANK REPAIR EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 32,000.
CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.
Consequence & remedy
Consequence: THIS DEFECT COULD RESULT IN A FIRE.
Remedy: CUES IS WORKING WITH CARRIER TO REMEDY THE AFFECTED VEHICLES. REPAIRS WILL BE MADE BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL BEGAN ON JANUARY 5, 2010. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR CUES AT 1-407-849-0190.
FORD IS RECALLING 87,515 MY 2008 F250, F-350, F-450, AND F-550 VEHICLES FOR FAILING TO COMPLY WITH ALL THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." SOME 40% SPLIT AND CAPTAIN'S CHAIR DRIVER'S SEATS, EQUIPPED WITH LUMBAR SUPPORTS, MAY HAVE IMPROPER WELDS AT THE JOINT OF THE SEAT BACK PIVOT BRACKET AND THE SEAT BACK FRAME.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT SIDE PIVOT BRACKET MAY CRACK OR BREAK, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL ADD A REINFORCEMENT TO THE DRIVER'S SEAT BACK FRAME ON THE 40% SPLIT OR CAPTAIN'S CHAIR SEAT EQUIPPED WITH LUMBAR SUPPORT OR, IF NECESSARY, THE SEAT BACK FRAME WILL BE REPLACED. THE RECALL BEGAN ON MARCH 28, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, EXCESSIVE TEMPERATURES IN THE DIESEL PARTICULATE FILTER IN THE EXHAUST SYSTEM MAY RESULT FROM EXCESS HYDROCARBONS IN THE EXHAUST.
Consequence & remedy
Consequence: LACK OF POWER OR ROUGH OPERATION, UNUSUAL NOISES FROM THE ENGINE OR EXHAUST, WHITE SMOKE FROM THE EXHAUST, AND POTENTIALLY A VISIBLE FLAME OUT THE TAILPIPE CAN OCCUR.
Remedy: DEALERS WILL REPROGRAM THE POWER TRAIN CONTROL MODULE. THE RECALL BEGAN ON APRIL 3, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, INSUFFICIENT CLEARANCE OF THE BATTERY POSITIVE (B+) WIRE TO THE RIGHT HAND SPLASH SHIELD BOLT MAY RESULT IN THE BATTERY B+ WIRE CONTACTING THE SPLASH SHIELD BOLT.
Consequence & remedy
Consequence: LONG TERM CONTACT COULD CAUSE WIRE CHAFE, RESULTING IN COPPER WIRE BEING EXPOSED. IF THIS CONDITION OCCURS, THE BATTERY B+ WIRE COULD SHORT TO GROUND INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSPECT THE BATTERY B+ WIRE LOCATION AND, IF NECESSARY, REPOSITION THE WIRE. THE RECALL BEGAN ON APRIL 3, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2008 Ford F-550 Sd Problems, Complaints & Recalls | Skip That Year
Illustration