IN-TANK FUEL PUMP FAILED AT ELEVATED TEMPERATURES, STRANDING US BESIDE THE ROAD FOR MANY HOURS IN EXTREMELY DANGEROUS LOCATION. WAS NOT DIAGNOSED ON FIRST FAILURE. WHEN COOL, WORKED AGAIN, AND WE WENT ON. FAILED AGAIN ON NEXT DAY. DEALER WHO REPAIRED STATED 42ND PUMP REPLACE SO FAR THIS YEAR. IF ONE DEALER REPLACED THIS MAN…
Read full complaint
IN-TANK FUEL PUMP FAILED AT ELEVATED TEMPERATURES, STRANDING US BESIDE THE ROAD FOR MANY HOURS IN EXTREMELY DANGEROUS LOCATION. WAS NOT DIAGNOSED ON FIRST FAILURE. WHEN COOL, WORKED AGAIN, AND WE WENT ON. FAILED AGAIN ON NEXT DAY. DEALER WHO REPAIRED STATED 42ND PUMP REPLACE SO FAR THIS YEAR. IF ONE DEALER REPLACED THIS MANY, PROBLEM MUST BE ENORMOUS NATIONWIDE.I BELIEVE THIS IS A SAFETY HAZARD BECAUSE IT CAN STRAND YOU IN DANGEROUS LOCATIONS. WE WERE TOWED THE FIRST TIME, BUT THE PROBLEM HAD GONE AWAY BY THE TIME WE WERE DROPPED OFF. THE SECOND TIME, THE DEALER ADVISED US TO LET IT COOL DOWN AND DRIVE IN. THE DEALER HAD REPLACED SO MANY HE KNEW JUST WHAT THE PROBLEM WAS.COST OF REPAIRS WAS $658.59. I BELIEVE FORD SHOULD RE-IMBURSE FOR REPAIRS CONSIDERING LARGE NUMBER OF FAILURES, AND THE SAFETY ISSUE!
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1995 Ford F-53 Problems, Complaints & Recalls | Skip That Year
Illustration