Forward Collision Avoidance. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports3 fire reports1 injury reports

Engine And Engine Cooling complaints

1 reports

Clear category filter

9,707 miles · Aug 18, 2026

Electrical SystemEngine And Engine CoolingFire

Read full complaint

The contact owned a 2024 Ford F-450 SD. The contact stated that while his fiancée was driving with cruise control set to 57 MPH, there was an abnormally strong smoky odor inside the cabin of the vehicle. No warning light was illuminated. The driver pulled over to the side of the road and there were flames coming from the engine bay. The driver called 9-1-1. The driver attempted to extinguish the fire with assistance using three fire extinguishers but failed to extinguish the fire. The vehicle became fully engulfed in flames before the Fire Department arrived on the scene. The fire department extinguished the fire; however, the entire vehicle burned, leaving only a fraction of the tailgate intact. Neither a Fire Department nor a Police report was filed. The contact's dog sustained a burn injury; however, the driver was not injured. The vehicle was towed to a tow yard and was pending the decision of the insurance company. The manufacturer was notified of the failure, but no assistance was provided, and the contact was referred to the insurance company for assistance. The failure mileage was approximately 9,707.

NHTSA ODI #11757734

Official recalls

26V104000 · Electrical System: Integrated Trailer Brake Control; Exterior Lighting:tail Lights

Feb 20, 2026

Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."

Consequence & remedy

Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

Additional source detail variants (2)

Exterior Lighting:tail Lights

Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.

Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.

Electrical System: Integrated Trailer Brake Control

25V315000 · Back Over Prevention:software

May 9, 2025

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

Consequence & remedy

Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.

24V806000 · Back Over Prevention: Sensing System: Camera; Structure:body:tailgate

Oct 25, 2024

Ford Motor Company (Ford) is recalling certain 2023-2024 F-250, F-350, and F-450 vehicles. Water may enter the Tailgate Park Assist Sensor Interface Module (TPASIM) and cause the rearview camera image to display intermittently or appear blue or black.

Consequence & remedy

Consequence: A rearview camera image that does not display can decrease the driver's visibility, increasing the risk of injury or crash.

Remedy: Dealers will replace the tailgate top camera, wire harness, TPASIM module, and update the Image Processing Module A (IPMA) software, free of charge. Owner notification letters were mailed August 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S66.

Additional source detail variants (2)

Back Over Prevention: Sensing System: Camera

Consequence: A rearview camera image that does not display can decrease the driver's visibility, increasing the risk of injury or crash.

Remedy: Dealers will replace the tailgate top camera, wire harness, TPASIM module, and update the Image Processing Module A (IPMA) software, free of charge. Owner notification letters were mailed August 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S66.

Structure:body:tailgate

Consequence: A rearview camera image that does not display can decrease the driver's visibility, increasing the risk of injury or crash.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.