NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
145 reports2,018 miles · Nov 5, 2014
Air BagsCrash
TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE CONTACT CRASHED INTO A DEER AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TOWED TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOT…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE CONTACT CRASHED INTO A DEER AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TOWED TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 2,018. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10652785
65,000 miles · Oct 30, 2014
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THE ENGINE OVERHEATED. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE EGR COOLER WAS FAULTY AND NEEDED TO BE REPLACED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE FAILURE WAS REPAIRED BUT THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOTIFIED OF T…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THE ENGINE OVERHEATED. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE EGR COOLER WAS FAULTY AND NEEDED TO BE REPLACED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE FAILURE WAS REPAIRED BUT THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. PAM
NHTSA ODI #10651475
72,000 miles · Oct 29, 2014
Steering
STEERING WOBBLE AND SHAKES. THIS HAS BEEN GETTING WORSE AS TIME GOES ON. ANYTIME I HIT A BUMP ON THE FREEWAY MY TRUCK STARTS TO VIOLENTLY SHAKE AND WOBBLE. IT IS EVEN WORSE ON A ROAD CURVE. IT IS VERY DANGEROUS TO DRIVING ON THE FREEWAY IN THE MOUNTAINS. I FEW TIMES I ALMOST LOST CONTROL. THE SHAKE DOES NOT GO AWAY UNTIL I SLOW…
Read full complaint
STEERING WOBBLE AND SHAKES. THIS HAS BEEN GETTING WORSE AS TIME GOES ON. ANYTIME I HIT A BUMP ON THE FREEWAY MY TRUCK STARTS TO VIOLENTLY SHAKE AND WOBBLE. IT IS EVEN WORSE ON A ROAD CURVE. IT IS VERY DANGEROUS TO DRIVING ON THE FREEWAY IN THE MOUNTAINS. I FEW TIMES I ALMOST LOST CONTROL. THE SHAKE DOES NOT GO AWAY UNTIL I SLOW DOWN BELOW 40MPH WHICH CAUSES ANOTHER DANGEROUS SITUATION WHILE ON THE FREEWAY. I HAVE CHANGED TIRES, CHECKED PRESSURE AND ROTATED TIRES. ALSO, I REPLACED STEERING DAMPENER. NOTHING HAS WORKED TO DIMINISH THE SHAKE. I ALSO HAD THE 4 WHEEL ALIGNMENT CHECKED AND THE SHOP SHOWED ME THAT IT WAS CORRECT. THEY CHECKED EVERYTHING AND COULD NOT FIND ANYTHING THAT WAS WORN OUT AND NEEDED CHANGING. I WAS TOLD NO REPAIRS NEEDED. THIS IS A VERY DANGEROUS SITUATION AND NEEDS TO BE CORRECTED BEFORE BODIES START PILING UP. *TR
NHTSA ODI #10651012
139,141 miles · Oct 22, 2014
Wheels
WHILE PARKED, A CRACK IN THE CIRCUMFERENCE OF THE DRIVERS SIDE ALUMINUM WHEEL WAS NOTICED. THE CRACK EXTENDS FROM SPOKE TO SPOKE ON THE 20" FACTORY FORD RIM. AFTER SOME RESEARCH ON THE INTERNET, I AM NOT THO ONLY ONE EXPERIENCING THIS SITUATION. IN MOST CASES SUCH AS MINE THE RIMS ARE CRACKING IN THE SAME PLACE AND IN MOST CASES…
Read full complaint
WHILE PARKED, A CRACK IN THE CIRCUMFERENCE OF THE DRIVERS SIDE ALUMINUM WHEEL WAS NOTICED. THE CRACK EXTENDS FROM SPOKE TO SPOKE ON THE 20" FACTORY FORD RIM. AFTER SOME RESEARCH ON THE INTERNET, I AM NOT THO ONLY ONE EXPERIENCING THIS SITUATION. IN MOST CASES SUCH AS MINE THE RIMS ARE CRACKING IN THE SAME PLACE AND IN MOST CASES THERE WAS NO DAMAGE NOTED TO THE WHEEL FROM POTHOLES OR IMPACTS, THE RIM IS DEFECTIVE AND CRACKING. I HAVE CONTACTED FORD AND THERE IS NO RECALL AT THIS POINT AND THE TRUCK IS NOT UNDER WARRANTY. HOWEVER THIS APPEARS TO BIG A HUGE SAFETY ISSUE, AS IF THE WHEEL WOULD CONTINUE TO CRACK, IT WOULD NOT HOLD AIR AN THE TIRE COULD GO FLAT IMMEDIATELY. I WOULD LIKE TO SEND A PICTURE OF THIS TO SHOW THE ISSUE. THERE ARE SEVERAL PICTURES ON THE INTERNET OF THE SAME WHEEL (5 SPOKE 20" ALUMINUM WHEEL 2006 F-350 TRUCKS). *TR
NHTSA ODI #10649276
42,000 miles · Oct 21, 2014
EngineFuel/propulsion System
2006 FORD F-350 6.0 DIESEL CAB AND CHASIS -- EGR VALVE 1ST TIME FIXED BY FORD DEALER NO COST, EGR VALVE 2ND TIME FIXED AT COST, EGR VALVE 3RD TIME BY-PASSED, 16 FUEL INJECTORS REPLACED. DELAMINATING GAS TANK, OVER A DOZEN FUEL FILTERS AT $60,00 A POP, NEW FUEL PUMP, NEW GAS TANK, 8 MORE NEW FUEL INJECTORS. POSSIBLE TURBO ISSUES …
Read full complaint
2006 FORD F-350 6.0 DIESEL CAB AND CHASIS -- EGR VALVE 1ST TIME FIXED BY FORD DEALER NO COST, EGR VALVE 2ND TIME FIXED AT COST, EGR VALVE 3RD TIME BY-PASSED, 16 FUEL INJECTORS REPLACED. DELAMINATING GAS TANK, OVER A DOZEN FUEL FILTERS AT $60,00 A POP, NEW FUEL PUMP, NEW GAS TANK, 8 MORE NEW FUEL INJECTORS. POSSIBLE TURBO ISSUES AND I MAY BE FORGETTING SOMETHING. *TR
NHTSA ODI #10649047
20,000 miles · Apr 2, 2014
SteeringSuspension
TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT THE SUSPENSION WAS UNSTABLE AND WOULD SHAKE WHILE THE VEHICLE WAS BEING DRIVEN AROUND A CURVE OR AT VARIOUS SPEEDS SPORADICALLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE DEALER REPLACED THE POWER STEERING HOSES AND THE STEERING STA…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT THE SUSPENSION WAS UNSTABLE AND WOULD SHAKE WHILE THE VEHICLE WAS BEING DRIVEN AROUND A CURVE OR AT VARIOUS SPEEDS SPORADICALLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE DEALER REPLACED THE POWER STEERING HOSES AND THE STEERING STABILIZER HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT A CASTER ADJUSTMENT WOULD NEED TO BE PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DECLINED TO PROVIDE THE CONTACT A REMEDY TO REPAIR THE VEHICLE. THE FAILURE MILEAGE WAS 20,000.
NHTSA ODI #10576849
161,000 miles · Mar 3, 2014
Air BagsCrash
TL* THE CONTACT OWNS A 2006 FORD F-350 . THE CONTACT STATED THAT THE DRIVER WAS TRAVELING AN UNKNOWN SPEED AND CRASHED INTO AN EMBANKMENT. THE IMPACT CAUSED THE VEHICLE TO FLIP IN REVERSE AND LAND ON THE PASSENGER'S SIDE. THE AIR BAGS FAILED TO DEPLOY. THE DRIVER WAS KILLED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. TH…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD F-350 . THE CONTACT STATED THAT THE DRIVER WAS TRAVELING AN UNKNOWN SPEED AND CRASHED INTO AN EMBANKMENT. THE IMPACT CAUSED THE VEHICLE TO FLIP IN REVERSE AND LAND ON THE PASSENGER'S SIDE. THE AIR BAGS FAILED TO DEPLOY. THE DRIVER WAS KILLED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 161,000. *TR
NHTSA ODI #10566823
60,000 miles · Feb 11, 2014
SteeringSuspension
TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT THE WHILE DRIVING APPROXIMATELY 35 MPH, THE FRONT END OF THE VEHICLE AND THE STEERING WHEEL EXPERIENCED SEVERE VIBRATION AFTER THE CONTACT DROVE OVER A ROAD DIP. THE CONTACT STATED THAT THE DEFECT WOULD RECUR WHEN DRIVING AT ANY SPEED AND ANYTIME THE VEHICLE WAS DRI…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT THE WHILE DRIVING APPROXIMATELY 35 MPH, THE FRONT END OF THE VEHICLE AND THE STEERING WHEEL EXPERIENCED SEVERE VIBRATION AFTER THE CONTACT DROVE OVER A ROAD DIP. THE CONTACT STATED THAT THE DEFECT WOULD RECUR WHEN DRIVING AT ANY SPEED AND ANYTIME THE VEHICLE WAS DRIVEN OVER A DIP OR ROAD WINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 60,000.
NHTSA ODI #10563867
181,000 miles · Jan 16, 2014
Steering
DRIVING VEHICLE WITH FIFTH WHEEL 31 FT CAMPER IN TOW VEHICLE LURCHED TO THE LEFT AND ATTEMPTS TO CORRECT FOUND GREAT RESISTANCE IN STEERING RESPONSE. ON SEVERAL OCCASIONS SINCE AND AT NO SPECIFIC SPEED THE VEHICLE WILL LURCH TO THE LEFT OR RIGHT OR SHIMMY TO THE POINT THAT STEERING BECOMES ALMOST UNRESPONSIVE. I HAD THE VEHICLE …
Read full complaint
DRIVING VEHICLE WITH FIFTH WHEEL 31 FT CAMPER IN TOW VEHICLE LURCHED TO THE LEFT AND ATTEMPTS TO CORRECT FOUND GREAT RESISTANCE IN STEERING RESPONSE. ON SEVERAL OCCASIONS SINCE AND AT NO SPECIFIC SPEED THE VEHICLE WILL LURCH TO THE LEFT OR RIGHT OR SHIMMY TO THE POINT THAT STEERING BECOMES ALMOST UNRESPONSIVE. I HAD THE VEHICLE CHECKED AND WAS ADVISED NOTHING WAS IN NEED OF REPLACEMENT. THEN I RECEIVED A LETTER FROM FORD MOTOR CO DESCRIBING THE EXACT STEERING SITUATION THAT I AM EXPERIENCING ALONG WITH RECOMMENDATIONS TO KEEP TIRES INFLATED PROPERLY, WHICH I HAVE AND CONTINUE TO HAVE CORRECT. I CONTACTED FORD TO VOICE MY CONCERN AND WAS ADVISED THIS IS "JUST A NORMAL QUALITY OF A SOLID FRONT AXEL 4 WHEEL DRIVE TRUCK". I USE THIS VEHICLE TO PULL A CAMPER AND WHEN THIS "SEVERE VIBRATION AND OSCILLATION" OCCURS IT CAUSES THE TRUCK/TRAILER TO LURCH SO FAR AS TO CAUSE IT TO SHIFT LANES. THIS PROBLEM OCCURS AT ALL SPEEDS, EVEN HIGHWAY SPEEDS OF 70MPH. I WAS ALSO TOLD THAT THE LETTER WAS ONLY A "NOTIFICATION OF THE SITUATION AND HOW TO AVOID" AND NOT A RECALL. FURTHERMORE, FORD ADVISED THAT I TAKE THE VEHICLE IN TO A FORD DEALER AT MY COST TO ENSURE THAT THIS WAS THE CAUSE OF THE PROBLEM. THIS SITUATION IS SEVERE ENOUGH THAT IT COULD AND PERHAPS HAS BEEN THE CAUSE OF TRAFFIC ACCIDENTS. HOW LONG WILL THIS BE ALLOWED TO GO ON BEFORE A RECALL IS ISSUED? HAVING IDENTIFIED A VEHICLE STEERING PROBLEM, THAT IN MY OPINION COULD BE LIFE THREATENING, SHOULD BE SUFFICIENT CAUSE FOR A RECALL TO BE ISSUED. *TR
NHTSA ODI #10560235
112,000 miles · Nov 19, 2013
Engine
TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STARTED TO EMIT WHITE SMOKE. THE VEHICLE TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE TURBO BOOSTER AND FUEL INJECTORS WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHIC…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STARTED TO EMIT WHITE SMOKE. THE VEHICLE TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE TURBO BOOSTER AND FUEL INJECTORS WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 112,000 AND THE CURRENT MILEAGE WAS 124,000.
NHTSA ODI #10552880
Official recalls
1Jul 13, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Illustration