NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
64 reportsClear category filter2,716 miles · Nov 10, 2004
Engine And Engine CoolingCrash
INTERMITTENTLY WHILE DRIVING ENGINE SHUT OFF FOLLOWED BY THE METERS ON THE DASHBOARD READING ZERO. THEN, VEHICLE STALLED. THE CONSUMER PUT VEHICLE INTO NEUTRAL AND RESTARTED. WHEN THIS HAPPENED BEFORE LOST CONTROL OF VEHICLE. THE DEALERSHIP PERFORMED SEVERAL DIAGNOSTIC TESTS, AND REPLACED THE PCM GROUND/ENGINE GROUND,AND W…
Read full complaint
INTERMITTENTLY WHILE DRIVING ENGINE SHUT OFF FOLLOWED BY THE METERS ON THE DASHBOARD READING ZERO. THEN, VEHICLE STALLED. THE CONSUMER PUT VEHICLE INTO NEUTRAL AND RESTARTED. WHEN THIS HAPPENED BEFORE LOST CONTROL OF VEHICLE. THE DEALERSHIP PERFORMED SEVERAL DIAGNOSTIC TESTS, AND REPLACED THE PCM GROUND/ENGINE GROUND,AND WIRING GOING TO THE PCM. THE FAILURE STILL EXISTED. THE CONSUMER INVOKED THE LEMON LAW BECAUSE THE DEALERSHIP WAS UNABLE TO RECTIFY THE FAILURE. *AK *SC CONSUMER ADVISED THAT THE ENGINE STALLED AND RESULTED IN THE VEHICLE LEAVING THE ROADWAY. THE VEHICLE ENTERED THE FRONT YARD OF HOME AND DAMAGED THE LAWN. THERE WERE NO INJURIES OR DAMAGE TO THE VEHICLE. *DSY
NHTSA ODI #10090178
31,000 miles · Oct 19, 2004
Engine And Engine Cooling
WHEN PULLING OFF FROM AN INTERSECTION, THE VEHICLE STALLED. MOMENTS LATER, THE CONSUMER RESTARTED THE VEHICLE ALL POWER RESUMED AS NORMAL. OWNER HAS TAKEN THE VEHICLE BACK TO THE DEALER WHO WANTED TO KEEP THE VEHICLE FOR A COUPLE OF DAYS SO THEY MAY FIND OUT WHAT WAS CAUSING THE DEFECT. PROVIDE FURTHER DETAILS. *JB
NHTSA ODI #10097186
15,000 miles · Oct 17, 2004
Engine And Engine Cooling
ALL OF THE FOLLOWING IS DOCUMENTED ON FORDS COMPUTER SYSTEM THROUGH MAGNUSSENS IN NEWARK, CA. JUNE04, STARTED WITH A ROUGH IDLE PROBLEM TOOK MY 2004 F350 BACK TO DEALER. DID A REFLASH SEEM TO FIX FOR A WHILE. PROGRESSED TO ROUGH AND SEARCHING IDLE. APPROXIMATELY 9 TIMES BACK TO DEALER, EACH TIME EITHER CLEAR CHECK ENGINE LIGHT …
Read full complaint
ALL OF THE FOLLOWING IS DOCUMENTED ON FORDS COMPUTER SYSTEM THROUGH MAGNUSSENS IN NEWARK, CA. JUNE04, STARTED WITH A ROUGH IDLE PROBLEM TOOK MY 2004 F350 BACK TO DEALER. DID A REFLASH SEEM TO FIX FOR A WHILE. PROGRESSED TO ROUGH AND SEARCHING IDLE. APPROXIMATELY 9 TIMES BACK TO DEALER, EACH TIME EITHER CLEAR CHECK ENGINE LIGHT OR REPLACE PARTS, APPROXIMATELY 7 OR 8 DAYS OUT OF SERVICE FROM JUNE TILL LATE AUGUST, LAST TIME REPLACED THE ENTIRE TURBO ASSEMBLY. EACH TIME JUST REPLACED PARTS, NEVER DID THE DEALERSHIP OR FORD CORPORATE HAVE A DEFINITE ANSWER TO WHAT CAUSED THE PROBLEM. EACH TIME CODE P0299 WAS ON THE CHECK ENGINE. BETWEEN THE 2 AND 9TH INCIDENTS, THE VEHICLE STALLED UNEXPECTEDLY IN THE MIDDLE OF A DOWNHILL COASTING TURN ALMOST RESULTING IN A CRASH EACH TIME. TOTAL OF 5 TIMES, LAST OCCURRENCE OF STALL WAS FIRST TIME VEHICLE PRESENTED ANY PROBLEMS SINCE TURBO REPLACEMENT ON TWO THURSDAYS AGO ON MY WAY TO WORK. AFTER I GOT IN TO WORK I CALLED FORD SUPPORT AND MY DEALERSHIP AND STARTED A REPLACEMENT PROCESS THROUGH WHAT FORD CALLS THE DSB DISPUTE SETTLEMENT BOARD. I AM NOT COMFORTABLE DRIVING THIS PARTICULAR UNIT ANY MORE AND FEAR I MIGHT NOT BE ABLE TO STOP THE VEHICLE SAFELY ONE OF THESE TIMES IT STALLS AND MAY CAUSE INJURY TO MYSELF OR ANOTHER. I HAVE DONE A LOT OF RESEARCH REGARDING OTHERS WHO MIGHT HAVE HAD THIS PROBLEM AND IT LED ME HERE. *JB
NHTSA ODI #10095928
Mileage unknown · Oct 15, 2004
Engine And Engine CoolingVehicle Speed Control
WHILE DRIVING,THE VEHICLE STALL. THE DRIVER TRIED TO RESTART,BUT WAS ABLE TO DO SO. THE CONSUMER NOTICED THAT THE VEHICLE STARTED ACCELERATED SUDDENLY WITHOUT WARNING. THE DRIVER APPLIED THE BRAKES AND THE VEHICLE CONTINUE TO ACCELERATING WITH SPEED. THE DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND DROVE IT TO THE D…
Read full complaint
WHILE DRIVING,THE VEHICLE STALL. THE DRIVER TRIED TO RESTART,BUT WAS ABLE TO DO SO. THE CONSUMER NOTICED THAT THE VEHICLE STARTED ACCELERATED SUDDENLY WITHOUT WARNING. THE DRIVER APPLIED THE BRAKES AND THE VEHICLE CONTINUE TO ACCELERATING WITH SPEED. THE DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND DROVE IT TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THIS PROBLEM COULD NOT BE DUPLICATED. PLEASE FILL IN ADDITIONAL INFORMATION. *NM
NHTSA ODI #10096994
Mileage unknown · Oct 6, 2004
Engine And Engine Cooling
WHILE DRIVING VEHICLE STALLED. CONSUMER WAS UNABLE TO RESTART VEHICLE, AND HAD IT TOWED TO THE DEALER FOR INSPECTION. DEALER INFORMED CONSUMER THAT THE PROBLEM COULD NOT BE DUPLICATED. *AK
NHTSA ODI #10095298
10,000 miles · Sep 8, 2004
Engine And Engine Cooling
WHILE DRIVING VEHICLE STALLED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10091570
11,803 miles · Aug 31, 2004
Engine And Engine Cooling
ENGINE STALLS/STOPS RUNNING, LEADING TO A LOSS OF STEERING AND BRAKING. THIS HAS OCURRED THREE TIMES, TWICE AT LOW SPEED WHEN COMING TO A STOP, ONCE AT HIGH SPEED.*AK
NHTSA ODI #10088868
Mileage unknown · Jun 25, 2004
Engine And Engine Cooling
WHEN DECELERATING VEHICLE STALLED. DEALERSHIP SERVICED VEHICLE, AND TECHNICIAN COULD NOT DUPLICATE THE PROBLEM. *AK
NHTSA ODI #10079903
Mileage unknown · Jun 24, 2004
Engine And Engine Cooling
WHILE DRIVING, T HE VEHICLE STALLED SEVERAL TIMES. THE CONSUMER WOULD RESTART THE VEHICLE WHILE IN MOTION. THE BRAKES WOULD GO OUT WHEN THIS WOULD OCCUR. *AK THE PROBLEM SEEMED TO BE RESOLVED. THE DEALER REPLACED THE EGR VALVE (EXHAUST GAS-RECIRCULATION). THE VEHICLE IDLED ERRATICALLY. THE INJECTOR PRESSURE REGULATOR WAS …
Read full complaint
WHILE DRIVING, T HE VEHICLE STALLED SEVERAL TIMES. THE CONSUMER WOULD RESTART THE VEHICLE WHILE IN MOTION. THE BRAKES WOULD GO OUT WHEN THIS WOULD OCCUR. *AK THE PROBLEM SEEMED TO BE RESOLVED. THE DEALER REPLACED THE EGR VALVE (EXHAUST GAS-RECIRCULATION). THE VEHICLE IDLED ERRATICALLY. THE INJECTOR PRESSURE REGULATOR WAS REPLACED. THE EBP SENSOR AND THE EGR VALVE DID NOT WORK PROPERLY AND BOTH WERE REPLACED. THE EBP SIGNAL REMAINED TO FLUCTUATE. ALSO ,THE TURBO CHARGER WAS NOT WORKING PROPERLY. *SC *JB
NHTSA ODI #10073590
Mileage unknown · Jun 21, 2004
Engine And Engine Cooling
CONSUMER NOTICED THAT ENGINE STALLED AT ANY SPEED. DEALERSHIP SERVICED THE VEHICLE SEVERAL TIMES, BUT COULD NOT DUPLICATE THE PROBLEM. *AK
NHTSA ODI #10079559
Official recalls
2Jul 13, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
May 17, 2004
CERTAIN LARIAT AND KING RANCH MODEL PICKUP TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." SOME TRUCKS WERE INADVERTENTLY EQUIPPED WITH AN INCORRECT LOAD RANGE TIRE. THIS WOULD RESULT IN INCORRECT TIRE LOAD RATINGS FOR THE STATED VEHICLE AXLE GROSS AXLE WEIGHT RATING. ALSO, THE TIRE MAY BE INFLATED ABOVE THE DOT LISTED INFLATION PRESSURE.
Consequence & remedy
Consequence: IF A TIRE WAS OPERATED IN AN OVER-LOADED OR OVER-INFLATED CONDITION, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH CAN CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE ANY INCORRECT LOAD RANGE TIRES. ADDITIONALLY, IF ANY TIRE REQUIRED REPLACEMENT, IT IS RECOMMENDED THAT THE WHEEL LUG NUT TORQUE BE CHECKED WITHIN 500 MILES AFTER ANY TIRE REPLACEMENT. OWNER NOTIFICATION BEGAN ON MAY 21, 2004. OWNERS SHOULD CONTACT. FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP05005 · Spark Plug Ejection From Cylinder Head
Opened Sep 22, 2005 · Closed Jan 4, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
PE04070 · Engine Stalling
Opened Oct 7, 2004 · Closed Feb 15, 2005
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:diesel
TWENTY FIVE OF THE ODI FAILURE REPORTS ARE DUPLICATIVE OF FORD COMPLAINTS.TWENTY ODI REPORTS DO NOT CONTAIN A VIN (AND MAY OR MAY NOT BE DUPLICATIVE OF FORD REPORTS).THE 14 ALLEGED CRASHES AND 2 ALLEGED INJURIES WERE ALL MINOR.SUBMITTED DURING PRELIMINARY EVALUATION (PE) 04-070, FORD'S RESPONSE TO ODI'S INFORMATION REQUEST (IR) LETTER CONTAINED ABOUT 5,000 CONSUMER REPORTS (MORS) AND 8,700 FIELD REPORTS (CQIS).FORD REVIEWED THE COMPLAINTS AND CATEGORIZED THEM.THE MANUFACTURER REPORTS SHOWN ABOVE REPRESENT A COUNT OF UNIQUE VEHICLES THAT FORD CATEGORIZED AS ALLEGEDLY STALLING DUE TO A SUBJECT ENGINE COMPONENT ('A' CATEGORY, SEE FORD'S IR RESPONSE LETTER FOR FURTHER DETAIL); SOME OF THESE VEHICLES RECEIVED MULTIPLE REPORTS.ODI HAS NOT YET CONFIRMED FORD'S CATEGORIZATION OF THESE REPORTS, NOR HAS ODI CONFIRMED FORD'S CATEGORIZATION OF THE REMAINING REPORTS (WHICH FORD STATES DO NOT PERTAIN TO THE ALLEGED DEFECT).FORD SUBMITTED NEARLY 19,000 WARRANTY CLAIMS, MANY OF WHICH INVOLVED CLAIMS FOR A TECHNICAL SERVICE BULLETIN (TSB 04-13-08) AND FIELD SERVICE ACTION (FSA 03B05) WHICH FORD IDENTIFIED AS POTENTIAL REMEDIES FOR STALLING COMPLAINTS.ODI HAS NOT CONFIRMED THAT EITHER OF THESE ARE A REMEDY FOR ENGINE STALLING COMPLAINTS.SEVERAL OTHER DEALER COMMUNICATIONS RELATED TO ENGINE STALL WERE ALSO SUBMITTED AS WELL AS OVER 50 PRODUCT MODIFICATIONS, 15 OF WHICH INVOLVE REVISIONS TO THE SOFTWARE FOR THE ELECTRONIC ENGINE CONTROL UNIT.FURTHER INVESTIGATION IS REQUIRED AND ODI IS UPGRADING PE04-070 TO AN ENGINEERING ANALYSIS (EA).DURING THE EA, ODI WILL ESTABLISH AND UPDATE MANUFACTURER FAILURE REPORT COUNTS, FURTHER INVESTIGATE THE FREQUENCY AND TREND OF STALLING COMPLAINTS, AND DETERMINE THE SCOPE AND SAFETY IMPLICATION OF STALLING EVENTS.ODI WILL ALSO INVESTIGATE FORD'S REMEDIES, THEIR EFFECTIVENESS, AND WHETHER FURTHER ACTION IS REQUIRED.
Illustration