NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
110 reports100,100 miles · May 19, 2025
Power Train
The contact owns a 2022 Ford F-350 SD. The contact stated while driving 45 MPH, the vehicle was shuddering abnormally while shifting from second through fourth gear. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed and determined that the transmission needed to be replace…
Read full complaint
The contact owns a 2022 Ford F-350 SD. The contact stated while driving 45 MPH, the vehicle was shuddering abnormally while shifting from second through fourth gear. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and a claim was filed. The failure mileage was approximately 100,100.
NHTSA ODI #11661875
Mileage unknown · May 3, 2025
Back Over PreventionForward Collision Avoidance
I was driving on [XXX] in St Louis County Missouri during rush hours traffic. I experienced a blow out on my drivers front tire. I was surrounded by lots of heavy traffic from passenger cars to tractor trailer going more than 60 mph. I slowly got to the right shoulder. Modot and the state highway patrol blocked the traffic aw…
Read full complaint
I was driving on [XXX] in St Louis County Missouri during rush hours traffic. I experienced a blow out on my drivers front tire. I was surrounded by lots of heavy traffic from passenger cars to tractor trailer going more than 60 mph. I slowly got to the right shoulder. Modot and the state highway patrol blocked the traffic away from us while AAA changed my tire. After I was ready to leave I noticed my traffic early collision warning, and other safety warning systems were not working now. I also noticed my rear view camera was not operating either. This was the first time I noticed any issue with my safety systems. I got. Ew tires and changed them all 6 out. Still my rear view camera is not operating. I did notice Ford was getting ready to put in a recall for rear view camera for F350’s from 2015 to 2025. I do have a 2022 so I feel I am in the recall. Please let me know if I should go to my dealer for repairs under the recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11658714
Mileage unknown · Apr 25, 2025
Vehicle Speed Control
While driving with the cruise set I wanted to reduce speed and hit the minus speed button on the cruise control which caused the vehicle to speed up which made me hit it quickly a couple more times to slow it down and it responded by speeding up more and led me to slam on the brakes. Luckily no one was in front of me so I didn’t…
Read full complaint
While driving with the cruise set I wanted to reduce speed and hit the minus speed button on the cruise control which caused the vehicle to speed up which made me hit it quickly a couple more times to slow it down and it responded by speeding up more and led me to slam on the brakes. Luckily no one was in front of me so I didn’t rear end them when it sped up and no one was behind me that could have rear ended me when I slammed on the brakes.
NHTSA ODI #11656890
90,000 miles · Apr 14, 2025
Fuel System, Diesel
The contact owns a 2022 Ford F-350 SD. The contact stated while driving 15 MPH, the vehicle lost motive power and vehicle stalled. The contact stated there was an abnormal sound coming from the engine. An unknown message was displayed on the instrument panel. The vehicle failed to restart and was pulled into a gas station by ano…
Read full complaint
The contact owns a 2022 Ford F-350 SD. The contact stated while driving 15 MPH, the vehicle lost motive power and vehicle stalled. The contact stated there was an abnormal sound coming from the engine. An unknown message was displayed on the instrument panel. The vehicle failed to restart and was pulled into a gas station by another driver. The vehicle was then towed to the residence. A mobile mechanic diagnosed that the CP4 pump had failed. The contact was informed that the CP4 pump needed to be replaced. The vehicle had not been repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.
NHTSA ODI #11654457
Mileage unknown · Apr 11, 2025
Fuel System, Diesel
The contact owns a 2022 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. T…
Read full complaint
The contact owns a 2022 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA ODI #11654055
Mileage unknown · Apr 6, 2025
Electrical System
Minor issue started during heavy rain last week, went out in morning and power steps would not function. After starting, the rear sliding window opened and would not shut. Researched solution and reset the steps in the computer. Let truck sit for 5 hours at work (not raining) and apparently circuit dried out and window was able …
Read full complaint
Minor issue started during heavy rain last week, went out in morning and power steps would not function. After starting, the rear sliding window opened and would not shut. Researched solution and reset the steps in the computer. Let truck sit for 5 hours at work (not raining) and apparently circuit dried out and window was able to close. Fast forward to Thursday night (4/1), flood rains had started. On the way home from work, the rear sliding window started opening again by itself, but was able to close it with the switch. It did this several times. Went out to start the truck Friday evening and all i got was flickering lights that dimmed when the start button was pushed. No controls worked. By Saturrday morning, there was no lights or any control. all electronics are non-functional. I checked and the batteries are fully charged, so it is not a battery/alternator problem - I expect water has infiltrated into the electronics/computer. Luckily, this short out did not happen on the whole system while I was driving.
NHTSA ODI #11653065
62,000 miles · Feb 14, 2025
Power Train
The contact owns a 2022 Ford F-350. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the transmission before the vehicle jerked while shifting from park(P) to drive(D). No warning lights were illuminated. The contact stated that while attempting to accelerate, the transmissio…
Read full complaint
The contact owns a 2022 Ford F-350. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the transmission before the vehicle jerked while shifting from park(P) to drive(D). No warning lights were illuminated. The contact stated that while attempting to accelerate, the transmission hesitated to shift briefly before accelerating and then functioned normally. The failure became regular. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The vehicle was repaired, but the failure reoccurred 3 times. The vehicle was taken to the dealer and remained at the dealer unrepaired. The manufacturer was notified of the failure, and contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 62,000.
NHTSA ODI #11642726
Mileage unknown · Feb 8, 2025
Fuel/propulsion System
After the truck had been sitting in the driveway for a couple days I noticed a wet spot underneath the truck, I looked under the truck and noticed there was diesel on the fuel line and the top of the fuel tank was wet with diesel fuel.
NHTSA ODI #11641545
Mileage unknown · Jan 31, 2025
Steering
violent shaking , wobbling of the steering wheel
NHTSA ODI #11639881
60,000 miles · Jan 27, 2025
Electrical System
The contact owns a 2022 Ford F-350 SD. The contact stated that there was a sulfur odor coming from the front end of the vehicle. After inspecting the vehicle, the contact noticed white smoke coming from the batteries. There were no warning lights illuminated. The contact replaced both batteries. The dealer was informed of the fa…
Read full complaint
The contact owns a 2022 Ford F-350 SD. The contact stated that there was a sulfur odor coming from the front end of the vehicle. After inspecting the vehicle, the contact noticed white smoke coming from the batteries. There were no warning lights illuminated. The contact replaced both batteries. The dealer was informed of the failures and confirmed that the batteries were not covered under warranty. The vehicle had not been taken to the dealer. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 60,000.
NHTSA ODI #11638731
Official recalls
17Mar 31, 2026
Ford Motor Company (Ford) is recalling certain 2021-2023 Lincoln Navigator, Expedition, and 2022-2023 F-250 SD, F-350 SD, F-450 SD, F-550 SD, and F-600 SD vehicles. The windshield wiper arms may break, causing the wipers to fail.
Consequence & remedy
Consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the wiper arms, as necessary, free of charge. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S24.Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 1, 2026.
Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, 2021-2022 F600, and 2022 F750 vehicles previously repaired incorrectly under recall number 24V957. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed mailed April 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S17. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 18, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Additional source detail variants (2)
Exterior Lighting:tail Lights
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Electrical System: Integrated Trailer Brake Control
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Oct 24, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.
Consequence & remedy
Consequence: A detached wind deflector can become a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 30, 2025.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The 360-degree view camera system may not display a rearview image properly in certain lighting conditions.
Consequence & remedy
Consequence: A rearview camera image that does not display properly can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the image processing module software, free of charge.This will be a phased campaign, with the remedy becoming available in different phases based on model years. Interim letters notifying owners of the safety risk were mailed on October 30, 2025. Additional letters will be mailed once the remedy is available on each phase. Owner notification letters were mailed May 19, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA8. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 13, 2025.
Jul 7, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
Feb 28, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality can extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.
Jan 31, 2025
Ford Motor Company (Ford) is recalling certain 2021 Expedition, 2021-2022 Super Duty F-250, F-350, F-450, F-550, F-600, and 2020-2022 Lincoln Corsair vehicles. The rearview camera may display a blank or distorted image.
Consequence & remedy
Consequence: Rearview camera failure can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera as necessary, free of charge. Owner notification letters were mailed September 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S05.
Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, F600, and 2021-2022 F-650, F750 vehicles. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) and Transmission Control Module (TCM) software, free of charge. Owner notification letters were mailed January 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S78.
Nov 9, 2023
Ford Motor Company is recalling certain 2022-2023 Ford Super Duty F-350, F-450, F-550, and F-600 vehicles. The fasteners for the front wheel hub extender may be insufficiently tightened, which can result in the wheel and wheel extender detaching from the vehicle.
Consequence & remedy
Consequence: Wheel detachment can result in a loss of vehicle control and create a road hazard, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicle until the repair has been performed. Dealers will inspect the front wheel hub extender retaining nuts. If the retaining nuts are loose, dealers will replace the wheel hub extender, retaining nuts, and hub assembly. Repairs will be performed free of charge. Owner notification letters were mailed December 7, 2023. Owners may contact Ford customer service at -866-436-7332. Ford's number for this recall is 23S59.
Additional source detail variants (2)
Wheels:lugs/nuts/bolts/studs
Ford Motor Company is recalling certain 2022-2023 Ford Super Duty F-350, F-450, F-550, and F-600 vehicles. The fasteners for the front wheel hub extender may be insufficiently tightened, which can result in the wheel and wheel extender detaching from the vehicle.
Consequence: Wheel detachment can result in a loss of vehicle control and create a road hazard, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicle until the repair has been performed. Dealers will inspect the front wheel hub extender retaining nuts. If the retaining nuts are loose, dealers will replace the wheel hub extender, retaining nuts, and hub assembly. Repairs will be performed free of charge. Owner notification letters were mailed December 7, 2023. Owners may contact Ford customer service at -866-436-7332. Ford's number for this recall is 23S59.
Power Train:axle Hubs
Ford Motor Company is recalling certain 2022-2023 Ford Super Duty F-350, F-450, F-550, and F-600 vehicles. The fasteners for the front wheel hub extender may be insufficiently tightened, which can result in the wheel and wheel extender detaching from the vehicle.
Consequence: Wheel detachment can result in a loss of vehicle control and create a road hazard, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicle until the repair has been performed. Dealers will inspect the front wheel hub extender retaining nuts. If the retaining nuts are loose, dealers will replace the wheel hub extender, retaining nuts, and hub assembly. Repairs will be performed free of charge. Owner notification letters were mailed December 7, 2023. Owners may contact Ford customer service at -866-436-7332. Ford's number for this recall is 23S59.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
May 27, 2022
Ford Motor Company (Ford) is recalling certain 2022 F-Super Duty F-250, F-350, F-450, F-550, F600, and 2023 E-Series vehicles. In addition, certain 2016 E-Series, 2017 and 2019 F-450, 2021 F-350, and 2021 Transit vehicles that received a reprinted label are also included in this recall. The Safety Certification Labels are missing the tire size, rim type, and tire pressure values for both the front and rear axles. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 110, "Tire Selection and Rim", and 120, "Wheels and Rims-Other Than Passenger Cars."
Consequence & remedy
Consequence: Missing tire information could lead to an incorrect tire or rim being installed, or incorrect tire pressure, increasing the risk of a crash.
Remedy: Dealers will replace the Safety Certification Label, free of charge. Owner notification letters were mailed July 6, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C09.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Mar 25, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality could result in extended stopping distance, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S17.
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Nov 24, 2021
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250 and F-350 vehicles. The strength of the driver-side air bag cover may be insufficient.
Consequence & remedy
Consequence: During a crash, the air bag cover may break apart and project fragments towards occupants, increasing the risk of injury.
Remedy: Dealers will replace the driver-side air bag module, free of charge. Owner notification letters were mailed December 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S49.
Oct 15, 2021
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence & remedy
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Additional source detail variants (2)
Air Bags:sensor:side Impact
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Air Bags:side/window
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration