NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
188 reportsMileage unknown · Mar 28, 2025
Fuel/propulsion SystemFireInjury
We were leaving Kerrville Tx around [XXX] on our way to Colorado for a fishing trip. We got to Colorado City Tx 3:45pm to refuel and grab a late lunch, we left at 4:30pm. We went through Snyder and Post Tx and approximately 5:45pm 1.2 miles southeast of Southland Tx, I had a warning come up on the dash saying Low Fuel Pressure a…
Read full complaint
We were leaving Kerrville Tx around [XXX] on our way to Colorado for a fishing trip. We got to Colorado City Tx 3:45pm to refuel and grab a late lunch, we left at 4:30pm. We went through Snyder and Post Tx and approximately 5:45pm 1.2 miles southeast of Southland Tx, I had a warning come up on the dash saying Low Fuel Pressure and Reduced Engine Power and had smoke coming in then I pulled over asap and upon opening my door flames hit my leg and even more smoke began to fill the cab rapidly. We were fighting for our life’s. You could see fuel dripping/ flowing driver side under hood, location secondary fuel filter you can even see a trail on the pavement. I knew I had to move quickly and grabbed my 2 fire extinguishers and put to use and after I started throwing all combustibles and as many tools used on the ranch away from the vehicle. 6 Great Samaritans helped with 7 fire extinguisher as we made time to be able to separate truck and trailer by pulling the trailer from the back. But with 8-9 fire extinguishers did not put it out which is a serious problem, I now unfortunately know the taste of fire extinguishers and vehicle smoke. I got all combustibles and the trailer separated and I knew the truck was gone and I needed to get away, It seemed something was fueling it! It all happened so quickly. [XXX] and [XXX] was closed. The first firetruck with water showed up at 6:07pm and the cab of the truck had completely melted away. A Great Samaritan offered to haul the saved trailer to an rv park. I Thanked the Great Samaritans, Firefighters and Sheriff for the help with the unbelievable shocking event that had just happened. 7:05 we were in route to the rv park as the Sheriff cleared me to go. Now I have been dealing with smoke inhalation. I have never seen such an intense fire and it had me fight or flight mode. Truck had been maintained to the up most. This was a very traumatic event and has affected my breathing, sleep, PTSD and my confidence to drive INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT
NHTSA ODI #11651363
125,924 miles · Mar 26, 2025
Steering
The contact owns a 2020 Ford F-350. The contact stated while driving 5 MPH, the steering wheel became inoperable. The contact stated that the steering wheel was turning in a circular motion. There were no warning lights illuminated. The contact was able to stop the vehicle. There were no warning lights illuminated. The vehicle w…
Read full complaint
The contact owns a 2020 Ford F-350. The contact stated while driving 5 MPH, the steering wheel became inoperable. The contact stated that the steering wheel was turning in a circular motion. There were no warning lights illuminated. The contact was able to stop the vehicle. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the steering drive line drive shaft U-joint needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 125,924.
NHTSA ODI #11650818
Mileage unknown · Mar 24, 2025
Fuel System, Diesel
The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was unavailable. The dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable am…
Read full complaint
The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was unavailable. The dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA ODI #11650150
336,000 miles · Feb 24, 2025
Fuel System, Diesel
The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The contact stated while driving at various speeds, the vehicle occasionally experienced a loss of automotive power. The check engine wa…
Read full complaint
The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The contact stated while driving at various speeds, the vehicle occasionally experienced a loss of automotive power. The check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed with a fuel pump and fuel hose failure. The contact was informed that the fuel pump and fuel hose needed to be replaced. The vehicle was left at the local dealer pending the repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 336,000. VIN tool confirms parts not available.
NHTSA ODI #11644594
120,000 miles · Feb 21, 2025
EngineFuel System, Diesel
The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the check eng…
Read full complaint
The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the check engine warning light was illuminated, and the low fuel pressure message was displayed on the instrument panel. The contact stated that while driving at various speeds and attempting to accelerate, there was a lag in motive power. The vehicle was taken to the dealer who diagnosed the vehicle and determined that the fuel filters had failed. The fuel filters were replaced. The manufacturer was not made aware of the issue. The failure mileage was 120,000. VIN tool confirms parts not available.
NHTSA ODI #11644171
22,000 miles · Jan 31, 2025
Latches/locks/linkages
The contact owns a 2020 Ford F-350. The contact stated that while hauling a trailer, the tailgate lowered unexpectedly. Additionally, during the summer, the door latch system failed to open from outside while the doors were unlocked. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it wa…
Read full complaint
The contact owns a 2020 Ford F-350. The contact stated that while hauling a trailer, the tailgate lowered unexpectedly. Additionally, during the summer, the door latch system failed to open from outside while the doors were unlocked. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the latching spring and the latching system needed to be repaired. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 22,000.
NHTSA ODI #11639923
Mileage unknown · Jan 31, 2025
Electrical SystemForward Collision AvoidanceUnknown Or Other
Computer-dash info screens and drive modes. I am unable to change or check onboard dash info upon starting vehicle. Dash does not hold settings one day to the next. Unable to get into or change settings such as trailer settings-so can’t change braking effort-dangerous when hauling 20,000# trailer! Cannot put truck in tow mode o…
Read full complaint
Computer-dash info screens and drive modes. I am unable to change or check onboard dash info upon starting vehicle. Dash does not hold settings one day to the next. Unable to get into or change settings such as trailer settings-so can’t change braking effort-dangerous when hauling 20,000# trailer! Cannot put truck in tow mode or any other mode-defaults to slippery road mode. Again dangerous. Says hill start assist, hill descent assist and pre-collision assist is unavailable . This is all very potentially dangerous especially when hauling! Dealer cannot find problem. After truck is driven a while settings can be re-entered-truck has to be turned off first. Unable to load video of start up.
NHTSA ODI #11639899
Mileage unknown · Jan 22, 2025
Power Train
CDF cylinder failure in transmission leading to multiple hard shifts that could cause loss of traction and slick roads.
NHTSA ODI #11637767
112,000 miles · Jan 22, 2025
Fuel System, Diesel
The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957 (Fuel System, Diesel); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while one of his…
Read full complaint
The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957 (Fuel System, Diesel); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while one of his employees was driving approximately 45 MPH, the vehicle lost motive power. The contact stated that a person in a residential area assisted with pushing the vehicle to the side of the road. The check engine warning light was illuminated. The vehicle failed to restart and was towed to an independent mechanic who was diagnosed with fuel pump failure. The contact was informed that the fuel pump needed to be replaced. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The vehicle remained with the independent mechanic and had not been driven since. The failure mileage was approximately 112,000. VIN tool confirms parts not available.
NHTSA ODI #11637634
Mileage unknown · Jan 21, 2025
Fuel/propulsion System
Cp4 catastrophic failure which is a known and common problem it caused my truck to die while on the highway almost causing a crash
NHTSA ODI #11637387
Official recalls
15Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, 2021-2022 F600, and 2022 F750 vehicles previously repaired incorrectly under recall number 24V957. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed mailed April 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S17. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 18, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The 360-degree view camera system may not display a rearview image properly in certain lighting conditions.
Consequence & remedy
Consequence: A rearview camera image that does not display properly can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the image processing module software, free of charge.This will be a phased campaign, with the remedy becoming available in different phases based on model years. Interim letters notifying owners of the safety risk were mailed on October 30, 2025. Additional letters will be mailed once the remedy is available on each phase. Owner notification letters were mailed May 19, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA8. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 13, 2025.
Sep 19, 2025
Ford Motor Company (Ford) is recalling certain 2020-2021 F-250, F-350, and F-450 vehicles. The steering column upper shaft may detach from the steering column and result in a loss of steering control.
Consequence & remedy
Consequence: A loss of steering control increases the risk of a crash.
Remedy: Dealers will inspect the steering column, and repair or replace the upper shaft as necessary, free of charge. Owner notification letters were mailed February 20, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S94. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 23, 2025.
Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, F600, and 2021-2022 F-650, F750 vehicles. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) and Transmission Control Module (TCM) software, free of charge. Owner notification letters were mailed January 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S78.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
Aug 26, 2022
Ford Motor Company (Ford) is recalling certain 2017-2020 F-Super Duty F-250, F-350, F-450, and 2017-2020 Lincoln Continental vehicles equipped with the 360-degree camera system. Degradation of the camera's anit-reflective lens coating can lead to a foggy or cloudy rearview camera image.
Consequence & remedy
Consequence: Lack of a clear rearview camera image can reduce the driver's visibility of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Ford customer service at 1-800-1-866-436-7332. Ford's number for this recall is 22S51.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020 Super Duty F-250, F-350, F-450, and F-550 vehicles equipped with 6.7L diesel engines. A washer within the vehicle's transmission can disintegrate, causing metallic debris to become lodged in the 'Park' mechanism.
Consequence & remedy
Consequence: Debris lodged within the 'Park' mechanism may prevent the vehicle from achieving or holding 'Park,' increasing the risk of a vehicle rollaway and a crash.
Remedy: Dealers will replace a gearset within the transmission, free of charge. Owner notification letters were mailed on April 19, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S22.
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Jul 15, 2021
Ford Motor Company (Ford) is recalling certain 2020-2021 F-350 Super Duty pickup trucks equipped with 6.7L diesel engines and Dana model 275 rear axles. The rear axle housing may not support the load of the pickup truck and deform, which could result in driveshaft separation.
Consequence & remedy
Consequence: Driveshaft separation may result in a loss of drive power, or unintended vehicle movement if the vehicle is in park without the parking brake applied, increasing the risk of a crash.
Remedy: Dealers will inspect the axle housing for deformities, and repair or replace the housing, as necessary, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall 21S31.
Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 27, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S10.
Feb 18, 2021
Ford Motor Company (Ford) is recalling certain 2020 F-Super Duty F350 vehicles equipped with a 6.7L diesel engine, single rear wheels (SRW), 4X4 Crew Cab, Long Box, and a 12k or 12.4k Gross Vehicle Weight Rating. These vehicles may display overstated payload capacity values on the Tire and Loading Information (TREAD) Label, overstated Accessory Reserve Capacity (ARC) values on the Safety Certification Label, and overstated weight values on the Truck Camper Loading Documentation. If the vehicle is loaded to the payload stated on the TREAD label, it may exceed the Gross Vehicle Weight Rating (GVWR) or Gross Axle Weight Rating (GAWR) and overload the vehicle.
Consequence & remedy
Consequence: An overloaded vehicle can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the Tire and Loading Information Label, Safety Certification Label, and the Truck Camper Loading Document (if applicable), free of charge. The recall began March 23, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S06.
Feb 18, 2021
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence & remedy
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Additional source detail variants (2)
Visibility:windshield:critical Fasteners
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Visibility:windshield
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Jun 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Super-Duty F-250, F-350, and F-550 diesel pickups. The transmission torque converter damper plate was not tempered, resulting in a brittle damper plate that may fracture and cause the engine to stall or require increased brake pedal effort in order to stop the vehicle.
Consequence & remedy
Consequence: An engine stall or requiring additional braking effort to stop the vehicle can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the transmission assembly, free of charge. This recall began July 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S33.
Additional source detail variants (2)
Power Train:automatic Transmission:torque Converter
Ford Motor Company (Ford) is recalling certain 2020 Super-Duty F-250, F-350, and F-550 diesel pickups. The transmission torque converter damper plate was not tempered, resulting in a brittle damper plate that may fracture and cause the engine to stall or require increased brake pedal effort in order to stop the vehicle.
Consequence: An engine stall or requiring additional braking effort to stop the vehicle can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the transmission assembly, free of charge. This recall began July 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S33.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2020 Super-Duty F-250, F-350, and F-550 diesel pickups. The transmission torque converter damper plate was not tempered, resulting in a brittle damper plate that may fracture and cause the engine to stall or require increased brake pedal effort in order to stop the vehicle.
Consequence: An engine stall or requiring additional braking effort to stop the vehicle can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the transmission assembly, free of charge. This recall began July 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S33.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE24014 · Sogefi Secondary Diesel Fuel Filter Leak
Opened May 9, 2024 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.
RQ21001 · Power Tailgate Release Systems
Opened Jan 15, 2021 · Closed Jan 10, 2024
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Structure:body:door
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration