NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
53 reportsClear category filter10 miles · Sep 7, 2022
Power Train
The contact owns a 2020 Ford F-350, The contact stated that after the vehicle had been turned off for an extended period, after restarting the vehicle, the vehicle would not immediately drive forward or in reverse; however, the vehicle would roll if on an inclined surface. The vehicle was taken to the dealer who diagnosed that t…
Read full complaint
The contact owns a 2020 Ford F-350, The contact stated that after the vehicle had been turned off for an extended period, after restarting the vehicle, the vehicle would not immediately drive forward or in reverse; however, the vehicle would roll if on an inclined surface. The vehicle was taken to the dealer who diagnosed that the condition was caused by transmission fluid draining back from the torque converter. The contact was informed that manufacturer was aware of the condition and had advised that no service be performed to resolve the issue; but owners should be advised in order to prevent the condition from occurring, to allow the engine to run for a while before attempting to drive. The manufacturer was contacted and advised the contact that no service would be performed to correct the condition. The contact was concerned that in an emergency situation the vehicle could not immediately be moved or the roll away condition would create a safety hazard. The failure mileage was 10.
NHTSA ODI #11483310
130,000 miles · Jul 8, 2022
Power Train
The contact owns a 2020 Ford F-350. The contact stated while driving 30 MPH, the accelerator pedal was depressed; however, the vehicle failed to exceed 30 MPH. There was no warning light illuminated. The contact was able to continue driving. The vehicle was taken to the dealer where it was diagnosed and determined that the trans…
Read full complaint
The contact owns a 2020 Ford F-350. The contact stated while driving 30 MPH, the accelerator pedal was depressed; however, the vehicle failed to exceed 30 MPH. There was no warning light illuminated. The contact was able to continue driving. The vehicle was taken to the dealer where it was diagnosed and determined that the transmission needed to be replaced. The manufacturer was notified of the failure and a case was opened. The manufacturer then followed up with the dealer and was informed that the failure was not associated with NHTSA Campaign Number: 22V256000 (Power Train) even though the VIN was included. The manufacturer closed the case and referred the contact to the NHTSA. The dealer informed the contact that she would be responsible for the cost of the repair. The vehicle was not repaired. The failure mileage was approximately 130,000.
NHTSA ODI #11472901
Mileage unknown · Mar 23, 2022
Power Train
Brand new 2020 F350 started having issues around 62,000 miles....we have reported these issues to Ford in Harriman and Ford in Lenoir (They do not have a transmission specialist available in Lenoir and Ford in Harriman states they don't honor my extended warranty that we purchased through Ford). In January we started having issu…
Read full complaint
Brand new 2020 F350 started having issues around 62,000 miles....we have reported these issues to Ford in Harriman and Ford in Lenoir (They do not have a transmission specialist available in Lenoir and Ford in Harriman states they don't honor my extended warranty that we purchased through Ford). In January we started having issues when we were traveling on the interstate heading towards Chattanooga. Which is only about 45 minutes to an hour away. The wrench light came on and the truck started to shift hard and at a high RPM , getting stuck in 7th gear not wanting to shift between 3rd and 4th gear. The truck started to go into limp mode and we managed to get it home and bring it to Ford in Harriman (Jerry Duncan Ford). They stated the TCM needed to be reset, and proceeded with that costing $165. Three weeks later, my truck lost all gears including park and makes a really loud grinding/screeching noise when you try to shift to anything but neutral. The truck was presenting the same issues as the first time, we got it towed to Jerry Duncan and informed them of a recall on the 2020 F350 made between the dates of February 2019- August 2020 and April 2019 - July 2020 manufactured at the Kentucky plant during these dates. My truck (same year make and model as recall ) was manufactured from the Kentucky Plant in November of 2019, showing the same issues and symptoms of the recall. Putting my truck dead smack in the recall time frame, again showing the same issues and symptoms stated in the recall. Preliminary DX from Jerry Duncan was that the Transfer case Mechanism has failed, ignoring the recalls on the truck (there is also 1 regarding back up camera and 1 regarding tow capacity that has never been addressed properly) $80k truck has been sitting in the shop for two weeks and won't be looked at for another week and half, and only has 72,000 miles on it, purchased a year ago. There is not urgency in this matter and I feel we are being booted to the back of the line.
NHTSA ODI #11457943
163,000 miles · Dec 30, 2021
Power Train
The contact owns a 2020 Ford F-350. The contact stated that while attempting to reverse the vehicle, the engine revved but the vehicle would not move. The power train malfunction warning light illuminated. The vehicle was taken to the dealer and diagnosed with number one planetary and ring gear assembly failure. The number one p…
Read full complaint
The contact owns a 2020 Ford F-350. The contact stated that while attempting to reverse the vehicle, the engine revved but the vehicle would not move. The power train malfunction warning light illuminated. The vehicle was taken to the dealer and diagnosed with number one planetary and ring gear assembly failure. The number one planetary and ring gear assembly needed to be replaced. The vehicle was not repaired. Upon investigation, the contact related the failure to Customer Satisfaction Program: 21B03 (Number One Planetary and Ring Gear Assembly) however, the dealer informed the contact that the VIN was not included in the program. The manufacturer was made aware of the failure and referred the contact to file a complaint with NHTSA. The failure mileage was approximately 163,000.
NHTSA ODI #11445654
Mileage unknown · Dec 8, 2021
Power Train
The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 21V536000 (Power Train). The contact took the vehicle to local dealer but was not able to complete the recall due to not having and employee to weld the axle. The contact was not content with welding the axle. The manufacturer was mad…
Read full complaint
The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 21V536000 (Power Train). The contact took the vehicle to local dealer but was not able to complete the recall due to not having and employee to weld the axle. The contact was not content with welding the axle. The manufacturer was made aware of the issue. The contact had not experienced a failure.
NHTSA ODI #11443120
5,000 miles · Oct 4, 2021
Power Train
The contact owns a 2020 Ford F-350. The contact stated that the vehicle was hard to shift. The vehicle lunged forward about a foot. While driving, the vehicle skipped 4th, 5th, and 7th gear. The vehicle shutdown and went into limp mode. The power train message was displayed. The vehicle was taken to the local dealer and diagnose…
Read full complaint
The contact owns a 2020 Ford F-350. The contact stated that the vehicle was hard to shift. The vehicle lunged forward about a foot. While driving, the vehicle skipped 4th, 5th, and 7th gear. The vehicle shutdown and went into limp mode. The power train message was displayed. The vehicle was taken to the local dealer and diagnosed with the PCM needing to be reprogrammed. The vehicle was repaired however, the failure recurred. The vehicle was taken to another local dealer - Cole Ford LLC (410 E Chicago St, Coldwater, MI 49036, (517) 278-5661) and diagnosed that the vehicle was working as designed. The manufacturer was notified however, no further assistance was provided. The approximate failure mileage was 5,000.
NHTSA ODI #11435344
152,000 miles · Aug 23, 2021
Power Train
The contact owns a 2020 Ford F-350. The contact stated while driving at various speeds, the transmission experienced rough shifting and the maintenance warning light was displayed. The transmission later became stuck in 7th and 3rd gears and the vehicle went into limp mode reducing the speed to 35 mph. The vehicle was driven to …
Read full complaint
The contact owns a 2020 Ford F-350. The contact stated while driving at various speeds, the transmission experienced rough shifting and the maintenance warning light was displayed. The transmission later became stuck in 7th and 3rd gears and the vehicle went into limp mode reducing the speed to 35 mph. The vehicle was driven to the local dealer, but the cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 152,000.
NHTSA ODI #11430150
1,031 miles · Mar 8, 2021
Power TrainSuspensionUnknown Or Other
I PURCHASED THIS TRUCK ON 09/23/20. AT DELIVERY THE STEERING WHEEL WAS NOT ALIGNED CORRECTLY AND HAD TO BE ADJUSTED. TRUCK HAS HAD A CONSTANT VIBRATION THAT IS FELT THRU THE STEERING AND BODY. THE VIBRATION INCREASES WITH SPEED. AT 1031 MILES A REPAIR ATTEMPT WAS MADE THAT WAS UNSUCCESSFUL, AT 3225 MILES AGAIN A FAILED ATTEM…
Read full complaint
I PURCHASED THIS TRUCK ON 09/23/20. AT DELIVERY THE STEERING WHEEL WAS NOT ALIGNED CORRECTLY AND HAD TO BE ADJUSTED. TRUCK HAS HAD A CONSTANT VIBRATION THAT IS FELT THRU THE STEERING AND BODY. THE VIBRATION INCREASES WITH SPEED. AT 1031 MILES A REPAIR ATTEMPT WAS MADE THAT WAS UNSUCCESSFUL, AT 3225 MILES AGAIN A FAILED ATTEMPT WAS MADE AT CORRECTING, AT 3735 ANOTHER FILED ATTEMPT. AT 8156 ANOTHER FAILED ATTEMPT. AND AGAIN AT 8934 ANOTHER MORE EXTENSIVE REPAIR ATTEMPT WAS MADE WITH NO POSITIVE RESULTS. I WILL UPLOAD ALL REPAIR WORK ORDERS. THERE IS A SERIOUS PROBLEM IN THE DRIVETRAIN OF THE VEHICLE THAT FORD AS OF YET HAS BEEN UNABLE TO CORRECT. THE VIBRATION IS CONSTANT AND AT HIGHWAY SPEED HAS MADE PEOPLE CAR SICK. I AM FEARFUL THAT THERE IS A FAILING COMPONENT IN THE TRUCK THAT WHEN IT FINALLY BREAKS WILL CAUSE A SERIOUS ACCIDENT. THEY HAVE USED A VCMM VIBRATION ANALIZER THAT LISTED A HOST OF POTENTIAL PROBLEMS AND IN THEIR WORDS THE RESULTS WERE MISLEADING. THIS IS A HEAVY DUTY TRUCK THAT I FEAR TOWING MY TRAILERS WITH BECAUSE THEY CAN'T TELL ME WHY IT HAS THE VIBRATION. I ALMOST BELIEVE THAT THEY KNOW THE PROBLEM AND WON'T DISCLOSE IT TO ME. THE MOST CONCERNING STATEMENT MADE IN THE REPAIR ATTEMPT IS THAT THEY COMPARED MY TRUCK TO AN INSTOCK UNIT AND IT DRIVE COMPARABLE.
NHTSA ODI #11399711
3,200 miles · Dec 26, 2020
Power TrainService BrakesSteering
ON 3 OCCASIONS SINCE I BOUGHT THE PU NEW ON JULY 24TH, 2020 I EXPERIENCED WHAT THE FORD DEALER NOW CALLS DEATH WOBBLE. THE FIRST TIME HAPPENED ON SEPT 2ND WHILE DRIVING DOWN HILL PULLING MY TRAILER AT ABOUT 50MPH. WHEN I STEPPED ON THE BRAKE THE STEERING WHEEL AND BRAKE PEDAL STARTED TO SHAKE VIOLENTLY. I HAD LITTLE CONTROL UNTI…
Read full complaint
ON 3 OCCASIONS SINCE I BOUGHT THE PU NEW ON JULY 24TH, 2020 I EXPERIENCED WHAT THE FORD DEALER NOW CALLS DEATH WOBBLE. THE FIRST TIME HAPPENED ON SEPT 2ND WHILE DRIVING DOWN HILL PULLING MY TRAILER AT ABOUT 50MPH. WHEN I STEPPED ON THE BRAKE THE STEERING WHEEL AND BRAKE PEDAL STARTED TO SHAKE VIOLENTLY. I HAD LITTLE CONTROL UNTIL MY SPEED DROPPED. I TOOK THE PU TO THE DEALER SEPT 16TH. THEY SAID THEY COULD FIND NO PROBLEM AND STATED IF THEIR AGENT COULD NOT EXPERIENCE THE PROBLEM WHILE DRIVING THE PU THEY COULD NOT FIX IT. ON THE SECOND TIME I WAS DRIVING THE PU EMPTY AT HIGHWAY SPEED AND AGAIN WHILE BRAKING THE STEERING AND BRAKES SHOOK VIOLENTLY. UP TO THIS POINT I WAS THINKING THE BRAKES WERE THE PROBLEM. I STARTED TRACKING THE BRAKE TEMPERATURE WHICH SHOWED A LARGE VARIETY OF TEMPS FOR SIMILAR DRIVING CONDITIONS. I PROVIDED THE NUMBERS TO THE DEALER. I WAS TOLD A FEW DAYS LATER ON OCT 29TH THAT THE TEMPS WERE NORMAL AND MY DRIVING STYLE NEEDED TO BE ADJUSTED FOR A VEHICLE OF THIS TYPE. ON THE THIRD TIME NOV 15TH I WAS AGAIN PULLING THE TRAILER BUT THIS TIME AT 40MPH IN WET AND SNOWY CONDITIONS WHEN I STEPPED ON THE BRAKE I EXPERIENCED THE SHAKING TO THE POINT OF LOSING CONTROL. WHEN I TOOK THE PU TO THE DEALER WITH JUST 8000 MILES ON THE TRUCK THEY AGAIN SAID THEY COULD DO NOTHING WITHOUT THEIR AGENT SEEING THE PROBLEM THEMSELVES. BUT THIS TIME ON THE PAPERWORK THEY DESCRIBED THE PROBLEM AS 'DEATH WOBBLE'. I CHECKED THE NHTSA SITE FINDING SEVERAL COMPLAINTS SIMILAR TO MINE. THE INTERNET IS ALSO LOADED WITH COMPLAINTS AND POSSIBLE FIXES SINCE FORD WON'T OR CAN'T FIX THE PROBLEM. FORD CLEARLY KNOWS THIS PROBLEM EXISTS BECAUSE THEY HAVE PUT A NAME TO THE PROBLEM BUT THEY ARE DOING NOTHING ON MY PU (AND MANY OTHERS) TO FIX THE PROBLEM.
NHTSA ODI #11384965
37,000 miles · Nov 23, 2020
Power Train
TL* THE CONTACT OWNS A 2020 FORD F-350. THE CONTACT STATED THAT THE TRANSMISSION AND TORQUE CONVERTER WERE REPLACED FIVE TIMES WITHIN THE LAST 9,000 MILES. THE VEHICLE WAS TAKEN TO CARUSO FORD LINCOLN (3500 CHERRY AVE, LONG BEACH, CA 90807; (562) 426-3301) WHERE ALL THE REPAIRS WERE MADE HOWEVER, THE FAILURE PERSISTED. THE MANUF…
Read full complaint
TL* THE CONTACT OWNS A 2020 FORD F-350. THE CONTACT STATED THAT THE TRANSMISSION AND TORQUE CONVERTER WERE REPLACED FIVE TIMES WITHIN THE LAST 9,000 MILES. THE VEHICLE WAS TAKEN TO CARUSO FORD LINCOLN (3500 CHERRY AVE, LONG BEACH, CA 90807; (562) 426-3301) WHERE ALL THE REPAIRS WERE MADE HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND A CASE WAS FILED. THE APPROXIMATE FAILURE MILEAGE WAS 37,000.
NHTSA ODI #11375954
Official recalls
15Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, 2021-2022 F600, and 2022 F750 vehicles previously repaired incorrectly under recall number 24V957. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed mailed April 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S17. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 18, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The 360-degree view camera system may not display a rearview image properly in certain lighting conditions.
Consequence & remedy
Consequence: A rearview camera image that does not display properly can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the image processing module software, free of charge.This will be a phased campaign, with the remedy becoming available in different phases based on model years. Interim letters notifying owners of the safety risk were mailed on October 30, 2025. Additional letters will be mailed once the remedy is available on each phase. Owner notification letters were mailed May 19, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA8. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 13, 2025.
Sep 19, 2025
Ford Motor Company (Ford) is recalling certain 2020-2021 F-250, F-350, and F-450 vehicles. The steering column upper shaft may detach from the steering column and result in a loss of steering control.
Consequence & remedy
Consequence: A loss of steering control increases the risk of a crash.
Remedy: Dealers will inspect the steering column, and repair or replace the upper shaft as necessary, free of charge. Owner notification letters were mailed February 20, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S94. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 23, 2025.
Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, F600, and 2021-2022 F-650, F750 vehicles. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) and Transmission Control Module (TCM) software, free of charge. Owner notification letters were mailed January 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S78.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
Aug 26, 2022
Ford Motor Company (Ford) is recalling certain 2017-2020 F-Super Duty F-250, F-350, F-450, and 2017-2020 Lincoln Continental vehicles equipped with the 360-degree camera system. Degradation of the camera's anit-reflective lens coating can lead to a foggy or cloudy rearview camera image.
Consequence & remedy
Consequence: Lack of a clear rearview camera image can reduce the driver's visibility of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Ford customer service at 1-800-1-866-436-7332. Ford's number for this recall is 22S51.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020 Super Duty F-250, F-350, F-450, and F-550 vehicles equipped with 6.7L diesel engines. A washer within the vehicle's transmission can disintegrate, causing metallic debris to become lodged in the 'Park' mechanism.
Consequence & remedy
Consequence: Debris lodged within the 'Park' mechanism may prevent the vehicle from achieving or holding 'Park,' increasing the risk of a vehicle rollaway and a crash.
Remedy: Dealers will replace a gearset within the transmission, free of charge. Owner notification letters were mailed on April 19, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S22.
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Jul 15, 2021
Ford Motor Company (Ford) is recalling certain 2020-2021 F-350 Super Duty pickup trucks equipped with 6.7L diesel engines and Dana model 275 rear axles. The rear axle housing may not support the load of the pickup truck and deform, which could result in driveshaft separation.
Consequence & remedy
Consequence: Driveshaft separation may result in a loss of drive power, or unintended vehicle movement if the vehicle is in park without the parking brake applied, increasing the risk of a crash.
Remedy: Dealers will inspect the axle housing for deformities, and repair or replace the housing, as necessary, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall 21S31.
Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 27, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S10.
Feb 18, 2021
Ford Motor Company (Ford) is recalling certain 2020 F-Super Duty F350 vehicles equipped with a 6.7L diesel engine, single rear wheels (SRW), 4X4 Crew Cab, Long Box, and a 12k or 12.4k Gross Vehicle Weight Rating. These vehicles may display overstated payload capacity values on the Tire and Loading Information (TREAD) Label, overstated Accessory Reserve Capacity (ARC) values on the Safety Certification Label, and overstated weight values on the Truck Camper Loading Documentation. If the vehicle is loaded to the payload stated on the TREAD label, it may exceed the Gross Vehicle Weight Rating (GVWR) or Gross Axle Weight Rating (GAWR) and overload the vehicle.
Consequence & remedy
Consequence: An overloaded vehicle can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the Tire and Loading Information Label, Safety Certification Label, and the Truck Camper Loading Document (if applicable), free of charge. The recall began March 23, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S06.
Feb 18, 2021
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence & remedy
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Additional source detail variants (2)
Visibility:windshield:critical Fasteners
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Visibility:windshield
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Jun 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Super-Duty F-250, F-350, and F-550 diesel pickups. The transmission torque converter damper plate was not tempered, resulting in a brittle damper plate that may fracture and cause the engine to stall or require increased brake pedal effort in order to stop the vehicle.
Consequence & remedy
Consequence: An engine stall or requiring additional braking effort to stop the vehicle can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the transmission assembly, free of charge. This recall began July 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S33.
Additional source detail variants (2)
Power Train:automatic Transmission:torque Converter
Ford Motor Company (Ford) is recalling certain 2020 Super-Duty F-250, F-350, and F-550 diesel pickups. The transmission torque converter damper plate was not tempered, resulting in a brittle damper plate that may fracture and cause the engine to stall or require increased brake pedal effort in order to stop the vehicle.
Consequence: An engine stall or requiring additional braking effort to stop the vehicle can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the transmission assembly, free of charge. This recall began July 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S33.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2020 Super-Duty F-250, F-350, and F-550 diesel pickups. The transmission torque converter damper plate was not tempered, resulting in a brittle damper plate that may fracture and cause the engine to stall or require increased brake pedal effort in order to stop the vehicle.
Consequence: An engine stall or requiring additional braking effort to stop the vehicle can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the transmission assembly, free of charge. This recall began July 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S33.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE24014 · Sogefi Secondary Diesel Fuel Filter Leak
Opened May 9, 2024 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.
RQ21001 · Power Tailgate Release Systems
Opened Jan 15, 2021 · Closed Jan 10, 2024
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Structure:body:door
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration