IllustrationVEHICLE STARTED SHAKING VIOLENTLY WHEN I WAS DRIVING ON THE HIGHWAY WITH 60 MPH, I LOST CONTROL. LUCKILY THERE WAS NO CAR NEXT TO MINE BUT IF THERE WAS I WOULD HAVE CRASHED. I CAN NOT TRUST THIS TRUCK ANY LONGER. I AM TERRIFIED TO DRIVE.
2019 Ford F-350 Sd
Owner reports · Recalls · Investigations
More warning signs than most F-350 Sd years
Owner complaints for the 2019 Ford F-350 Sd are substantially higher than the model-year median of 73.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-350 Sd years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1440–25K
6825–50K
1850–75K
675–100K
7100–150K
4150K+
247 reports with mileage · 219 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 266 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 227 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Wheels. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports6 fire reports7 injury reports
Steering complaints
266 reportsOUR VEHICLE HAS EXPERIENCED THE FORD "DEATH WOBBLE" ON MULTIPLE OCCASIONS. THIS IS PARTICULARLY CONCERNING AND DANGEROUS WHILE TOWING A 20K POUND FIFTH WHEEL. AT ONE POINT THE WOBBLE WAS SO SEVERE THAT IT DAMAGED OUR FIFTH WHEEL, THE BED OF THE TRUCK, AND WE COULD NOT CONTROL THE VEHICLE WHEN WE HIT A BUMP IN THE ROAD. FORD H…
Read full complaint
OUR VEHICLE HAS EXPERIENCED THE FORD "DEATH WOBBLE" ON MULTIPLE OCCASIONS. THIS IS PARTICULARLY CONCERNING AND DANGEROUS WHILE TOWING A 20K POUND FIFTH WHEEL. AT ONE POINT THE WOBBLE WAS SO SEVERE THAT IT DAMAGED OUR FIFTH WHEEL, THE BED OF THE TRUCK, AND WE COULD NOT CONTROL THE VEHICLE WHEN WE HIT A BUMP IN THE ROAD. FORD HAS A BAD REPUTATION FOR THIS ISSUE, LONG STANDING, AND I REQUEST THE FEDERAL GOVERNMENT WOULD INVESTIGATE WHY THEY CONTINUE TO PRODUCE VEHICLES WITHOUT CORRECTING THE ISSUE. WE HAVE HAD OURS FIXED BUT THIS COULD HAVE RESULTED IN DEATH AND IT IS NOT ACCEPTABLE THAT FORD CONTINUES TO SELL A PRODUCT WITH A POTENTIALLY DEADLY SAFETY ISSUE. THE DATE BELOW IS ONE OF MANY DATES.
WHILE DRIVING MY FORD F350 APPROXIMATELY 50MPH ON A STATE HIGHWAY, I HIT A SLIGHT DEPRESSION IN THE ROADWAY AFTER CROSSING A BRIDGE. THE VEHICLE'S FRONT END AND STEERING WHEEL BEGAN SHAKING VIOLENTLY . I HAD TO COME TO ALMOST A COMPLETE STOP TO MAKE THE SHAKING STOP. I BELIEVE THIS TO BE THE PROBLEM DESCRIBED AS THE FORD DEA…
Read full complaint
WHILE DRIVING MY FORD F350 APPROXIMATELY 50MPH ON A STATE HIGHWAY, I HIT A SLIGHT DEPRESSION IN THE ROADWAY AFTER CROSSING A BRIDGE. THE VEHICLE'S FRONT END AND STEERING WHEEL BEGAN SHAKING VIOLENTLY . I HAD TO COME TO ALMOST A COMPLETE STOP TO MAKE THE SHAKING STOP. I BELIEVE THIS TO BE THE PROBLEM DESCRIBED AS THE FORD DEATH WOBBLE. THE VEHICLE HAD 27800 MILES AT THE TIME OF THE INCIDENT. I HAVE SCHEDULED AN APPOINTMENT WITH THE DEALER FOR AN INSPECTION AND REPAIR. I STOPPED TO EXAMINE THE FRONT OF MY VEHICLE, BUT THERE WAS NO APPARENT REASON FOR THE INCIDENT.
DRIVING DOWN THE ROAD AT AROUND 60 MPH WHEN TRUCK HAD VIOLENT SHAKING ISSUE. HAD TO COME TO A COMPLETE STOP TO GET IT UNDER CONTROL. SHAKING SO BAD COULD HARDLY HANG ON TO STEERING WHEEL. THOUGHT THAT WAS SCARY AND ODD, WENT DOWN THE HIGHWAY ABOUT A MILE DID IT AGAIN! (THIS WAS GOING STRAIGHT BUT HITTING SOME UNEVEN ROAD. ONCE W…
Read full complaint
DRIVING DOWN THE ROAD AT AROUND 60 MPH WHEN TRUCK HAD VIOLENT SHAKING ISSUE. HAD TO COME TO A COMPLETE STOP TO GET IT UNDER CONTROL. SHAKING SO BAD COULD HARDLY HANG ON TO STEERING WHEEL. THOUGHT THAT WAS SCARY AND ODD, WENT DOWN THE HIGHWAY ABOUT A MILE DID IT AGAIN! (THIS WAS GOING STRAIGHT BUT HITTING SOME UNEVEN ROAD. ONCE WAS A SEAM AT A BRIDGE) TURNED AROUND AND HEAD HOME DID IT TWICE MORE. READY FOR IT THIS TIME. GOT HOME LOOKED ON THE COMPUTER FOUND IT IS A KNOWN PROBLEM CALLED THE DEATH WOBBLE. CALLED DEALER AND THEY SAID BRING IT AND WE WILL REPLACE THE STEERING SHOCK. WELL AS A MECHANIC OF HEAVY EQUIPMENT AND A DRIVER OF PICK UP TRUCKS FOR OVER 40+ YEARS I KNOW THIS IS ONLY A BAND AID! THE VALUE OF THE TRUCK AND THE VALUE OF THE LIVES IN THIS TRUCK DEMANDS MORE ATTENTION THEN A BAND AID. NO DASH CAM TO CAPTURE EVENT AND NOT GOING BACK OUT AND TRYING TO GET IT AS THEY HAVE IT ON YOUTUBE (COME TO FIND OUT). I NOW KNOW THIS IS A KNOWN PROBLEM BUT NOT SURE IF THE WIFE COULD HAVE BEEN ABLE TO HOLD ON TO THE WHEEL AND IF NOT THE WOULD HAVE BEEN A CRASH. WISH I HAD KNOWN THIS BEFORE I BOUGHT THIS TRUCK! VERY VERY DANGEROUS. AS A KNOWN ISSUE (FOR SOME) FOR A FEW YEARS NOW DO PEOPLE NEED TO DIE BEFORE FORD HAS A RECALL ON THIS AND FIXES THE ISSUE. I THOUGHT I DID MY RESEARCH ON THIS VEHICLE THROUGH CAR FAX AND OTHER SITES AND DID NOT SEE THIS ISSUE.
ON THREE OCCASIONS, ON HIGHWAYS, WE HAVE HIT A POT HOLE OR BUMP, AND THE F350 GOES INTO AN EXTREME WOBBLE WITH THE STEERING WHEEL. IT IS INCREDIBLY JARRING AND WE'VE ALMOST LOST CONTROL. WHEN BROUGHT TO DEALER, THEY REPLACED THE DAMPER. I'VE NOW DONE RESEARCH AND THERE ARE COUNTLESS PERSONS GOING THROUGH THIS EXACT ISSUE: HTTPS:…
Read full complaint
ON THREE OCCASIONS, ON HIGHWAYS, WE HAVE HIT A POT HOLE OR BUMP, AND THE F350 GOES INTO AN EXTREME WOBBLE WITH THE STEERING WHEEL. IT IS INCREDIBLY JARRING AND WE'VE ALMOST LOST CONTROL. WHEN BROUGHT TO DEALER, THEY REPLACED THE DAMPER. I'VE NOW DONE RESEARCH AND THERE ARE COUNTLESS PERSONS GOING THROUGH THIS EXACT ISSUE: HTTPS://WWW.FACEBOOK.COM/GROUPS/158686091563038 I CAN'T BELIEVE THIS IS SO PREVALENT AND UNADDRESSED. SOMEONE'S GOING TO BE HURT BADLY OR WORSE. APPARENTLY THE DEALERS JUST ARE REPLACING THE DAMPER TO COVER THEMSELVES. THIS IS NOT A LONG TERM SOLUTION. I HAVE NO VIDEO, BUT THE FACEBOOK GROUP HAS TONS! IT'S CRAZY AND IT IS EXACTLY WHAT HAPPENED!
MY 2019 FORD F-350 WITH 16,000 MILES ON THE ODOMETER IS EXPERIENCING VIOLET SHAKING OF THE STEERING WHEEL WHILE TRAVELING AT SPEEDS OF 50-65 MPH ON THE HIGHWAY. THE ONLY WAY TO GET THE VEHICLE UNDER CONTROL IS TO SLOW DOWN ON DANGEROUS HIGHWAYS TO BELOW 30 MPH. I FEEL IT'S GOING TO CAUSE AN ACCIDENT SOONER OR LATER. THE VEHICL…
Read full complaint
MY 2019 FORD F-350 WITH 16,000 MILES ON THE ODOMETER IS EXPERIENCING VIOLET SHAKING OF THE STEERING WHEEL WHILE TRAVELING AT SPEEDS OF 50-65 MPH ON THE HIGHWAY. THE ONLY WAY TO GET THE VEHICLE UNDER CONTROL IS TO SLOW DOWN ON DANGEROUS HIGHWAYS TO BELOW 30 MPH. I FEEL IT'S GOING TO CAUSE AN ACCIDENT SOONER OR LATER. THE VEHICLE IS ALL STOCK AND NO MODIFICATIONS OF THE TIRES, WHEELS, OR SUSPENSION HAVE BEEN PERFORMED.
I WAS DRIVING ON THE FREEWAY AT ABOUT 70 MPH AND WENT OVER A BRIDGE SEAM IN THE ROADWAY. THE SEAM WAS AT AN ANGLE. THE ENTIRE VEHICLE SHOOK BADLY. THE STEERING WHEEL SHOOK AND RATTLED SO MUCH I HAD DIFFICULTY HOLDING ON TO IT. AS A RESULT, THE TRUCK VEERED OUT OF MY LANE AND IN TO THE OTHER LANE (THANK GOODNESS THERE WASN'T ANOT…
Read full complaint
I WAS DRIVING ON THE FREEWAY AT ABOUT 70 MPH AND WENT OVER A BRIDGE SEAM IN THE ROADWAY. THE SEAM WAS AT AN ANGLE. THE ENTIRE VEHICLE SHOOK BADLY. THE STEERING WHEEL SHOOK AND RATTLED SO MUCH I HAD DIFFICULTY HOLDING ON TO IT. AS A RESULT, THE TRUCK VEERED OUT OF MY LANE AND IN TO THE OTHER LANE (THANK GOODNESS THERE WASN'T ANOTHER VEHICLE THERE) BEFORE I COULD GRAB THE WHEEL AGAIN AND SLOW THE TRUCK. HAD TO SLOW DOWN TO ABOUT 30-35 MPH TO GET THE SHAKING TO STOP. SURPRISED I WASN'T REAR-ENDED IN THAT PROCESS... THIS HAS HAPPENED SEVERAL TIMES - ALL WHILE AT OR OVER ABOUT 50 MPH, AND AFTER DRIVING OVER SOME UNEVEN PAVEMENT/PAVEMENT IMPERFECTIONS (VERY MILD UNEVENNESS SUCH AS A BRIDGE SEAM AND SMALL ROADWAY PATCH; DOESN'T MATTER IF I HIT IT AT AN ANGLE OR NOT). THE FIRST TIME THIS HAPPENED WAS 5/25/2020 WHEN I BOUGHT THE TRUCK. IT DIDN'T LAST LONG AND I THOUGHT IT WAS A FLUKE... BUT NOW IT HAPPENS MORE FREQUENTLY. THE TRUCK SHAKES EVEN WORSE/ SHAKING LASTS WAY LONGER WHEN THE UNEVEN SURFACE IS MORE PRONOUNCED SUCH AS A POTHOLE, THE UNEVEN SURFACE IS AN ANGLE, OR THE PATH DRIVEN IS ON A CURVE. I ONCE HAD A JEEP WRANGLER (EARLY 2000'S) THAT DID THIS. IT WAS KNOWN AS THE "DEATH WOBBLE." THIS FEELS THE SIMILAR EXCEPT THE SHAKING IS MORE VIOLENT.
WHILE DRIVING MY FORD F350 ON A RURAL HIGHWAY AT 55 MPH (60 MPH LIMIT) WENT OVER RAILROAD TRACKS AND EXPERIENCED WHAT IS COMMONLY KNOWN AS THE "DEATH WOBBLE". MY TRUCK ONLY HAS 12,200 MILES ON IT. I HAVE HEARD OF THIS, BUT UNTIL YOU EXPERIENCE IT FOR YOURSELF, THERE IS NO WAY TO KNOW HOW SCARY IT IS TO LOSE CONTROL OF A 7,000+ P…
Read full complaint
WHILE DRIVING MY FORD F350 ON A RURAL HIGHWAY AT 55 MPH (60 MPH LIMIT) WENT OVER RAILROAD TRACKS AND EXPERIENCED WHAT IS COMMONLY KNOWN AS THE "DEATH WOBBLE". MY TRUCK ONLY HAS 12,200 MILES ON IT. I HAVE HEARD OF THIS, BUT UNTIL YOU EXPERIENCE IT FOR YOURSELF, THERE IS NO WAY TO KNOW HOW SCARY IT IS TO LOSE CONTROL OF A 7,000+ POUND VEHICLE. I WAS LUCKY THAT I WAS ABLE TO PULL OVER ON THE SHOULDER TO STOP IT, THIS TIME. I HAVE READ SEVERAL BLOGS ABOUT FORD DEALERS NOT TREATING THIS SERIOUSLY UNLESS THE INCIDENT(S) ARE REPORTED TO NHTSA. I AM SURE THIS WILL HAPPEN AGAIN AS IT SEEMS TO ALWAYS BE PRESENT ON VEHICLES THAT START.
HIT A FEW BUMPS IN THE ROAD AND THE FRONT LEFT (DRIVERS) TIRE WOBBLES AS IF IS GOING TO FALL OFF. HAVE TO SLOW FROM INTERSTATE SPPES TO 25 MPH TO STOP IT. THIS HAS HAPPENED SEVERAL TIMES NOW.
GOING DOWN THE ROAD AT HIGHWAY SPEEDS. HITTING A BUMP TRUCK SHAKES UNCONTROLLABLY IT'S WORSE WHEN IN A CURVE. HAVE TO SLOW DOWN TO APPROX 35 MPH TO GET IT TO STOP.
Official recalls
1125V572000 · Back Over Prevention: Sensing System: Camera
Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
23V420000 · Equipment:other:owners/service/other Manual
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
22V644000 · Back Over Prevention: Sensing System: Camera
Aug 26, 2022
Ford Motor Company (Ford) is recalling certain 2017-2020 F-Super Duty F-250, F-350, F-450, and 2017-2020 Lincoln Continental vehicles equipped with the 360-degree camera system. Degradation of the camera's anit-reflective lens coating can lead to a foggy or cloudy rearview camera image.
Consequence & remedy
Consequence: Lack of a clear rearview camera image can reduce the driver's visibility of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Ford customer service at 1-800-1-866-436-7332. Ford's number for this recall is 22S51.
22V252000 · Back Over Prevention: Sensing System: Camera
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2019 F-150, Super Duty F-250, F-350, F-450, and F-550 vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that displays a blank or distorted image can reduce the drivers view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
22V087000 · Power Train:driveline:driveshaft; Structure:frame And Members:underbody Shields
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
21V155000 · Tires
Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 27, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S10.
19V880000 · Seat Belts:pretensioner; Structure:body:roof And Pillars
Dec 11, 2019
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
Additional source detail variants (2)
Seat Belts:pretensioner
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
Structure:body:roof And Pillars
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
19V864000 · Latches/locks/linkages:tailgate:latch
Dec 4, 2019
Ford Motor Company (Ford) is recalling certain 2017-2019 Super Duty F-250, F-350, and F-450 trucks equipped with an electric tailgate latch release switch mounted in the tailgate handle. Water may enter the electrical wiring system and cause a short circuit, activating the switch and releasing the tailgate latches.
Consequence & remedy
Consequence: Unintended tailgate opening may allow unrestrained cargo to fall out of the truck bed and become a road hazard, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits and will install a new tailgate handle release switch, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S48.
19V808000 · Exterior Lighting:headlights
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2018-2019 F-250, F-350 and F-450 Super Duty trucks. The Daytime Running Lights (DRL) may not dim when the headlight switch is moved into the "On" position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford has notified owners, and dealers will reprogram the Body Control Module (BCM) software, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C10.
19V278000 · Engine; Equipment:electrical
Apr 8, 2019
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
18V802000 · Power Train:automatic Transmission
Nov 14, 2018
Ford Motor Company (Ford) is recalling certain 2019 Ford F-250 Super Duty, F-350 Super Duty and F-450 Super Duty vehicles. An incorrect transmission case casting may cause the park pawl assembly to not be secured, possibly resulting in unintended vehicle movement.
Consequence & remedy
Consequence: Unintended vehicle movement can increase the risk of a crash.
Remedy: Ford will notify owners and dealers will inspect the transmission case, replacing the transmission as necessary, free of charge. The recall began December 7, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S36.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE24014 · Sogefi Secondary Diesel Fuel Filter Leak
Opened May 9, 2024 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ21001 · Power Tailgate Release Systems
Opened Jan 15, 2021 · Closed Jan 10, 2024
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Structure:body:door
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18011 · Power Tailgate Opens Unintended
Opened Oct 12, 2018 · Closed Dec 12, 2019
Status: closed (inferred from source dates) · Electrical System:wiring; Structure:body:tailgate:hinge And Attachments
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.
Additional source detail variants (2)
Electrical System:wiring
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.
Structure:body:tailgate:hinge And Attachments
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.