The contact owns a 2016 Ford F-350. The contact stated while driving 60 MPH, there was an abnormal knocking sound coming from the engine compartment. The vehicle was taken to the local dealer where it was diagnosed and determined that the cylinder was not operating as needed, and there was engine damage. The vehicle was not rep…
Read full complaint
The contact owns a 2016 Ford F-350. The contact stated while driving 60 MPH, there was an abnormal knocking sound coming from the engine compartment. The vehicle was taken to the local dealer where it was diagnosed and determined that the cylinder was not operating as needed, and there was engine damage. The vehicle was not repaired. The vehicle was previously taken to the local dealer, Summerville Ford (9700 Dorchester Rd, Summerville, SC 29485); where it was diagnosed and determined that there were metal shavings in the fuel system in the high-pressure fuel pump. The vehicle was repaired; however, the failure recurred. There was black smoke while driving and the check engine warning light was illuminated. The contact stated that the turbo charger, body mounts, and coolant pump were replaced; however, the failure persisted. The manufacturer was not yet contacted. The failure mileage was approximately 82,800.
NHTSA ODI #11666336
52,860 miles · Apr 8, 2025
Fuel System, Diesel
The contact owns a 2016 Ford F-350. The contact stated that the check engine warning light was illuminated. The contact stated that after adding diesel particulate filter fluid in the vehicle, the message that the vehicle was low on fluid was displayed, and the vehicle would unintendedly decelerate to under 50 MPH. The vehicle w…
Read full complaint
The contact owns a 2016 Ford F-350. The contact stated that the check engine warning light was illuminated. The contact stated that after adding diesel particulate filter fluid in the vehicle, the message that the vehicle was low on fluid was displayed, and the vehicle would unintendedly decelerate to under 50 MPH. The vehicle was taken to the dealer, who replaced the DPF pump and burner. Approximately 30,000 miles later, the failure recurred, and the vehicle was returned to the dealer. The dealer replaced the DPF pump and burner again. The manufacturer was informed of the failure and opened a case. The manufacturer transferred the contact to the NHTSA Hotline to report the failure. The failure mileage was 52,860.
NHTSA ODI #11653421
150,000 miles · Jun 3, 2024
Fuel System, Diesel
The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the engine seized. The check engine warning light illuminated. The contact stated that the vehicle failed to restart. The vehicle was towed to an independent mechanic where it was diagnosed with a failed fuel pump and metal shaving…
Read full complaint
The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the engine seized. The check engine warning light illuminated. The contact stated that the vehicle failed to restart. The vehicle was towed to an independent mechanic where it was diagnosed with a failed fuel pump and metal shavings inside the fuel system. The contact was informed that the fuel system and injectors needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 150,000.
NHTSA ODI #11592147
100,000 miles · Jul 25, 2023
Fuel System, Diesel
The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to reach her destination but had to periodically start the vehicle and let it run to ensure that the vehicle would remain operable. No warning lights were illuminate…
Read full complaint
The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to reach her destination but had to periodically start the vehicle and let it run to ensure that the vehicle would remain operable. No warning lights were illuminated. The vehicle was taken to the dealer, who determined that the diesel exhaust fluid tank had frozen and needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 100,000.
NHTSA ODI #11534446
44,000 miles · Sep 16, 2022
EngineFuel System, Diesel
The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the diesel particulate filter needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the fai…
Read full complaint
The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the diesel particulate filter needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 44,000.
NHTSA ODI #11484822
36,000 miles · Aug 24, 2022
Fuel System, Diesel
The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the diesel particulate filter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the f…
Read full complaint
The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the diesel particulate filter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The contact related the failure to Customer Satisfaction Program: 20M06 (Diesel Particulate Filter Warranty Extension) however, the VIN was not included. The failure mileage was approximately 36,000.
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
Ford Motor Company (Ford) is recalling certain 2016 Super Duty F-250, F-350, F-450, and F-550 vehicles. Dust may accumulate in the steering wheel clock spring, causing a disconnection in the electrical connection resulting in the driver's air bag not deploying as intended.
Consequence & remedy
Consequence: A disconnected driver's air bag can result in it not deploying, as intended, during a crash, increasing the risk of injury.
Remedy: Dealers will replace the steering wheel clock spring, free of charge. Remedy parts are expected to become available in the 3rd Quarter of 2023. An interim notification letter informing owners of the safety risk was mailed on July 6, 2022. Owner notification letters were mailed July 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S35.
Ford Motor Company (Ford) is recalling certain model year 2016 Ford F-250, F-350, F-450, and F-550 trucks manufactured April 5, 2016, to April 11, 2016. The tires installed during assembly of the affected vehicles may have sustained damage to the inner sidewall, possibly resulting in a loss of air or a tire rupture.
Consequence & remedy
Consequence: A rapid loss of air or a tire rupture while the vehicle is being driven may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires for damage and replace them as necessary, free of charge. The recall began on May 23, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S17.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
2016 Ford F-350 Sd Problems, Complaints & Recalls | Skip That Year