NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
13 reportsClear category filter55,000 miles · Nov 24, 2010
Power Train
MY 2005 FORD 350 4X4 CRACKED THE TRANS CASE BECAUSE OR THE LOW/REVERSE SNAP RING CAME LOOSE & BROKE THE TRANS CASE AT 55000 MI. TALKED TO FORD ABOUT THIS & THEY SAID THERE IS NOTHING THEY COULD DO &THERE HAS NOT BEEN A PROBLEM WITH THIS, BUT I FOUND OUT THAT THEY HAVE HAD A PROBLEM & HAD A RECALL ON THIS (RECALL #05B27). FORD …
Read full complaint
MY 2005 FORD 350 4X4 CRACKED THE TRANS CASE BECAUSE OR THE LOW/REVERSE SNAP RING CAME LOOSE & BROKE THE TRANS CASE AT 55000 MI. TALKED TO FORD ABOUT THIS & THEY SAID THERE IS NOTHING THEY COULD DO &THERE HAS NOT BEEN A PROBLEM WITH THIS, BUT I FOUND OUT THAT THEY HAVE HAD A PROBLEM & HAD A RECALL ON THIS (RECALL #05B27). FORD DEALER SAID THAT THIS WOULD COST ME $4622.00. THEY FIXED THIS PROBLEM I THINK IN THE 2006 MODELS THEREFORE THEY KNEW THEY HAD A PROBLEM. MY WARRANTY RAN OUT ON THIS TRUCK ABOUT 1 MONTH AGO. *TR
NHTSA ODI #10367810
60,000 miles · Oct 12, 2009
Power Train
I HAVE A FORD F350 KING RANCH 2005 AND IT WOBBLES VIOLENTLY AFTER HITTING A BUMP OR UNEVEN PATCH. IT DOES IT ABOVE 40 MPH. DEALER HAD ME PURCHASE A STABILIZER AND THEY PUT IT ON- IT HELPED BUT DIDN'T SOLVE IT. I JUST DRIVE THE TRUCK WHEN I NEED. I TOOK IT IN 6 MONTHS LATER AND THEY SAID THEY MUST INVESTIGATE BY DEDUCTION. THEY W…
Read full complaint
I HAVE A FORD F350 KING RANCH 2005 AND IT WOBBLES VIOLENTLY AFTER HITTING A BUMP OR UNEVEN PATCH. IT DOES IT ABOVE 40 MPH. DEALER HAD ME PURCHASE A STABILIZER AND THEY PUT IT ON- IT HELPED BUT DIDN'T SOLVE IT. I JUST DRIVE THE TRUCK WHEN I NEED. I TOOK IT IN 6 MONTHS LATER AND THEY SAID THEY MUST INVESTIGATE BY DEDUCTION. THEY WANTED TO CHARGE ME TO FIRST DO A BALANCE, THEN A WHEEL ALIGNMENT. I TOLD THEM NO- IT SHOULD BE A RECALL. MY FEAR IS THAT THE VIOLENT WOBBLE WILL LEAD TO OTHER PROBLEMS. HELP. *TR
NHTSA ODI #10287059
45,906 miles · Jul 21, 2009
Power Train
ABOUT A MILE AFTER I TURNED OFF OF HWY 101 ONTO HWY 166 GOING EAST WHILE HAULING MY 32' TOYHAULER WITH MY 2005 FORD F350 SUPERDUTY 4X4 DRW CREW CAB TRUCK WHEN SMOKE STARTED BILLOWING OUT THE REAR OF MY TRUCK, A FRIEND THAT WAS FOLLOWING ME THOUGHT MY TRUCK WAS ON FIRE AS FLUID SPRINKLED ON HIS WINDSHIELD. I WAS NOT ABLE TO SAFEL…
Read full complaint
ABOUT A MILE AFTER I TURNED OFF OF HWY 101 ONTO HWY 166 GOING EAST WHILE HAULING MY 32' TOYHAULER WITH MY 2005 FORD F350 SUPERDUTY 4X4 DRW CREW CAB TRUCK WHEN SMOKE STARTED BILLOWING OUT THE REAR OF MY TRUCK, A FRIEND THAT WAS FOLLOWING ME THOUGHT MY TRUCK WAS ON FIRE AS FLUID SPRINKLED ON HIS WINDSHIELD. I WAS NOT ABLE TO SAFELY PULL OVER FOR A COUPLE OF MILES. WHEN I STOPPED I FOUND THAT MY TRANSMISSION FLUID HAD SPEWED OUT ONTO THE TAIL PIPE OF THE TRUCK THAT CAUSED THE SMOKE AND ALL OVER THE HIGHWAY. I HAD THE TRUCK AND TRAILER TOWED TO SANTA MARIA FORD AND HAD TO WAIT A DAY FOR THEM TO OPEN. WHEN THEY INSPECTED THE TRANSMISSION, THE MECHANIC TOLD ME THAT THE PROBLEM WAS A FAULTY RETAINER (SNAP) RING THAT CAME OFF (UNSEATED) THE LOW/REVERSE CLUTCH THAT CAUSED THE CRACK IN THE TRANSMISSION CASE. THE MECHANIC TOLD ME THERE WAS A FORD RECALL ON THIS PROBLEM A FEW YEARS EARLIER. HE DID NOT WANT ME TO MENTION THAT HE TOLD ME ANYTHING TO ANYONE AT THE FORD DEALERSHIP, BECAUSE HE WAS AFRAID OF LOSING HIS JOB. I LEFT THE TRUCK AT THE DEALER BECAUSE THEY SAID IT NEEDED A REBUILT TRANSMISSION. WHEN I RETURNED HOME I RESEARCHED THE PROBLEM AND FOUND FORD RECALL 05B27 THAT WAS EXACTLY THE PROBLEM THAT HAD OCCURRED. THE RECALL STATED THAT YOU HAD TO HAVE A SNOWPLOW PACKAGE INSTALLED ON THE TRUCK TO RECEIVE THE RECALL. THIS TRUCK DID NOT HAVE THE SNOWPLOW PACKAGE. BUT, IT DID HAVE THE EXACT TRANSMISSION WITH THE FAULTY SNAP RING THAT THE TRUCKS WITH THE SNOWPLOW PACKAGE HAD. IT SHOULD NOT MATTER IF MY TRUCK HAD A SNOWPLOW PACKAGE OR NOT. FORD KNEW THAT MY TRUCK HAD THE FAULTY PART INSTALLED IN THE TRANSMISSION AND NEVER SENT ME A RECALL. I COULD HAVE HAD AN ACCIDENT OR MAY HAVE CAUSED ONE, DUE TO THIS (FORD MOTOR COMPANY KNOWN) FAULTY PART CRACKING THE TRANSMISSION CASE AND SPEWING TRANSMISSION FLUID ALL OVER THE ROAD. HWY 166 IS A VERY WINDING ROAD IN AREAS AND WHO KNOWS IF AN ACCIDENT MAY HAVE HAPPENED DUE TO THE EXCESS SLIPPERY FLUID ALL OVER THE ROAD. MY COST $4441.00. *TR
NHTSA ODI #10277636
10,000 miles · Apr 17, 2009
Power Train
1. TRYING TO SHIFT TRUCK INTO 4X4 LOW 2. THE TRUCK WILL NOT SHIFT INTO 4X4 LOW. THERE IS A "SHIFT ON THE FLY" KNOB ON THE DASH AND YOU CAN SHIFT TRUCK INTO 4X4 HIGH, OR 4X4 LOW. IT WILL SHIFT INTO 4X4 HIGH BUT NOT 4X4 LOW. 3. I HAVE TAKEN THE TRUCK INTO THE DEALERSHIP TO ADDRESS THE PROBLEM. THEY VERIFIED THE PROBLEM BUT …
Read full complaint
1. TRYING TO SHIFT TRUCK INTO 4X4 LOW 2. THE TRUCK WILL NOT SHIFT INTO 4X4 LOW. THERE IS A "SHIFT ON THE FLY" KNOB ON THE DASH AND YOU CAN SHIFT TRUCK INTO 4X4 HIGH, OR 4X4 LOW. IT WILL SHIFT INTO 4X4 HIGH BUT NOT 4X4 LOW. 3. I HAVE TAKEN THE TRUCK INTO THE DEALERSHIP TO ADDRESS THE PROBLEM. THEY VERIFIED THE PROBLEM BUT COULD NOT FIX. *TR
NHTSA ODI #10265896
63,726 miles · Sep 16, 2008
Power Train
TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHEN THE VEHICLE WAS PLACED INTO REVERSE, IT WOULD NOT BACK UP. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT THE REVERSE CLUTCH RETAINER RING, THE REVERSE PISTON RETAINER RING, THE CLUTCH HOUSING, AND THE TRANSMISSION CASE NEEDED TO BE REPLACED. THE FAILURE MILEAGE…
Read full complaint
TL*THE CONTACT OWNS A 2005 FORD F-350 SUPERDUTY. WHEN THE VEHICLE WAS PLACED INTO REVERSE, IT WOULD NOT BACK UP. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT THE REVERSE CLUTCH RETAINER RING, THE REVERSE PISTON RETAINER RING, THE CLUTCH HOUSING, AND THE TRANSMISSION CASE NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 63,726.
NHTSA ODI #10242402
Mileage unknown · Aug 29, 2008
Exterior LightingPower Train
I RENTED A TRUCK FROM U-HAUL IN ELK GROVE, CA AT 4:50PM ON 8/28/08. ONCE THE VEHICLE WAS ABOVE 45MPH IT STARTED TO SHAKE VIOLENTLY AND ONCE IT WAS DARK, THE TAIL LIGHTS ON THE RIGHT SIDE WERE SHOWN TO BE NON-FUNCTIONING. THE REPRESENTATIVE DID NOT DO A VEHICLE INSPECTION WITH ME, IN FACT, HE TOOK OFF BEFORE I EVEN PULLED OUT OF …
Read full complaint
I RENTED A TRUCK FROM U-HAUL IN ELK GROVE, CA AT 4:50PM ON 8/28/08. ONCE THE VEHICLE WAS ABOVE 45MPH IT STARTED TO SHAKE VIOLENTLY AND ONCE IT WAS DARK, THE TAIL LIGHTS ON THE RIGHT SIDE WERE SHOWN TO BE NON-FUNCTIONING. THE REPRESENTATIVE DID NOT DO A VEHICLE INSPECTION WITH ME, IN FACT, HE TOOK OFF BEFORE I EVEN PULLED OUT OF THE DRIVE-WAY. I CALLED THE REPAIR SERVICE BECAUSE I FELT THE VEHICLE WAS UNSAFE AND WAS TOLD BY THE MECHANIC THEY SENT OUT THAT THE REAR END WAS COMING APART AND THAT THE POWER BRAKE SYSTEM HAD NO POWER WHEN I CAME TO A COMPLETE STOP. I INFORMED U-HAUL AND THEY INSISTED THAT I STILL DRIVE THE VEHICLE BACK TO THEIR FACILITY. I REFUSED, CITING THAT IT WAS UNSAFE AND ILLEGAL TO DRIVE A VEHICLE WITHOUT THE WORKING TAIL LIGHTS. THEY THEN CHARGED MY CREDIT CARD FOR THE RENTAL AND MILEAGE EVEN THOUGH THE VEHICLE STILL SAT IN MY DRIVE-WAY WITHOUT THEM KNOWING WHAT THAT MILEAGE WOULD BE. *TR
NHTSA ODI #10240236
36,800 miles · Aug 14, 2008
Power Train
08/2007 AT 27,127 MILES FORD F350 SUPERDUTY WAS TAKEN IN TO DEALER FOR REPAIR DUE TO THE FOLLOWING: HESITATION UPON ACCELERATION AND TRANSMISSION CATCHING AND LOUD BANG, LIKE IT IS JERKING INTO GEAR. DEALER REPAIRED UNDER WARRANTY. 08/2008 AT 36,800 MILES (JUST OUT OF WARRANTY) TAKEN IN AGAIN FOR SAME PROBLEM AND DEALER WAN…
Read full complaint
08/2007 AT 27,127 MILES FORD F350 SUPERDUTY WAS TAKEN IN TO DEALER FOR REPAIR DUE TO THE FOLLOWING: HESITATION UPON ACCELERATION AND TRANSMISSION CATCHING AND LOUD BANG, LIKE IT IS JERKING INTO GEAR. DEALER REPAIRED UNDER WARRANTY. 08/2008 AT 36,800 MILES (JUST OUT OF WARRANTY) TAKEN IN AGAIN FOR SAME PROBLEM AND DEALER WANT TO CHARGE US TO REPLACE TRANSMISSION. THE VEHICLE HAS NEVER BEEN USED TO PULL TRAILERS OR HEAVY EQUIPMENT SO THERE IS NO REASON FOR THE TRANSMISSION TO BE FAILING WITH SO LITTLE MILEAGE. *TR
NHTSA ODI #10238128
Mileage unknown · Jan 2, 2006
Engine And Engine CoolingPower Train
I'VE HAD MY 05 'F-350 DIESEL IN THE SHOP FOR MORE THAN A TOTAL OF 10 WEEKS BLOWN HEAD GASKETS BLOWN HEADS AND TRANSMISSION PROBLEMS WHICH NO ONE CAN SEEM TO FIX CORRECTLY I PERSONALLY THINK FOR SHOULD HAVE A RECALL ON THESE TRUCKS. *JB
NHTSA ODI #10146708
30,000 miles · Dec 28, 2005
Fuel System, GasolinePower Train
DT: THE CONTACT STATED THE VEHICLE STALLED INTERMITTENTLY. THE FIRST TIME THE VEHICLE STALLED IT IMMEDIATELY RESTARTED. THE SECOND TIME THE VEHICLE STALLED IT WAS TOWED TO THE DEALERSHIP. DURING BOTH INCIDENTS THE VEHICLE WAS TRAVELING AT 70 MPH. THE DEALERSHIP REPLACED THE FUEL SYSTEM INJECTORS AND MODULES. AFTER THE REPLACEM…
Read full complaint
DT: THE CONTACT STATED THE VEHICLE STALLED INTERMITTENTLY. THE FIRST TIME THE VEHICLE STALLED IT IMMEDIATELY RESTARTED. THE SECOND TIME THE VEHICLE STALLED IT WAS TOWED TO THE DEALERSHIP. DURING BOTH INCIDENTS THE VEHICLE WAS TRAVELING AT 70 MPH. THE DEALERSHIP REPLACED THE FUEL SYSTEM INJECTORS AND MODULES. AFTER THE REPLACEMENTS THE ENGINE BLEW OUT. ADDITIONALLY, THE DEALER DIAGNOSED A PROBLEM WITH THE TRANSMISSION AT 8,000 MILES, AND REPAIRS WERE MADE. BASED ON ALL THE PROBLEMS WITH THIS VEHICLE, IT HAS BEEN AT THE DEALERSHIP FOR THREE MONTHS. *AK
NHTSA ODI #10146280
1,231 miles · Oct 20, 2005
Power TrainSuspension
DT: THE CONTACT STATED WHILE MAKING A RIGHT HAND TURN THE VEHICLE HESITATED. THE TRANSMISSION WILL CATCH, AND THERE IS A LOUD BANG , AND THEN THE VEHICLE WILL LUNGE FORWARD. WHEN THE VEHICLE IS IN REVERSE THE TRANSMISSION HESITATES AS WELL. IT SEEMS AS THOUGH THERE MAY BE SOMETHING BROKEN IN THE TRANSMISSION OR IN THE REAR S…
Read full complaint
DT: THE CONTACT STATED WHILE MAKING A RIGHT HAND TURN THE VEHICLE HESITATED. THE TRANSMISSION WILL CATCH, AND THERE IS A LOUD BANG , AND THEN THE VEHICLE WILL LUNGE FORWARD. WHEN THE VEHICLE IS IN REVERSE THE TRANSMISSION HESITATES AS WELL. IT SEEMS AS THOUGH THERE MAY BE SOMETHING BROKEN IN THE TRANSMISSION OR IN THE REAR SUSPENSION. THE DEALERSHIP WHERE THE VEHICLE WAS PURCHASED REFERRED THE CONTACT TO A LOCAL DEALER TO HAVE THE VEHICLE INSPECTED. THE VEHICLE WAS NOT INSPECTED TO DETERMINE THE EXACT CAUSE OF THE PROBLEM. *AK THE CONSUMER HAD DIFFICULTY PLACING THE VEHICLE INTO PARK. UPDATED 11/16/105. *JB
NHTSA ODI #10140300
Official recalls
3Jul 13, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Jun 10, 2005
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Jun 9, 2005
ON CERTAIN PICKUP TRUCKS AND CHASSIS CAB VEHICLES EQUIPPED WITH 5.4L OR 6.8L GASOLINE ENGINES, THE FUEL JUMPER LINE MAY HAVE AN INCORRECT END FORM.
Consequence & remedy
Consequence: THE FUEL LINE MAY SEPARATE AT THE CONNECTION TO THE MAIN FUEL BUNDLE. IF THE FUEL LINE SEPARATES, AN OPERATOR MAY NOTICE A GASOLINE ODOR AND/OR FUEL ON THE GROUND, LOSS OF POWER, AND THE ENGINE WILL EVENTUALLY STALL. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN EXTERNAL RETENTION CLIP AT THE FUEL JUMPER LINE TO THE MAIN FUEL BUNDLE CONNECTION. THE RECALL BEGAN ON JUNE 20, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Illustration