IllustrationSEVERE SHAKING IN FRONT END AROUND 60MPH. TRUCK BECOMES UNCONTROLLABLE AND VERY DANGEROUS. "DEATH SHUDDER"
2012 Ford F-250
Owner reports · Recalls · Investigations
More warning signs than most F-250 years
Owner complaints for the 2012 Ford F-250 are substantially higher than the model-year median of 119.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-250 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
290–25K
3825–50K
2550–75K
2975–100K
46100–150K
31150K+
198 reports with mileage · 68 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 125 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 112 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports5 fire reports4 injury reports
Suspension complaints
125 reportsWHEN TRAVELING AT SPEEDS IN EXCESS OF 50 MILE AN HOUR THE VEHICLE IS SUBJECT TO DOING A DEATH WOBBLE WHEN CROSSING UNEVEN PAVEMENT OR HITTING BUMPS. THE VEHICLE SHAKES SO VIOLENTLY THAT IT BECOMES HARD TO CONTROL AND HAS TO COME TO A STOP TO REGAIN FULL CONTROL. I HAVE THIS NICE TRUCK THAT I HAVE TO AVOID INTERSTATE TRAVEL BECAU…
Read full complaint
WHEN TRAVELING AT SPEEDS IN EXCESS OF 50 MILE AN HOUR THE VEHICLE IS SUBJECT TO DOING A DEATH WOBBLE WHEN CROSSING UNEVEN PAVEMENT OR HITTING BUMPS. THE VEHICLE SHAKES SO VIOLENTLY THAT IT BECOMES HARD TO CONTROL AND HAS TO COME TO A STOP TO REGAIN FULL CONTROL. I HAVE THIS NICE TRUCK THAT I HAVE TO AVOID INTERSTATE TRAVEL BECAUSE OF FEAR OF HURTING MYSELF OR SOMEONE ELSE. I HAVE HAD BEARINGS AND TRACK BAR REPLACED, HAD TRUCK REALIGNED AND TIRES BALANCED TO TRY TO FIX THE PROBLEM WITH NO LUCK. I'M GETTING READY TO PURCHASE A STEERING STABILIZER TO TRY BUT I'M RUNNING OUT OF OPTIONS AND MONEY TO SINK IN TRUCK BUT IT HAS TO BE FIXED. AFTER A LOT OF RESEARCH AND TALKING TO OTHERS WITH SIMILAR PROBLEM IT SOUNDS LIKE FORD NEEDS TO STEP UP AND HAVE A FIX FOR THE PROBLEM. THEY CHARGE PREMIUM PRICES FOR THEIR PRODUCTS BUT MINE HAS TO SET AT THE HOUSE OR TRAVEL BACK ROADS TO STAY SAFE. ANY HELP WOULD BE GREATLY APPRECIATED.
MY TRUCK HAS THE DEATH WOBBLE I BROUGHT THIS ISSUE IN SEVERAL TIMES AT THIS TIME NO ONE COULD TELL ME WHAT THE ISSUES WAS OVER THE YEARS IT BECAME WORSE I FIXED SOME OF THE ISSUE AT MY OWN EXPENSE STILL HAVE ISSUES WORRIED I MAY DIE OR KILL SOMEONE ELSE WHEN THE WOBBLE OCCURS
DRIVING VEHICLE LAST YEAR BOTH MY WIFE AND MYSELF EXPERIENCED WHAT IS NOW KNOW AS 'THE DEATH WOBBLE' WHERE THE FRONT END BEGINS TO SHAKE WILDLY ABOVE APPROX 60 MILES PER HOUR. MADE AN APPOINTMENT WITH MY LOCAL DEALER TO INSPECT/FIX THE PROBLEM AND WAS INFORMED MY VEHICLE WAS EXPERIENCING 'DEATH WOBBLE' (SERVICE ADVISORS WORDS)CO…
Read full complaint
DRIVING VEHICLE LAST YEAR BOTH MY WIFE AND MYSELF EXPERIENCED WHAT IS NOW KNOW AS 'THE DEATH WOBBLE' WHERE THE FRONT END BEGINS TO SHAKE WILDLY ABOVE APPROX 60 MILES PER HOUR. MADE AN APPOINTMENT WITH MY LOCAL DEALER TO INSPECT/FIX THE PROBLEM AND WAS INFORMED MY VEHICLE WAS EXPERIENCING 'DEATH WOBBLE' (SERVICE ADVISORS WORDS)COMMON TO F250'S. OVER 1400 DOLLARS WORTH OF REPAIRS WERE MADE IN JUNE OF 2018. REPORTED SYMPTOMS AGAIN TO MY DEALER WHEN TRUCK WAS BROUGHT IN FOR NORMAL SERVICE. WAS ADVISE STEERING BOX NEEDED TO BE REPLACED WITHIN THE NEXT YEAR. OUR DRIVING HABITS ARE TO AVOID ANY POT HOLES OR OTHER ROAD ANOMALIES WE KNOW ABOUT ON THE HIGHWAYS WE DRIVE ON BECAUSE THE WOBBLE CAN STILL BE FELT. MY PLAN IS TO HAVE THE STEERING BOX REPLACED THIS WEEK WHICH WILL COST OVER 1000 DOLLARS.
BETWEEN 55 AND 65 MPH WHEN YOU HIT A BUMP IN THE ROAD THE TRUCK BEGINS TO SHAKE VIOLENTLY AND YOU ALMOST LOOSE CONTROL. THE ONLY WAY TO RECOVER CONTROL OF THE VEHICLE IS TO SLOW DOWN TO ALMOST A STOP. IT IS CALLED THE DEATH WOBBLE. MY TRUCK IS STOCK FROM THE FACTORY AND ONLY HAS 56,00O MILES ON IT.
TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING ABOVE 55 MPH, THE VEHICLE SUDDENLY EXPERIENCED SEVERE VIBRATION IN THE FRONT SUSPENSION AFTER DRIVING OVER UNEVEN PAVEMENT. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. DURING THE FAILURE THE DRIVER WAS NOT IMMEDIATELY ABLE TO STOP THE VEHICLE WHILE THE …
Read full complaint
TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING ABOVE 55 MPH, THE VEHICLE SUDDENLY EXPERIENCED SEVERE VIBRATION IN THE FRONT SUSPENSION AFTER DRIVING OVER UNEVEN PAVEMENT. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. DURING THE FAILURE THE DRIVER WAS NOT IMMEDIATELY ABLE TO STOP THE VEHICLE WHILE THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER PARAMOUNT FORD OF VALDESE LOCATED (101 MALCOLM BLVD, VALDESE) WHO REPLACED ALL FOUR TIRES AND THE STEERING STABILIZER SHOCK AND BALL JOINTS WERE REPLACE BY THE INDEPENDENT MECHANIC BUT THE FAILURES RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000.
GETTING THE DEATH WOBBLE, HAVE REPLACED THE SHOCKS AND DAMPER, NOT LUCK. THE STEERING WHEEL SHAKES VIOLENTLY SOMETIMES WHEN HIT A BUMP AT 60 MILES PER HOUR. ITS TERRIBLE.
CURRENTLY HAVE 53K MILES. PROBLEM RARE, STARTED AT 10K OR LESS. WITH OUR WILTHOUT PICKUP CAMPER LOADS: AT 60MPH OR HIGHER WHEN HITTING BRIDGE EXPANSION JOINTS OR RR TRACKS (PARTICULARLY AT ANGLES) IN WHICH ONE WHEEL STRIKES IRREGULARITY FIRST, A VIOLENT WHEEL AND STEERING WHEEL SHAKE BEGINS. MUST IMMEDIATLY SLOW VEHICLE TO S…
Read full complaint
CURRENTLY HAVE 53K MILES. PROBLEM RARE, STARTED AT 10K OR LESS. WITH OUR WILTHOUT PICKUP CAMPER LOADS: AT 60MPH OR HIGHER WHEN HITTING BRIDGE EXPANSION JOINTS OR RR TRACKS (PARTICULARLY AT ANGLES) IN WHICH ONE WHEEL STRIKES IRREGULARITY FIRST, A VIOLENT WHEEL AND STEERING WHEEL SHAKE BEGINS. MUST IMMEDIATLY SLOW VEHICLE TO STOP IT. COMPLETE LOSS OF VEHICLE CONTROL WHEN ACTIVE. TOTAL OF PERHAPS 6 OCCURRENCES. CURRENTLY IN SHOP FOR INVESTIGATION. SERIOUS SAFETY ISSUE.
WE HAVE EXPERIENCED DEATH WOBBLE ON THE HIGHWAY MULTIPLE TIMES. THIS IS ABSOLUTELY A SAFETY HAZARD AND NEEDS TO BE ADDRESSED BEFORE SOMEONE IS KILLED. HAVING TO SLOW DOWN RAPIDLY TO 30 MPH ON THE INTERSTATE IS NOT SAFE. OUR TRUCK IS UNDER FORD'S EXTENDED WARRANTY. FIRST THEY BLAMED IT ON THE TIRES SO WE HAD THEM REPLACED …
Read full complaint
WE HAVE EXPERIENCED DEATH WOBBLE ON THE HIGHWAY MULTIPLE TIMES. THIS IS ABSOLUTELY A SAFETY HAZARD AND NEEDS TO BE ADDRESSED BEFORE SOMEONE IS KILLED. HAVING TO SLOW DOWN RAPIDLY TO 30 MPH ON THE INTERSTATE IS NOT SAFE. OUR TRUCK IS UNDER FORD'S EXTENDED WARRANTY. FIRST THEY BLAMED IT ON THE TIRES SO WE HAD THEM REPLACED AND THAT DID NOT FIX IT. NOW, THEY HAVE REPLACED THE ENTIRE FRONT END TWICE WITHOUT A RESOLUTION. THE TRUCK NOW SHAKES SLIGHTLY AT ALL TIMES NO MATTER WHAT SPEED.
THE FRONT OF THE VEHICLE WOULD WOBBLE VIOLENTLY UPON HITTING A BUMP OR HOLE IN THE ROAD AT SPEEDS AS LOW AS 50 MPH. AGGRESSIVE BREAKING WAS REQUIRED TO MAINTAIN CONTROL AND STOP THE WOBBLING.
Official recalls
111V582000 · Power Train:automatic Transmission
Dec 8, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-150 VEHICLES MANUFACTURED FROM SEPTEMBER 9, 2011, THROUGH SEPTEMBER 22, 2011, AND MODEL YEAR 2012 F-250, F-350, F-450 AND F-550 HEAVY DUTY VEHICLES MANUFACTURED FROM SEPTEMBER 12, 2011, THROUGH SEPTEMBER 22, 2011. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 114, THEFT PROTECTION. THE TRANSMISSION CAN BE SHIFTED OUT OF THE PARK POSITION WITHOUT PRESSING THE BRAKE PEDAL DUE TO BRAKE SHIFT INTERLOCK SWITCH PROBLEM.
Consequence & remedy
Consequence: THIS WILL ALLOW THE OPERATOR TO INADVERTENTLY SHIFT THE VEHICLE INTO GEAR WITHOUT THE BRAKE PEDAL BEING DEPRESSED, INCREASING THE RISK OF A CRASH OR INJURY TO A NEARBY PEDESTRIAN.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE BRAKE SHIFT INTERLOCK SWITCH FUNCTION AND REPLACE THE SWITCH IF NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 22, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ14005 · Vehicle Commanded Engine Shutdown
Opened Jan 13, 2015 · Closed Mar 15, 2016
Status: closed (inferred from source dates) · Electrical System:software; Engine; Engine And Engine Cooling:engine:diesel; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Additional source detail variants (5)
Electrical System:software
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:engine:diesel
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:exhaust System:emission Control
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:exhaust System
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.