IllustrationSPONGE BRAKE PEDAL DEALER SAID NOTHING IS WRONG
2012 Ford F-250
Owner reports · Recalls · Investigations
More warning signs than most F-250 years
Owner complaints for the 2012 Ford F-250 are substantially higher than the model-year median of 119.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-250 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
290–25K
3825–50K
2550–75K
2975–100K
46100–150K
31150K+
198 reports with mileage · 68 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 125 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 112 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports5 fire reports4 injury reports
Service Brakes complaints
9 reportsON MARCH 27,2021. I WAS RETURNING FROM A SHOPPING TRIP. I PULLED INTO MY DRIVE WAY PARKED, TURNED OFF THE TRUCK. OPENED DOOR AND IMMEDIATELY SMELLED HOT BRAKES. I TURNED LOOKED TO REAR OF VEHICLE NOTICED SMOKE RISING FROM DRIVER AND PASSENGER SIDE. I IMMEDIATELY GRABBED GARDEN HOSE A SPRAYED DOWN THE BRAKES REAR AND FRONT, WATER…
Read full complaint
ON MARCH 27,2021. I WAS RETURNING FROM A SHOPPING TRIP. I PULLED INTO MY DRIVE WAY PARKED, TURNED OFF THE TRUCK. OPENED DOOR AND IMMEDIATELY SMELLED HOT BRAKES. I TURNED LOOKED TO REAR OF VEHICLE NOTICED SMOKE RISING FROM DRIVER AND PASSENGER SIDE. I IMMEDIATELY GRABBED GARDEN HOSE A SPRAYED DOWN THE BRAKES REAR AND FRONT, WATER TURNED TO STEAM INSTANTLY. AS TO WHEN THE BRAKES LOCKED UP I CANNOT PIN POINT, BUT GOING TO SAY WHEN I TURNED TO MY STREET WHICH IS JUST UNDER 3/4 MILE FROM HOUSE. ONCE I WAS SURE VEHICLE WAS SAFE I CALLED SERVICE DEPARTMENT TO MAKE AN APPOINTMENT TO INITIATE REPAIRS. REPAIRS COMPLETE APRIL 6, 2021. I DID NOT RECEIVE ANY REAL ANSWER AS TO THE CAUSE.
TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING, HE HAD TO SLAM ON THE BRAKES TO AVOID CRASHING INTO A VEHICLE THAT HAD TURNED IN FRONT OF HIM. THE BRAKE PEDAL WENT SOFT WHILE PRESSED DOWN. THE VEHICLE WAS TAKEN TO RON TIRAPELLI FORD (4355 W. JEFFERSON ST, SHOREWOOD, IL 60404, (815) 725-3033). THE D…
Read full complaint
TL* THE CONTACT OWNS A 2012 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING, HE HAD TO SLAM ON THE BRAKES TO AVOID CRASHING INTO A VEHICLE THAT HAD TURNED IN FRONT OF HIM. THE BRAKE PEDAL WENT SOFT WHILE PRESSED DOWN. THE VEHICLE WAS TAKEN TO RON TIRAPELLI FORD (4355 W. JEFFERSON ST, SHOREWOOD, IL 60404, (815) 725-3033). THE DEALER CHECKED THE BRAKES AND RECOMMENDED THAT THE BRAKE PADS BE CHANGED AND THE BRAKE LINES BE BLED TO REMOVE AIR IN THE SYSTEM. THE CONTACT PICKED UP THE VEHICLE AND TESTED THE BRAKE PEDAL AND THE BRAKE PEDAL WENT DOWN TO THE FLOORBOARD. THE CONTACT HAD THE MANAGER STEP ON THE BRAKE PEDAL AND IT WENT DOWN TO THE FLOOR. THE DEALER MADE AN APPOINTMENT THE NEXT DAY AND PROVIDED COMPLETE SERVICE CHECK. THE FAILURE RECURRED AGAIN WHILE DRIVING 45 MPH. THE CONTACT TOOK THE VEHICLE BACK TO THE SAME HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 95,000. THE VIN WAS NOT AVAILABLE.
SOFT PEDAL, BRAKE SYSTEM PEDAL PRESSURE HAS MOVEMENT WHEN STARTING. WHILE DRIVING HAS LIMITED STOPPING POWER.
THE VEHICLE'S ENGINE WILL STALL (CUT OFF) WITHOUT ANY INDICATION OR NOTICE DURING MOTION OR AT A STOP. THIS HAS HAPPENED AT CITY SPEEDS (LESS THAN 25 MPH) AND AT HIGHWAY SPEEDS (GREATER THAN 55 MPH) THE VEHICLE WILL NOT IMMEDIATELY START BUT MAY START AFTER STANDING FOR SOME TIME. THIS CAUSES POWER STEERING, POWER BRAKES AND…
Read full complaint
THE VEHICLE'S ENGINE WILL STALL (CUT OFF) WITHOUT ANY INDICATION OR NOTICE DURING MOTION OR AT A STOP. THIS HAS HAPPENED AT CITY SPEEDS (LESS THAN 25 MPH) AND AT HIGHWAY SPEEDS (GREATER THAN 55 MPH) THE VEHICLE WILL NOT IMMEDIATELY START BUT MAY START AFTER STANDING FOR SOME TIME. THIS CAUSES POWER STEERING, POWER BRAKES AND OTHER IMPORTANT SAFETY FEATURES TO BE DEGRADED OR LOST.
WE WENT TO SLOW DOWN AND THE BRAKES DIDN'T FEEL RIGHT AND WASN'T STOPPING THE TRUCK BY THE TIME WE DID STOP THE BRAKES WHERE SMOKING. *TR
WE CAME TO A RED LIGHT AND THE BRAKES FAILED TO STOP WE HAD TO PUT THE TRUCK TO A SUDDEN STOP BY USING THE TRAILER SWITCH. WE CALLED THE DEALER BUT THEY SAID THEY COULDN'T HELP SO WE HAD TO MAKE THE REPAIRS ON A BACK ROAD WE COULD NOT FIND ANY COMPANY WILLING TO TOW TRUCK AND TRAILER SO WE GOT A RIDE TO A PARTS STORE AND GOT TH…
Read full complaint
WE CAME TO A RED LIGHT AND THE BRAKES FAILED TO STOP WE HAD TO PUT THE TRUCK TO A SUDDEN STOP BY USING THE TRAILER SWITCH. WE CALLED THE DEALER BUT THEY SAID THEY COULDN'T HELP SO WE HAD TO MAKE THE REPAIRS ON A BACK ROAD WE COULD NOT FIND ANY COMPANY WILLING TO TOW TRUCK AND TRAILER SO WE GOT A RIDE TO A PARTS STORE AND GOT THE PARTS OEM BRAKE PADS AND CALIPERS, PROBLEM IS THE TRUCK IS SHOWING SIGNS OF SAME ISSUE WITH 130 MILES ON REPAIR. *TR
WHEN DRIVING DOWN THE ROAD AND I START TO BRAKE THE VEHICLE MY FOOT TRAVELS HALF THE DISTANCE TO THE FLOOR BEFORE THE BRAKES ENGAGE AND START TO STOP VEHICLE. THIS HAPPENS ON HIGHWAY AND RESIDENTIAL DRIVING. MADE MY CONCERNS KNOWN TO FORD DEALER BUT I GET A PRINTOUT OF HOW "NEW" BRAKES WORK. WHEN I MADE IT CLEAR TO AVOID ACCID…
Read full complaint
WHEN DRIVING DOWN THE ROAD AND I START TO BRAKE THE VEHICLE MY FOOT TRAVELS HALF THE DISTANCE TO THE FLOOR BEFORE THE BRAKES ENGAGE AND START TO STOP VEHICLE. THIS HAPPENS ON HIGHWAY AND RESIDENTIAL DRIVING. MADE MY CONCERNS KNOWN TO FORD DEALER BUT I GET A PRINTOUT OF HOW "NEW" BRAKES WORK. WHEN I MADE IT CLEAR TO AVOID ACCIDENTS I HAD TO PUMP BRAKES IN ORDER TO ENGAGE BRAKES TO STOP VEHICLE, DEALER AGAIN INDICATES THAT IS THE WAY IT IS TO WORK. HAD DEALER SERVICE REPRESENTATIVE CLIMBED INTO TRUCK AND DEPRESS BRAKES WHILE VEHICLE WAS STOPPED WITH TRANSMISSION IN PARKED AND DECLARED "NO PROBLEMS" AND "BRAKES WORKED AS IT SHOULD". WHEN I AGIAN MENTION IT ONLY HAPPENS WHEN DRIVING OR VEHICLE IN MOTION, DEALER AGAIN ADVISES THIS IS THE NEW BOOSTER. I HAVE REPEATEDLY MENTION THAT THE BRAKES OR BOOSTER ARE DEFECTIVE I GET NO REPONSE FROM DEALER. REQUEST NHTSA INVESTIGATE THE PROBLEMS WITH THE BRAKES. I HAVE AVOIDED ACCIDENTS BY PUMPING BRAKE PEDAL TO ENGAGE BRAKES SOONER. *TR
I DROVE THRU 12" OF SNOW ON MY ROAD TO MY HOME. THE BRAKE PEDAL WENT TO THE FLOOR AND I HAD NO BRAKING POWER AT ALL. I CHECKED IF THERE WAS ANY LEAKS AND THERE WERE NONE. THE TEMP WAS ABOUT 20 DEGREES AT THIS TIME. I WAITED UNTIL THE NEXT DAY WHEN THE TEMP WAS AT 30 DEGREES AND TRIED THE BRAKES AGAIN AND THEY WERE AT FULL ST…
Read full complaint
I DROVE THRU 12" OF SNOW ON MY ROAD TO MY HOME. THE BRAKE PEDAL WENT TO THE FLOOR AND I HAD NO BRAKING POWER AT ALL. I CHECKED IF THERE WAS ANY LEAKS AND THERE WERE NONE. THE TEMP WAS ABOUT 20 DEGREES AT THIS TIME. I WAITED UNTIL THE NEXT DAY WHEN THE TEMP WAS AT 30 DEGREES AND TRIED THE BRAKES AGAIN AND THEY WERE AT FULL STRENGTH. I CALLED DEALER AND WAS TOLD THEY NEVER HEARD OF PROBLEM BEFORE. I CALLED FORD CUST CARE DEPT AND DESCRIBED WHAT HAPPENED. THEY TOLD ME THAT THEY WOULD NEED TO DUPLICATE THE BRAKE ISSUE TO REPAIR IT.. AT THIS POINT NEITHER DEALER OR FORD IS WILLING TO DRILL DOWN TO FIND OUT WHAT HAD HAPPENED. I DO NOT FEEL SAFE IN THIS VEHICLE AT THIS TIME. *TR
Official recalls
111V582000 · Power Train:automatic Transmission
Dec 8, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-150 VEHICLES MANUFACTURED FROM SEPTEMBER 9, 2011, THROUGH SEPTEMBER 22, 2011, AND MODEL YEAR 2012 F-250, F-350, F-450 AND F-550 HEAVY DUTY VEHICLES MANUFACTURED FROM SEPTEMBER 12, 2011, THROUGH SEPTEMBER 22, 2011. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 114, THEFT PROTECTION. THE TRANSMISSION CAN BE SHIFTED OUT OF THE PARK POSITION WITHOUT PRESSING THE BRAKE PEDAL DUE TO BRAKE SHIFT INTERLOCK SWITCH PROBLEM.
Consequence & remedy
Consequence: THIS WILL ALLOW THE OPERATOR TO INADVERTENTLY SHIFT THE VEHICLE INTO GEAR WITHOUT THE BRAKE PEDAL BEING DEPRESSED, INCREASING THE RISK OF A CRASH OR INJURY TO A NEARBY PEDESTRIAN.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE BRAKE SHIFT INTERLOCK SWITCH FUNCTION AND REPLACE THE SWITCH IF NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 22, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ14005 · Vehicle Commanded Engine Shutdown
Opened Jan 13, 2015 · Closed Mar 15, 2016
Status: closed (inferred from source dates) · Electrical System:software; Engine; Engine And Engine Cooling:engine:diesel; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Additional source detail variants (5)
Electrical System:software
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:engine:diesel
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:exhaust System:emission Control
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:exhaust System
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.