Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
2325–50K
2350–75K
1175–100K
30100–150K
13150K+
122 reports with mileage · 22 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports3 fire reports1 injury reports
What owners actually said
144 reports
129,000 miles · Oct 12, 2011
Suspension
MY FORD F250 HAS A VERY DANGEROUS WOBBLE WHEN I HIT A BUMP ON THE HIGHWAY. I HAVE CHECKED THE TIRE PRESSURE AND ALL FOUR TIRES ARE FINE. AFTER DOING SOME RESEARCH I HAD FOUND THAT THIS IS A ON GOING PROBLEM WITH THE FORD SD TRUCKS. SOMETHING HAS TO BE DONE OR SOMEONE IS GOING TO GET KILLED DUE TO A BAD ACCIDENT. EVERY DEALER THA…
Read full complaint
MY FORD F250 HAS A VERY DANGEROUS WOBBLE WHEN I HIT A BUMP ON THE HIGHWAY. I HAVE CHECKED THE TIRE PRESSURE AND ALL FOUR TIRES ARE FINE. AFTER DOING SOME RESEARCH I HAD FOUND THAT THIS IS A ON GOING PROBLEM WITH THE FORD SD TRUCKS. SOMETHING HAS TO BE DONE OR SOMEONE IS GOING TO GET KILLED DUE TO A BAD ACCIDENT. EVERY DEALER THAT I TALK TO HAS NEVER HEARD OF THIS PROBLEM BUT YET I SEE IT POSTED ALL OVER THE INTERNET. I AM VERY UPSET AND I AM GOING TO TAKE LEGAL ACTION. *KB
NHTSA ODI #10429550
20,000 miles · Oct 3, 2011
Engine And Engine CoolingStructure
FRAME IS RUSTING, HEADERS ARE LEAKING FROM RUST. *TR
NHTSA ODI #10428260
50,035 miles · Sep 27, 2011
SteeringSuspension
CRUISING ALONG THE HIGHWAY, IF I HIT A BUMP IN THE ROAD DOING ANY SPEED OVER 55 MPH THE TRUCK BEGINS TO SHAKE VERY BADLY!! SO BAD THAT I CAN HARDLY CONTROL THE TRUCK. ONLY WAY TO MAKE IT STOP IS TO SLOW TO 40 MPH. VERY UNSAFE TO DRIVE ON ANY HIGHWAY!! THERE IS NO BAD PARTS ON THIS TRUCK...
NHTSA ODI #10428509
105,000 miles · Sep 17, 2011
Fuel System, Gasoline
STALLS OUT AFTER HOT RUN AND WONT RESTART UNTIL COOLS DOWN AND SOMETIMES AFTER COOL DOWN IT WONT START WITHOUT USING ASTARTER FLUID.STARTS STALLING AROUND 60 MPH.THIS IS A 6.0 DIESEL TRUCK.HAS STOPPED RUNNING RUNNING DOWN THE ROAD AFTER YOU LET OFF GAS PEDAL.HAVE NOTIFIED FORD OF THIS PROBLEM AND FOUND THAT THERE WAS A RECALL ON…
Read full complaint
STALLS OUT AFTER HOT RUN AND WONT RESTART UNTIL COOLS DOWN AND SOMETIMES AFTER COOL DOWN IT WONT START WITHOUT USING ASTARTER FLUID.STARTS STALLING AROUND 60 MPH.THIS IS A 6.0 DIESEL TRUCK.HAS STOPPED RUNNING RUNNING DOWN THE ROAD AFTER YOU LET OFF GAS PEDAL.HAVE NOTIFIED FORD OF THIS PROBLEM AND FOUND THAT THERE WAS A RECALL ON THIS TRUCK.WAS TOLD THAT THERE IS NOT A RECALL BY FORD WHEN I CALLED THEM. *TT
NHTSA ODI #10425848
60,000 miles · Sep 12, 2011
SteeringSuspension
DURING HIGHWAY SPEEDS AND YOU HIT A SET OF BUMPS OR A SINGLE BUMP MY TRUCK WILL VIOLENTLY SHAKE AT THE FRONT END. IT FEELS LIKE THE WHOLE FRONT END OF THE TRUCK IS COMING APART! FORD WILL NOT ADMIT ANYTHING IS WRONG.. THERE ARE COUNTLESS ENTRIES ABOUT THIS ALL OVER THE WEB.. IS SOMEBODY GOING TO DO SOMETHING?? *TR
NHTSA ODI #10424761
65,000 miles · Aug 10, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE VEHICLE WOULD OVERHEAT AND THEN STALL. THE VEHICLE WOULD NOT RESTART AFTER THE FAILURES. BOTH THE DEALER AND MANUFACTURER WERE AWARE OF THE FAILURE; HOWEVER, THEY DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC, WHO REPLACED THE HIGH PR…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE VEHICLE WOULD OVERHEAT AND THEN STALL. THE VEHICLE WOULD NOT RESTART AFTER THE FAILURES. BOTH THE DEALER AND MANUFACTURER WERE AWARE OF THE FAILURE; HOWEVER, THEY DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC, WHO REPLACED THE HIGH PRESSURE OIL PUMP, OIL SENDING UNIT, FUEL INJECTION CONTROL MODULE, AND THE EGR COOLER. AS A RESULT, THE HEAD GASKET BLEW OUT. NO ADDITIONAL REPAIRS WERE PERFORMED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 114,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10418376
18,723 miles · Jul 24, 2011
SteeringSuspension
MY KIDS AND I WERE DRIVING ON I-70 WEST COMING FROM CAMBRIDGE OHIO TO COLUMBUS. WE HIT A ROUGH SPOT IN THE ROAD AND THE FRONT END STARTED SHAKING VIOLENTLY FROM SIDE TO SIDE. THE WHOLE TRUCK WAS SHAKING. I LET MY FOOT OFF THE ACCELERATOR AND CHANGED LANES. THIS DID NOT STOP THE SHAKING. I WENT OFF ON THE BERM AND CONTINUED TO S…
Read full complaint
MY KIDS AND I WERE DRIVING ON I-70 WEST COMING FROM CAMBRIDGE OHIO TO COLUMBUS. WE HIT A ROUGH SPOT IN THE ROAD AND THE FRONT END STARTED SHAKING VIOLENTLY FROM SIDE TO SIDE. THE WHOLE TRUCK WAS SHAKING. I LET MY FOOT OFF THE ACCELERATOR AND CHANGED LANES. THIS DID NOT STOP THE SHAKING. I WENT OFF ON THE BERM AND CONTINUED TO SLOW DOWN. AT APPROX. 35-40 MPH IT STOPPED SHAKING. I CHECKED THE TIRES AND ALL WERE FINE. WE PROCEEDED ON AND ROUGHLY 10 MILES DOWN THE ROAD IT DID IT AGAIN. I AGAIN TOOK MY FOOT OFF THE GAS AND HEADED TOWARDS THE BERM, I DID TRY HITTING THE BRAKES THIS TIME. BRAKES MADE NO DIFFERENCE. THE SHAKING DID NOT STOP UNTIL WE WERE BETWEEN 35 AND 40 MPH. I HAVE OWNED THIS TRUCK SINCE IT HAD 5,000 MILES ON IT AND HAVE TRAVELED THIS ROAD MANY TIMES. THE TRUCK HAS ALWAYS BOUNCED AROUND WHEN HITTING ROUGH ROAD SURFACES, HOWEVER, IT STOPPED ONCE PAST THE ROUGH SPOT. MY TRUCK IS ONLY USED OCCASIONALLY AND HAS ALL OF ITS ORIGINAL COMPONENTS IT LEFT THE FACTORY WITH, INCLUDING THE TIRES. I CAN NOT FIND ANY LOOSE TIE ROD ENDS. ONCE I GOT HOME I TURNED OFF THE TRUCK AND WHEN I WENT TO RESTART IT TO PULL INTO THE GARAGE THE BATTERY WAS COMPLETELY DEAD. THIS COULD OF BEEN TOTALLY COINCIDENCE, HOWEVER, I BELIEVE THE VIOLENT SHAKING CAUSED A BATTERY PLATE TO SHORT OUT. IN MY OPINION THIS IS COMPLETELY UNACCEPTABLE AND IS NOT A SAFE CONDITION FOR ANYONE TO BE IN AT HIGHWAY SPEEDS. IF MY WIFE HAD BEEN DRIVING, SHE WOULD NOT HAVE BEEN ABLE TO CONTROL THE VEHICLE. I APPRECIATE YOUR PROMPT ATTENTION TO THIS MATTER AS IT COULD HAVE VERY SERIOUS AND UNFORTUNATE CONSEQUENCES FOR OTHER OWNERS WHO COULD EXPERIENCE THIS PROBLEM, AT ANY TIME, WITHOUT WARNING.
NHTSA ODI #10415851
68,783 miles · Jul 5, 2011
Tires
TIRE TREAD SEPARATION AND SUBSEQUENT BLOWOUT WHILE TOWING A TRAILER. SECOND TIME IN SIX WEEKS WITH THIS TYPE TIRE/MILEAGE. *KB
NHTSA ODI #10410493
68,000 miles · May 2, 2011
Steering
TL*THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH WHEN THE STEERING WHEEL SUDDENLY VEERED TO THE RIGHT. AS HE CORRECTED THE STEERING WHEEL IT VEERED TO THE LEFT SENDING HIM ACROSS TWO LANES OF TRAFFIC AND DROVE INTO THE MEDIAN. THE VEHICLE WAS TAKEN TO A DEALER WHO ADVISED HIM THA…
Read full complaint
TL*THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH WHEN THE STEERING WHEEL SUDDENLY VEERED TO THE RIGHT. AS HE CORRECTED THE STEERING WHEEL IT VEERED TO THE LEFT SENDING HIM ACROSS TWO LANES OF TRAFFIC AND DROVE INTO THE MEDIAN. THE VEHICLE WAS TAKEN TO A DEALER WHO ADVISED HIM THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 68,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10398511
74,950 miles · Apr 20, 2011
Fuel System, Gasoline
THE FUEL INJECTION CONTROL MODULE (FICM) FAILED ON MY TRUCK, CAUSING THE ENGINE TO NOT START OR RUN. THIS IS A VERY COMMON COMPONENT FAILURE FOR THE 6.0L DIESEL ENGINE. IF IT FAILS WHEN THE VEHICLE IS BEING DRIVEN, IT COULD CAUSE LOSS OF CONTROL, LOSS OF POWER STEERING, LOSS OF BRAKING CAPABILITY. FORD MUST BE AWARE OF THE CO…
Read full complaint
THE FUEL INJECTION CONTROL MODULE (FICM) FAILED ON MY TRUCK, CAUSING THE ENGINE TO NOT START OR RUN. THIS IS A VERY COMMON COMPONENT FAILURE FOR THE 6.0L DIESEL ENGINE. IF IT FAILS WHEN THE VEHICLE IS BEING DRIVEN, IT COULD CAUSE LOSS OF CONTROL, LOSS OF POWER STEERING, LOSS OF BRAKING CAPABILITY. FORD MUST BE AWARE OF THE COMMON FAILURE OF THIS COMPONENT, YET NO RECALL TO REPLACE THESE FAULTY MODULES HAS BEEN ISSUED. IN THE INTEREST OF PUBLIC SAFETY, I REQUEST THAT FORD BE REQUIRED TO REPLACE ALL EXISTING FICM'S ON THE 6.0L DIESEL ENGINE WITH ONE OF BETTER QUALITY, AND REIMBURSE ALL OWNERS OF THESE VEHICLES THAT HAVE ALREADY PAID THE EXCESSIVE REPAIR COSTS, COMMONLY OVER $1000, TO HAVE THEIR FAILED FICM'S REPLACED.
NHTSA ODI #10397721
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
2005 Ford F-250 Problems, Complaints & Recalls | Skip That Year
Illustration