NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
19 reportsClear category filterMileage unknown · Feb 2, 2001
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
THE BRAKES WERE REPAIRED SEVERAL TIMES BECAUSE THEY DID NOT STOP THE TRUCK WHICH WAS USED FOR PULLING A TRAILER, THE CONSUMER TOOK THE VEHICLE TO ANOTHER DEALER WHO FIXED THE PROBLEM BY FIXING THE RABS VALVE, NOW THE VEHICLE CAN BE STOPPED PROPERLY, THE CONSUER REQUEST REIMBURSEMET FOR THE MONEY SPENT TRYING TO CORRECT THE BRAK…
Read full complaint
THE BRAKES WERE REPAIRED SEVERAL TIMES BECAUSE THEY DID NOT STOP THE TRUCK WHICH WAS USED FOR PULLING A TRAILER, THE CONSUMER TOOK THE VEHICLE TO ANOTHER DEALER WHO FIXED THE PROBLEM BY FIXING THE RABS VALVE, NOW THE VEHICLE CAN BE STOPPED PROPERLY, THE CONSUER REQUEST REIMBURSEMET FOR THE MONEY SPENT TRYING TO CORRECT THE BRAKING PROBLEM. NLM
NHTSA ODI #559389
Mileage unknown · Oct 19, 2000
Service Brakes, Hydraulic
BRAKE LINE BROKE, THERE IS ONLY MORE FOR FRONT & BACK
NHTSA ODI #734771
Mileage unknown · Nov 16, 1998
Service Brakes, Hydraulic
ON NOVEMBER 13, 1998 I TOOK MY 1992 FORD F250 4X4 PICKUP TO THE TOM DENCHEL FORD DEALERSHIP IN PROCESSOR, WASHINGTON TO GET THE 60,000 MILE SERVICE. A SHORT TIME AFTER I LEFT THE TRUCK THERE I GOT A PHONE CALL FROM THE SERVICE MANAGER, DOUGLAS BUTLER. HE SAID THAT I HAD A PROBLEM WITH THE REAR BRAKES. ONE SIDE LEAKED OIL ONT…
Read full complaint
ON NOVEMBER 13, 1998 I TOOK MY 1992 FORD F250 4X4 PICKUP TO THE TOM DENCHEL FORD DEALERSHIP IN PROCESSOR, WASHINGTON TO GET THE 60,000 MILE SERVICE. A SHORT TIME AFTER I LEFT THE TRUCK THERE I GOT A PHONE CALL FROM THE SERVICE MANAGER, DOUGLAS BUTLER. HE SAID THAT I HAD A PROBLEM WITH THE REAR BRAKES. ONE SIDE LEAKED OIL ONTO THE BRAKE LINING. HE RECOMMENDED THAT AN UPDATED BEARING AND SEAL SHOULD BE INSTALLED, THE DRUM TURNED AND NEW BRAKES PUT IN. OF COURSE HE RECOMMENDED HAVING BOTH SIDES DONE, WHICH I APPROVED. THE TOTAL COST INCLUDING BOTH PARTS AND LABOR WAS APPROXIMATELY $580. I HAD JUST TAKEN MY CAMPER OFF THE TRUCK AND NOTICED THAT WHEN I BRAKED ONE OF THE REAR WHEELS WOULD LOCK UP. I DIDN'T THINK MUCH ABOUT THIS UNTIL THE SERVICE. WHEN I PICKED THE VEHICLE UP I ASKED MR. BUTLER IF THIS WAS A KNOWN PROBLEM TO FORD AND HE SAID YES. A SERVICE BULLETIN HAD BEEN ISSUED. HE SAID THAT HE HAD TO MAKE THE BEARING AND SEAL REPAIR ON A REGULAR BASIS. I DON'T HAVE THE SERVICE BULLETIN NUMBER BUT THE NUMBER OF THE SERVICE KIT IS F4TZ-1177-C. ON PAGE 1 OF THE SERVICE KIT AN IMPORTANT NOTICE STATES: THE PURPOSE OF THIS KIT IS TO UPGRADE THE FORD DESIGN 10.25-INCH RING GEAR AXLE FULL FLOAT HUB TO THE LATEST DESIGN. THIS KIT IS NOT REQUIRED IF, AFTER DISASSEMBLY, YOU DISCOVER THE HUB CONTAINS AN OIL SLINGER AS SHOWN IN FIGURE 1. IF THE HUB DOES NOT CONTAIN AN OIL SLINGER, CONTINUE WITH PROCEDURE. SINCE THE ORIGINAL DESIGN WAS FLAWED AND COULD HAVE CAUSED A BRAKING FAILURE I RECOMMEND THAT FORD VOLUNTARILY RECALL ALL TRUCKS WITH THIS PROBLEM AND FIX AT THEIR COST. THEY SHOULD ALSO REIMBURSE ME FOR MY COSTS.
NHTSA ODI #700634
Mileage unknown · Jun 30, 1997
Power TrainService Brakes, Hydraulic
THE RIGHT BACK WHEEL SEAL IS LEAKING OIL ONTO THE BRAKE, AND WHEN APPLYING THE BRAKES, CAUSES THE BRAKES NOT TO GRAB. DEALER IS AWARE OF PROBLEM. PROBLEM HAS NOT BEEN CORRECTED. *AK
NHTSA ODI #813647
Mileage unknown · Jun 10, 1997
EquipmentService Brakes, HydraulicSuspension
BRAKE CALIPERS CRACKED.
NHTSA ODI #518302
Mileage unknown · Mar 19, 1997
Service Brakes, Hydraulic
WHEN APPLYING ABS BRAKES AT LOW SPEEDS, THE FRONT BRAKES ARE LOCKING UP. *AK
NHTSA ODI #808457
Mileage unknown · Feb 14, 1997
Service Brakes, Hydraulic
BRAKES ARE NOT STOPPING THE TRUCK FULLY.(REAR BRAKES). *AK
NHTSA ODI #808984
Mileage unknown · Dec 2, 1996
Service Brakes, Hydraulic
BRAKES HAVE BEEN REPLACED SEVERAL TIMES.
NHTSA ODI #511969
Mileage unknown · Apr 23, 1996
Power TrainService Brakes, HydraulicSuspension
AXLES SEALS LEAK, CAUSING REAR BRAKES TO FAIL FOUR TIMES.
NHTSA ODI #601427
Mileage unknown · Mar 19, 1996
Service Brakes, Hydraulic
PURCHASED TRUCK NEW THE HYDRAULIC BRAKE WAS REPLACED FOUR TIMES AND ISON ITS FIFTH ONE. PLEASE DESCRIBE . *AK
NHTSA ODI #980909
NHTSA investigations
9EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
EA95012 · Failure Of Serpentine Belt
Opened Mar 31, 1995 · Closed May 28, 1996
Status: closed (inferred from source dates) · Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Additional source detail variants (2)
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE93015 · Parking Brake Failure
Opened Mar 9, 1993 · Closed Jul 27, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92055 · Engine Compartment Fires
Opened Jun 24, 1992 · Closed Aug 20, 1992
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
Illustration