CLUTCH WILL SLIP DURING OPERATION WHEN PULLING A BOAT OUT OF THE WATER AND ONTO A TRAILER. ALSO, OVERDRIVE LIGHT ON THE INSTRUMENT PANEL WILL INTERMITTENTLY ILLUMINATE. DEALERSHIP REPLACED TRANSMISSION AT 30,000 MILES, AND HAS CHANGED COMPUTER CODES SEVERAL TIMES. THESE REPAIRS HAVE FAILED TO EFFECTIVELY REMEDY THE PROBLE…
Read full complaint
CLUTCH WILL SLIP DURING OPERATION WHEN PULLING A BOAT OUT OF THE WATER AND ONTO A TRAILER. ALSO, OVERDRIVE LIGHT ON THE INSTRUMENT PANEL WILL INTERMITTENTLY ILLUMINATE. DEALERSHIP REPLACED TRANSMISSION AT 30,000 MILES, AND HAS CHANGED COMPUTER CODES SEVERAL TIMES. THESE REPAIRS HAVE FAILED TO EFFECTIVELY REMEDY THE PROBLEM. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION.*AK
NHTSA ODI #8003162
Mileage unknown · Feb 2, 2001
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
THE BRAKES WERE REPAIRED SEVERAL TIMES BECAUSE THEY DID NOT STOP THE TRUCK WHICH WAS USED FOR PULLING A TRAILER, THE CONSUMER TOOK THE VEHICLE TO ANOTHER DEALER WHO FIXED THE PROBLEM BY FIXING THE RABS VALVE, NOW THE VEHICLE CAN BE STOPPED PROPERLY, THE CONSUER REQUEST REIMBURSEMET FOR THE MONEY SPENT TRYING TO CORRECT THE BRAK…
Read full complaint
THE BRAKES WERE REPAIRED SEVERAL TIMES BECAUSE THEY DID NOT STOP THE TRUCK WHICH WAS USED FOR PULLING A TRAILER, THE CONSUMER TOOK THE VEHICLE TO ANOTHER DEALER WHO FIXED THE PROBLEM BY FIXING THE RABS VALVE, NOW THE VEHICLE CAN BE STOPPED PROPERLY, THE CONSUER REQUEST REIMBURSEMET FOR THE MONEY SPENT TRYING TO CORRECT THE BRAKING PROBLEM. NLM
NHTSA ODI #559389
Mileage unknown · Jan 3, 2001
Power Train
GEAR SHIFT SHAFT BROKE. NLM
NHTSA ODI #785226
Mileage unknown · Dec 28, 2000
Power Train
GEAR SHIFT SHAFT FAILED WHEN CONSUMER SHIFTED INTO DRIVE, CONSUMER BELIEVES THIS IS POORLY DESIGNED. NLM
NHTSA ODI #785199
Mileage unknown · Oct 28, 2000
Power Train
THIS IS THE THIRD TRANSMISSIONS FAILURE CAUSED BY PRE-MATURE TORQUE CONVERTER BUSHING FAILURE, CREATING EXCESSIVE HEAT AND PUMP MELT-DOWN AND TRANSMISSION FAILURE.*AK
NHTSA ODI #735315
Mileage unknown · Jul 31, 2000
Power Train
SPEEDOMETER HAS GONE BAD/MALFUNCTIONED, CAUSING SPEEDOMETER READING TO BE INACCURATE DUE TO INCORRECT LANGUAGE THAT SPEEDOMETER IS READING, ALSO, DUE TO MALFUNCTIONED SPEEDOMETER, ONE CANNOT DETERMINE THE ACTUAL SPEED TRAVELING. CONSUMER HAS CONTACTED DEALER. *AK
NHTSA ODI #866287
Mileage unknown · Apr 15, 2000
Power Train
TRANSMISSION WILL GO TO NEUTRAL WHILE BEING DRIVEN. USUALLY OCCURS AFTER 30 OR MORE MINUTES OF DRIVING AND UNDER LIGHT OR CRUISE LOAD. AFTER INCIDENT, IT USUALLY DOES NOT HAPPEN AGAIN UNTIL NEXT WARM UP CYCLE THE FOLLOWING DAY, WEEK OR MONTH. OCCURRENCES HAVE BEEN EVERY FEW MONTHS FOR THE PAST 3 YEARS. MOST RECENT OCC…
Read full complaint
TRANSMISSION WILL GO TO NEUTRAL WHILE BEING DRIVEN. USUALLY OCCURS AFTER 30 OR MORE MINUTES OF DRIVING AND UNDER LIGHT OR CRUISE LOAD. AFTER INCIDENT, IT USUALLY DOES NOT HAPPEN AGAIN UNTIL NEXT WARM UP CYCLE THE FOLLOWING DAY, WEEK OR MONTH. OCCURRENCES HAVE BEEN EVERY FEW MONTHS FOR THE PAST 3 YEARS. MOST RECENT OCCURRENCE WAS SEVERE WITH 3 CYCLES OF JUMPING TO NEUTRAL AND BACK INTO GEAR QUICKLY ONE AFTER THE OTHER FOLLOWING ABOUT 45 MINUTES OF DRIVING. FOR THE REMAINDER OF THE DRIVE (ABOUT 20 MINUTES) OPERATION WAS NORMAL. WE ARE NOW CONCERNED TOTAL FAILURE IS IMMINENT. *AK
NHTSA ODI #721487
Mileage unknown · Feb 11, 2000
Power Train
SECOND TIME REVERSE HAS GONE OUT. FIRST TIME HAD AROUND 37000 MILES ON IT. *AK
NHTSA ODI #718616
Mileage unknown · Jan 29, 1999
Power Train
TRANSMISSION LOCKED UP WHILE DRIVING ON DRY GRAVEL. DEALER CONTACTED AND IS AWARE OF PROBLEM, STATES THIS HAPPENS ONCE IN A WHILE. REPAIRWORK TO REPLACE NEW TRANSMISSION TO BE DONE AT OWNER'S EXPENSE. *AK.ET.
NHTSA ODI #834269
Mileage unknown · Jan 21, 1999
Power Train
COMPLETE TRANSMISSION FAILURE CAUSING OVERHEATING AND WARPING.
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
Consequence & remedy
Consequence: SPILLED FUEL CAN RESULT IN A FIRE WHEN EXPOSED TO ASOURCE OF IGNITION.
Remedy: REPLACEMENT OF THE FUEL PRESSURE REGULATOR AND INSTALLATION OF REDUNDANT CHECK VALVES.
WATER CAN ENTER THE DOOR LATCH RELEASE CABLE. IF THE VEHICLE IS OPERATED IN BELOW FREEZING TEMPERATURES, THE WATER IN THE DOOR LATCH RELEASE CABLE CAN FREEZE AND CAUSE THE LATCH MECHANISM TO MALFUNCTION.
Consequence & remedy
Consequence: THE MALFUNCTION OF THE DOOR LATCH RELEASE CAN RESULT INTHREE DIFFERENT PROBLEMS: 1) THE DOOR WILL NOT BE ABLE TO BE RELATCHED, 2) THEINSIDE DOOR HANDLE CAN BECOME INOPERATIVE, AND 3) THE DOOR COULD APPEAR TO BELATCHED WHEN IT IS NOT, ALLOWING THE DOOR TO OPEN UNEXPECTEDLY IF IT IS JARRED,AND INCREASING THE RISK OF INJURY TO THE ADJACENT SEAT OCCUPANT.
Remedy: REVISED DOOR RELEASE CABLES AND WATER SHIELDS WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9
EA99032 · Dual Fuel Tank Crossflow/leakage
Opened Nov 4, 1999 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Additional source detail variants (2)
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
Vehicle Speed Control:linkages
ON JULY 14, 1993 FORD FILED A DEFECT INFORMATION REPORT CONCERNING FUEL TANK CROSS FLOW LEAKAGE ON F-SERIES LIGHT TRUCKS AND CAB CHASSIS BUILT FROM JULY 22, 1989 THROUGH DECEMBER 17, 1992.THE REMEDY WAS TO REPLACE THE FUEL PRESSURE REGULATOR AND INSTALL A CHECK VALVE BETWEEN EACH FUEL SUPPLY LINE AND FUEL TANK (2) TO REPAIR THE SUPPLY SIDE FUEL CROSS FLOW PROBLEM (RECALL 93V-125).ODI OPENED RQ98-008 ON MAY 29, 1998 BECAUSE OF THE LARGE NUMBER OF ALLEGED REMEDY FAILURES AND REPORTS OF FUEL CROSS FLOW ON VEHICLES OUTSIDE OF THE RECALL POPULATION.BASED ONTHE INFORMATION RECEIVED FROM FORD ON AUGUST 11, SEPTEMBER 30, AND DECEMBER 15, 1998, AND THE INCREASING TREND OF REMEDY FAILURES AND OUT OF SCOPE CROSSFLOW REPORTS, ODI OPENED EA99-032 ON NOVEMBER 4, 1999.THE ATTACHED ENGINEERING ANALYSIS CLOSING REPORT FULLY DESCRIBES THE RESULTS OF THIS INVESTIGATION AND REASON FOR CLOSING.THE SUBJECT VEHICLES CAN EXPERIENCE FUEL TRANSFER FROM ONE TANK TO THE OTHER DUE TO MALFUNCTIONS IN THE FUEL SYSTEM.WHEN FUEL IS PUMPED OR RETURNED TO THE NON-OPERATING TANK (CROSS FLOW), THE CAPACITY OF THE NON-OPERATING TANK CAN BE EXCEEDED, CAUSING FUEL TO OVERFLOW PAST THE FILLER CAP, CREATING A FIRE POTENTIAL.
EA95012 · Failure Of Serpentine Belt
Opened Mar 31, 1995 · Closed May 28, 1996
Status: closed (inferred from source dates) · Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Additional source detail variants (2)
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
EA93022 · Idle Air Spd Ctrl Vlv Malf
Opened Jul 30, 1993 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE93015 · Parking Brake Failure
Opened Mar 9, 1993 · Closed Jul 27, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE93010 · Idle Air Spd Ctrl Vlv Malf
Opened Mar 2, 1993 · Closed Jul 30, 1993
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93001 · Fuel Expulsion
Opened Jan 7, 1993 · Closed Aug 20, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92077 · Fuel Expulsion
Opened Sep 9, 1992 · Closed Jan 7, 1993
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92055 · Engine Compartment Fires
Opened Jun 24, 1992 · Closed Aug 20, 1992
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
1992 Ford F-250 Problems, Complaints & Recalls | Skip That Year
Illustration