NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
45 reportsClear category filterMileage unknown · Nov 25, 2025
Fuel System, DieselSteering
The contact owns a 2020 Ford F-250 SD. The contact received notifications of NHTSA Campaign Numbers: 24V957000 (Fuel System, Diesel) and 25V626000 (Steering); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amou…
Read full complaint
The contact owns a 2020 Ford F-250 SD. The contact received notifications of NHTSA Campaign Numbers: 24V957000 (Fuel System, Diesel) and 25V626000 (Steering); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure.
NHTSA ODI #11701438
97,000 miles · Nov 13, 2025
Fuel System, DieselSteering
The contact owns a 2020 Ford F-250. The contact received notifications of NHTSA Campaign Numbers: 24V957000 (Fuel System, Diesel) and 25V626000 (Steering); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. While…
Read full complaint
The contact owns a 2020 Ford F-250. The contact received notifications of NHTSA Campaign Numbers: 24V957000 (Fuel System, Diesel) and 25V626000 (Steering); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. While the contact’s husband was driving approximately 45-50MPH, the vehicle suddenly lost motive power and power steering functionality. The driver coasted to the side of the road, and the vehicle became inoperable. The vehicle was towed to the dealer, who determined that the high-pressure fuel pump (CP4 pump) had failed and there were metal fragments inside the fuel line. The CP4 pump was replaced. The dealer confirmed that the recall repairs were not completed. The manufacturer was made aware of the failure. The failure mileage was approximately 97,000.
NHTSA ODI #11699233
Mileage unknown · Nov 6, 2025
Steering
Safety of all people are affected by driving my truck with a steering wheel that might separate and cause a crash.. no loaner until fixed ...
NHTSA ODI #11697821
Mileage unknown · Oct 31, 2025
Steering
On October 29, 2025, while traveling around a sweeping freeway transition ramp at 65 MPH in my 2020 Ford F-250 (46k miles on it), I hit a bump in the road. Suddenly the truck began violent, uncontrollable shaking of the front end of the truck and the steering wheel, feeling like the truck was about to fall apart. This terrifyin…
Read full complaint
On October 29, 2025, while traveling around a sweeping freeway transition ramp at 65 MPH in my 2020 Ford F-250 (46k miles on it), I hit a bump in the road. Suddenly the truck began violent, uncontrollable shaking of the front end of the truck and the steering wheel, feeling like the truck was about to fall apart. This terrifying, chaotic event caused me to struggle to steer and maintain control of the vehicle, sending me into the center divide. My son in law and 2 year old grandson were in the vehicle with me, visibly shaken by the event. Thankfully I was not pulling my travel trailer at the time, this could have ended in a critical situation. No warning lamps illuminated. Ford is aware of this issue and previously ordered a "customer satisfaction" repair, but that only covers 2017-2019 trucks. The truck is scheduled to be taken to the Ford dealership today 10/31/2025, however we are unclear whether there will be a cost for the repair.
NHTSA ODI #11696757
Mileage unknown · Oct 9, 2025
Fuel System, DieselSteering
The contact owns a 2020 Ford F-250. The contact had received notifications of NHTSA Campaign Numbers: 24V957000(Fuel System, Diesel) and 25V626000(Steering); however, the parts to do the recall repairs were not yet available. The contact had contacted an unknown local dealer several times and had been advised that the recall pa…
Read full complaint
The contact owns a 2020 Ford F-250. The contact had received notifications of NHTSA Campaign Numbers: 24V957000(Fuel System, Diesel) and 25V626000(Steering); however, the parts to do the recall repairs were not yet available. The contact had contacted an unknown local dealer several times and had been advised that the recall parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not contacted. The contact had not experienced a failure.
NHTSA ODI #11692421
Mileage unknown · Mar 25, 2025
Steering
Steering column failed. Loud pop and steering wheel became floppy and wold move in every direction including in and out. Fortunately it happened while driving in my driveway. I delivered it to a local service center where repairs were completed. I still have the old parts available for inspection. Only 50004 miles on the vehicle…
Read full complaint
Steering column failed. Loud pop and steering wheel became floppy and wold move in every direction including in and out. Fortunately it happened while driving in my driveway. I delivered it to a local service center where repairs were completed. I still have the old parts available for inspection. Only 50004 miles on the vehicle.
NHTSA ODI #11650390
Mileage unknown · Feb 7, 2025
Steering
I have been experiencing what is known as the “death wobble”. While driving at normal highway speeds, bumps or rough patches in the road will cause my vehicle to violently shudder. It is extremely difficult to maintain control and the vehicle has to coast to reduce speed to 20 mph before the shudder will stop. This is a known is…
Read full complaint
I have been experiencing what is known as the “death wobble”. While driving at normal highway speeds, bumps or rough patches in the road will cause my vehicle to violently shudder. It is extremely difficult to maintain control and the vehicle has to coast to reduce speed to 20 mph before the shudder will stop. This is a known issue in previous year model F-series trucks. I have taken my vehicle to a dealership and had the issue confirmed as the steering stabilizer, however, Ford refuses to remedy the issue stating my year model is not affected. Ford claims the affected years models end at 2019. My vehicle is a 2020, however, my manufacturer date is 10/19. I believe my vehicle is actually what is considered a “half year”, meaning it received certain 2019 parts and certain 2020 parts. This issue is extremely dangerous for me as well as other motorists.
NHTSA ODI #11641256
Mileage unknown · Feb 4, 2025
SteeringUnknown Or Other
When temperature is below 32 degree clock spring in steering makes noise and causes steering to become stiff also renders horn in operable in positions while driving. I have brought this vehicle to get it fixed under warranty and the temperature raised to 40 degrees and everything worked as it should. I got cut off the other day…
Read full complaint
When temperature is below 32 degree clock spring in steering makes noise and causes steering to become stiff also renders horn in operable in positions while driving. I have brought this vehicle to get it fixed under warranty and the temperature raised to 40 degrees and everything worked as it should. I got cut off the other day and when I honked my horn it made no noise!
NHTSA ODI #11640718
45,000 miles · Nov 25, 2024
SteeringSuspension
The contact owns a 2020 Ford F-250. The contact stated while driving approximately 70 MPH, the vehicle drove over a bump on the highway and the front end started wobbling to the left and the right and the vehicle started shaking violently. The contact stated there was no warning light illuminated. The contact took his foot off t…
Read full complaint
The contact owns a 2020 Ford F-250. The contact stated while driving approximately 70 MPH, the vehicle drove over a bump on the highway and the front end started wobbling to the left and the right and the vehicle started shaking violently. The contact stated there was no warning light illuminated. The contact took his foot off the accelerator pedal to slow the vehicle. The contact was not depressing the brake pedal during the failure. The contact was able to slow and stop the vehicle. The contact turned off and started the vehicle and was able to resume normal operation. The contact stated while driving 50 MPH over a bump in the roadway, the vehicle started shaking and swaying to the left and the right. The contact stopped the vehicle and turned off and restarted the vehicle, and the vehicle drove normally. The contact had taken the vehicle to a local dealer; however, the vehicle was not yet diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 45,000.
NHTSA ODI #11627223
Mileage unknown · Oct 4, 2024
Steering
Same as my previous Complaint dated yesterday, 10/3/2024, Ray Varner Ford, a Ford Dealer, tried to sell me the wrong Power Steering Fluid for this truck. I gave the Vehicle year, make, model and VIN # and they still tried to sell me passenger car steering fluid. Varner Ford LLC 2026 N Charles G Seviers Blvd, Clinton TN 37716 on…
Read full complaint
Same as my previous Complaint dated yesterday, 10/3/2024, Ray Varner Ford, a Ford Dealer, tried to sell me the wrong Power Steering Fluid for this truck. I gave the Vehicle year, make, model and VIN # and they still tried to sell me passenger car steering fluid. Varner Ford LLC 2026 N Charles G Seviers Blvd, Clinton TN 37716 on Invoice [XXX], on which I purchased brake fluid but rejected the wrong PS fluid. This 250 3/4 ton truck uses Ford Automatic Transmission Fluid (ATF), not power steering fluid, and adding the wrong fluid will result in system damage, failure and possibly accident if steering control is lost. A mechanic at a local Tire and Lube business told me that adding this incorrect fluid will result in damage to the seals in the PS system, so apparently this is a known problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11618056
Official recalls
14Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, 2021-2022 F600, and 2022 F750 vehicles previously repaired incorrectly under recall number 24V957. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed mailed April 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S17. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 18, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The 360-degree view camera system may not display a rearview image properly in certain lighting conditions.
Consequence & remedy
Consequence: A rearview camera image that does not display properly can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the image processing module software, free of charge.This will be a phased campaign, with the remedy becoming available in different phases based on model years. Interim letters notifying owners of the safety risk were mailed on October 30, 2025. Additional letters will be mailed once the remedy is available on each phase. Owner notification letters were mailed May 19, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA8. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 13, 2025.
Sep 19, 2025
Ford Motor Company (Ford) is recalling certain 2020-2021 F-250, F-350, and F-450 vehicles. The steering column upper shaft may detach from the steering column and result in a loss of steering control.
Consequence & remedy
Consequence: A loss of steering control increases the risk of a crash.
Remedy: Dealers will inspect the steering column, and repair or replace the upper shaft as necessary, free of charge. Owner notification letters were mailed February 20, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S94. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 23, 2025.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, F600, and 2021-2022 F-650, F750 vehicles. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) and Transmission Control Module (TCM) software, free of charge. Owner notification letters were mailed January 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S78.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
Aug 26, 2022
Ford Motor Company (Ford) is recalling certain 2017-2020 F-Super Duty F-250, F-350, F-450, and 2017-2020 Lincoln Continental vehicles equipped with the 360-degree camera system. Degradation of the camera's anit-reflective lens coating can lead to a foggy or cloudy rearview camera image.
Consequence & remedy
Consequence: Lack of a clear rearview camera image can reduce the driver's visibility of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Ford customer service at 1-800-1-866-436-7332. Ford's number for this recall is 22S51.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020 Super Duty F-250, F-350, F-450, and F-550 vehicles equipped with 6.7L diesel engines. A washer within the vehicle's transmission can disintegrate, causing metallic debris to become lodged in the 'Park' mechanism.
Consequence & remedy
Consequence: Debris lodged within the 'Park' mechanism may prevent the vehicle from achieving or holding 'Park,' increasing the risk of a vehicle rollaway and a crash.
Remedy: Dealers will replace a gearset within the transmission, free of charge. Owner notification letters were mailed on April 19, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S22.
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 27, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S10.
Feb 18, 2021
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence & remedy
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Additional source detail variants (2)
Visibility:windshield:critical Fasteners
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Visibility:windshield
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Jun 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Super-Duty F-250, F-350, and F-550 diesel pickups. The transmission torque converter damper plate was not tempered, resulting in a brittle damper plate that may fracture and cause the engine to stall or require increased brake pedal effort in order to stop the vehicle.
Consequence & remedy
Consequence: An engine stall or requiring additional braking effort to stop the vehicle can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the transmission assembly, free of charge. This recall began July 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S33.
Additional source detail variants (2)
Power Train:automatic Transmission:torque Converter
Ford Motor Company (Ford) is recalling certain 2020 Super-Duty F-250, F-350, and F-550 diesel pickups. The transmission torque converter damper plate was not tempered, resulting in a brittle damper plate that may fracture and cause the engine to stall or require increased brake pedal effort in order to stop the vehicle.
Consequence: An engine stall or requiring additional braking effort to stop the vehicle can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the transmission assembly, free of charge. This recall began July 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S33.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2020 Super-Duty F-250, F-350, and F-550 diesel pickups. The transmission torque converter damper plate was not tempered, resulting in a brittle damper plate that may fracture and cause the engine to stall or require increased brake pedal effort in order to stop the vehicle.
Consequence: An engine stall or requiring additional braking effort to stop the vehicle can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the transmission assembly, free of charge. This recall began July 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S33.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE24014 · Sogefi Secondary Diesel Fuel Filter Leak
Opened May 9, 2024 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.
RQ21001 · Power Tailgate Release Systems
Opened Jan 15, 2021 · Closed Jan 10, 2024
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Structure:body:door
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration