IllustrationON 7 OCCASIONS MY 2018 F250 HAS HAD SEVERE DEATH WOBBLE. AS LOW AS 40MPH UP TO 75 MPH IT HAS ONLY 32000 MILES WHEN THIS FIRST OCCURRED IT HAS BEEN TO THE FORD DEALER 4X FOR THIS ISSUE AND THEY HAVE DONE THEIR SO CALLED REPAIRS AND IT STILL DOES IT
2018 Ford F-250 Sd
Owner reports · Recalls · Investigations
More warning signs than most F-250 Sd years
Owner complaints for the 2018 Ford F-250 Sd are substantially higher than the model-year median of 89.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-250 Sd years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1170–25K
12725–50K
2850–75K
875–100K
11100–150K
2150K+
293 reports with mileage · 104 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 252 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 198 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Wheels. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports9 fire reports3 injury reports
Steering complaints
252 reportsAT APPROXIMATELY 9,000 MILES THE VEHICLE EXHIBITED THE "DEATH WOBBLE" AT SPEEDS BETWEEN 45 MPH TO 70 MPH, MAKING IT ALMOST IMPOSSIBLE TO CONTROL UNTIL YOU CAN GET IT DOWN TO BELOW 35 MPH. SOMETIMES WHEN YOU HIT A BUMP, AND SOMETIMES AN EXPANSION JOINT. THE DEALERSHIP PERFORMED TSB 18-2268. THE PROBLEM RESUMED AT APPX. 12,000 MIL…
Read full complaint
AT APPROXIMATELY 9,000 MILES THE VEHICLE EXHIBITED THE "DEATH WOBBLE" AT SPEEDS BETWEEN 45 MPH TO 70 MPH, MAKING IT ALMOST IMPOSSIBLE TO CONTROL UNTIL YOU CAN GET IT DOWN TO BELOW 35 MPH. SOMETIMES WHEN YOU HIT A BUMP, AND SOMETIMES AN EXPANSION JOINT. THE DEALERSHIP PERFORMED TSB 18-2268. THE PROBLEM RESUMED AT APPX. 12,000 MILES.RETURNED TO DEALERSHIP, AND THEY DO NOT HAVE PARTS TO REPAIR. THEY SAY THE PARTS ARE BACK ORDERED.
I'VE HIT THE "DEATH WOBBLE" IN MY 2018 F-250 AT 30,000 MILES. IT HAS HAPPENED THREE TIMES AFTER HITTING A BUMP IN THE ROAD DRIVING AT HIGHWAY SPEEDS 70-75MPH. IT STOPPED AFTER AGGRESSIVELY BRAKING AND SLOWING TO ABOUT 30MPH. I HAVE AN APPOINTMENT WITH A LOCAL DEALERSHIP TO REPAIR BUT I'M NOT CONFIDENT IT WILL BE RESOLVED AFTER R…
Read full complaint
I'VE HIT THE "DEATH WOBBLE" IN MY 2018 F-250 AT 30,000 MILES. IT HAS HAPPENED THREE TIMES AFTER HITTING A BUMP IN THE ROAD DRIVING AT HIGHWAY SPEEDS 70-75MPH. IT STOPPED AFTER AGGRESSIVELY BRAKING AND SLOWING TO ABOUT 30MPH. I HAVE AN APPOINTMENT WITH A LOCAL DEALERSHIP TO REPAIR BUT I'M NOT CONFIDENT IT WILL BE RESOLVED AFTER READING ABOUT OTHER OWNERS EXPERIENCES.
WHILE TRAVELING WITH MY WIFE AND TWO SMALL CHILDREN NORTH ON I-25 NEAR THE E-470 EXCHANGE DOING THE POSTED SPEED LIMIT OF 75MPH, WE HIT A SMALL BUMP IN THE FAR RIGHT HAND LANE AND THE TRUCK BEGAN TO VIOLENTLY SHAKE AND WOBBLE TO THE POINT I ALMOST LOST CONTROL AND HIT AN 18 WHEELER IN THE ADJACENT LANE. I WAS FORCED TO APPLY MY …
Read full complaint
WHILE TRAVELING WITH MY WIFE AND TWO SMALL CHILDREN NORTH ON I-25 NEAR THE E-470 EXCHANGE DOING THE POSTED SPEED LIMIT OF 75MPH, WE HIT A SMALL BUMP IN THE FAR RIGHT HAND LANE AND THE TRUCK BEGAN TO VIOLENTLY SHAKE AND WOBBLE TO THE POINT I ALMOST LOST CONTROL AND HIT AN 18 WHEELER IN THE ADJACENT LANE. I WAS FORCED TO APPLY MY BRAKES AGGRESSIVELY TO TRY AND CONTROL THE VEHICLE. I PULLED OFF THE HIGHWAY AND STOPPED TO INSPECT THE FRONT END. I COULD FIND NOTHING WRONG WITH THE TIRES, RIMS, NOR THE FRONT AXEL. I HAVE SINCE SPOKEN TO THE FORD DEALERSHIP WHERE I PURCHASED THIS VEHICLE FROM AND HAVE BEEN GIVEN THE SAME SONG AND DANCE THAT I SEE REPORTED FREQUENTLY ONLINE REGARDING THIS DEATH WOBBLE EXPERIENCE AND THE DEALERSHIP'S INVOLVEMENT, OR LACK THERE OF, IN DEALING WITH PROVIDING A RESOLUTION.
FORD F250 LARIAT 2018 HAS DEATH WOBBLE AT HIGHWAY SPEEDS BETWEEN 50 AND 80 MPH VERY UNSAFE SCARES THE BJESUS OUT OF ME N MY FAMILY BOUGHT IT TO PULL A TRAILER BEHIND IT . DONOT WANT DO DO THAT IN FEAR OF SOMEONE GETTING SEVERLY INJURIED OR WORSE!! ITS BEEN TO FORD DEALERSHIP THEY WANT TO PUT A BAN…
Read full complaint
FORD F250 LARIAT 2018 HAS DEATH WOBBLE AT HIGHWAY SPEEDS BETWEEN 50 AND 80 MPH VERY UNSAFE SCARES THE BJESUS OUT OF ME N MY FAMILY BOUGHT IT TO PULL A TRAILER BEHIND IT . DONOT WANT DO DO THAT IN FEAR OF SOMEONE GETTING SEVERLY INJURIED OR WORSE!! ITS BEEN TO FORD DEALERSHIP THEY WANT TO PUT A BANDAGE ON IT FOR $800.00 WITH NO GUARANTEE TO FIX THE PROBLEM!! THEY TAUGHT THEIR EMPLOYEES WELL DENY DENY DENY. WHAT A WASTE OF 48,000 DOLLARS (SHAME ON FORD ) BOUGHT ON NOVEMBER 2 2019
TRUCK HAS 16,000 MILES ON IT. PURCHASED NEW FROM DEALER. WITHIN 1,000 MILES EXPERIENCED RANDOM FRONT END SHAKE, WAS OCCASIONAL ON ROUGH ROAD. RECENTLY IT OCCURRED IN ONE WEEKEND 6 TIMES. ALL ON DIFFERENT INTERSTATE ROADS BETWEEN PENNSYLVANIA AND NEW JERSEY. SHOOK SO HARD AND VIOLENTLY BOTH FOG LIGHTS CRACKED ON THE TRUCK INCLUDI…
Read full complaint
TRUCK HAS 16,000 MILES ON IT. PURCHASED NEW FROM DEALER. WITHIN 1,000 MILES EXPERIENCED RANDOM FRONT END SHAKE, WAS OCCASIONAL ON ROUGH ROAD. RECENTLY IT OCCURRED IN ONE WEEKEND 6 TIMES. ALL ON DIFFERENT INTERSTATE ROADS BETWEEN PENNSYLVANIA AND NEW JERSEY. SHOOK SO HARD AND VIOLENTLY BOTH FOG LIGHTS CRACKED ON THE TRUCK INCLUDING ONE OF THE FOG LIGHT MOUNTS. HAPPENS ON ANY ROAD. HAPPENS ANY SPEED ABOVE 45MPH. CONCRETE ROADS ARE THE WORST AND BRIDGE JOINTS. TRUCK NOW LOOSES GRIP WHEN DRIVING OVER BUMPS. FEELS LIKE ON ICE. CIOCCA FORD WILL NOT WARRANTY BROKEN PARTS SUCH AS FOG LIGHTS AND ONE MOUNT. THEY WILL NOT CORRECT ALIGNMENT ISSUE DUE TO STEERING STABILITY ISSUE AKA DEATH WOBBLE. TRUCK NOW PULLS TO THE RIGHT. TRUCK DOES NOT FEEL SAFE TO DRIVE WITH MY CHILDREN IN IT, ESPECIALLY IN THE SNOW SEASON KNOWING ANY BUMP COULD SET IT OFF. I HAVE TRIED ALL DIFFERENT AIR PRESSURES STILL GET DEATH WOBBLE. STILL BREAKS TRUCK TRACTION ON BUMPS. THIS WOBBLE OCCURS EVEN ON SECONDARY ROADS. THE WOBBLE CAUSES STEERING WHEEL TO SHAKE BACK AND FORTH 3-4 INCHES. THE ENTIRE FRONT OF THE TRUCK VIBRATES AND SHAKES. THE WOBBLE WON'T STOP UNTIL SPEED IS DROPPED BELOW 35MPH. THIS SHAKE WILL CAUSE LOSS OF STEERING AND CONTROL IN ANY WEATHER CONDITION. WHEN IT OCCURS YOU HAVE ALL YOU CAN DO TO HOLD THE STEERING WHEEL, THERE IS NO TURNING ABILITY WHEN THIS OCCURS. THE STEERING STABILIZER IS OFTEN QUOTED AS THE ISSUE FOR THIS. I BELIEVE FROM MY EXPERIENCE AND RESEARCH THE SHOCKS ARE ALSO NOT ADEQUATE FROM THE LOSS OF TRACTION STEERING. STEERING LINKAGE IS ALSO WEAK. FORD HAS A REENGINEERED SOLUTION, HOWEVER UNKNOWN AVAILABILITY. THIS TRUCK IS NOW A SAFETY HAZARD TO MYSELF AND OTHERS, AND CIOCCA FORD IS NOT OFFERING A SOLUTION FOR THE SAFETY CONCERN.
1ST INCIDENT 2/10/2019, WHEN THE VEHICLE HIT A BUMP IN ROAD THE TRUCK STEERING WOULD SHAKE AND CAUSE VEHICLE TO BOUNCE TO THE RIGHT UNCONTROLLABLE, VEHICLE IN SHOP 2/12/19 TO REPLACE STEERING STRUT. VEHICLE MILEAGE 10,699 ON 11/15/2019 A TRIP FROM MD TO KY, TRAVEL APPROXIMATELY 72 MPH AND ABOUT 5 HOURS IN TRIP, THE VEHICLE H…
Read full complaint
1ST INCIDENT 2/10/2019, WHEN THE VEHICLE HIT A BUMP IN ROAD THE TRUCK STEERING WOULD SHAKE AND CAUSE VEHICLE TO BOUNCE TO THE RIGHT UNCONTROLLABLE, VEHICLE IN SHOP 2/12/19 TO REPLACE STEERING STRUT. VEHICLE MILEAGE 10,699 ON 11/15/2019 A TRIP FROM MD TO KY, TRAVEL APPROXIMATELY 72 MPH AND ABOUT 5 HOURS IN TRIP, THE VEHICLE HIT A SMALL BUMP IN ROAD ON HIGHWAY 79, THE VEHICLE FRONT BEGAN TO SHAKE VIOLENTLY AND PULL THE TRUCK TO THE RIGHT UNCONTROLLABLE. I MANAGE TO MAINTAIN CONTROL AND SLOW VEHICLE DOWN AT APPROXIMATELY 10 MPH ON THE SHOULD THE SHAKING STOPPED. CONTACT DEALER THE SAME DAY AND HAVE AN APPOINTMENT ON 12/2/19 TO REVIEW. THE VEHICLE STEERING SHAKE WHEN DRIVING AT SPEEDS ABOUT 40 MPH AND WILL BEGAN SHAKING AGAIN WHEN HITTING A BUMP IN ROAD. VEHICLE MILEAGE IS 25210.
WHILE TRAVELING ON I-74 AT 70MPH WE HIT A ROAD EXPANSION JOINT (SLIGHT BUMP) ON A BRIDGE AND THE TRUCK BEGAN TO SHAKE AND WOBBLE TO THE POINT I ALMOST LOST CONTROL AND HIT THE BRIDGE RAILING, I HIT MY BRAKES TO TRY AND CONTROL THE VEHICLE WHEN I WAS ALMOST HIT BY A SEMI TRUCK. I PULLED OFF THE INTERSTATE AND STOPPED. I COULD F…
Read full complaint
WHILE TRAVELING ON I-74 AT 70MPH WE HIT A ROAD EXPANSION JOINT (SLIGHT BUMP) ON A BRIDGE AND THE TRUCK BEGAN TO SHAKE AND WOBBLE TO THE POINT I ALMOST LOST CONTROL AND HIT THE BRIDGE RAILING, I HIT MY BRAKES TO TRY AND CONTROL THE VEHICLE WHEN I WAS ALMOST HIT BY A SEMI TRUCK. I PULLED OFF THE INTERSTATE AND STOPPED. I COULD FIND NOTHING WRONG AND CONTINUED ON AND AGAIN WHEN I WAS DOING 65MPH I ALMOST LOST CONTROL OF THE TRUCK WHEN WE HIT ANOTHER EXPANSION. IT SHOOK SO BAD IT ALMOST PULLED THE STEERING WHEEL OUT OF MY HANDS. I GOT OFF TO THE SIDE AGAIN ALMOST CAUSING A TRAFFIC CRASH. I FULLY STOPPED AND THEN SLOWLY DROVE OFF OF THE INTERSTATE AND DROVE HOME ON A SECONDARY ROAD AND IT WAS FINE UNTIL I WAS ON INDIANA 63 / US 41 I GOT THE TRUCK TO 60 MPH AND IT AGAIN SHOOK VIOLENTLY WHEN WE HIT A SLIGHT BUMP OF AN EXPANSION JOINT. I AM TAKING IT TO THE SHOP TOMORROW MORNING. I NEVER KNEW THIS WAS A PROBLEM U TIL I LOOKED THIS UP ON GOOGLE. HOW CAN FORD CONTINUE TO SELL THESE TRUCKS WITH A KNOW SAFETY DEFECT AND NHTSA DOES NOTHING TO WARN US.
WHEN DRIVING AT SPEEDS BETWEEN 45 AND 65 THE STEERING WHEEL WILL START SHAKING SIDE TO SIDE VIOLENTLY. I HAVE HAD THE TRUCK FOR ABOUT A MONTH AND IT HAS HAPPENED 4 TIMES. IT SHAKES SO BAD YOU ALMOST LOSE CONTROL. THE ONLY WAY TO GET IT TO STOP IS TO SLOW WAY DOWN, TO APPROXIMATELY 15 MPH OR STOP COMPLETELY. THIS IS PRETTY CONV…
Read full complaint
WHEN DRIVING AT SPEEDS BETWEEN 45 AND 65 THE STEERING WHEEL WILL START SHAKING SIDE TO SIDE VIOLENTLY. I HAVE HAD THE TRUCK FOR ABOUT A MONTH AND IT HAS HAPPENED 4 TIMES. IT SHAKES SO BAD YOU ALMOST LOSE CONTROL. THE ONLY WAY TO GET IT TO STOP IS TO SLOW WAY DOWN, TO APPROXIMATELY 15 MPH OR STOP COMPLETELY. THIS IS PRETTY CONVENIENT WHEN YOUR ON THE INTERSTATE. FORD NEEDS TO OFFER A REPAIR BEFORE SOMEONE DIES!
THIS TRUCK HAD DEATH WOBBLE AT 17K MILES, FORD REPLACED THE STEERING STABILIZER, WOBBLE IS BACK AT 40K MILES AND WE HAVE TO BUY ANOTHER STABILIZER OUT OF POCKET. THIS IS ONE OF SEVERAL 17-19 F250S WE OWN THAT HAS HAD DEATH WOBBLE. FORD NEEDS TO STEP UP WITH THE RECALL.
Official recalls
925V572000 · Back Over Prevention: Sensing System: Camera
Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
22V880000 · Power Train:driveline:driveshaft
Nov 29, 2022
Ford Motor Company (Ford) is recalling certain 2017-2018 F-Super Duty F-250, F-350, and F-450 4x4 vehicles. A radial damper inside the driveshaft may move out of position over time, which can cause a driveshaft imbalance and result in a fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power. Additionally, a vehicle rollaway could occur while parked if the parking brake is not engaged. Either of these scenarios increases the risk of a crash.
Remedy: Dealers will replace the driveshaft, free of charge. Owner notification letters were mailed July 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S74.
22V644000 · Back Over Prevention: Sensing System: Camera
Aug 26, 2022
Ford Motor Company (Ford) is recalling certain 2017-2020 F-Super Duty F-250, F-350, F-450, and 2017-2020 Lincoln Continental vehicles equipped with the 360-degree camera system. Degradation of the camera's anit-reflective lens coating can lead to a foggy or cloudy rearview camera image.
Consequence & remedy
Consequence: Lack of a clear rearview camera image can reduce the driver's visibility of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Ford customer service at 1-800-1-866-436-7332. Ford's number for this recall is 22S51.
22V087000 · Power Train:driveline:driveshaft; Structure:frame And Members:underbody Shields
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
21V155000 · Tires
Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 27, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S10.
19V880000 · Seat Belts:pretensioner; Structure:body:roof And Pillars
Dec 11, 2019
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
Additional source detail variants (2)
Seat Belts:pretensioner
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
Structure:body:roof And Pillars
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
19V864000 · Latches/locks/linkages:tailgate:latch
Dec 4, 2019
Ford Motor Company (Ford) is recalling certain 2017-2019 Super Duty F-250, F-350, and F-450 trucks equipped with an electric tailgate latch release switch mounted in the tailgate handle. Water may enter the electrical wiring system and cause a short circuit, activating the switch and releasing the tailgate latches.
Consequence & remedy
Consequence: Unintended tailgate opening may allow unrestrained cargo to fall out of the truck bed and become a road hazard, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits and will install a new tailgate handle release switch, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S48.
19V808000 · Exterior Lighting:headlights
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2018-2019 F-250, F-350 and F-450 Super Duty trucks. The Daytime Running Lights (DRL) may not dim when the headlight switch is moved into the "On" position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford has notified owners, and dealers will reprogram the Body Control Module (BCM) software, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C10.
19V278000 · Engine; Equipment:electrical
Apr 8, 2019
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE24014 · Sogefi Secondary Diesel Fuel Filter Leak
Opened May 9, 2024 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ21001 · Power Tailgate Release Systems
Opened Jan 15, 2021 · Closed Jan 10, 2024
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Structure:body:door
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18011 · Power Tailgate Opens Unintended
Opened Oct 12, 2018 · Closed Dec 12, 2019
Status: closed (inferred from source dates) · Electrical System:wiring; Structure:body:tailgate:hinge And Attachments
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.
Additional source detail variants (2)
Electrical System:wiring
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.
Structure:body:tailgate:hinge And Attachments
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.