IllustrationAT 42000 MILES I STARTED TO EXPERIENCE WHAT IS KNOWN AS THE DEATH WOBBLE WHEN I HIT A ROUGH PATCH IN THE ROAD. TOOK THE TRUCK TO THE LOCAL DEALER AND THEY HAD IT FOR A WEEK AND TOLD ME THE COULDN'T FIND AN ISSUE. ISSUE IS GETTING PROGRESSIVELY WORSE AND OCCURING MORE FREQUENTLY.
2016 Ford F-250 Sd
Owner reports · Recalls · Investigations
More warning signs than most F-250 Sd years
Owner complaints for the 2016 Ford F-250 Sd are substantially higher than the model-year median of 89.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-250 Sd years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
240–25K
2525–50K
2850–75K
1775–100K
25100–150K
14150K+
133 reports with mileage · 155 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 117 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 111 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports5 fire reports5 injury reports
Suspension complaints
111 reportsWHILE TRAVELING 65MPH IN A POSTED 65MPH ZONE, I DROVE OVER UNEVEN PAVEMENT. THIS CAUSED THE STEERING WHEEL AND VEHICLE TO VIOLENTLY SHAKE. SO SEVERE WAS THE SHAKING THAT MY COFFEE CUP SHOOK OUT OF THE SNUG CUP HOLDER IT WAS IN, THE OVERHEAD SUNGLASS STORAGE COMPARTMENT CAME OPEN AND THE PASSENGER-SIDE SUN VISOR CAME DOWN. WHEN…
Read full complaint
WHILE TRAVELING 65MPH IN A POSTED 65MPH ZONE, I DROVE OVER UNEVEN PAVEMENT. THIS CAUSED THE STEERING WHEEL AND VEHICLE TO VIOLENTLY SHAKE. SO SEVERE WAS THE SHAKING THAT MY COFFEE CUP SHOOK OUT OF THE SNUG CUP HOLDER IT WAS IN, THE OVERHEAD SUNGLASS STORAGE COMPARTMENT CAME OPEN AND THE PASSENGER-SIDE SUN VISOR CAME DOWN. WHEN I APPLIED THE BRAKES, THE SHAKING BECAME WORSE AND I COULD NOT CONTROL THE VEHICLE. ONLY WHEN I DECELERATED WITHOUT BRAKING DID THE SHAKING STOP, AT ABOUT 35MPH. THIS WAS EXTREMELY TERRIFYING, SO MUCH SO THAT A FELLOW MOTORIST, WHO WITNESSED THE ORDEAL, STOPPED BEHIND ME ON THE SHOULDER TO MAKE SURE I WAS OKAY.
THIS TRUCK STARTING DOING THE DEATH WOBBLE AT ABOUT 50 MPH. RAN OVER SOME RUMBLE STRIPS APPROACHING A STOP SIGN AND THE WHEELS SHOOK VIOLENTLY. PUT NEW DRAG LINK, TIE ROD AND STEERING DAMPNER, STILL DID IT. PUT NEW TRACKBAR AND BALL JOINT, BUSHING AND HAD ALIGNMENT STILL DOING IT. IT IS AT DEALER NOW REPLACING TRACK BAR BALL…
Read full complaint
THIS TRUCK STARTING DOING THE DEATH WOBBLE AT ABOUT 50 MPH. RAN OVER SOME RUMBLE STRIPS APPROACHING A STOP SIGN AND THE WHEELS SHOOK VIOLENTLY. PUT NEW DRAG LINK, TIE ROD AND STEERING DAMPNER, STILL DID IT. PUT NEW TRACKBAR AND BALL JOINT, BUSHING AND HAD ALIGNMENT STILL DOING IT. IT IS AT DEALER NOW REPLACING TRACK BAR BALL JOINT, SHOCKS AND HAVING ALIGNMENT SHIMMED. TOTAL COST ABOUT 3500.
WHEN DRIVING ON ROAD/INTERSTATE OVER 60 MPH AND HIT A ROUGH SPOT IN THE ROAD THE FRONT END SHAKES VIOLENTLY. ALMOST LOOSING CONTROL OF THE VEHICLE. THIS HAPPENS VERY OFTEN. SHAKES SO BAD YOU NEED TO SLOW DOWN TO ABOUT 30 MPH BEFORE IT STOPS. NOT SAFE.
WITH 37K MILES ON MY VEHICLE AND ALL MAINTENANCE PERFORMED AND FOLLOWED BY DEALER, I WAS DRIVING DOWN HIGHWAY AT 70 MPH HAULING A 13K LB 5TH WHEEL RV WHEN SUDDENLY TRUCK AND STEERING STARTED TO SHAKE VIOLENTLY. WITH A HEAVY LOAD ATTACHED I BRAKED AND SLOWED VEHICLE TO 50 MPH TO STOP SHAKING. I WAS 200 MILES FROM NEAREST FORD …
Read full complaint
WITH 37K MILES ON MY VEHICLE AND ALL MAINTENANCE PERFORMED AND FOLLOWED BY DEALER, I WAS DRIVING DOWN HIGHWAY AT 70 MPH HAULING A 13K LB 5TH WHEEL RV WHEN SUDDENLY TRUCK AND STEERING STARTED TO SHAKE VIOLENTLY. WITH A HEAVY LOAD ATTACHED I BRAKED AND SLOWED VEHICLE TO 50 MPH TO STOP SHAKING. I WAS 200 MILES FROM NEAREST FORD DEALER IN EL PASO AND DROVE TRUCK AND RV THERE FOR IMMEDIATE SERVICE. INTERNET RESEARCH SHOWS THIS CONDITION IS COMMON WITH F250 TRUCKS EVEN UNDER 10K MILES! THIS IS A VERY DANGEROUS AND LIFE THREATENING EPISODE ESPECIALLY AT HIGHWAY SPEED. THERE IS A FORD TSA WHICH DESCRIBES THIS PROBLEM.
DEATH WOBBLE- 2016 FORD F-250 IS EXPERIENCING THE DEATH WOBBLE AT SPEEDS ABOVE 60MPH. THIS IS A CONTINUING PROBLEM, THE SERVICE MANAGER AT MY LOCAL DEALERSHIP STATED THERE IS NO TSB FROM FORD RECOGNIZING THE 2016 HAS A PROBLEM WITH THE DEATH WOBBLE. THE DEALERSHIP HAS REPLACED THE PARTS IN THE FRONT END THAT FORD SAYS TO ON MODE…
Read full complaint
DEATH WOBBLE- 2016 FORD F-250 IS EXPERIENCING THE DEATH WOBBLE AT SPEEDS ABOVE 60MPH. THIS IS A CONTINUING PROBLEM, THE SERVICE MANAGER AT MY LOCAL DEALERSHIP STATED THERE IS NO TSB FROM FORD RECOGNIZING THE 2016 HAS A PROBLEM WITH THE DEATH WOBBLE. THE DEALERSHIP HAS REPLACED THE PARTS IN THE FRONT END THAT FORD SAYS TO ON MODELS THAT EXPERIENCE THE SAME ISSUE. THIS HAS NOT FIXED THE PROBLEM. THIS IS A SERIOUS SAFETY ISSUE WITH ALL THESE VEHICLE AND FORD KNOWS ABOUT THIS ISSUE AND HAS NOT DONE ANYTHING TO HELP THE CONSUMER. I HAVE SPENT OVER $2000 TO FIX THIS AND IT'S NOT FIXED YET.
AT 82000 MILES HAD A SHIMMING IN THE FRONT END OCCUR. WAS NOT ALWAYS PRESENT WHILE DRIVING BUT AT TIMES THE STEERING WHEEL WOULD START SHAKING MAKING IT HARD TO MAINTAIN IN THE ROAD.
VEHICLE HAS A HOPPING THAT OCCURS AT SPEEDS OF 40-80 MPH, HAVE TRIED SEVERAL REMEDIES, NONE OF WHICH WORK. HOPPING SENSATION IS SO SEVERE THAT I WOULD BE WORRIED TO PUT CHILDREN IN THE BACK SEAT OF THE VEHICLE. MANUFACTURER IS AWARE OF THE PROBLEM, HAS A TSB IN AN ATTEMPT TO REMEDY THE PROBLEM. THE MANUFACTURER NUMBER OF THE TSB…
Read full complaint
VEHICLE HAS A HOPPING THAT OCCURS AT SPEEDS OF 40-80 MPH, HAVE TRIED SEVERAL REMEDIES, NONE OF WHICH WORK. HOPPING SENSATION IS SO SEVERE THAT I WOULD BE WORRIED TO PUT CHILDREN IN THE BACK SEAT OF THE VEHICLE. MANUFACTURER IS AWARE OF THE PROBLEM, HAS A TSB IN AN ATTEMPT TO REMEDY THE PROBLEM. THE MANUFACTURER NUMBER OF THE TSB IS 16-0087. MANUFACTURER CLAIMS ISSUE IS CAUSED BY FRAME FLEX. NO KNOWN FIX FOR THE ISSUE. ENGINE ALSO HAS A CONSISTENT ISSUE OF PUTTING DIESEL FUEL INTO THE ENGINE OIL, MANUFACTURER ALSO CLAIMS THIS ISSUE IS "NORMAL"
VEHICLE EXPERIENCES SEVERE BOUNCE BETWEEN 70-75 MPH. FORD HAS CONFIRMED ISSUE AND HAS STATED IT IS A "CHARACTERISTIC OF THE VEHICLE". ISSUE WAS REPORTED TO DEALER AND FORD AT TIME OF PURCHASE. BOUNCE IS VERY PRONOUNCED AND VEHICLE IS NOT SAFE DURING OPERATION.
I WAS DRIVING DOWN THE HIGHWAY AND ALL OF A SUDDEN TWICE WITHIN 10 MILES OF EACH OTHER MY TRUCK STARTED VIOLENTLY SHAKING ALOST SENDING ME INTO ANOTHER LANE AND LOSING CONTROL. HAD TO SLOW DOWN ALMOST TO A STOP BEFORE IT WOULD QUIT. *TR
Official recalls
325V572000 · Back Over Prevention: Sensing System: Camera
Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
22V337000 · Air Bags:frontal:driver Clockspring/spiral Cassette
May 13, 2022
Ford Motor Company (Ford) is recalling certain 2016 Super Duty F-250, F-350, F-450, and F-550 vehicles. Dust may accumulate in the steering wheel clock spring, causing a disconnection in the electrical connection resulting in the driver's air bag not deploying as intended.
Consequence & remedy
Consequence: A disconnected driver's air bag can result in it not deploying, as intended, during a crash, increasing the risk of injury.
Remedy: Dealers will replace the steering wheel clock spring, free of charge. Remedy parts are expected to become available in the 3rd Quarter of 2023. An interim notification letter informing owners of the safety risk was mailed on July 6, 2022. Owner notification letters were mailed July 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S35.
16V246000 · Tires:sidewall
Apr 26, 2016
Ford Motor Company (Ford) is recalling certain model year 2016 Ford F-250, F-350, F-450, and F-550 trucks manufactured April 5, 2016, to April 11, 2016. The tires installed during assembly of the affected vehicles may have sustained damage to the inner sidewall, possibly resulting in a loss of air or a tire rupture.
Consequence & remedy
Consequence: A rapid loss of air or a tire rupture while the vehicle is being driven may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires for damage and replace them as necessary, free of charge. The recall began on May 23, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S17.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE24014 · Sogefi Secondary Diesel Fuel Filter Leak
Opened May 9, 2024 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.