2016 Ford F-250 Sd

The contact owns a 2016 Ford F-250. The contact stated that while driving at various speeds, the vehicle drove over a bump in the roadway and the contact observed a loud vibrating noise, and the vehicle started shaking violently. Additionally, the steering wheel vibrated uncontrollably, making it difficult to steer the vehicle. The vehicle was slowed down, steered to the side of the road, and turned off. The vehicle was taken to a dealer and was diagnosed and determined that the track joint and damper assembly needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was unknown.

The problem is commonly called "DEATH WOBBLE". The steering system enters an extremely violent wobble/shake making control of the vehicle nearly impossible. 2 independent service centers have addressed the issue. The first did repairs, including warranty replacement of a faulty part and the truck still has the "DEATH WOBBLE". The 2nd independent service center made note of the 2nd faulty replacement part (TRACK BAR) and reports "TRACK BAR BUSHING IS MOVING EXCESSIVELY. TRACK BAR SHOULD BE REPLACED." No other physical inspections have been performed. There were no vehicle warning lights due to this issue. There were a few incidences of the "DEATH WOBBLE" prior to my first appointment with an independent service center. That first appointment was approx. 2/19/2024, completed on 2/27/2024. Second time completed on 6/21/2024.

I have had my vehicle inspected and supposedly repaired for the death wobble by two separate ford dealerships (Castle Rock Ford in Castle Rock, CO and Phil Long Ford in Colorado Springs CO). I continue to have safety issues as when I hit pot holes or rough roads, the steering and suspension system shakes the front wheels and steering wheel to the point that I have to come to a full stop. The entire steering system and shocks have been replaced (some parts multiple times) over the past two years. Please assists.

It has been labeled as the death wobble. When driving down the highway at 65-70 mph and I hit a bump, pothole or a washboard effect in the road with the left front wheel. The whole truck will shake violently. So much that I can barely hold on to the steering wheel. The only way to stop the shaking is to slow the truck down to 30-40 mph. In the middle of the highway. I can watch the other vehicles around me scatter and put on their brakes as they try and avoid me. Sometimes it’s to hard to control and I will waver into another lane or on coming traffic. This happens sporadically and without warning. I have taken the truck to the Ford dealership for $3000 in steering component repairs . I have 60,000 miles on it and it is only used for personal use and never abused. This is a design defect that is going to get someone killed. A heavy duty truck should not have the parts wearing out to such a degree that threatens the lives of everyone on the road around me.

The contact owns a 2016 Ford F-250. The contact stated while driving at an undisclosed speed, the steering wheel was shaking uncontrollably. The contact stated that the steering wheel was shaking, and it was difficult to hold onto the steering wheel. The contact decelerated and the vehicle was taken to an independent mechanic. The vehicle was not diagnosed or repaired. The contact stated that the failure had previously occurred, and the vehicle was repaired; however, the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,000.

After we drove over a bumpy section of road the truck experienced uncontrollable shaking. The road conditions were not severe, but were the cause of the shaking. During the immediate aftermath no input was possible apart from taking my foot off the accelerator. The shaking was severe and uncontrolled causing other vehicles in the vicinity to react. It felt like the truck was going to flip over. This has now happened several times since we purchased the truck. We recently had new brakes installed, but that is not the reason for the shaking.

-I was driving 65 mph in morning rush traffic when I drove over an overpass. Near the end of the there are some small wrinkles in the concrete. Once I drove over these wrinkles in the pavement, my steering wheel and front end started violently shaking. I removed my foot from the accelerator and once my speed decreased to I'd say 20-30 mph the shaking stopped. My research show that this if referred to as the Ford Death Wobble. -The system that failed were likely the track bar bushing, damper bracket, ball joints, control arms, shocks, and struts. Yes, the truck is available for inspection upon request. -When the front end of the truck started violently shacking I was going 65 mph in lunch rush hour traffic. I'd say that my life and the life of the drivers of the vehicles to my left, right, and rear were at risk. -No, the problem has not been reproduced or confirmed by a dealer or anyone else. -No, the vehicle or components have not been inspected by anyone. -No, there were not any warning lamps, messages or other symptoms of the problem prior to the failure, nor did any warning appear during or after the shaking. -My best assessment of the cause