The reductant heater (DEF heater) has went out. Ford will not honor the 5 year/ 60,000 miles power train warranty or the 8 year/ 80,000 mile emissions warranty to repair the issue. According to web sources dealerships maintain a regular supply of these heaters as they replace 5 to 6 a week in the winter. My truck is 4 years and…
Read full complaint
The reductant heater (DEF heater) has went out. Ford will not honor the 5 year/ 60,000 miles power train warranty or the 8 year/ 80,000 mile emissions warranty to repair the issue. According to web sources dealerships maintain a regular supply of these heaters as they replace 5 to 6 a week in the winter. My truck is 4 years and 58,000 miles.
NHTSA ODI #11446068
232,000 miles · Nov 20, 2020
Power TrainSteeringSuspension
DEATH WOBBLE FRONT END AT HIGHWAY SPEEDS.
NHTSA ODI #11375645
55,000 miles · Feb 18, 2020
EngineFuel/propulsion SystemPower Train
SERVICE ENGINE LIGHT CAME ON TWICE WHILE VEHICLE WAS UNDER WARRANTY. DEALER SERVICED BOTH TIMES AND WAS UNABLE TO RECTIFY OR UNDERSTAND THE PROBLEM. THEY ONLY CLEARED THE FAULT CODES. THE CODE IDENTIFIED WAS FOR THE REDUCTANT HEATER PUMP - LOW VOLTAGE. THE SAME CODE JUST CAME BACK ON FOR THE 3RD TIME - THIS TIME IDENTIFIED BY A…
Read full complaint
SERVICE ENGINE LIGHT CAME ON TWICE WHILE VEHICLE WAS UNDER WARRANTY. DEALER SERVICED BOTH TIMES AND WAS UNABLE TO RECTIFY OR UNDERSTAND THE PROBLEM. THEY ONLY CLEARED THE FAULT CODES. THE CODE IDENTIFIED WAS FOR THE REDUCTANT HEATER PUMP - LOW VOLTAGE. THE SAME CODE JUST CAME BACK ON FOR THE 3RD TIME - THIS TIME IDENTIFIED BY A DIESEL PERFORMANCE SHOP - WITH ADVICE TO REPLACE THE REDUCTANT PUMP. PREVIOUS MAKE AND MODEL SUPERDUTY TRUCKS HAVE HAD RECALLS FOR THE SAME THING. THIS IS AN OBVIOUS ISSUE, NOT SURE WHY FORD SERVICE SHOPS COULD NOT RECTIFY. TRUCK IS NOW OUT OF WARRANTY AND I AM FORCED TO PAY OUT OF POCKET. UNACCEPTABLE SERVICE AND CARE! -COLD WEATHER EACH TIME -ENGINE LIGHT COMES ON - SAME CODE EACH TIME -REDUCED SPEED AND SLUGGISH PERFORMANCE -CODE CLEARED - TRUCK PERFORMS NORMAL -OBVIOUS THAT THE REDUCTANT HEAT PUMP IS NOT DOING WHAT IT IS DESIGNED TO DO.
NHTSA ODI #11309982
Mileage unknown · Oct 30, 2016
Electronic Stability Control (esc)Power TrainSuspension
I WAS DRIVING DOWN THE HIGHWAY AND ALL OF A SUDDEN TWICE WITHIN 10 MILES OF EACH OTHER MY TRUCK STARTED VIOLENTLY SHAKING ALOST SENDING ME INTO ANOTHER LANE AND LOSING CONTROL. HAD TO SLOW DOWN ALMOST TO A STOP BEFORE IT WOULD QUIT. *TR
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
Ford Motor Company (Ford) is recalling certain 2016 Super Duty F-250, F-350, F-450, and F-550 vehicles. Dust may accumulate in the steering wheel clock spring, causing a disconnection in the electrical connection resulting in the driver's air bag not deploying as intended.
Consequence & remedy
Consequence: A disconnected driver's air bag can result in it not deploying, as intended, during a crash, increasing the risk of injury.
Remedy: Dealers will replace the steering wheel clock spring, free of charge. Remedy parts are expected to become available in the 3rd Quarter of 2023. An interim notification letter informing owners of the safety risk was mailed on July 6, 2022. Owner notification letters were mailed July 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S35.
Ford Motor Company (Ford) is recalling certain model year 2016 Ford F-250, F-350, F-450, and F-550 trucks manufactured April 5, 2016, to April 11, 2016. The tires installed during assembly of the affected vehicles may have sustained damage to the inner sidewall, possibly resulting in a loss of air or a tire rupture.
Consequence & remedy
Consequence: A rapid loss of air or a tire rupture while the vehicle is being driven may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires for damage and replace them as necessary, free of charge. The recall began on May 23, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S17.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
2016 Ford F-250 Sd Problems, Complaints & Recalls | Skip That Year
Illustration