NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
295 reports38,000 miles · Dec 1, 2009
Engine And Engine Cooling
I HAVE A 2005 FORD F250, 6.0L DIESEL. THIS POWER PLANT IS USED ON SEVERAL FORD MODEL VEHICLES AND HAS AN INHERENT PROBLEM WITH IT'S EGR SYSTEM. WHEN THE EGR SYSTEM FAILS, THE VEHICLES LOOSES ALL THROTTLE RESPONSE. RESEND 03/05/10. *LJ ON NOVEMBER 25TH, 2009, I WAS STOP AT AN INTERSECTION WAITING TO MERGE ONTO A VERY BUSY HIGH…
Read full complaint
I HAVE A 2005 FORD F250, 6.0L DIESEL. THIS POWER PLANT IS USED ON SEVERAL FORD MODEL VEHICLES AND HAS AN INHERENT PROBLEM WITH IT'S EGR SYSTEM. WHEN THE EGR SYSTEM FAILS, THE VEHICLES LOOSES ALL THROTTLE RESPONSE. RESEND 03/05/10. *LJ ON NOVEMBER 25TH, 2009, I WAS STOP AT AN INTERSECTION WAITING TO MERGE ONTO A VERY BUSY HIGHWAY. WHEN THE TIME CAME TO MERGE ONTO THE HIGHWAY, MY VEHICLE FAIL TO ACCELERATE, IT CREPT INTO THE PATH OF ON COMING TRAFFIC AND I HAD TO PERFORM AN ADVASIVE MANEUVER (IMMEDIATELY PULL OFF THE HIGHWAY) TO PROTECT ME AND OTHERS FROM A POTENTIAL ACCIDENT. THIS SITUATION HAS HAPPEN TO ME ON MORE THEN ONE OCCASION AND IS INTERMITTENT. WHEN I REPORTED THIS TO MY DEALERSHIP, THEY PERFORMED A PROCEDURE TO CLEAN OUT THE CARBON BUILDUP WITHIN THE INTAKE SYSTEM AND TOLD ME THAT THIS WAS CONSIDERED ROUTINE MAINTENANCE, THIS IS NOT MENTIONED ANYWHERE IN THE OPERATORS MANUAL. I BELIEVE THIS IS A PUBLIC SAFETY ISSUE THAT FORD SHOULD RECOGNIZE AND PROVIDE A FIX. *TR
NHTSA ODI #10294149
65,000 miles · Nov 24, 2009
Parking Brake
RIGHT REAR PARKING BRAKE FAILED. REAR BRAKE ASSEMBLY PLATE CORRODED THROUGH AND ALLOWED RETAINING STUD TO PULL THROUGH PLATE. PARKING BRAKE ASSEMBLY LOST INTEGRITY CAUSING BRAKE DRAG AND SQUEALING NOISE. BRAKE PART FAILED IN 65000 MILES. CONCERNED FAILURE COULD HAVE BECOME CATASTROPHIC AT FREEWAY SPEEDS IF PARKING BRAKE LOCKED U…
Read full complaint
RIGHT REAR PARKING BRAKE FAILED. REAR BRAKE ASSEMBLY PLATE CORRODED THROUGH AND ALLOWED RETAINING STUD TO PULL THROUGH PLATE. PARKING BRAKE ASSEMBLY LOST INTEGRITY CAUSING BRAKE DRAG AND SQUEALING NOISE. BRAKE PART FAILED IN 65000 MILES. CONCERNED FAILURE COULD HAVE BECOME CATASTROPHIC AT FREEWAY SPEEDS IF PARKING BRAKE LOCKED UP WHEEL. PART IS AVAILABLE. *TR
NHTSA ODI #10293472
33,250 miles · Nov 16, 2009
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2005 FORD F250 SUPER DUTY. HE EXPERIENCED BRAKE FAILURE TWICE WHILE DRIVING, BUT WAS ABLE TO AVOID TWO CRASHES. THE VEHICLE WAS TAKEN TO THE DEALER AND THE FRONT ROTORS WERE REPLACED. AFTER THE REPAIR HE EXPERIENCED REDUCED BRAKING CAPABILITY. HE ALSO SMELLED A BURNING ODOR DURING BRAKE APPLICATION AND U…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F250 SUPER DUTY. HE EXPERIENCED BRAKE FAILURE TWICE WHILE DRIVING, BUT WAS ABLE TO AVOID TWO CRASHES. THE VEHICLE WAS TAKEN TO THE DEALER AND THE FRONT ROTORS WERE REPLACED. AFTER THE REPAIR HE EXPERIENCED REDUCED BRAKING CAPABILITY. HE ALSO SMELLED A BURNING ODOR DURING BRAKE APPLICATION AND UPON FURTHER INSPECTION, HE NOTICED THAT THE FRONT ROTORS WERE DEFECTIVE. HE WAS IN THE PROCESS OF TAKING THE VEHICLE BACK TO THE DEALER. THE FAILURE AND CURRENT MILEAGES WERE 59,300. UPDATED 12/07/09. *LJ UPDATED 12/08/09
NHTSA ODI #10292319
45,000 miles · Oct 8, 2009
Steering
I OWN A 2005 F250 SUPER DUTY, MY TRUCK EXPERIENCES THE "DEATH WOBBLE" WHEN EVER I GO OVER AN UNEVEN OR A POT HOLE IN THE ROAD. I LIVE IN ARKANSAS, AND OUR ROADS ARE NOT THE BEST. SO THIS HAPPENS JUST ABOUT EVERY TIME I DRIVE THE THING. I JUST PURCHASED THIS VEHICLE IN SEPTEMBER OF 2009. APPARENTLY WHEN I TEST DROVE THE TRUCK I W…
Read full complaint
I OWN A 2005 F250 SUPER DUTY, MY TRUCK EXPERIENCES THE "DEATH WOBBLE" WHEN EVER I GO OVER AN UNEVEN OR A POT HOLE IN THE ROAD. I LIVE IN ARKANSAS, AND OUR ROADS ARE NOT THE BEST. SO THIS HAPPENS JUST ABOUT EVERY TIME I DRIVE THE THING. I JUST PURCHASED THIS VEHICLE IN SEPTEMBER OF 2009. APPARENTLY WHEN I TEST DROVE THE TRUCK I WAS ON SMOOTH PAVEMENT OTHERWISE I WOULDN'T HAVE BOUGHT IT. *TR
NHTSA ODI #10286754
25,000 miles · Sep 25, 2009
Power Train
SEVERE FRONT END WOBBLE CAUSING ENGINE TO FAIL, ALL POWER IS LOST ON THE VEHICLE ACCORDING TO FORD FICM HARNESS WAS BAD THEY REPLACED IT NOW THE ABS LIGHT INDICATES A PROBLEM WITH THE BRAKES......NO REPAIRS YET VEHICLE STILL IN SHOP. *TR
NHTSA ODI #10285291
100 miles · Sep 24, 2009
SuspensionCrash
FORD F-250 SUPERDUTY- WHILE DRIVING AT 55MPH OR HIGHER,AND YOU HIT A SMALL POTHOLE OR DIP IN THE ROAD, THIS VEHICLE GOES INTO A VIOLENT SHIMMY. THE VEHICLE IS UNCONTROLLABLE AND EXTREMELY DANGEROUS. I WON'T LET ANY OF MY FAMILY MEMBERS RIDE IN THE TRUCK WITH ME AND CRINGE AT THE THOUGHTS OF HAVING TO DRIVE IT ON THE INTERSTATE! …
Read full complaint
FORD F-250 SUPERDUTY- WHILE DRIVING AT 55MPH OR HIGHER,AND YOU HIT A SMALL POTHOLE OR DIP IN THE ROAD, THIS VEHICLE GOES INTO A VIOLENT SHIMMY. THE VEHICLE IS UNCONTROLLABLE AND EXTREMELY DANGEROUS. I WON'T LET ANY OF MY FAMILY MEMBERS RIDE IN THE TRUCK WITH ME AND CRINGE AT THE THOUGHTS OF HAVING TO DRIVE IT ON THE INTERSTATE! IT HAS SHAKEN ME OFF THE ROAD AND INTO THE DITCH OR MEDIAN SEVERAL TIMES. *TR
NHTSA ODI #10285130
42,000 miles · Sep 21, 2009
Power Train
2005 FORD F-250 TRANSMISSION CIRCLIP IS COMING OFF CAUSING TRANSMISSION TO LEAK AND ULTIMATELY FAIL. WE KNOW OF 6 PEOPLE THAT THIS HAS HAPPENED TO, NOW US. FORD HAD A "CUSTOMER SATISFACTION BULLETIN 05B27" THAT EXPIRED AT THE END OF 2006. WE FOUND THIS ON OUR OWN. FORD IS ABSOLUTELY NO HELP WITH THIS ISSUE. PLEASE READ THE …
Read full complaint
2005 FORD F-250 TRANSMISSION CIRCLIP IS COMING OFF CAUSING TRANSMISSION TO LEAK AND ULTIMATELY FAIL. WE KNOW OF 6 PEOPLE THAT THIS HAS HAPPENED TO, NOW US. FORD HAD A "CUSTOMER SATISFACTION BULLETIN 05B27" THAT EXPIRED AT THE END OF 2006. WE FOUND THIS ON OUR OWN. FORD IS ABSOLUTELY NO HELP WITH THIS ISSUE. PLEASE READ THE DIESEL FORMS ON THE INTERNET. *TR
NHTSA ODI #10284793
60,000 miles · Sep 4, 2009
Electrical System
TL- THE CONTACT OWNS A 2005 FORD F250. HE STATES THAT WHILE DRIVING AND WITH OUT WARNING THE VEHICLE STARTS TO STALL AND SHUTS OFF. HE THEN HAS TO PULL THE VEHICLE SIDE AND WAIT ABOUT 10 MINUTES AND THEN TURN THE VEHICLE BACK ON. WHEN THE VEHICLE IS TURNED BACK ON IT DRIVES FINE AFTERWARDS WITHOUT A PROBLEM. THE DEALER WAS CONTA…
Read full complaint
TL- THE CONTACT OWNS A 2005 FORD F250. HE STATES THAT WHILE DRIVING AND WITH OUT WARNING THE VEHICLE STARTS TO STALL AND SHUTS OFF. HE THEN HAS TO PULL THE VEHICLE SIDE AND WAIT ABOUT 10 MINUTES AND THEN TURN THE VEHICLE BACK ON. WHEN THE VEHICLE IS TURNED BACK ON IT DRIVES FINE AFTERWARDS WITHOUT A PROBLEM. THE DEALER WAS CONTACT AND THEY TO;D HIM THAT THERE WAS A RECALL FOR THE VEHICLE BUT HIS VIN NUMBER WAS NOT INCLUDED. THE RECALL IS COMPONENT: ELECTRICAL SYSTEM:WIRING NHTSA CAMPAIGN ID NUMBER: 05V270000 , THE VEHICLE IS EXPERIENCING THE SAME SYMPTOMS INCLUDED IN THIS RECALL. THIS HAS OCCURED ONCE AGAIN WHERE THE VEHICLE WAS REPAIRED UNDER WARRANTY AND KNOW IS REOCCURING AGAIN BUT THIS TIME IT IS WORSE. THE VEHICLE WILL BE REPAIRED AT OWNERS EXPENSE. THE FAILURE MILEAGE WAS 60000 AND CURRENT MILEAGE WAS 103000.
NHTSA ODI #10282876
17,520 miles · Aug 24, 2009
Structure
TL*THE CONTACT OWNS A 2005 FORD F-250 PURCHASED BRAND NEW IN 2005. WHILE STEPPING ON THE DRIVER'S SIDE RUNNING BOARD, THE ENTIRE BOARD BROKE OFF THE TRUCK. THE RUNNING BOARD CONSIST OF FIVE MOUNTED PIECES AND ALL FIVE PIECES BROKE SIMULTANEOUSLY. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 17,520.
NHTSA ODI #10281570
20,000 miles · Aug 23, 2009
Suspension
I BOUGHT A 2005 F250 CREW CAB AND SINCE ABOUT 25K MILES MY TRUCK WILL WOBBLE WHEN I HIT A BUMP AT 45-60 MILES PER HOUR. THE SHACK/WOBBLE IS SO INTENSE THAT YOU FEEL THE FRONT OF THE TRUCK IS GOING TO LOOSE THE TIRES. THIS HAS HAPPENED ABOUT 6 TIMES NOW AND I KNOW SOMETHING IS VERY WRONG BUT FORD WILL NOT DO ANYTHING EXCEPT TELL …
Read full complaint
I BOUGHT A 2005 F250 CREW CAB AND SINCE ABOUT 25K MILES MY TRUCK WILL WOBBLE WHEN I HIT A BUMP AT 45-60 MILES PER HOUR. THE SHACK/WOBBLE IS SO INTENSE THAT YOU FEEL THE FRONT OF THE TRUCK IS GOING TO LOOSE THE TIRES. THIS HAS HAPPENED ABOUT 6 TIMES NOW AND I KNOW SOMETHING IS VERY WRONG BUT FORD WILL NOT DO ANYTHING EXCEPT TELL ME TO CHECK MY TIRE PRESSURE. TIRE PRESSURE IS CHECKED ALMOST MONTHLY ON MY TRUCK AND I KNOW THAT IS NOT THE ISSUE. IT IS HARD TO HAVE RE-CREATE THE ISSUE WITH A TECH, SINCE IT DOES NOT HAPPEN ALL THE TIME. I AM GETTING THE RUN AROUND WITH FORD AND HAVE SPENT THOUSANDS OF DOLLARS TRYING TO FIX THE PROBLEM MYSELF. I KNOW OF OTHER FORD OWNERS THAT HAVE THE SAME PROBLEM AND FORD REFUSES TO DO ANYTHING. *TR
NHTSA ODI #10281464
Official recalls
3Jul 13, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Jun 10, 2005
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Jun 9, 2005
ON CERTAIN PICKUP TRUCKS AND CHASSIS CAB VEHICLES EQUIPPED WITH 5.4L OR 6.8L GASOLINE ENGINES, THE FUEL JUMPER LINE MAY HAVE AN INCORRECT END FORM.
Consequence & remedy
Consequence: THE FUEL LINE MAY SEPARATE AT THE CONNECTION TO THE MAIN FUEL BUNDLE. IF THE FUEL LINE SEPARATES, AN OPERATOR MAY NOTICE A GASOLINE ODOR AND/OR FUEL ON THE GROUND, LOSS OF POWER, AND THE ENGINE WILL EVENTUALLY STALL. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN EXTERNAL RETENTION CLIP AT THE FUEL JUMPER LINE TO THE MAIN FUEL BUNDLE CONNECTION. THE RECALL BEGAN ON JUNE 20, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Illustration