NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
102 reportsMileage unknown · Dec 30, 2025
Service Brakes
complete loss of brakes. there was zero response from the brake pedal for several complete pumps to the floor. after about 4 complete "stomps", the brakes locked, resulting in a violent and sudden stop. at the time, the dash began flashing multiple warning messages about display failure and also ABS failure and making many al…
Read full complaint
complete loss of brakes. there was zero response from the brake pedal for several complete pumps to the floor. after about 4 complete "stomps", the brakes locked, resulting in a violent and sudden stop. at the time, the dash began flashing multiple warning messages about display failure and also ABS failure and making many alarm sounds, further distracting me from dealing with a very dangerous situation. Had this occurred at speed and not at a fast idle speed, serious injury or death would likely have occurred. this is a Xcelerate fleet vehicle, and fleet services took the vehicle to a non-dealership shop, which claims to have fixed the problem but could not complete the recall repairs. fleet has only just today agreed to tow the vehicle to a Ford dealership for recall repair. This incident occurred on 9/26/2025.
NHTSA ODI #11707805
3,000 miles · Dec 29, 2025
Forward Collision AvoidanceCrash
The contact owns a 2025 Ford F-150. The contact stated that while idle at a red light, while using the brake hold feature, the vehicle's brakes suddenly released, causing them to rear-end the vehicle in front. No air bags deployed. There were no injuries or medical attention needed. A police report was filed. The vehicle was tak…
Read full complaint
The contact owns a 2025 Ford F-150. The contact stated that while idle at a red light, while using the brake hold feature, the vehicle's brakes suddenly released, causing them to rear-end the vehicle in front. No air bags deployed. There were no injuries or medical attention needed. A police report was filed. The vehicle was taken to the dealer; however, the vehicle was not diagnosed. The vehicle's cruise control was set to 15 mph when entering and passing through a school zone, and once out of the school zone, the speed limit increased to 30 MPH at which time the vehicle accelerated to the higher speed with the cruise control still set to 15 MPH and activated. The manufacturer was informed of the failure. The failure mileage was approximately 3,000.
NHTSA ODI #11707547
Mileage unknown · Dec 23, 2025
Forward Collision AvoidanceVehicle Speed Control
In November, shortly after engaging adaptive cruise control on [XXX] the truck indicated an incorrect speed limit of 45 mph and immediately started braking HARD causing a hazard on a busy roadway. I stomped on the gas trying to override the automation until I could disable the feature. This is a commonly reported issue on for…
Read full complaint
In November, shortly after engaging adaptive cruise control on [XXX] the truck indicated an incorrect speed limit of 45 mph and immediately started braking HARD causing a hazard on a busy roadway. I stomped on the gas trying to override the automation until I could disable the feature. This is a commonly reported issue on forums and local news reports ( [XXX] ) and does not appear to have a fix so I have not bothered to take it to the dealer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11706810
Mileage unknown · Dec 18, 2025
Power Train
The contact owns a 2025 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V512000 (Power Train); however, the part to do the recall repair was not yet available. In addition, the contact later received a second recall notification that parts were now available for the recall repair. The dealer was contact…
Read full complaint
The contact owns a 2025 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V512000 (Power Train); however, the part to do the recall repair was not yet available. In addition, the contact later received a second recall notification that parts were now available for the recall repair. The dealer was contacted, and the contact was informed that parts were not available. The contact stated that the situation needed to be investigated if the parts were not available. The manufacturer was not contacted. The contact had not experienced a failure.
NHTSA ODI #11705824
Mileage unknown · Dec 11, 2025
Electrical SystemForward Collision Avoidance
I was turning right, out of a store parking lot onto the street, at very low speed. Suddenly the truck accelerated on its own. I had to quickly hit the brake to prevent striking a vehicle in front of me that had stopped for a red traffic signal. I believe there is a possibility that Ford's new method of activating cruise cont…
Read full complaint
I was turning right, out of a store parking lot onto the street, at very low speed. Suddenly the truck accelerated on its own. I had to quickly hit the brake to prevent striking a vehicle in front of me that had stopped for a red traffic signal. I believe there is a possibility that Ford's new method of activating cruise control (which now only requires a single button press after which the truck will set current speed OR 15 MPH, whichever is greater) could be to blame. If a driver turning the steering wheel makes contact with a single button on the steering wheel with his/her hand or palm by accident, this seems to cause the unexpected acceleration. It is a quite dangerous situation that in my opinion Ford should correct by requiring TWO steps to activate cruise control as opposed to one.
NHTSA ODI #11704439
Mileage unknown · Dec 3, 2025
Electrical System
The truck has recently and randomly been making a very loud static/poping sound that actually sometimes hurts my ears. After this static continuously plays even when I reset the sync system, cycle the ignition or turn the volume to zero, it still continues. This is followed by a strong electrical burning smell. After 10 minutes …
Read full complaint
The truck has recently and randomly been making a very loud static/poping sound that actually sometimes hurts my ears. After this static continuously plays even when I reset the sync system, cycle the ignition or turn the volume to zero, it still continues. This is followed by a strong electrical burning smell. After 10 minutes this stops and the passenger side speakers are the only ones that work. The initial very loud pop/crackle is dangerous and has made me jump where it started me mid lane change as if something had collided with the truck. This lapse in concentration due to a natural startling reaction could cause an accident.
NHTSA ODI #11702795
Mileage unknown · Dec 1, 2025
Exterior Lighting
Water erosion to the wiring harness to the front headlights led to an outage of the LEDs on glad of the vehicle.
NHTSA ODI #11702373
Mileage unknown · Nov 29, 2025
Air BagsElectrical SystemSeats
Normal driving to work. Airbag light came on. Notification on Ford app about front air bag system not working correctly. Contact Ford for service. Contacted Denooyer Ford for service that was recommended. Same dealership I purchased the truck from. Service was able to schedule me within a week but recommended not driving the …
Read full complaint
Normal driving to work. Airbag light came on. Notification on Ford app about front air bag system not working correctly. Contact Ford for service. Contacted Denooyer Ford for service that was recommended. Same dealership I purchased the truck from. Service was able to schedule me within a week but recommended not driving the vehicle as it possibly didn't have working airbags. During service they corrected 2 other recalls on the vehicle and informed me that the air bag system warranty work would be 1-2 years on replacement parts. Dealer recommended not driving vehicle till proper replacement parts got installed to correct faulty air bag sensor in seat. Dealer told me that they don't have any rental vehicles in the meantime. 1-2 years of not driving a new vehicle is not acceptable.
NHTSA ODI #11702010
5,330 miles · Nov 25, 2025
Power Train
The contact owns a 2025 Ford F-150. The contact stated that while pulling into the driveway and depressing the brake pedal, the gear shifter independently shifted to park(P), locked, and remained in park(P). The contact turned off and restarted the vehicle, and the vehicle responded as intended. A dealer was contacted. The vehic…
Read full complaint
The contact owns a 2025 Ford F-150. The contact stated that while pulling into the driveway and depressing the brake pedal, the gear shifter independently shifted to park(P), locked, and remained in park(P). The contact turned off and restarted the vehicle, and the vehicle responded as intended. A dealer was contacted. The vehicle was taken to the dealer, where it was diagnosed, but the diagnostic information was unknown. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 5,330.
NHTSA ODI #11701445
Mileage unknown · Nov 24, 2025
EngineStructureUnknown Or Other
My 2025 F-150 Tremor (5.0 V8, 402A package with modular front bumper) has a large open area in the front bumper. Through this opening you can clearly see the front of the engine and related components. This appears to be a design issue rather than a one-off build problem. Other 2025 Tremor owners with the same 402A modular bump…
Read full complaint
My 2025 F-150 Tremor (5.0 V8, 402A package with modular front bumper) has a large open area in the front bumper. Through this opening you can clearly see the front of the engine and related components. This appears to be a design issue rather than a one-off build problem. Other 2025 Tremor owners with the same 402A modular bumper are reporting the same concern and asking whether a cover is missing from the factory. My concern is that the exposed opening could allow rocks, road debris, or off-road obstacles to directly impact vital components at highway speed or when driving on rough/uneven surfaces. This may increase the risk of damage, fluid leaks, or sudden loss of power/steering if components are struck. It also appears inconsistent with typical under-engine protection on off-road-oriented trims. I am asking NHTSA to review whether this bumper configuration provides adequate protection for critical components on the 2025 F-150 Tremor and whether a design change or shield/plate is needed for safety.
NHTSA ODI #11701316
Official recalls
13Sep 9, 2026
Ford Motor Company (Ford) is recalling certain 2023-2027 F-150 vehicles. The fuel tank may be improperly secured and leak fuel, or detach from the vehicle while driving.
Consequence & remedy
Consequence: A detached tank can create a road hazard, increasing the risk of a crash. In addition, a fuel leak can cause an engine stall or increase the risk of a fire.
Remedy: Dealers will inspect and replace the fuel tank straps, as necessary, free of charge. Owner notification letters are expected to be mailed September 21, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S69. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 14, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Additional source detail variants (2)
Exterior Lighting:tail Lights
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Electrical System: Integrated Trailer Brake Control
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Dec 1, 2025
Ford Motor Company (Ford) is recalling certain 2025 Lincoln Navigator, F-150, Expedition, Bronco, and Ranger vehicles. The Electronic Brake Booster (EBB) module may malfunction while driving or when the driver is utilizing an Advanced Driver Assistance System (ADAS) feature, resulting in a loss of power brake assist.
Consequence & remedy
Consequence: An unexpected loss of power brake assist while driving can extend stopping distance and increase the risk of a crash. Additionally, a loss of power brake assist while ADAS features are engaged can result in the vehicle not braking as expected, increasing the risk of a crash.
Remedy: Dealers will replace the electronic brake booster, free of charge. Owner notification letters were mailed February 26, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SD4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 3, 2025.
Aug 22, 2025
Ford Motor Company (Ford) is recalling certain 2025-2026 F-550 SD, F-450 SD, F-350 SD, F-250 SD, and 2025 F-150 vehicles. The Instrument Panel Cluster (IPC) may fail at startup.
Consequence & remedy
Consequence: An instrument panel display that does not show critical information, such as warning lights or vehicle speed, increases the risk of a crash.
Remedy: The instrument panel cluster software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed September 5, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S88.
Aug 8, 2025
Ford Motor Company (Ford) is recalling certain 2023-2025 F-150 vehicles equipped with the Trailer Tow Max Duty package and a 9.75-inch heavy duty axle with a 3/4 float axle design. The rear axle hub bolt may fatigue and break, which can result in damage to the axle hub splines.
Consequence & remedy
Consequence: Damaged axle hub splines can result in a vehicle rollaway when in park without the parking brake applied or cause a loss of drive power. Either of these conditions can increase the risk of a crash.
Remedy: Dealers will replace the left and right rear axle shaft assemblies, free of charge. This is a phased recall. Ford owners will receive letters in multiple phases, beginning August 2025 through Winter 2025. Phase 1 will include 2023 F-150 model year vehicles. Phase 2 will include 2025 F-150 model year vehicles and Phase 3 will include 2024 F-150 model year vehicles. Interim owner notification letters informing owners of the safety risk were mailed August 22, 2025. Owner notification letters were mailed August 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S82. This recall expands previous NHTSA recall number 23V896.
Jul 25, 2025
Ford Motor Company (Ford) is recalling certain 2025 Lincoln Navigator, F-150, Expedition, Bronco, and Ranger vehicles. The Electronic Brake Booster (EBB) module may malfunction while driving or when the driver is utilizing an Advanced Driver Assistance System (ADAS) feature, resulting in a loss of power brake assist.
Consequence & remedy
Consequence: An unexpected loss of power brake assist while driving can extend stopping distance and increase the risk of a crash. Additionally, a loss of power brake assist while ADAS features are engaged can result in the vehicle not braking as expected, increasing the risk of a crash.
Remedy: The EBB module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed on August 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S77.
Jun 13, 2025
Ford Motor Company (Ford) is recalling certain 2025 Transit, F-150, and Explorer vehicles. The connecting rod and rod bearing components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: A damaged engine can result in engine failure and a stall, increasing the risk of a crash.
Remedy: Dealers will inspect the connecting rods and replace the engine long block assembly as necessary, free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S55.
Jun 13, 2025
Ford Motor Company (Ford) is recalling certain 2025 F-150 trucks. Contact with the engine coolant hose may chafe the engine wire harness or cause a pull out of the Powertrain Control Module (PCM) connector pins, causing the engine to stall.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will inspect, replace the engine wire harness as necessary, and relocate the engine coolant hose, free of charge. Owner notification letters were mailed September 12, 2025. The parts are anticipated to be available the third quarter of 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S63.
Additional source detail variants (2)
Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings
Ford Motor Company (Ford) is recalling certain 2025 F-150 trucks. Contact with the engine coolant hose may chafe the engine wire harness or cause a pull out of the Powertrain Control Module (PCM) connector pins, causing the engine to stall.
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will inspect, replace the engine wire harness as necessary, and relocate the engine coolant hose, free of charge. Owner notification letters were mailed September 12, 2025. The parts are anticipated to be available the third quarter of 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S63.
Electrical System:wiring
Ford Motor Company (Ford) is recalling certain 2025 F-150 trucks. Contact with the engine coolant hose may chafe the engine wire harness or cause a pull out of the Powertrain Control Module (PCM) connector pins, causing the engine to stall.
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will inspect, replace the engine wire harness as necessary, and relocate the engine coolant hose, free of charge. Owner notification letters were mailed September 12, 2025. The parts are anticipated to be available the third quarter of 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S63.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2025 F-150 vehicles. The lower intermediate shaft fasteners may be improperly attached to the steering gear, allowing the shaft to come loose or detach.
Consequence & remedy
Consequence: A lower intermediate shaft that detaches can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the lower intermediate shaft fasteners as necessary, free of charge. Owner notification letters were mailed May 30, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S46.
Apr 23, 2025
Ford Motor Company (Ford) is recalling certain 2025 F-150 vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: A missing air bag warning label will not warn occupants about the risks of air bag deployment, increasing the risk of injury in a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed May 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C12.
Mar 28, 2025
Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Expedition, and 2024 Lincoln Navigator vehicles equipped with 3.5L GTDI engines. The engine may have a misaligned engine cup plug, which can result in a rapid oil leak.
Consequence & remedy
Consequence: A rapid oil leak can result in an engine stall, increasing the risk of a crash. In addition, an oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will inspect the engine cup plug alignment, and replace the plug if necessary, free of charge. Owner notification letters were mailed May 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S30.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Bronco, 2024 Ranger, 2025 Mustang, Explorer, and Aviator vehicles. The transmission valve body may have been machined incorrectly, which can cause reverse gear failure, or unexpected forward movement in reverse or neutral gear.
Consequence & remedy
Consequence: Unexpected vehicle movement increases the risk of a crash.
Remedy: Dealers will replace the transmission main control valve body, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S19.
Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, 2024 Expedition and 2024 Lincoln Navigator vehicles equipped with a 3.5L GTDI engine. The engines may have a misaligned engine cup plug, which can result in a rapid oil leak.
Consequence & remedy
Consequence: A rapid oil leak can result in an engine stall, increasing the risk of a crash. In addition, an oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will inspect the engine cup plug alignment, and replace the plug if necessary, free of charge. Owner notification letters were mailed on May 23, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S70.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration