2024 Ford F-150

The rear window of my 2024 Ford F-150 XLT violently exploded without warning. I was actively entering the truck when the explosion occurred. There was no collision, or object that stroked the glass. The extremely loud explosion terrified me, and because I initially did not know what had occurred, I contacted police. I have a police report of the incident. The failed component was the rear window/rear glass assembly. The shattered glass and vehicle were available for inspection following the incident and was towed to Ford. The sudden failure presented a serious safety risk because I was at the driver's seat when the glass exploded. I could have sustained significant lacerations from the glass. Other occupants could also potentially be injured. The failure has not been independently reproduced. The failure was directly observed by me, and the police were contacted immediately following the incident. I have reported the incident to Ford. Ford has been notified of the failure, but I have not received an adequate explanation establishing why the rear window suddenly exploded. I have subsequently researched similar reports involving Ford F-150 rear-window failures and discovered other consumer complaints describing sudden or unexplained rear-window shattering, including reports raising concerns regarding the rear defroster and/or associated electrical components. I did not use a rear defroster - the car was off. This raises concerns about whether Ford has adequately investigated a potential recurring defect and whether consumers should have been warned. The vehicle had had no warning lamps. This incident occurred on a vehicle purchased new in 2024. I have also experienced another major problem with the vehicle. I am requesting that NHTSA investigate whether sudden rear-window failure in the Ford F-150 represents a safety defect, whether Ford had prior notice of similar failures, and whether additional investigation, consumer notification, or a safety recall is warranted.

VIN # [XXX] Ford Customer Service Current Case Number: [XXX] Integrated Trailer Module Failure after recall completion. NHTSA Campaign ID Recall # 26C10 was completed at Coconut Point Ford in Florida on 3/26/2026. This recall identified that when towing a trailer, the integrated Trailer Module may lose communication with the trailer possibly causing a loss of brake and turn signal lights or a loss of brake function. On [XXX] in the middle of a seriously steep and dangerous decent, the system reported that the trailer was disconnected from the truck causing, loss of trailer brake control which in turn cause a reliance on the truck. The antilock brake system failed moments later. I had to literally stand on the brakes to slow down to keep from going over the side of the mountain. At the end of the dirt road where it Ts onto the highway we could not stop. We travel with a 23 foot 2019 Vintage Cruiser manufactured by Gulf Stream. That weighs approximately 5200 lbs empty; I have a Cat Scale reading of 4840 pounds from a 12/6/24 weight with my previous truck. We do not travel with any water in our Black, Grey or Fresh Water tanks so even fully loaded we are still well within specs for this trucks towing capacity. The brake control on the truck was set to 5. Faricy Boys Ford in Canon City Colorado, verified that a recall had been completed and worked on the truck for 3 full days, testing many things including tailgate malfunctions and miscellaneous electrical systems trying to replicate the problem, no dealer has been able to replicate the problem. They finally replaced all the brakes and rotors as well as flushing the brake system. I respectfully requested that Ford Motor Company assign the review of this case to a regional Customer Service Manager / Engineer to review the complete repair history of this vehicle, via registered mail. We haven heard anything yet. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I own a 2024 Ford F-150 Lightning Platinum built in August 2024. The vehicle has been at the dealership for over 45 days for severe, unresolved electrical safety defects. I have attached photographic proof of the main defects. The first three photos show the driver's instrument display screen behind the steering wheel completely blacking out on startup, blinding critical safety gauges like the speedometer. The center screen stays on, but the main cluster is totally dead. Fourth and fifth photos show the driver's seat memory failure. I manually set my lumbar support to a comfortable 3-4-3 setting and save it, but every time the truck sits, the seat completely deflates to a flat zero default on startup. This causes an immediate driving distraction and ergonomic hazard. The factory navigation also randomly shouts driving directions out of nowhere without any driver input. The dealership is currently trying to install a temporary "bypass wire" hack on my factory harness just to see if it fixes the seat memory. However, Ford's internal hotline (SSSC) refuses to authorize repairs for the black screen or phantom navigation until a tech physically catches it glitching on command. Ford’s policy is to return the vehicle unrepaired if it does not fail during active observation. I am requesting NHTSA to investigate Ford's active evasion of safety recall 25V540 (Ford 25S88). The official recall paperwork states the defective supplier software entered production on May 14, 2024. My truck was manufactured in August 2024—squarely within the defective window—yet Ford is using a model-year loophole to exclude 2024 vehicles from the recall population. They are denying owners a permanent factory software remedy and forcing dealers to use unapproved, temporary physical workarounds. The vehicle is at the dealership and available for federal inspection if need be.

The truck had been parked in our driveway for approximately 24 hrs when my wife went to the drivers side door to retrieve something that she had left in the center console. After she retrieved what she was looking for she pushed the door closed and the rear window spontaneously and completely shattered. There had been no prior damage whatsoever. The vehicle was towed to our Ford dealership on March 17th. The service manager at our dealership submitted our warranty claim to Ford and then informed us ~36 hrs later that Ford had not issued any TSBs or SSMs for the 2024 rear window or related parts / functions and therefore would decline to repair the rear window. We have asked them to resubmit the claim because we were not satisfied with Ford declining it. It is now April 2nd and we still have not heard back.

The digital dash cluster will randomly blank out while driving. After it sits for aboutba few hrs parked, it will turn back on just to repeat it down the road again. I tried bring it up with the dealership a few times and I was told they aren't able to replicate the issue and it's within factory spec. This is extremely dangerous since this creates issues of not knowing how fast the vehicle is going, and no indicators of what the truck is doing.

Have had the truck for 11 months (since new) I have never had the issue. The display (for radio, navigation etc.) just started switching to a different screen. I was using the navigation and the screen switched to display radio information without being touched. When I switched to Google Maps from car play. The map just froze up and would not unfreeze until I turned off the truck and restarted. Had I been going somewhere and was depending on the navigation system. I could have been in a situation that could have caused an accident. Ford engineers are saying this is normal!

While I was driving, my instrument panel went dark, as if it were turned off. I could no longer see my odometer. Turning the car off and on did not resolve the issue. After the car was off for a half hour or so, the problem was no longer happening. Problem occurred on March 10, 2026. Only happened once so far. Will be taking to dealer for analysis.

After operating the vehicle normally and backing into a parking space, I stopped the vehicle and selected Park, turned the vehicle off, and exited. Before the driver’s door was closed, the vehicle began to roll forward unexpectedly. I ran back to the vehicle and reentered it to regain control, with the driver’s door still open and the seatbelt not fastened. After stopping the vehicle, I selected Reverse, at which point the vehicle surged backward unexpectedly. The open driver’s door struck another vehicle and the driver, and my vehicle continued backward, colliding with a fence and then a tree. The vehicle did not behave as expected after Park was selected, creating a serious safety risk to myself and others. Several vehicle systems appeared to malfunction or fail during the incident. The specific component or system responsible is not yet known, and the vehicle is currently available for inspection. The incident resulted in property damage and back pain, for which I later sought medical care. The vehicle has been inspected by a collision repair facility and is currently being handled through insurance. The manufacturer has been informed and stated that insurance should make determinations regarding the incident.