IllustrationMy f 150 2.7 2019 has a front engine noise when cold start up. It will go away when in a couple minutes!!! Is there a problem w/ this engine? I just wanted to go on record about this problem!!!
2019 Ford F-150
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2019 Ford F-150 do not stand out strongly from the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1080–25K
6525–50K
9650–75K
7475–100K
76100–150K
12150K+
431 reports with mileage · 891 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 726 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 319 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 98 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports7 fire reports13 injury reports
Engine complaints
319 reports1) Vehicle transmission erratic shifting ,skips gear 2 and 4 a lot and sometimes from stop to 33 mph it seems to go into neutral then bang back into gear. Grand kids in back gets knocked around hard enough to lose food/drinks. It dose to back but now the truck is less than 10MPH. 2) On start up something in the engine jingle…
Read full complaint
1) Vehicle transmission erratic shifting ,skips gear 2 and 4 a lot and sometimes from stop to 33 mph it seems to go into neutral then bang back into gear. Grand kids in back gets knocked around hard enough to lose food/drinks. It dose to back but now the truck is less than 10MPH. 2) On start up something in the engine jingle and gaggle sound for 1-3 seconds.. This happens when truck has been sitting for long period.
My 2019 Ford F-150 (2.7L EcoBoost) is subject to Emission Recall 24E12, which addresses a defective PCM calibration that Ford acknowledges "could, over time, reduce the effectiveness of the emissions control system and the monitoring accuracy of the catalytic converter's efficiency." COMPONENT: Catalytic converter system and pow…
Read full complaint
My 2019 Ford F-150 (2.7L EcoBoost) is subject to Emission Recall 24E12, which addresses a defective PCM calibration that Ford acknowledges "could, over time, reduce the effectiveness of the emissions control system and the monitoring accuracy of the catalytic converter's efficiency." COMPONENT: Catalytic converter system and powertrain control module (PCM). Vehicle is available for inspection at Rich Ford in Albuquerque, NM, where it has been serviced for this issue. TIMELINE: Prior to the 24E12 recall repair, my truck had intermittent P0420/P0430 codes (catalyst efficiency below threshold). The check engine light would illuminate and then clear on its own. I brought the vehicle to Rich Ford for the 24E12 PCM reprogram. Within approximately one month of the recall repair, the same catalytic converter codes returned, except now the condition is constant and no longer clears. This timeline is documented in my FordPass app and the dealer's service records. SAFETY RISK: The constant check engine light prevents the vehicle from passing Bernalillo County emissions testing, which is required for registration in Albuquerque, NM. I am unable to legally register my vehicle due to a condition caused by a manufacturer-acknowledged defect. DEALER CONFIRMATION: Rich Ford diagnosed the recurring P0420/P0430 codes. They initially attempted to charge me $300+ for extended diagnostics. They are now consulting with Ford about whether a catalytic converter replacement will be covered under the recall. PRIOR SYMPTOMS: The intermittent check engine light with P0420/P0430 codes existed before the recall repair but was not constant. The recall repair worsened the condition from intermittent to persistent. PATTERN: Ford's recall documentation states the MIL "may illuminate even though a catalytic converter repair may not be necessary," yet numerous owners report being quoted $1,900-$2,100+ for cat replacement at their own expense after the 24E12 reprogram. Ford corporate confirmed the $300
I have had my 2019 Ford F-150 for 5 years now and always noticed that it was consuming oil. After further investigation I discovered that Ford put out TSB 19-2365 (and 19-2338) which I never received pertaining to oil consumption. I talked to Ford and they said they would inspect for a mere $199.00 dollars for a problem they new…
Read full complaint
I have had my 2019 Ford F-150 for 5 years now and always noticed that it was consuming oil. After further investigation I discovered that Ford put out TSB 19-2365 (and 19-2338) which I never received pertaining to oil consumption. I talked to Ford and they said they would inspect for a mere $199.00 dollars for a problem they new was a problem for my 5.0 liter coyote engine. Since the problem began I now have a faulty catalytic converter and 02 sensors because of this defect. I also have to purchase a catch can to prevent oil getting through to the catalytic converter.
Ford has had a known problem with their cam phaser in 2017-2020 Truck and SUV's. My truck got the recall 21B10 accomplished in 2021 and just a couple years later requires $5600 to fix a failed camshaft gear/sprocket. Ford refuses to help pay for the required repair.
Sudden downshifting, missing shift, sudden deceleration, harsh banging into gear.
Cam phaser recall
Transmission issue. Sudden down shift and spike in RPMS while driving. Hard shift during acceleration.
I took my truck in to be repaired for an incompetent tow truck driver wrapping a chain around the pinion yoke to put my truck on a flatbed because the alternator failed. Once the pinion seal repair was completed, the repair shop told me there were codes popping up on how it was running. The codes were related to the timing and …
Read full complaint
I took my truck in to be repaired for an incompetent tow truck driver wrapping a chain around the pinion yoke to put my truck on a flatbed because the alternator failed. Once the pinion seal repair was completed, the repair shop told me there were codes popping up on how it was running. The codes were related to the timing and were likely the cam phasers needing to be replaced with the timing. It turns out that the engine was needing to be replaced because there were grooves in the cam journals from metal shavings that were caused after the cam phaser lock out pin broke. The engine was on backorder from Ford and after a little over 3 months, I got a new engine for a mere $12,314. This is for a used truck that I purchased and have only owned for just going on 2 years. I called Ford corporate office to see if I could get help paying for the repairs but they told me that I had to take it directly to a Ford dealership. The Ford dealerships nearby are 3 or more months out, just to take a look at your vehicle and diagnose it. I couldn't wait that long, so I went to a local mechanic shop that I trust. It was hard enough having to wait 3 months for my engine to be replaced, let alone waiting 3 months for Ford to diagnose it and then however long for them to actually replace it.
The contact owns a 2019 Ford F-150. The contact stated that the Auto START/STOP feature was inoperable. The contact stated that the vehicle was shaking, and while idling, the vehicle started jerking abnormally. The contact stated that the transmission was slow to shift. The check engine warning light was illuminated, and the mes…
Read full complaint
The contact owns a 2019 Ford F-150. The contact stated that the Auto START/STOP feature was inoperable. The contact stated that the vehicle was shaking, and while idling, the vehicle started jerking abnormally. The contact stated that the transmission was slow to shift. The check engine warning light was illuminated, and the message cylinder #6 misfire was displayed, but had turned off. The contact received notification of NHTSA Campaign Number: 25E070000 (Power Train). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the issue and confirmed the remedy was not yet available, and opened a case. The failure mileage was approximately 155,000.
Official recalls
926V373000 · Exterior Lighting:headlights
Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
25V442000 · Back Over Prevention:software
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
24V852000 · Equipment:other:labels
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
22V252000 · Back Over Prevention: Sensing System: Camera
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2019 F-150, Super Duty F-250, F-350, F-450, and F-550 vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that displays a blank or distorted image can reduce the drivers view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed June 2, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
20V097000 · Exterior Lighting:headlights
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.
19V805000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.
Consequence & remedy
Consequence: Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.
19V633000 · Seats:front Assembly:recliner; Seats:mid/rear Assembly
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
19V278000 · Engine; Equipment:electrical
Apr 8, 2019
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
18V894000 · Engine
Dec 18, 2018
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
Consequence & remedy
Consequence: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.